Chevrolet Forward Control P30 (1985-1999) buss bar Wiring diagrams

1-2 SHIFT SOL 1-2 SHIFT SOLENOID 2-3 SHIFT SOL 2-3 SHIFT SOLENOID 3-2 SHIFT SOL 3-2 SHIFT SOLENOID A/C COMPRESSOR RELAY, GENERATOR, TURBO CHARGER POWER VALVE A/T INPUT SPEED SENSOR (LEFT SIDE OF TRANSMISSION) A/T ISS SENS HI IN A/T ISS SENS LO IN ACCELERATOR PEDAL POSITION MODULE (ATTACHED TO ACCELERATOR PEDAL) APP 1 SIGNAL IN APP 2 SIGNAL IN APP 3 SIGNAL IN AUTOMATIC TRANSMISSION BATTERY IN BLK WIRE BLK/WHT WIRE BRAKE SWITCH IN BRN WIRE BRN/WHT WIRE BUSS BAR CLASS II DATA DATA LINK CONNECTOR (PARTIAL) (BELOW DASH, NEAR STEERING COLUMN) DK BLU WIRE DK BLU/WHT WIRE DK GRN/WHT WIRE ECM 1 FUSE 12 ECM-BAT FUSE 6 ECT SENSOR IN ELECTRONIC BRAKE CONTROL MODULE ENGINE COOLANT TEMPERATURE SENSOR (TOP FRONT OF ENGINE) FUEL PUMP RELAY, FUEL PUMP SWITCH/ENGINE OIL PRESSURE INDICATOR SENSOR GAUGES FUSE 8 GRY WIRE HAZARD LAMPS FLASHER (ABOVE STEERING COLUMN) HOT AT ALL TIMES HOT IN RUN HOT IN RUN OR START I-3 FUSE 9 I/P FUSE BLOCK IGNITION IN INSTRUMENT CLUSTER LT BLU WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/BLK WIRE MIL CONTROL ORG/ WIRE PCM GROUND PCS SOL HI OUT PCS SOL LO OUT PNK INSTRUMENT CLUSTER WIRE PNK WIRE POWERTRAIN CONTROL MODULE (LEFT SIDE OF DRIVER'S ISLAND) PPL PPL/WHT WIRE PRESS CTRL SOLENOID RED WIRE RED/BLK WIRE SENSOR GROUND SERVICE ENGINE SOON INDICATOR STOP-HAZ FUSE 11 STOPLAMP SWITCH IN TFT SENSOR IN TORQUE CONVERTER CLUTCH BRAKE, STOPLAMP SWITCH TRANS FLUID TEMP SENSOR TRANS RANGE "A" TRANS RANGE "B" TRANS RANGE "C" TRANS RANGE PRESSURE SWITCH ASSEMBLY TRANSMISSION FUSE 17 TWISTED WIRE PAIR VEHICLE SPEED SENSOR (LEFT REAR OF TRANSMISSION) VEHICLE SPEED SENSOR CALIBRATOR (ABOVE ACCELERATOR PEDAL) VEHICLE SPEED SENSOR CALIBRATOR, ENGINE SHUTOFF SOLENOID VSS HI IN VSS LO IN VSS OUT YEL WIRE YEL/BLK WIRE

1-2 SHIFT SOL 1-2 SHIFT SOLENOID 2-3 SHIFT SOL 2-3 SHIFT SOLENOID 3-2 SHIFT SOL 3-2 SHIFT SOLENOID A/C COMPRESSOR RELAY, GENERATOR PNK WIRE A/T INPUT SPEED SENSOR (LEFT SIDE OF TRANSMISSION) A/T ISS SENS HI IN A/T ISS SENS LO IN APP 1 SIGNAL IN APP 2 SIGNAL IN APP 3 SIGNAL IN AUTOMATIC TRANSMISSION BATTERY IN BLK WIRE BLK/WHT WIRE BRAKE SWITCH IN BRN WIRE BRN/WHT WIRE BUSS BAR CLASS II DATA DATA LINK CONNECTOR (PARTIAL) (BELOW DASH, NEAR STEERING COLUMN) DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/WHT WIRE ECM 1 FUSE 12 ECM-BAT FUSE 6 ECT SENSOR IN ELECTRONIC BRAKE CONTROL MODULE ENGINE COOLANT TEMPERATURE SENSOR (TOP FRONT OF ENGINE) FUEL PUMP RELAY, ENGINE OIL PRESSURE INDICATOR SENSOR GAUGES FUSE 8 GRY WIRE HAZARD LAMPS FLASHER (ABOVE STEERING COLUMN) HOT AT ALL TIMES HOT IN RUN HOT IN RUN OR START I-3 FUSE 9 I/P FUSE BLOCK IGNITION IN INSTRUMENT CLUSTER LT BLU WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/BLK WIRE MIL CONTROL ORG/ WIRE PCM GROUND PCS SOL HI OUT PCS SOL LO OUT PNK WIRE POWERTRAIN CONTROL MODULE (LEFT SIDE OF DRIVER'S ISLAND) PPL PPL/WHT WIRE PRESS CTRL SOLENOID RED WIRE RED/BLK WIRE SENSOR GROUND SERVICE ENGINE SOON INDICATOR STOP-HAZ FUSE 11 STOPLAMP SWITCH IN TFT SENSOR IN TORQUE CONVERTER CLUTCH, STOPLAMP SWITCH TRANS FLUID TEMP SENSOR TRANS RANGE "A" TRANS RANGE "B" TRANS RANGE "C" TRANS RANGE PRESSURE SWITCH ASSEMBLY TRANSMISSION FUSE 17 TWISTED WIRE PAIR VEHICLE SPEED SENSOR (LEFT REAR OF TRANSMISSION) VEHICLE SPEED SENSOR BUFFER VEHICLE SPEED SENSOR BUFFER (ABOVE ACCELERATOR PEDAL) VSS HI IN VSS LO IN VSS OUT YEL WIRE YEL/BLK WIRE

2-3 SHIFT SOL A/T INPUT SPEED SENSOR (LEFT SIDE OF TRANSMISSION) ANTI-LOCK BRAKES AUTOMATIC TRANSMISSION BLK WIRE BRN WIRE BRN/WHT WIRE BUSS BAR CRUISE CONTROL SYSTEMS DASH FUSE BLOCK DATA LINK CONNECTOR (PARTIAL) (BELOW DASH, NEAR STEERING COLUMN) DK BLU WIRE DK BLU/WHT WIRE ECM BAT FUSE ECM I FUSE ENGINE CONTROLS SYSTEMS ENGINE COOLANT TEMPERATURE SENSOR (TOP FRONT OF ENGINE) FUEL INJECTORS (ENGINE CONTROLS) FUEL PUMP RELAY GAUGES FUSE GRY WIRE GRY/RED WIRE HOT AT ALL TIMES HOT IN HOT IN RUN OR START HOT IN RUN, BULB TEST OR START I-3 FUSE INSTRUMENT CLUSTER LT BLU/WHT WIRE LT GRN WIRE LT GRN/BLK WIRE ORG/ WIRE PNK IGNITION FEED WIRE PNK WIRE POWERTRAIN CONTROL MODULE (LEFT SIDE OF DASH) PPL PPL PNK WIRE PPL/WHT WIRE PRESSURE CONTROL SOL RANGE MODE SELECTOR RED WIRE RED/BLK WIRE RUN WIRE SERVICE ENGINE SOON INDICATOR STOP LAMPS, TORQUE CONVERTER BRAKE SWITCH SWITCH TAN WIRE TCC PWM SOL 1-2 SHIFT SOL THROTTLE POSITION SENSOR (ON SIDE OF THROTTLE BODY) TRANS FLUID TEMP SENSOR TRANS FUSE VEHICLE SPEED SENSOR (LEFT REAR SIDE OF TRANSMISSION) VEHICLE SPEED SENSOR BUFFER (ABOVE ACCELERATOR PEDAL) WHT/BLK WIRE YEL WIRE YEL/BLK WIRE

7.4L 7.4L VIN J 6.5L VIN F A/C COMPRESSOR RELAY FAN CONTROL RELAY ALTERNATOR BATTERY BATTERY JUNCTION BLOCK (ON FORWARD LEFT SIDE OF THE BULKHEAD) BLK WIRE BLU WIRE BUSS BAR CONNECTOR FOR DOME LAMP DATA LINK CONNECTOR DIESEL ECM-BAT FUSE 6 ELECTRONIC BRAKE CONTROL MODULE ENG BAT FUSE 10 FAN CONTROL RELAY GLOW PLUG CONTROLLER FUEL PUMP RELAY FUSIBLE LINK FUSIBLE LINK (10 GA- FUSIBLE LINK (10 GA-RUST) FUSIBLE LINK (14 GA- FUSIBLE LINK (16 GA- FUSIBLE LINK (18 GA. FUSIBLE LINK (12 GA. GRY WIRE HAZARD FLASHER HEADLAMPS SWITCH HEADLAMPS SWITCH STOPLAMP SWITCH HORN DM FUSE 3 HORN RELAY I/P FUSE BLOCK (MOUNTED ON THE DASH) IGNITION SWITCH (DIAGRAM 2 OF 4) ORG/ WIRE PARK BRAKE PUMP MOTOR RELAY POWERTRAIN CONTROL MODULE VEHICLE CONTROL MODULE PWR CIRCUIT BREAKER 2 RED WIRE SEATBELT AND LAMPS ALARM MODULE SECONDARY BATTERY (DIESEL ONLY) STARTER MOTOR STARTER RELAY STOP-HAZ FUSE 11 TAIL LAMPS FUSE 7

1996 VFTC 6.5L VIN F 6.5L VIN F 7.4L VIN J 7.4L VIN J (L29), 6.5L VIN F (L65) ENGINES ONLY 7.4L VIN N A/C COMPRESSOR CONTROL RELAY BATTERY BATTERY JUNCTION BLOCK (ON FORWARD LEFT SIDE OF THE BULKHEAD) BLANK FUSE BLK WIRE BUSS BAR DATA LINK CONNECTOR (DLC) DIESEL ONLY DOME LAMP ENG-BAT FUSE FAN CONTROL RELAY FUEL PUMP RELAY FUSIBLE LINK (10 GA-RUST) FUSIBLE LINK (14 GA- FUSIBLE LINK (16 GA- FUSIBLE LINK 12 GA. BLUE FUSIBLE LINK 18 GA. BLUE GENERATOR (ON RIGHT FRONT OF ENGINE) GLOW PLUG CONTROL RELAY HAZARD LAMPS FLASHER HEADLAMPS SWITCH HORN RELAY HORN- DM FUSE I/P FUSE BLOCK (MOUNTED ON THE I/P) IGNITION SWITCH ONLY ORG/ WIRE POWERTRAIN CONTROL MODULE (PCM) POWERTRAIN CONTROL MODULE (PCM) VEHICLE CONTROL MODULE (VCM) PWR CIRCUIT BREAKER RED WIRE SEAT BELTS/ LAMPS ALARM MODULE SECONDARY BATTERY (DIESEL ONLY) STARTER MOTOR (ON RIGHT REAR SIDE OF ENGINE) STARTER RELAY STOP- HAZ FUSE ECM- BAT FUSE TAIL LAMPS FUSE TO HEADLAMPS SWITCH (CAVITY E) TORQUE CONVERTER CLUTCH (TCC), STOPLAMPS SWITCH

1996 VFTC 7.4L VIN J ENGINE 7.4L VIN J ENGINES A/C COMPRESSOR RELAY GENERATOR AUX CIRCUIT BREAKER 13 BRN WIRE BUSS BAR CANADIAN MODELS CRUISE CONTROL MODULE CRUISE CONTROL SWITCH DAYTIME RUNNING LAMP RELAY DK GRN WIRE ELECTRONIC BRAKE CONTROL MODULE FROM ENG-1 FUSE (DIAGRAM 2 OF 4) FROM IGNITION SWITCH (DIAGRAM 2 OF 4) GAUGES FUSE 8 GRY WIRE HTR FUSE 1 I-3 FUSE 9 I/P FUSE BLOCK (MOUNTED ON THE DASH) INSTR LPS FUSE 16 INSTRUMENT CLUSTER INTERIOR LIGHTS SYSTEM (INSTRUMENT PANEL DIMMER SWITCH) NCA WIRE ORG/ WIRE PNK PNK WIRE PNK WIRE SEATBELT/ LAMPS ALARM MODULE DAYTIME RUNNING LAMP CONTROL MODULE TO ECM 1 FUSE DIAGRAM 3 OF 4) TORQUE CONVERTER CLUTCH AND STOP LAMPS SWITCH TURN B/U FUSE 5 TURN SIGNAL FLASHER VEHICLE CONTROL MODULE WIPER MOTOR BREAKOUT) PNK WIRE

1996 VFTC 6.5L VIN F PNK ONLY WIRE 7.4L VIN J (L29), 6.5L VIN F (L65) ENGINES 7.4L VIN J, 6.5L VIN F (L65) ENGINES ONLY PNK WIRE 7.4L VIN N A/C COMPRESSOR CONTROL RELAY AUTO APPLY PARK BRAKE SWITCH AUX CIRCUIT BREAKER BACKUP LAMP SWITCH BRN WIRE BUSS BAR CANADIAN MODELS CAVITY A) CRUISE CONTROL MODULE DAYTIME RUNNING LAMPS MODULE DAYTIME RUNNING LAMPS RELAY ENGINE FROM IGNITION SWITCH GAUGES FUSE GENERATOR HOT IN RUN, START HTR FUSE I-3 FUSE I/P AUXILIARY FUSE BLOCK (MOUNTED ON THE I/P FUSE BLOCK) AUTO APPLY FUSE I/P FUSE BLOCK (MOUNTED ON THE I/P) INSTRUMENT CLUSTER NCA WIRE ORG/ WIRE PARK BRAKE LOW PRESSURE SWITCH PARK/NEUTRAL POSITION (PNP), BACKUP LAMP SWITCH PNK PNK WIRE PNK WIRE PPL SEATBELTS/ LAMPS ALARM MODULE SPEED CONTROL SWITCH TORQUE CONVERTER CLUTCH, STOPLAMPS SWITCH TURBO CHARGER POWER VALVE SOLENOID TURN SIGNAL FLASHER TURN SIGNAL SWITCH TURN-B/U FUSE VEHICLE CONTROL MODULE (VCM)