Chevrolet Forward Control P30 (1985-1999) eng bat fuse 10 Wiring diagrams

A/C COMPRESSOR ENABLE RLY CTRL A/C COMPRESSOR, CLUTCH (LEFT SIDE OF ENGINE) A/C LOW PRESSURE SWITCH SIGNAL A/C REQUEST SIGNAL BLK WIRE BLU WIRE DK GRN WIRE ENG BAT FUSE 10 GAUGES FUSE 8 GRN WIRE HOT AT ALL TIMES HOT IN RUN, START I/P FUSE BLOCK (BODY BUILDER INSTALLED) (BEHIND DASH PANEL) NCA WIRE ORG/ WIRE PNK WIRE PROVISIONS FOR BODY BUILDER HVAC WHT WIRE

AUX FAN CTRL AUX FAN SW SIGNAL BLK WIRE BLU WIRE DK BLU WIRE ENG BAT FUSE 10 ENGINE COOLANT FAN MOTOR (MOUNTED TO RADIATOR) FAN CONTROL RELAY (ON TOP OF STEERING COLUMN SUPPORT, BEHIND STEERING COLUMN) FUSIBLE LINK (18 GA- HOT AT ALL TIMES I/P FUSE BLOCK (BEHIND DASH PANEL) ORG/ WIRE RED WIRE VEHICLE CONTROL MODULE (VCM) (ON TOP OF RADIATOR SUPPORT)

3 2 PPL BLK WIRE DATA LINK CONNECTOR (DLC) (BELOW DASH, NEAR STEERING COLUMN) DIESEL GAS ELECTRONIC BRAKE CONTROL MODULE (EBCM) (BELOW RADIATOR, ON LOWER CROSSMEMBER) ENG BAT FUSE 10 HOT AT ALL TIMES I/P FUSE BLOCK ORG/ WIRE PPL PPL DATA CLSS 2 SERIAL DATA TAN WIRE TAN/WHT WIRE WHT/BLK WIRE

BLK WIRE BLK/WHT WIRE DATA CLSS 2 DATA LINK CONNECTOR (BELOW DASH, NEAR STEERING COLUMN) DIAG SIG DIESEL GASOLINE ELECTRONIC BRAKE CONTROL MODULE (EBCM) (BELOW RADIATOR, ON LOWER CROSSMEMBER) ENG BAT FUSE 10 HOT AT ALL TIMES I/P FUSE BLOCK ORG/ WIRE PPL PPL SERIAL DATA SERIAL DATA TAN/WHT WIRE VEHICLE CONTROL MODULE (VCM) (TOP OF RADIATOR SUPPORT)

A/C COMPRESSOR RELAY ACCESSORY JUNCTION BLOCK (LEFT INTERIOR BULKHEAD, NEAR RELAY BRACKET) AUXILIARY ENGINE COOLANT FAN RELAY (DIESEL ONLY) GLOW PLUG CONTROLLER (DIESEL) BATT BUS BATTERY BATTERY JUNCTION BLOCK (LEFT SIDE OF ENGINE BULKHEAD) BLK WIRE BLU WIRE DATA LINK CONNECTOR DIESEL DOME LAMP (PROVISIONS FOR) ECM-BAT FUSE 6 ELECTRONIC BRAKE CONTROL MODULE ENG BAT FUSE 10 FUEL PUMP RELAY VEHICLE CONTROL MODULE FUSIBLE LINK (10 GA-RUST) FUSIBLE LINK (12 GA- FUSIBLE LINK (14 GA- FUSIBLE LINK (16 GA- FUSIBLE LINK (18 GA- GAS GENERATOR GRY WIRE HAZARD LAMP FLASHER HEADLAMPS SWITCH HORN DM FUSE 3 HORN RELAY I/P FUSE BLOCK (DASH PANEL PROVIDED BY BODY BUILDER) ORG/ WIRE OTHERS POWERTRAIN CONTROL MODULE PWR BUS PWR CIRCUIT BREAKER RED WIRE REMOTE BATTERY ACCESS TERMINAL BLOCK (REAR OF RIGHT RADIATOR CORE SUPPORT PANEL) SEAT BELT ALARM MODULE SECONDARY BATTERY (DIESEL ONLY) STARTER RELAY STARTER SOLENOID STOP-HAZ FUSE 11 STUD TAIL LPS FUSE 7 TO IGNITION SWITCH (DIAGRAM 2 OF 4) TORQUE CONVERTER CLUTCH, STOPLAMPS SWITCH TRANSMISSION CONTROL MODULE (A/T ONLY) FUEL PUMP RELAY W/DELUXE SCHOOL BUS OPTION

7.4L 7.4L VIN J 6.5L VIN F A/C COMPRESSOR RELAY FAN CONTROL RELAY ALTERNATOR BATTERY BATTERY JUNCTION BLOCK (ON FORWARD LEFT SIDE OF THE BULKHEAD) BLK WIRE BLU WIRE BUSS BAR CONNECTOR FOR DOME LAMP DATA LINK CONNECTOR DIESEL ECM-BAT FUSE 6 ELECTRONIC BRAKE CONTROL MODULE ENG BAT FUSE 10 FAN CONTROL RELAY GLOW PLUG CONTROLLER FUEL PUMP RELAY FUSIBLE LINK FUSIBLE LINK (10 GA- FUSIBLE LINK (10 GA-RUST) FUSIBLE LINK (14 GA- FUSIBLE LINK (16 GA- FUSIBLE LINK (18 GA. FUSIBLE LINK (12 GA. GRY WIRE HAZARD FLASHER HEADLAMPS SWITCH HEADLAMPS SWITCH STOPLAMP SWITCH HORN DM FUSE 3 HORN RELAY I/P FUSE BLOCK (MOUNTED ON THE DASH) IGNITION SWITCH (DIAGRAM 2 OF 4) ORG/ WIRE PARK BRAKE PUMP MOTOR RELAY POWERTRAIN CONTROL MODULE VEHICLE CONTROL MODULE PWR CIRCUIT BREAKER 2 RED WIRE SEATBELT AND LAMPS ALARM MODULE SECONDARY BATTERY (DIESEL ONLY) STARTER MOTOR STARTER RELAY STOP-HAZ FUSE 11 TAIL LAMPS FUSE 7

3 4 5 6 7 8 9 10 11 12 13 14 15 16 PNK PNK WIRE A/C COMPRESSOR HIGH PRESSURE CUT-OFF SWITCH (REAR OF A/C COMPRESSOR) BLK WIRE BREAKOUT) BRN WIRE BRN/WHT WIRE DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE ENG BAT FUSE 10 ENGINE COOLANT TEMPERATURE (ECT) SENSOR (TOP FRONT OF ENGINE) FROM ECT SENSOR BREAKOUT) FROM TPS BREAKOUT) FUEL GAUGE FUEL PUMP SWITCH, ENGINE OIL PRESSURE GAUGE SENSOR (TOP LEFT REAR OF ENGINE) FUEL SENDER, FUEL PUMP (TOP OF FUEL TANK) GAUGES FUSE 8 GRY WIRE HOT AT ALL TIMES HOT IN RUN, START I/P FUSE BLOCK (DASH PANEL PROVIDED BY BODY BUILDER) (BODY BUILDER INSTALLED) INSTRUMENT CLUSTER LT BLU/WHT WIRE LT GRN WIRE MALFUNCTION INDICATOR LAMP MANIFOLD ABSOLUTE PRESSURE (MAP) SENSOR (TOP REAR OF ENGINE) MAP REF LO MASS AIR FLOW SENSOR (MAF) (MOUNTED IN FRESH AIR INTAKE, BEHIND AIR FILTER BOX) NCA WIRE OIL PRESS GAUGE ORG/ WIRE PNK PNK PNK 2 3 4 5 WIRE PNK PNK WIRE PNK WIRE PPL RED WIRE RED/BLK WIRE REF LO TEMP REF THROTTLE POSITION (TP) SENSOR (ON THROTTLE BODY, TOP OF ENGINE) SENSOR BREAKOUT) SPEEDO- METER TACHO- METER TAN WIRE WHT WIRE YEL WIRE

18 19 PNK WIRE A/C COMPRESSOR CLUTCH RELAY (RIGHT SIDE OF DRIVER'S ISLAND) A/C HIGH PRESSURE CUT-OFF SWITCH (ON REAR OF THE A/C COMPRESSOR) BLK WIRE BLU WIRE BRN WIRE BRN/WHT WIRE DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/WHT WIRE ECM B FUSE 6 ENG BAT FUSE 10 FUEL LIFT PUMP (INSIDE RIGHT FRAME RAIL, AHEAD OF FUEL TANK) FUEL PUMP PRIME CONNECTOR FUEL PUMP RELAY (IN UNDERHOOD FUSE/RELAY CENTER) FUEL PUMP SWITCH AND ENGINE OIL PRESSURE GAUGE SWITCH (LEFT REAR OF ENGINE) GAUGES FUSE 8 GRN WIRE GRY WIRE HOT AT ALL TIMES HOT IN RUN AND START I/P FUSE BLOCK INDICATOR INSTRUMENT CLUSTER LT GRN WIRE MALFUNCTION INDICATOR LAMP (MIL) NCA WIRE OIL PRESS GAUGE ORG/ WIRE PNK PNK WIRE PNK WIRE RED WIRE SERVICE THROTTLE SOON INDICATOR SPEED METER TAN WIRE WAIT TO WATER IN FUEL INDICATOR WATER IN-FUEL INPUT WHT WIRE WHT/BLK WIRE YEL WIRE YEL/BLK WIRE

A/T A/T M/T BLK WIRE BLK/WHT WIRE BLU WIRE BRN (OR LT BLU) WIRE BRN WIRE BRN/WHT WIRE DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/WHT WIRE ECM-BAT FUSE 6 ENG BAT FUSE 10 FUEL HEATER (PART OF FUEL/WATER SEPARATOR) FUEL LIFT PUMP (INSIDE RIGHT FRAME RAIL) FUEL PUMP PRIME CONNECTOR (TAPED TO FUEL PUMP RELAY BREAKOUT) FUEL PUMP RELAY (ON ENGINE FIREWALL RELAY BRACKET, UNDER BATTERY JUNCTION BLOCK) GAUGES FUSE 8 GRN WIRE GRY WIRE HOT AT ALL TIMES HOT IN RUN AND START I/P FUSE BLOCK INDICATOR INSTRUMENT CLUSTER LT BLU WIRE LT GRN WIRE M/T MALFUNCTION INDICATOR LAMP (MIL) ORG/ WIRE PNK FEDERAL WIRE PNK PNK WIRE PNK WIRE RED WIRE SERVICE THROTTLE SOON INDICATOR SPEED METER TAN WIRE WAIT TO WASTEGATE SOLENOID (TOP LEFT REAR OF ENG) WATER IN FUEL INDICATOR WHT WIRE WHT/BLK WIRE YEL WIRE YEL/BLK WIRE

A/C COMPRESSOR HIGH PRESSURE CUT-OFF SWITCH (ON REAR OF A/C COMPRESSOR) BLK WIRE BREAKOUT FOR CRUISE CONTROL MODULE, TOWARD RELAYS) BRN WIRE BRN/WHT WIRE DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE ENG BAT FUSE 10 ENGINE COOLANT TEMPERATURE SENSOR (ON TOP FRONT OF ENGINE) FUEL GAUGE FUEL PUMP AND FUEL TANK SENDER (ON TOP OF FUEL TANK) FUEL PUMP/ OIL PRESSURE SWITCH (ON TOP LEFT REAR OF ENGINE) GAUGES FUSE 8 GRY WIRE HOT AT ALL TIMES HOT IN RUN AND START I/P FUSE BLOCK INSTRUMENT CLUSTER LT BLU/WHT WIRE LT GRN WIRE MALFUNCTION INDICATOR LAMP (MIL) "SERVICE ENGINE SOON" MANIFOLD ABSOLUTE PRESSURE (MAP) SENSOR (TOP CENTER FRONT OF ENGINE) MASS AIR FLOW SENSOR (RIGHT FRONT OF ENGINE COMP, ON AIR INTAKE ASSEMBLY) NCA WIRE OIL PRESS GAUGE ORG/ WIRE PNK 22 23 WIRE PNK PNK 2 3 WIRE PNK PNK WIRE PNK WIRE PPL PPL PNK 9 10 11 12 13 14 15 WIRE RED WIRE RED/BLK WIRE SPEED METER TACH TAN WIRE THROTTLE POSITION SENSOR (ON THROTTLE BODY, TOP OF ENGINE) TRANS FUSE 17 WHT WIRE YEL WIRE