Chevrolet Forward Control P30 (1985-1999) blk/red Wiring diagrams

ACC RADIO FUSE ACCY ACCY BULB TEST LOCK ACCY BULB TEST LOCK OFF AUTO APPLY PARK BRAKE AUX CB AUX CIRCUIT BREAKER HTR FUSE AUXILIARY COOLING FAN RELAY AUXILIARY COOLING FAN RELAY DAYTIME RUNNING LAMPS BATTERY BATTERY JUNCTION BLOCK BLK WIRE BLK/RED WIRE BRAKE WARNING ALARM BUZZER BRN WIRE BULB TEST DAYTIME RUNNING LAMPS RELAY DAYTIME RUNNING LAMPS MODULE DK GRN WIRE FROM PANEL DIMMER SWITCH ASSEMBLY (INTERIOR LIGHTS SYSTEM) FUEL PUMP RELAY FUEL PUMP OIL PRESSURE SWITCH HAZARD FLASHER FUSE BLOCK FUSIBLE FUSIBLE LINK GENERATOR GRY WIRE HEADLIGHT SWITCH HORN RELAY HORN/DM I/P CLUSTER BRAKE PRESSURE WARNING SWITCH IGNITION SWITCH INSTRUMENT CLUSTER LINK LOCK OFF LPS BUS GAGES FUSE INSTR-LPS FUSE OFF ORG/ WIRE PARK BRAKE WARNING SWITCH PCM PNK WIRE PNK/ WHT WIRE PNK/BLK WIRE PNK/WHT WIRE POWERTRAIN CONTROL MODULE PPL PWR ECM-BAT CIRCUIT BREAKER FUSE RED WIRE RELAY RUN WIRE SHUNT STARTER MOTOR STOP- HZ FUSE STOPLAMP SWITCH TAIL LPS FUSE FUSE TAN/WHT WIRE TO ALT, ECM-CRNK, TURN-B/U, TRANS, INJ FUSES AND IGNITION COIL TRANSMISSION POSITION INDICATOR LAMP WHT WIRE WINDSHIELD WIPER MOTOR WIPER SWITCH MODULE WIPER FUSE YEL WIRE

3 121 PNK WIRE 4.3L AND 7.4L 5.7L ACCY ALT FUSE BLK WIRE BLK/RED WIRE BLK/YEL WIRE BRN WIRE BRN/WHT WIRE BULB TEST DISTRIBUTOR (CENTER REAR OF ENGINE) DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE ENGINE COOLANT TEMPERATURE SENSOR (TOP FRONT OF ENGINE) FUSE BLOCK GRY WIRE HOT AT ALL TIMES HOT IN RUN, BULB TEST OR START IDLE SPEED ACTUATOR CONTROL SOLENOID (NO LOCATION AVAILABLE) IGNITION COIL (TOP RIGHT REAR OF ENGINE) IGNITION SWITCH INSTRUMENT CLUSTER KNOCK SENSOR (LEFT REAR OF ENGINE, NEAR OIL PRESSURE SENDER) KNOCK SENSOR MODULE (TOP RIGHT SIDE OF ENGINE) LOCK OFF LT BLU/WHT WIRE LT GRN WIRE MALFUNCTION (SERVICE ENGINE SOON) INDICATOR MANIFOLD ABSOLUTE PRESSURE SENSOR (ABOVE VALVE COVER) NCA WIRE ORG/ WIRE PNK 26 27 WIRE PNK WIRE PNK/BLK WIRE PPL PPL 2 3 4 PPL 24 25 PPL/WHT WIRE PROVISIONS FOR TACHOMETER RED WIRE RED/BLK WIRE RUN WIRE TAN/BLK WIRE TCC/BRAKE SWITCH (ON BRAKE PEDAL SUPPORT BRACKET) THROTTLE POSITION SENSOR (ON THROTTLE BODY) TRANS FUSE WHT WIRE WHT/BLK WIRE YEL WIRE YEL/BLK WIRE

5.7L 7.4L 7.4L ONLY AIR CONDITION- ING SYSTEM BLK WIRE BLK/RED WIRE BLK/WHT WIRE BLK/YEL WIRE BRN WIRE BRN/WHT WIRE DIAGNOSTIC TEST TP SENSOR SIGNAL INJECTOR 1 CONTROL DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/WHT WIRE DK GRN/YEL WIRE ECM BAT FUSE ECM I FUSE ECT SIGNAL EGR CONTROL EVAPORATIVE CANISTER PURGE CONTROL SOLENOID (TOP RIGHT SIDE OF ENGINE) EXHAUST GAS RECIRCULATION VALVE SOLENOID (TOP RIGHT SIDE OF ENGINE) FUEL PUMP RELAY CTRL PCS LOW FUEL PUMP SIGNAL MAP SIGNAL FUSE BLOCK GRY WIRE GRY/RED WIRE HOT AT ALL TIMES HOT IN RUN, BULB TEST OR START IC BYPASS SENSOR GROUND SENSOR GROUND TFT SIGNAL 470 455 PPL IDLE AIR CONTROL ACTUATOR (TOP REAR OF ENGINE) IDLE SPEED ACTUATOR CONTROL SOLENOID (NO LOCATION AVAILABLE) KNOCK SIGNAL EGR PINTLE POSITION SIGNAL LINEAR EGR VACUUM REGULATOR SOLENOID VALVE (TOP FRONT OF ENGINE) LT BLU/BLK WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/WHT WIRE NCA WIRE ORG/ WIRE OXYGEN SENSOR (IN EXHAUST MANIFOLD) OXYGEN SENSOR GROUND PNK 22 23 WIRE PNK RANGE SIGNAL A INPUT SPEED SIGNAL HIGH INPUT SPEED SIGNAL LOW WIRE PNK/BLK WIRE POWERTRAIN CONTROL MODULE (LEFT SIDE OF SHIPPING PANEL) PPL PPL 20 21 PPL/WHT WIRE RANGE SIGNAL B RANGE SIGNAL C MIL CONTROL RED WIRE RED/BLK WIRE TAN WIRE TAN/BLK WIRE TAN/WHT WIRE THROTTLE BODY FUEL INJECTOR #1 (TOP OF THROTTLE BODY UNIT) THROTTLE BODY FUEL INJECTOR #2 (TOP OF THROTTLE BODY UNIT) TRANSMISSION INPUT SPEED SENSOR (LEFT SIDE OF TRANSMISSION) WHT WIRE WHT/BLK WIRE YEL WIRE YEL/BLK WIRE

3 121 PNK WIRE ACCY BLK WIRE BLK/RED WIRE BLK/YEL WIRE BRN WIRE BRN/WHT WIRE BULB TEST DISTRIBUTOR (CENTER REAR OF ENGINE) DK BLU WIRE DK GRN/WHT WIRE ENGINE COOLANT TEMPERATURE SENSOR (TOP FRONT OF ENGINE) FUSE BLOCK GAGES FUSE GRY WIRE HOT AT ALL TIMES HOT IN RUN, BULB TEST OR START IGNITION COIL (TOP RIGHT REAR OF ENGINE) IGNITION SWITCH INSTRUMENT CLUSTER KNOCK SENSOR (LEFT REAR OF ENGINE, NEAR OIL PRESSURE SENDER) LOCK OFF LT BLU/WHT WIRE LT GRN WIRE MALFUNCTION (SERVICE ENGINE SOON) INDICATOR MANIFOLD ABSOLUTE PRESSURE SENSOR (ABOVE VALVE COVER) NCA WIRE ORG/ WIRE PNK 22 23 WIRE PNK WIRE PNK/BLK WIRE PPL PPL 20 21 PPL 3 4 PPL/WHT WIRE PROVISIONS FOR TACHOMETER RED WIRE RED/BLK WIRE RUN WIRE TAN/BLK WIRE TCC/BRAKE SWITCH (ON BRAKE PEDAL SUPPORT BRACKET) THROTTLE POSITION SENSOR (ON THROTTLE BODY) TRANS FUSE WHT WIRE WHT/BLK WIRE YEL WIRE YEL/BLK WIRE

1223 1222 SHIFT SOL B OUT SHIFT SOL A OUT HIGH IDLE SW OUT 3-2 CTRL OUT 1225 1226 419 RANGE MODE SEL B RANGE MODE SEL C SERV ENG SOON IND CTRL 465 1229 FUEL PMP RLY CTRL FORCE MOTOR HI 470 OR 452 496 1456 KNOCK SENS INPUT EGR INPUT A/T INPUT SPEED SENSOR (ON AUTO TRANSMISSION LEFT CENTER) BLK WIRE BLK/RED WIRE BLK/WHT WIRE BLU WIRE BREAKOUT FOR ENGINE COOLANT FAN MOTOR) BRN WIRE BRN/WHT WIRE BYPASS 5 VOLTS SENS GROUND SENS GROUND TRANS TEMP INPUT DIAG ENABLE-POWERTRAIN TP SENS IN DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/WHT WIRE ECT SENS INPUT EGR SOL OUT ELECTRONIC 4-SPD AUTOMATIC OVERDRIVE TRANSMISSION EVAPORATIVE CANISTER PURGE SOLENOID (TOP LEFT CENTER OF INTAKE MANIFOLD) FUEL INJ CTRL GRN WIRE GRY WIRE HOT IN RUN, START (CRANK) I/P FUSE BLOCK (MOUNTED ON THE I/P) IDLE AIR CONTROL VALVE MOTOR (ON LEFT SIDE OF THROTTLE BODY INTAKE) KNOCK SENSOR (KS) (ON RIGHT SIDE OF ENGINE BLOCK AHEAD OF STARTER) LT BLU/BLK WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/WHT WIRE LT LT LT PNK PNK WIRE OIL PRESS INPUT MAP SENS INPUT ORG/ WIRE OXYGEN SENSOR (IN EXHAUST STREAM AHEAD OF MUFFLER) PCM GROUND PNK IGNITION CAN PURGE SOL OUT WIRE PNK PNK 26 27 WIRE PNK WIRE POWERTRAIN CONTROL MODULE (PCM) (ON LEFT SIDE OF DRIVER'S ISLAND) PPL PPL 16 17 18 19 PPL 420 474 BRAKE SW INPUT PPL/WHT WIRE RANGE MODE SELECTOR RED WIRE RED/BLK WIRE SHIFT SOL. SHIFT SOL. SHIFT SOL. SHIFT SOL. FORCE MOTOR TAN WIRE TAN/BLK WIRE TRANS FUSE TRANS TEMP WHT WIRE WHT/BLK WIRE YEL WIRE YEL/BLK WIRE

4 7 8 9 11 12 13 15 VSS OUT VSS RETURN GROUND BLK WIRE BLK/RED WIRE BREAKOUT FOR ENGINE COOLANT FAN MOTOR, TOWARD CRUISE CONTROL MODULE) BRN WIRE BRN/WHT WIRE CONTACT CRUISE CONTROL MODULE (ON RADIATOR SUPPORT BRACKET) DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE ECM BAT FUSE ENG 1 FUSE ENGINE COOLANT TEMPERATURE SENSOR (FRONT, CENTER OF ENGINE COOLANT INTAKE) FROM BREAKOUT FOR CRUISE CONTROL MODULE, TOWARD ENG) FROM BREAKOUT FOR GENERATOR) GRY WIRE HOT AT ALL TIMES HOT IN RUN HOT IN RUN, START (CRANK) I-3 FUSE I/P FUSE BLOCK (MOUNTED ON THE I/P) IDLE SPEED CONTROL ACTUATOR (ON THROTTLE BODY) LEFT BULK- HEAD GROMMET UNDER I/P) LINEAR EGR SOLENOID VALVE (NO COMPONENT LOCATION AVAILABLE) LT GRN WIRE LT GRN/BLK WIRE ORG/ WIRE PNK 9 10 11 12 13 14 15 16 WIRE PNK PNK 1 2 3 4 5 WIRE PNK PNK 26 27 WIRE PNK WIRE PPL PPL 16 17 18 19 PPL TCC/STOPLAMP INPUT PPL/WHT WIRE RED WIRE TAN WIRE TAN/BLK WIRE THROTTLE POSITION SENSOR (ON LEFT SIDE OF THROTTLE BODY) VEHICLE SPEED SENSOR (ON LEFT REAR SIDE OF TRANSMISSION) VEHICLE SPEED SENSOR BUFFER (ON DRIVER'S ISLAND SUPPORT ABOVE ACCELERATOR PEDAL) VSS VSS LO VSS SIG VSS HI SECOND. VSS WHT WIRE YEL WIRE

BATTERY JUNCTION BLOCK (ON FORWARD LEFT SIDE OF BULKHEAD) BLK WIRE BLK/RED WIRE BRN WIRE BRN/WHT WIRE BYPASS DIST. REF HI DIST. REF LO DISTRIBUTOR DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE ECM 1 FUSE FUEL GAUGE FUEL PUMP PRIME CONNECTOR FUEL PUMP RELAY (AT RELAY CENTER RIGHT SIDE OF MAIN SUPPORT AT DRIVER'S ISLAND) FUEL PUMP, SENDER (ON TOP OF FUEL TANK) FUSIBLE LINK (16 GA- GAUGES FUSE GRY WIRE HIGH VOLTAGE IGNITION COIL WIRE HOT AT ALL TIMES HOT IN RUN, START (CRANK) I/P FUSE BLOCK (MOUNTED ON THE I/P) IGNITION COIL (ON BRACKET AT REAR OF INTAKE PLENUM) IGNITION MODULE IGNITION SWITCH INSTRUMENT CLUSTER LOCK OFF OIL PRESS GAUGE ORG/ WIRE PICKUP COIL PNK 9 10 11 12 13 14 15 16 WIRE PNK PNK 1 2 3 4 5 WIRE PNK WIRE PPL PPL/WHT WIRE RED WIRE RUN WIRE SERVICE ENGINE SOON INDICATOR SPEED METER TACHOMETER TEST LEAD TAN WIRE TAN/BLK WIRE THROTTLE BODY FUEL INJECTOR NO.1 (ON TOP OF INTAKE MANIFOLD) THROTTLE BODY FUEL INJECTOR NO.2 (ON TOP OF INTAKE MANIFOLD) WHT WIRE