Chevrolet Cutaway P30 (1985-1997) Wiring diagram engine performance 5.7l (vin r)s, commercial chassis

1 2 3 PNK PNK WIRE 1-2 SHIFT SOL CTRL TCC PWM SOL CTRL 15 16 PPL BLK LT BLU/ WIRE BLK WIRE BLK/WHT WIRE BRN WIRE BRN/WHT WIRE CAM POSIT SENS RTN CAM POSIT SENS SIG POWER FUEL INJ NO.8 CTRL PNK WIRE CKP SENSOR RETURN CKP SENSOR SIGNAL DK BLU WIRE DK BLU/WHT WIRE DK GRN/WHT WIRE EVAP CAN PURGE CTRL FUEL INJ NO.1 CTRL 2-3 SHIFT SOL CTRL GRY WIRE HALL EFFECT SENSOR CAMSHAFT POSITION (CMP) SENSOR (IN DISTRIBUTOR) HEATED OXYGEN IDLE AIR CONTROL (IAC) VALVE (LEFT SIDE OF AIR INTAKE SYSTEM) IGN FEED KNOCK SENS SIG KNOCK SENSOR (KS) (ENGINE BLOCK, LOWER RIGHT SIDE IN FRONT OF STARTER) LT BLU/BLK WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/ BLK WIRE LT GRN/BLK WIRE LT GRN/WHT WIRE NCA WIRE PNK PNK 28 29 WIRE PNK WIRE PNK/BLK WIRE PPL PPL CKP SENS RTN VSS RTN VSS SIG PPL PPL PPL/ WHT WIRE PPL/WHT WIRE PRE-CONVERTOR (LEFT EXHAUST PIPE AHEAD OF CATALYTIC CONVERTER) PRE-CONVERTOR (RIGHT EXHAUST PIPE AHEAD OF CATALYTIC CONVERTER) RED/BLK WIRE SENS GND TAN WIRE TAN/WHT WIRE VEHICLE CONTROL MODULE (VCM) (VCM BRACKET BOLTED TO LEFT RADIATOR SUPPORT) VEHICLE SPEED SENSOR (VSS) (LEFT REAR OF TRANSMISSION, NEAR CENTER) WHT DK GRN/ WIRE WHT LT BLU/ WIRE WHT LT GRN/ WIRE WHT TAN/ WIRE WHT WIRE YEL WIRE YEL/BLK WIRE

1 2 3 PNK PNK WIRE 1-2 SHIFT SOLENOID 15 16 PPL 2-3 SHIFT SOLENOID AUTOMATIC TRANSMISSION (A/T) (IF EQUIPPED) (REAR OF ENGINE) BLK WIRE BLK/WHT WIRE BRN WIRE DK BLU WIRE DK BLU/WHT WIRE ECM 1 FUSE ENG 1 FUSE FUEL INJECTOR NO.1 FUEL INJECTOR NO.2 FUEL INJECTOR NO.3 FUEL INJECTOR NO.4 FUEL INJECTOR NO.5 FUEL INJECTOR NO.6 FUEL INJECTOR NO.7 FUEL INJECTOR NO.8 GRY WIRE HEATED OXYGEN SENSOR HOT IN (ON) RUN, START (CRANK) I/P FUSE BLOCK (DASH PANEL PROVIDED BY BODY BUILDER) (BODY BUILDER INSTALLED) LT BLU WIRE LT BLU/BLK WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/BLK WIRE NCA WIRE PNK 5 6 7 WIRE PNK PNK 28 29 WIRE PNK PNK PNK PNK 1 2 3 4 WIRE PNK PNK PNK WIRE PNK PNK WIRE PNK WIRE PNK/BLK WIRE POST CONVERTOR (LEFT EXHAUST PIPE BEHIND CATALYTIC CONVERTER) POST CONVERTOR (RIGHT EXHAUST PIPE BEHIND CATALYTIC CONVERTER) PPL PPL/ WHT WIRE PPL/WHT WIRE PRESSURE CONTROL SOLENOID (PCS) RED WIRE RED/BLK WIRE TAN WIRE TAN/ WHT WIRE TAN/WHT WIRE TCC PWM SOLENOID TRANSMISSION FLUID TEMPERATURE (TFT) SENSOR (INTERNAL) TRANSMISSION RANGE (TR) PRESSURE SWITCH ASSEMBLY WHT WIRE YEL WIRE YEL/BLK WIRE

A/C COMPRESSOR HIGH PRESSURE CUT-OFF SWITCH (REAR OF A/C COMPRESSOR) BLK WIRE BREAKOUT) BRN WIRE BRN/WHT WIRE DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE ENG-BAT FUSE FROM ECT SENSOR BREAKOUT) FROM MAF SENSOR BREAKOUT) FROM TP SENSOR BREAKOUT) FUEL PUMP SWITCH, ENGINE OIL PRESSURE GAUGE SENSOR (TOP LEFT REAR OF ENGINE) FUEL SENDER, FUEL PUMP (TOP OF FUEL TANK) GAUGES FUSE GRY WIRE HOT AT ALL TIMES HOT IN (ON) RUN, START (CRANK) I/P FUSE BLOCK (DASH PANEL PROVIDED BY BODY BUILDER) (BODY BUILDER INSTALLED) INSTRUMENT CLUSTER LT BLU/WHT WIRE LT GRN WIRE M/T A/T MANIFOLD ABSOLUTE PRESSURE (MAP) SENSOR (INTAKE MANIFOLD, REAR CENTER) MAP MASS AIR FLOW (MAF) SENSOR (AIR INTAKE SYSTEM BETWEEN AIR CLEANER, ENGINE) NCA WIRE OIL PRESS GAUGE FUEL GAUGE ORG/ WIRE PNK 5 6 7 WIRE PNK PNK PNK PNK 1 2 3 4 WIRE PNK PNK WIRE PNK WIRE PPL RED WIRE RED/BLK WIRE REF LO REF LO TEMP REF THROTTLE POSITION (TP) SENSOR (INTAKE SYSTEM, LEFT SIDE) SERVICE ENGINE SOON INDICATOR SPEEDO- METER TAN WIRE TRANS FUSE WHT WIRE YEL WIRE

389 419 VSS OUTPUT MIL CTRL 900 900 SERVICE CIRCUIT POWER SERVICE CIRCUIT POWER A/C REQUEST SIG A/T INPUT SPEED SENSOR (TRANSMISSION, LEFT FRONT) A/T M/T PPL ANTI- LOCK BRAKES SYSTEM PPL BLK WIRE BLK/WHT WIRE BRN WIRE BRN/WHT WIRE CLUTCH PEDAL POSITION SWITCH (LEFT SIDE OF BRAKE PEDAL BRACKET) CLUTCH SIG CYLINDER NO.1 CYLINDER NO.4 CYLINDER NO.5 CYLINDER NO.3 CYLINDER NO.6 CYLINDER NO.7 CYLINDER NO.2 CYLINDER NO.8 DISTRIBUTOR (TOP REAR OF ENGINE) DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/WHT WIRE ECM BAT FUSE EVAP CAN PURGE SW SIG PCS SOL (LO) SYSTEM GND SYSTEM GND GND FUEL PUMP PRIME CONNECTOR (TAPED TO FUEL PUMP RELAY BREAKOUT) FUEL PUMP RELAY (ENGINE BULKHEAD RELAY BRACKET UNDER BATTERY JUNCTION BLOCK) GROUND GRY WIRE HIGH VOLTAGE COIL WIRE HOT AT ALL TIMES HOT IN ON, RUN I-3 FUSE I/P FUSE BLOCK (DASH PANEL PROVIDED BY BODY BUILDER) (BODY BUILDER INSTALLED) IGN FEED IGN FEED RANGE SIG "B" RANGE SIG "A" IGNITION COIL (BRACKET AT TOP EDGE OF RIGHT CYLINDER HEAD) IGNITION FEED LT BLU/WHT WIRE ORG/ WIRE PCS SOL (HI) INPUT SPD SENS SIG INPUT SPD SENS RTN TIMING CTRL SIG PNK IGN FEED WIRE PNK PNK WIRE PNK WIRE PPL PPL FROM LEFT BULKHEAD GROMMET) PPL PPL 420 1807 BRAKE SIG SERIAL DATA RANGE SIG "C" RED WIRE RED/ BLK WIRE RED/BLK WIRE SHIFT INTERLOCK SYSTEM SPARK PLUGS TIMING CONTROL RETURN TIMING CONTROL SIGNAL) VEHICLE CONTROL MODULE (VCM) (VCM BRACKET BOLTED TO LEFT RADIATOR SUPPORT) WHT WIRE WHT/ DK BLU WIRE WHT/BLK WIRE