Chevrolet Forward Control P30 (1985-1999) blk Wiring diagrams

AUTO APPLY FUSE 19 BLK WIRE BRAKE/TRANSMISSION SHIFT INTERLOCK (BTSI) SOLENOID (ON STEERING COLUMN) BRN WIRE DK GRN/WHT WIRE ELECTRONIC BRAKE CONTROL MODULE (BELOW RADIATOR ON CROSSMEMBER) HOT IN RUN HOT IN RUN AND START I-3 FUSE 9 I/P FUSE BLOCK PARK/NEUTRAL POSITION AND BACKUP LAMPS SWITCH (LEFT OF TRANS) PNK WIRE PPL TO BODY BUILDER HARNESS TORQUE CONVERTER CLUTCH AND STOP LAMPS SWITCH (AT BRAKE PEDAL SUPPORT) YEL WIRE

ACCY BATTERY BATTERY JUNCTION BLOCK (LEFT REAR OF ENGINE COMPT) BLK (OR WIRE BLK WIRE BULB TEST CHARGING CIRCUIT DIESEL DK BLU WIRE ENGINE CONTROLS (GLOW PLUGS) FUSIBLE LINK (16 GA- FUSIBLE LINK (16 GA- FUSIBLE LINK (10 GA- RUST) GAS GRY WIRE HOLD- IN COIL I/P FUSE BLOCK (BEHIND DASH PANEL) CRANK FUSE 18 IGNITION SWITCH LOCK M/T A/T OFF PPL PPL DIESEL PPL PPL PPL PPL (ENGINE HARN, NEAR LEFT FIREWALL GROMMET) PULL- IN COIL RED WIRE RUN WIRE SECONDARY BATTERY (DIESEL) STARTER MOTOR STARTER RELAY (ON ENGINE FIREWALL RELAY BRACKET) STARTER SOLENOID WHT WIRE YEL WIRE

1226 1225 TR SWITCH C TR SWITCH B TR SWITCH A 27 28 29 30 31 PPL A/C SYSTEM ANTILOCK BRAKES SYSTEM AUTOMATIC TRANSMISSION BATTERY BLK WIRE BLK/WHT WIRE BLU WIRE BLU/WHT WIRE BRN (OR LT BLU) WIRE BRN WIRE BRN/WHT WIRE CLOSURE SIGNAL BOOST SENSOR SIG PRESS CTRL SOL VLV LO DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/WHT WIRE DK PNK/ PNK WIRE ECT SIGNAL GRN WIRE GRY WIRE GRY/BLK WIRE LT BLU WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/WHT WIRE ORG/ WIRE ORG/BLK WIRE PNK PNK PPL 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 WIRE PNK WIRE PNK/BLK WIRE POWERTRAIN CONTROL MODULE (PCM) (LEFT SIDE OF DRIVER'S ISLAND ON RELAY BRACKET) PPL PPL CKP SEN GRD A/C REQUEST SIG PPL TCC/ABS BRAKE SW STOPLAMP SWITCH CRIUSE SET/COAST SIG 20 84 PPL/WHT WIRE PRESSURE CONTROL SOLENOID VALVE RANGE MODE SELECTOR RED WIRE RED/BLK WIRE RESUME SENSOR GND SET- SOLENOID VALVE 1-2 SHIFT SOLENOID VALVE 2-3 SHIFT SOLENOID VALVE TCC PWM SOLID STATE SPEED CONTROL SWITCH TAN WIRE TAN/BLK WIRE TIMING STEPPER MTR (LOW) TIMING STEPPER MTR (LOW) TOWARD BREAKOUT FOR GRNERATOR CONNECTOR) TRANSMISSION OUTPUT SPEED SENSOR (LEFT SIDE OF TRANS- MISSION, NEAR THE MIDDLE) TRANSMISSION SPEED INPUT TRANSMISSION TEMPERATURE SENSOR WHT WIRE WHT/BLK WIRE YEL WIRE YEL/BLK WIRE

27 28 29 30 31 PPL 5 VOLT REF ACCELERATOR PEDAL POSITION MODULE (ATTACHED TO ACCELERATOR PEDAL) APP 1 SENSOR APP 2 SENSOR APP 3 SENSOR BLK WIRE BLU WIRE BRN (OR LT BLU) WIRE BRN WIRE BRN/WHT WIRE CLOSURE GRD CLOSURE SIGNAL DK BLU/WHT WIRE DK GRN WIRE DK GRN/WHT WIRE ECM 1 FUSE 12 ELECTRONIC BRAKE CONTROL MODULE (BELOW RADIATOR, ON LOWER CROSSMEMBER) ENG 1 FUSE 15 ENGINE SHUTOFF SOLENOID (AT FUEL INJECTION PUMP) FUEL SOL CTRL FUEL SOL HIGH FUEL SOL LOW FUEL SOLE- NOID FUEL SOLENOID DRIVER (ON SIDE OF FUEL INJECTION PUMP) GRN WIRE GRY WIRE HAZARD LAMPS FLASHER (INNER LEFT SIDE STEERING COLUMN SUPPORT BRACKET) HIGH LOW HIGH RES SIG HOT AT ALL TIMES HOT IN HOT IN RUN OR START I-3 FUSE 9 I/P FUSE BLOCK IGNITION IGNITION TIMING STEPPER MOTOR (PART OF FUEL INJECTION PUMP) LOW HIGH LT BLU WIRE LT GRN WIRE LT PPL OPTICAL FUEL TEMPERATURE SENSOR (PART OF FUEL INJECTION PUMP ASSEMBLY) ORG/ WIRE ORG/BLK WIRE PNK PNK PPL 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 WIRE PNK WIRE PNK/BLK WIRE PPL PPL (I/P SIDE OF ENG HARN, 8 CM FROM BREAKOUT FOR TURN SIGNAL SWITCH CONNECTOR) PUMP CAM SIG RED WIRE RED/BLK WIRE RUN WIRE SENSOR GROUND STOP LAMP SWITCH (AT BRAKE PEDAL SUPPORT) STOP-HAZ FUSE 11 TAN WIRE TAN/BLK WIRE TORQUE CONVERTER CLUTCH (TCC), STOPLAMPS SWITCH (AT BRAKE PEDAL SUPPORT) TRANS FUSE 17 WHT WIRE WHT/BLK WIRE YEL WIRE YEL/BLK WIRE

BLK WIRE BLU WIRE BRN (OR LT BLU) WIRE BRN WIRE BRN/WHT WIRE DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/WHT WIRE ECM-BAT FUSE 6 ENG BAT FUSE 10 FUEL HEATER (PART OF FUEL/WATER SEPARATOR) FUEL LIFT PUMP (INSIDE RIGHT FRAME RAIL) FUEL PUMP PRIME CONNECTOR (TAPED TO FUEL PUMP RELAY BREAKOUT) FUEL PUMP RELAY (ON RIGHT SIDE OF DRIVER'S ISLAND) GAUGES FUSE 8 GRN WIRE GRY WIRE HOT AT ALL TIMES HOT IN RUN AND START I/P FUSE BLOCK INDICATOR INSTRUMENT CLUSTER LT BLU WIRE LT GRN WIRE MALFUNCTION INDICATOR LAMP (MIL) ORG/ WIRE PNK FEDERAL WIRE PNK PNK WIRE PNK WIRE RED WIRE SERVICE THROTTLE SOON INDICATOR SPEED METER TAN WIRE WAIT TO WASTEGATE SOLENOID (TOP LEFT REAR OF ENG) WATER IN FUEL INDICATOR WHT WIRE WHT/BLK WIRE YEL WIRE YEL/BLK WIRE

"SERV THROTTLE SOON" IND A/C ENABLE GROUND GROUND 451 551 A/C SYSTEM ANTILOCK BRAKES SYSTEM BATTERY BATTERY WASTEGATE SOL CTRL BLK WIRE BLK/WHT WIRE BRN WIRE BRN/WHT WIRE CALIFORNIA CALIFORNIA DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/WHT WIRE ESO CTRL FUSIBLE LINK FUSIBLE LINK (22 GA-RUST) FUSIBLE LINKS GLOW PLUG CONTROLLER (LEFT REAR OF ENG, NEAR FIREWALL) GRD IGNITION GLOW PLUG SIG RLY CTRL PNK WIRE HOT AT ALL TIMES LEFT BANK GLOW PLUGS LT BLU WIRE LT GRN WIRE NCA WIRE ORG/ WIRE PNK IGNITION RLY CTRL GRD BATTERY GLOW PLUG OUT WIRE PNK PNK 439 439 IGNITION IGNITION BATTERY MIL IND CTRL WIRE PNK PNK WIRE PNK WIRE POWERTRAIN CONTROL MODULE (PCM) (LEFT SIDE OF DRIVER'S ISLAND ON RELAY BRACKET) PPL PPL GLOW PLUG OUT GLOW PLUG OUT GLOW PLUG OUT GLOW PLUG OUT RED WIRE RIGHT BANK GLOW PLUGS TAN WIRE WHT WIRE WHT/BLK WIRE YEL WIRE YEL/BLK WIRE

2 3 PPL 2-3 SHIFT SOL CTRL ANTI-LOCK BRAKES SYSTEM BANK 2 SENSOR 1 (ON RIGHT EXHAUST DOWN PIPE, BEFORE CATALYTIC CONVERTER) BLK LT GRN/ WIRE BLK WIRE BLK/WHT WIRE BLU/BLK WIRE BRN WIRE BRN/WHT WIRE CAMSHAFT POSITION SENSOR (INTERNAL TO DISTRIBUTOR) CMP LOW FUEL GAUGE PPL DK BLU WIRE DK BLU/WHT WIRE FEED IGN GRN/BLK WIRE HEATED OXYGEN KS SIGNAL LEFT KNOCK SENSOR (ON LOWER LEFT SIDE OF ENGINE) LT BLU/ BLK WIRE LT BLU/ WHT WIRE LT BLU/BLK WIRE LT BLU/WHT WIRE LT GRN WHT/ WIRE LT GRN WIRE LT GRN/ BLK WIRE LT GRN/BLK WIRE LT GRN/WHT WIRE MAP SIGNAL IAT SIGNAL ECT SIGNAL NCA WIRE PNK 8 9 10 WIRE PNK IGN FEED SENS RTN SENS SIG WIRE PNK WIRE PNK/BLK WIRE PPL PPL CKP LOW VSS LOW VSS SIGNAL PPL PPL PPL/ WHT WIRE PPL/WHT WIRE RED/BLK WIRE RIGHT KNOCK SENSOR (ON LOWER RIGHT SIDE OF ENGINE) SENSOR RTN SIGNAL SENSOR T/P SIGNAL TAN WIRE TAN/WHT WIRE TFT SIGNAL MAF SIGNAL IAC HIGH IAC LOW INJECTOR 4 CTRL INJECTOR 3 CTRL VSS YEL WIRE YEL/BLK WIRE

2 3 PPL AUTOMATIC TRANSMISSION BANK 1 SENSOR 1 (ON LEFT EXHAUST SYSTEM DOWN PIPE, BEFORE CATALYTIC CONVERTER) BANK 1 SENSOR 2 (ON LEFT EXHAUST SYSTEM, AFTER CATALYTIC CONVERTER) BANK 2 SENSOR 2 (ON RIGHT EXHAUST SYSTEM AFTER CATALYTIC CONVERTER) BLK WIRE BLK/WHT WIRE BLU WIRE BLU/BLK WIRE BREAKOUT) BRN WIRE DK BLU WIRE DK BLU/WHT WIRE ECM 1 FUSE 12 ENG 1 FUSE 15 EXHAUST GAS RECIRCULATION VALVE SOLENOID (TOP LEFT SIDE OF ENG) FLUID TEMPERATURE SENSOR (INTERNAL) FORCE MOTOR FUEL INJ 1 FUEL INJ 2 FUEL INJ 4 FUEL INJ 5 FUEL INJ 3 FUEL INJ 6 FUEL INJ 7 FUEL INJ 8 GRN WIRE GRN/BLK WIRE GRY WIRE HEATED OXYGEN HOT IN RUN AND START I/P FUSE BLOCK IGNITION INTAKE AIR TEMP SENSOR (MOUNTED IN FRESH AIR INTAKE BEHIND AIR FILTER BOX) LT BLU/ WHT WIRE LT BLU/WHT WIRE LT GRN WIRE NCA WIRE PNK 8 9 10 WIRE PNK PNK 2 3 WIRE PNK PNK WIRE PNK WIRE PNK/BLK WIRE PPL PPL PNK 9 10 11 12 13 14 15 WIRE PPL/ WHT WIRE PPL/WHT WIRE PRESSURE PRESSURE SWITCH RED WIRE RED/BLK WIRE SOLENOID SOLENOID 1-2 SOLENOID 2-3 SWITCH TAN WIRE TAN/ WHT WIRE TAN/WHT WIRE TCC WHT PPL/ WIRE WHT WIRE YEL WIRE YEL/BLK WIRE

A/C COMPRESSOR HIGH PRESSURE CUT-OFF SWITCH (ON REAR OF A/C COMPRESSOR) BLK WIRE BREAKOUT FOR CRUISE CONTROL MODULE, TOWARD RELAYS) BRN WIRE BRN/WHT WIRE DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE ENG BAT FUSE 10 ENGINE COOLANT TEMPERATURE SENSOR (ON TOP FRONT OF ENGINE) FUEL GAUGE FUEL PUMP MODULE (ON TOP OF FUEL TANK) GAUGES FUSE 8 GRY WIRE HOT AT ALL TIMES HOT IN RUN AND START I/P FUSE BLOCK IN PCM BREAKOUT, 20 CM FROM MAIN HARNESS TOWARD FUEL PUMP RELAY) INSTRUMENT CLUSTER LT BLU/WHT WIRE LT GRN WIRE MALFUNCTION INDICATOR LAMP (MIL) "SERVICE ENGINE SOON" MANIFOLD ABSOLUTE PRESSURE (MAP) SENSOR (TOP CENTER FRONT OF ENGINE) MASS AIR FLOW SENSOR (RIGHT FRONT OF ENGINE COMP, ON AIR INTAKE ASSEMBLY) NCA WIRE ORG/ WIRE PNK 16 17 18 19 20 21 WIRE PNK 22 23 WIRE PNK PNK 2 3 WIRE PNK PNK WIRE PNK WIRE PPL PPL PNK 9 10 11 12 13 14 15 WIRE RED WIRE RED/BLK WIRE SPEED METER TACH THROTTLE POSITION SENSOR (ON THROTTLE BODY, TOP OF ENGINE) TRANS FUSE 17 WHT WIRE YEL WIRE

1 2 3 4 5 6 7 8 PNK PNK WIRE A/C COMP CYL SW A/C REQUEST SIGNAL AIR CONDITIONING SYSTEM AUX ELECT COOLING FAN BRAKE SIGNAL SERIAL DATA PPL PPL B(+) BATTERY FEED RANGE SIGNAL B RANGE SIGNAL A BLK RED/ WIRE BLK WIRE BLK/WHT WIRE BLU/WHT WIRE BRN WIRE BRN/WHT WIRE COOLING FANS SYSTEM CRUISE CONTROL MODULE (ON RADIATOR SUPPORT BRACKET) CRUISE CTRL ENGAGED CRUISE ENGAGED SIG CTRL EST CYLINDER 1 CYLINDER 4 CYLINDER 5 CYLINDER 3 CYLINDER 6 CYLINDER 7 CYLINDER 2 CYLINDER 8 DISTRIBUTOR DK BLU WIRE DK GRN WIRE DK GRN/ WHT WIRE DK GRN/WHT WIRE ECM B FUSE 6 EGR VALVE FEED EGR VLV CTRL FUEL PMP RLY CTRL 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 FUEL PUMP PRIME CONNECTOR (TAPED TO FUEL PUMP RELAY BREAKOUT) GRN WIRE GROUND GRY WIRE HIGH VOLTAGE COIL WIRE HOT AT ALL TIMES HOT IN RUN I-3 FUSE 9 I/P FUSE BLOCK IGN FEED IGNITION COIL (ON BRACKET AT REAR OF INTAKE PLENUM) IGNITION CONTROL MODULE (ON BRACKET AT REAR OF INTAKE PLENUM) LT BLU/BLK WIRE LT BLU/WHT WIRE ORG/ WIRE PCS HIGH INPUT SPEED SENS LOW INPUT SPEED SENS HIGH IC CNTRL PCS LOW VCM GROUND VCM GROUND SENS GROUND PNK 16 17 18 19 20 21 WIRE PNK 22 23 WIRE PNK IGN FEED WIRE PNK WIRE PPL PPL ANTI-LOCK BRAKES SYSTEM PPL PPL DATA LINK CONNECTOR (DLC) (BELOW DASH, NEAR STEERING COLUMN) 4 5 PPL FUEL LEVEL MODULE A/C REC PPL TCC/STOPLAMP INPUT RANGE SIGNAL "C" RED WIRE RED/BLK WIRE SENSOR GROUND SIGNAL TIMING CTRL ELEC SPK SPARK PLUGS SPEED SENSOR INPUT TCC STOPLAMP SWITCH (OPENS W/BRAKE DEPRESSED) (AT BRAKE PEDAL SUPPORT) VSS OUTPUT SIGNAL VSS OUTPUT SIGNAL CHECK ENGINE LP CTRL WHT WIRE WHT/ BLU WIRE WHT/BLK WIRE