Chevrolet Express G3500 (2013-2013) hot at all times Wiring diagrams

2 6 3 1 CAN BUS HI LO REF CAN BUS LO 32 33 34 35 36 37 38 VEHICLE SPD SIG CAN BUS HI DATA 5.3L, 4.8L, 6.0L 4.3L ABS MDL FUSE 2 ABS MTR FUSE 1 BLK WIRE BLK/PPL WIRE BRK SW FUSE 13 BRN WIRE BRN/WHT WIRE COMPUTER DATA LINES SYSTEM DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE ENGINE CONTROL MODULE (ECM) (LEFT SIDE OF ENGINE COMPT) FUSE 29 GRY WIRE GRY/BLK WIRE HI SPD GMLAN DATA + HI SPD GMLAN DATA + B+ HI SPD GMLAN DATA- HI SPD GMLAN DATA- GND HOT AT ALL TIMES HOT W/ RUN/CRNK RELAY 15 ENERGIZED IPC FUSE 10 LEFT FRONT WHEEL SPEED SENSOR (WSS) (ON INSIDE OF LEFT FRONT WHEEL) LEFT REAR WHEEL SPEED SENSOR (WSS) (AT LEFT REAR WHEEL HUB) LF WHEEL SPD SENS LOW REF LOW REF LOW REF RF WHEEL SPD SENS LT BLU WIRE LT BLU/WHT WIRE LT GRN WIRE MULTI-AXIS ACCELERATION SENSOR (ON FLOOR BETWEEN FRONT SEATS) ORG/ WIRE ORG/BLK WIRE PNK 3 4 5 WIRE PNK WIRE RADIO RED WIRE RED/BLK WIRE RED/WHT WIRE RIGHT FRONT WHEEL SPEED SENSOR (WSS) (ON INSIDE OF RIGHT FRONT WHEEL) SERIAL DATA ENABLE B+ SPD SIG VEHICLE STEERING ANGLE SENS CAN BUS LO DATA STOP LAMP SWITCH (BEHIND LEFT SIDE OF DASH, ABOVE BRAKE PEDAL) STR/WHL/ SNSR TAN WIRE TAN/BLK WIRE UNDERHOOD FUSE BLOCK (ON LEFT SIDE OF ENGINE COMPT) VEHICLE SPEED SIGNAL WHT WIRE WHT/BLK WIRE YEL WIRE

5.3L, 4.8L, 6.0L 4.3L 6.6L ABS IND. ABS MDL FUSE 2 ABS MTR FUSE 1 B+ SERIAL DATA ENABLE VEHICLE SPD SIG BLK WIRE BLK/WHT WIRE BODY CONTROL MODULE (BCM) (BEHIND LOWER RIGHT SIDE OF DASH) BRAKE BOOSTER FLUID FLOW ALARM SWITCH (IN POWER STEERING PUMP OUTLET HOSE) BRAKE FLUID LEVEL SWITCH (AT LEFT REAR OF ENGINE COMPT) BRAKE IND BRAKE PRESSURE DIFFERENTIAL SWITCH (ON BRAKE VALVE, NEAR FRONT OF EBCM) BRK FLUID LEVEL SENSOR SIG BRAKE WARNING INDICATOR CTRL BRK SW FUSE 13 COMPUTER DATA LINES SYSTEM DK GRN WIRE GND HI SPD GMLAN BUS - HI SPD GMLAN BUS - HEAVY DUTY HOT AT ALL TIMES HOT W/ RUN/CRNK RELAY 15 ENERGIZED INSTRUMENT PANEL CLUSTER (IPC) IPC FUSE 10 LEFT FRONT WHEEL SPEED SENSOR (WSS) (ON INSIDE OF LEFT FRONT WHEEL) LF WHEEL SPEED SENS LOW REF LIGHT DUTY LO SPD GMLAN LOGIC LT BLU WIRE LT BLU/BLK WIRE LT BLU/WHT WIRE OF DASH, ABOVE BRAKE PEDAL) PARK BRAKE SWITCH (UNDER LEFT PNK WIRE PPL PRK BRK SW RED/BLK WIRE RED/WHT WIRE RF WHEEL SPD SENS LOW REF RIGHT FRONT WHEEL SPEED SENSOR (WSS) (ON INSIDE OF RIGHT FRONT WHEEL) SIDE OF DASH) SIGNAL ENGINE CONTROL MODULE (ECM) (LEFT SIDE OF ENGINE COMPT) STOP LAMP SWITCH (BEHIND LEFT SIDE TAN WIRE TAN/BLK WIRE TAN/WHT WIRE TCC BRAKE SIG TOWARDS INSTRUMENT PANEL CLUSTER) UNDERHOOD FUSE BLOCK (ON LEFT SIDE OF ENGINE COMPT) VEHICLE SPEED YEL WIRE YEL/BLK WIRE

BLK WIRE BLOWER MOTOR (ON RIGHT REAR OF ENGINE COMPT, ON EVAPORATOR CASE) BLOWER MOTOR RELAY BRN WIRE BRN/WHT WIRE DEFOGGER SWITCH DEFOGGER CONTROL IND DEFOGGER SYSTEM DK BLU WIRE DK GRN/WHT WIRE EVAPORATIVE EMISSION SYSTEM LEAK DETECTION PUMP (6.6L) FRONT AUXILIARY HVAC CONTROL ASSEMBLY FRT BLWR FUSE 74 GRY WIRE HOT AT ALL TIMES HOT W/ RUN/ HVAC 1 FUSE 14 HVAC 2 FUSE 13 HVAC CNTRL FUSE 25 HVAC CONTROL SWITCH ASSEMBLY LOGIC LT BLU WIRE LT GRN WIRE MED OFF ORG/ WIRE PASSENGER COMPARTMENT FUSE BLOCK REAR BLWR FUSE 29 RED WIRE RED/BLK WIRE RED/WHT WIRE TAN WIRE UNDERHOOD FUSE BLOCK (ON LEFT SIDE OF ENGINE COMPT) W/ ELECTRIC REAR WINDOW DEFOGGER, POWER MIRRORS WHT WIRE YEL WIRE

A/C LOW PRESSURE SWITCH (ON SIDE OF ACCUMULATOR) AUXILIARY AIR TEMPERATURE ACTUATOR (ON AUXILIARY HVAC ASSEMBLY) AUXILIARY BLOWER MOTOR (ON AUXILIARY HVAC) AUXILIARY BLOWER MOTOR MEDIUM SPEED RELAY AUXILIARY BLOWER MOTOR RESISTOR (ON AUXILIARY HEATER MOTOR) AUXILIARY HVAC MODULE) AUXILIARY MODE DOOR ACTUATOR BATT GND BLK WIRE BLK/WHT WIRE BREAKOUT) BRN WIRE COMPUTER DATA LINES SYSTEM COOLANT HEATER BLOWER MOTOR COOLANT HEATER COMBUSTION SENSOR COOLANT HEATER CONTROL MODULE COOLANT HEATER GLOW PLUG COOLANT HEATER OVERHEAT TEMPERATURE SENSOR COOLANT HEATER AIR TEMPERATURE SENSOR COOLANT HEATER TEMPERATURE SENSOR DK BLU WIRE DK BLU/LT GRN WIRE DK GRN WIRE DRIVER INFORMATION CENTER (DIC) DISPLAY ENGINE COOLANT LEVEL SWITCH ENGINE COOLANT TEMPERATURE GAUGE FOH MDL FUSE FROM AUXILIARY BLOWER MOTOR BREAKOUT) FUEL PUMP GND SERIAL - SERIAL + SERIAL - SERIAL + GRN/RED WIRE GRY WIRE HOT AT ALL TIMES INSTRUMENT PANEL CLUSTER (IPC) LOGIC LOGIC COOLANT LEVEL SW SIG LOW REF LOW SPD GMLAN SERIAL DATA LT BLU WIRE LT GRN WIRE ORG/ WIRE PROVISIONAL RED/WHT WIRE SERIAL DATA TAN WIRE TAN/BLK WIRE UNDERHOOD FUSE BLOCK (ON LEFT SIDE OF ENGINE COMPT) VOLT WHT WIRE YEL WIRE

12 13 34 28 27 25 8 65 43 44 59 36 63 66 46 PRESS SENS LOW REF 19 21 69 14 71 CTRL SPD SIG CTRL SPD SIG SPEED SIG 21 22 58 4 24 40 SENS SIG LOW REF 6.6L 4.3L 4.8L, 5.3L, 6.0L A/C CMPRSR FUSE 18 A/C COMPRESSOR CLUTCH A/C COMPRESSOR CLUTCH RELAY 40 A/C REFRIGERANT PRESSURE SENSOR A/C SERIAL REQUEST DATA SIG BLK WIRE BODY CONTROL MODULE (BCM) (BEHIND LOWER RIGHT SIDE OF DASH) BRN/WHT WIRE CLUTCH RLY CTRL COMPT) COMPUTER DATA LINES SYSTEM COOLING FAN ASSEMBLY (6.6L) (BEHIND RADIATOR) DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE ENGINE CONTROL MODULE (ECM) (LEFT SIDE OF ENGINE COMPT) ENGINE COOLANT TEMPERATURE (ECT) SENSOR FAN CLTCH (EV) FUSE GMLAN - GMLAN + GMLAN DATA GRY WIRE HOT AT ALL TIMES HOT W/ PWR/TRN RELAY 49 ENERGIZED LOW REF LT BLU WIRE LT GRN WIRE OF ENGINE) ORG/BLK WIRE PNK WIRE REF TAN WIRE TAN/BLK WIRE UNDERHOOD FUSE BLOCK (ON LEFT SIDE OF ENGINE W/ AUXILIARY FUEL FIRED HEATER W/O AUXILIARY FUEL FIRED HEATER WHT (OR RED) WIRE WHT/BLK WIRE YEL WIRE

BLK WIRE BLOWER MOTOR (ON RIGHT REAR OF ENGINE COMPT, ON EVAPORATOR CASE) BLOWER MOTOR RELAY BREAKOUT) BRN WIRE BRN/WHT WIRE DEFOGGER SWITCH DEFOGGER IND DEFOGGER SYSTEM DK BLU WIRE DK GRN/WHT WIRE EVAPORATIVE EMISSION SYSTEM LEAK DETECTION PUMP (6.6L) FLOOR MIX BLEND DEF MAX A/C OFF A/C BI-LEV FRONT AUXILIARY HVAC CONTROL ASSEMBLY FRT BLWR FUSE 74 GND IGN GRY WIRE HOT AT ALL TIMES HOT W/ RUN/ HVAC 1 FUSE 14 HVAC 2 FUSE 13 HVAC CNTRL FUSE 25 HVAC CONTROL SWITCH ASSEMBLY LEFT REAR OF ENGINE) (4.3L: RIGHT REAR OF ENGINE) LOGIC 2 1 LT BLU WIRE LT GRN WIRE MAX A/C OFF A/C BI-LEV VENT MED OFF ORG/ WIRE PASSENGER COMPARTMENT FUSE BLOCK PNK/BLK WIRE PPL PPL/WHT WIRE REAR REAR AUXILIARY HVAC CONTROL ASSEMBLY REAR BLWR FUSE 29 RED WIRE RED/BLK WIRE RED/WHT WIRE RR AUX BLWR MTR CTRL SW FRT AUX BLWR MTR SPLICE BLOCK TAN WIRE UNDERHOOD FUSE BLOCK (ON LEFT SIDE OF ENGINE COMPT) VENT FLOOR DEF MIX BLEND W/ ELECTRIC REAR WINDOW DEFOGGER, POWER MIRRORS W/ RV UPFITTER W/O RV (ATTACHED TO LOWER RIGHT "B" PILLAR PART OF UPFITTER W/O RV UPFITTER W/O RV W/ RV UPFITTER UPFITTER WHT WIRE YEL WIRE

2501 2500 2501 2500 COMPUTER DATA LINES SYSTEM A/C LOW PRESSURE SWITCH (ON SIDE OF ACCUMULATOR) AUXILIARY AIR TEMPERATURE ACTUATOR (ON AUXILIARY HVAC ASSEMBLY) AUXILIARY BLOWER MOTOR (ON AUXILIARY HVAC) AUXILIARY BLOWER MOTOR MEDIUM SPEED RELAY AUXILIARY BLOWER MOTOR RESISTOR ASSEMBLY (ON AUXILIARY AUXILIARY HVAC MODULE) AUXILIARY MODE DOOR ACTUATOR BATT GND BLK WIRE BLK/WHT WIRE BLOWER MOTOR BREAKOUT) BREAKOUT) BRN WIRE COMPUTER DATA LINES SYSTEM COOLANT HEATER BLOWER MOTOR COOLANT HEATER COMBUSTION SENSOR COOLANT HEATER CONTROL MODULE COOLANT HEATER GLOW PLUG COOLANT HEATER OVERHEAT TEMPERATURE SENSOR COOLANT HEATER AIR TEMPERATURE SENSOR COOLANT HEATER TEMPERATURE SENSOR DK BLU WIRE DK BLU/LT GRN WIRE DK GRN WIRE DRIVER INFORMATION CENTER (DIC) DISPLAY ENGINE COOLANT LEVEL SWITCH ENGINE COOLANT TEMPERATURE GAUGE FOH MDL FUSE FUEL PUMP GND SERIAL - SERIAL + SERIAL - SERIAL + GRN/RED WIRE GRY WIRE HEATER MOTOR HOT AT ALL TIMES INSTRUMENT PANEL CLUSTER (IPC) LOGIC LOGIC COOLANT LEVEL SW SIG LOW REF LOW SPD GMLAN SERIAL DATA LT BLU WIRE LT GRN WIRE ORG/ WIRE PROVISIONAL RED/WHT WIRE SERIAL DATA TAN WIRE TAN/BLK WIRE UNDERHOOD FUSE BLOCK (ON LEFT SIDE OF ENGINE COMPT) VOLT WHT WIRE YEL WIRE

19 21 69 14 71 CTRL SPD SIG CTRL SPD SIG SPEED SIG 24 40 58 4 21 22 SENS SIG LOW REF 59 36 63 66 46 25 8 65 43 44 12 13 34 28 27 PRESS SENS LOW REF 6.6L 4.3L 4.8L, 5.3L, 6.0L A/C CMPRSR FUSE 18 A/C COMPRESSOR CLUTCH A/C COMPRESSOR CLUTCH RELAY 40 A/C REFRIGERANT PRESSURE SENSOR A/C SERIAL REQUEST DATA SIG BLK WIRE BODY CONTROL MODULE (BCM) (BEHIND LOWER RIGHT SIDE OF DASH) CLUTCH RLY CTRL COMPUTER DATA LINES SYSTEM COOLING FAN ASSEMBLY (6.6L) (BEHIND RADIATOR) DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE ENGINE COMPT) ENGINE CONTROL MODULE (ECM) (LEFT SIDE OF ENGINE COMPT) ENGINE COOLANT TEMPERATURE (ECT) SENSOR FAN CLTCH (EV) FUSE GMLAN - GMLAN + GMLAN DATA GRY WIRE HOT AT ALL TIMES HOT W/ PWR/TRN RELAY 49 ENERGIZED LOW REF LT BLU WIRE LT GRN WIRE OF ENGINE) ORG/BLK WIRE PNK WIRE REF TAN WIRE TAN/BLK WIRE UNDERHOOD FUSE BLOCK (ON LEFT SIDE OF W/ AUXILIARY FUEL FIRED HEATER W/O AUXILIARY FUEL FIRED HEATER W/O AUXILIARY FUEL FIRED HEATER W/ AUXILIARY FUEL FIRED HEATER WHT/BLK WIRE YEL WIRE

4.8L, 4.3L 5.3L, 6.0L BATT POS VOLT BCM 3 FUSE BLK WIRE BLK/WHT WIRE BODY CONTROL MODULE (BCM) (BEHIND LOWER RIGHT SIDE OF DASH) BRN WIRE COMPUTER DATA LINES SYSTEM DK GRN WIRE DRIVER INFORMATION CENTER DISPLAY ENGINE CONTROL MODULE HOOD AJAR SWITCH (W/ REMOTE ENGINE START) HOT AT ALL TIMES HOT AT ALL TIMES BODY FUSE IGN SW BLOCK (UNDER LEFT FUSE 22 FRONT SEAT) HOT W/ RUN/CRANK RELAY 15 ENERGIZED IGN VOLT IGN VOLT LO SPD DATA IGNITION SWITCH IPC FUSE LO SPD DATA LOCK LOGIC INSTRUMENT CLUSTER NCA WIRE PNK 19 1 WIRE PNK WIRE PNK/BLK WIRE PPL PPL CLOSED SW SIGNAL RED WIRE RED/WHT WIRE RUN WIRE SECURITY IND SERIAL DATA SERIAL DATA BUS- SW SIGNAL TAN WIRE TAN/BLK WIRE UNDERHOOD FUSE BLOCK (ON LEFT SIDE OF ENGINE COMPT) WHT WIRE

BLK WIRE BRN WIRE BRN/WHT WIRE DIMMING CTRL DK BLU WIRE HOT AT ALL TIMES HOT W/ RUN RELAY HVAC 2 FUSE 13 ORG/ WIRE PASSENGER COMPARTMENT FUSE BLOCK PROVISIONAL REAR BLWR FUSE 29 RED/WHT WIRE WHT WIRE