Chevrolet Cutaway P30 (1985-1997) pnk pnk Wiring diagrams

0.5 WATT) 1995 VFTC BLK WIRE BLK/YEL WIRE BRAKE IND BRAKE PRESSURE WARNING SWITCH (ON LEFT FRAME RAIL) IGNITION SWITCH BRAKE WARNING ALARM BUZZER (BEHIND LEFT SIDE OF I/P, NEAR FUSE BLOCK) BRN WIRE BRN/WHT WIRE COOLANT TEMP GAUGE CRUISE CONTROL SYSTEM DAYTIME RUNNING LAMPS IND DAYTIME RUNNING LAMPS MODULE (BEHIND LEFT SIDE OF I/P, ABOVE STEERING COLUMN) DAYTIME RUNNING LAMPS RELAY (BEHIND LEFT SIDE OF I/P, ABOVE STEERING COLUMN) DK BLU WIRE DK GRN WIRE DK GRN/YEL WIRE ELECTRONIC DELAY MODULE (BEHIND LEFT SIDE OF I/P, ON PARK BRAKE SUPPORT BRACKET) ENGINE CONTROLS SYSTEM FLOW SWITCH (NEAR POWER STEERING PUMP) FUEL GAUGE FUSE BLOCK GAGES FUSE GRY WIRE HEADLIGHTS SYSTEM HI-BEAM IND HOT IN RUN OR START HYDRO-BOOST PRESSURE WARNING SWITCH (NEAR MASTER CYLINDER) ILLUM LAMP ILLUM. LAMPS IN-LINE DIODE (BEHIND LEFT SIDE OF I/P, ABOVE FUSE BLOCK) IN-LINE DIODE (BEHIND LEFT SIDE OF I/P, ABOVE STEERING COLUMN) INSTRUMENT CLUSTER LEFT TURN IND LOW COOLANT IND LT BLU WIRE LT BLU/BLK WIRE LT GRN WIRE LT GRN/BLK WIRE MAL- FUNCTION IND OIL PRESS GAUGE PARK BRAKE WARNING SWITCH PNK PNK WIRE PNK WIRE PNK/BLK WIRE POWERTRAIN CONTROL MODULE (UNDER DRIVER'S SEAT) PPL RESISTOR RIGHT TURN IND SAFETY BELT IND SPEED- OMETER TAN WIRE TAN/WHT WIRE VEHICLE SPEED SENSOR (REAR OF TRANSMISSION) VEHICLE SPEED SENSOR BUFFER (BEHIND LEFT SIDE OF I/P) VOLT- METER W/ DRL W/ DRL PPL PPL W/O DRL WARNING SYSTEMS WHT WIRE YEL WIRE

29 30 VSS RTN VSS SIG ABS IND. AUTO PARK IND. BLK WIRE BLU WIRE BRN WIRE BRN/WHT WIRE COOLANT TEMPERATURE GAUGE DAYTIME RUNNING LAMPS CONTROL MODULE (NEAR STEERING COLUMN) DAYTIME RUNNING LIGHTS IND DIESEL DK DIODE NETWORK DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE ECM 1 FUSE ELECTRONIC BRAKE CONTROL MODULE (ON ABS CROSS MEMBER) ENGINE CONTROLS SYSTEM ENGINE CONTROLS SYSTEM (DIESEL ONLY) ENGINE CONTROLS SYSTEM HEADLIGHTS SYSTEM (W/ DRL) WARNING SYSTEM ENGINE COOLANT LEVEL SWITCH (DIESEL ONLY) (LOWER LEFT END OF SURGE TANK) ENGINE OIL PRESSURE GAUGE SENDER (TOP LEFT REAR OF ENGINE) FASTEN BELTS FUEL GAUGE FUEL PUMP SWITCH, ENGINE OIL PRESSURE GAUGE SENSOR (FRONT LEFT SIDE OF ENGINE) GAGES FUSE GASOLINE GLOW PLUGS IND. (DIESEL) GND IGN FEED IND CTRL PNK WIRE GRN WIRE GRY WIRE HOT IN HOT IN RUN OR START I/P FUSE BLOCK ENG-1 FUSE IGNITION SWITCH ILLUMINATION LAMPS IND INSTRUMENT CLUSTER LEFT TURN IND LOCK OFF ON LOW COOLANT IND. (DIESEL) LT BLU WIRE LT GRN WIRE LT GRN/BLK WIRE OIL PRESSURE GAUGE PARK BRAKE IN PARK BRAKE IND PARK BRAKE INDICATOR SWITCH (PARK BRAKE BRACKET SUPPORT) PNK PNK WIRE PNK WIRE PPL PPL PPL PPL/WHT WIRE PROVISION FOR BODY BUILDER RED WIRE RIGHT TURN IND. HI BEAM IND. RUN WIRE SERVICE ENGINE SOON IND SERVICE THROTTLE SOON IND (DIESEL) SPEEDOMETER TAN WIRE TAN/WHT WIRE TWISTED PAIR VEHICLE CONTROL MODULE VEHICLE SPEED SENSOR (LEFT REAR SIDE OF TRANSMISSION) VEHICLE SPEED SENSOR BUFFER VOLTMETER VSS (LO) VSS SIG VSS (HI) VSS (LO) VSS OUT VSS RTN GND IGN W/ DRL W/ DRL HEADLIGHTS SYSTEM ANTI-LOCK BRAKE SYSTEM INTERIOR LIGHTS SYSTEM W/ DRL LT W/O WATER IN FUEL IND. (DIESEL) WATER-IN-FUEL SENSOR (DIESEL ONLY) (PART OF FUEL INJECTION PUMP) WHT (OR LT GRN) WIRE WHT (OR WIRE WHT WIRE WHT/BLK WIRE YEL WIRE YEL/BLK WIRE

1996 VFTC ACC BUS AUTOMATIC TRANSMISSION AUTOMATIC TRANSMISSION (A/T) BRN WIRE CLUTCH PEDAL POSITION (CPP) SWITCH CRK (START) LOCK ON (RUN) OFF CRK (START) ON (RUN) LOCK OFF CRK (START) ON (RUN) OFF DIESEL DK BLU WIRE ENG 1 FUSE EVAPORATIVE EMISSIONS (EVAP) CANISTER PURGE SOLENOID VALVE FROM FUSIBLE LINK FUEL HEATER FUSE OUTPUT- ACCESSORY TYPE 3 FUSE GAS GLOW PLUG CONTROL SWITCH HEATED OXYGEN SENSOR HEATED OXYGEN SENSOR CAMSHAFT POSITION (CMP) SENSOR I/P FUSE BLOCK (DASH PANEL PROVIDED BY BODY BUILDER) (BODY BUILDER INSTALLED) IGNITION SWITCH LEFT POST CONVERTER (5.7L VIN R LEFT PRE- CONVERTER LINEAR EXHAUST GAS RECIRC- ULATION (EGR) SOLENOID VALVE LOCK MANUAL TRANSMISSION MASS AIR FLOW (MAF SENSOR) NCA WIRE ORG/ WIRE PARK/NEUTRAL POSITION (PNP), BACKUP LAMPS SWITCH PNK PNK WIRE PNK WIRE POST CONVERTER (4.3L VIN W PROVISIONS FOR WIPER/ WASHER MOTOR RADIO FUSE RED WIRE RIGHT POST CONVERTER (5.7L VIN R RIGHT PRE- CONVERTER TO I/P FUSE BLOCK: (AUX, I-3, TURN B/U,, HTR FUSES) TRANS FUSE VEHICLE CONTROL MODULE (VCM) WATER- IN-FUEL SENSOR AUXILIARY ENGINE COOLANT FAN RELAY WHT WIRE WINDSHIELD WIPER/ WASHER SWITCH WIPER FUSE YEL WIRE

1996 VFTC 6.5L VIN Y A/C COMPRESSOR CLUTCH RELAY AUTOMATIC TRANSMISSION AUX FUSE BACK UP LAMPS SWITCH BRN WIRE CANADIAN MODELS ONLY CAVITY A) DAYTIME RUNNING LAMP (DRL) RELAY DAYTIME RUNNING LAMPS (DRL) CONTROL MODULE DIESEL ECM 1 FUSE FROM IGNITION SWITCH FUEL INJECTION PUMP FUEL SHUT-OFF SOLENOID GAS GAS MODELS ONLY GAUGES FUSE GENERATOR GENERATOR HOT IN RUN, START HTR BUS HTR FUSE I-3 FUSE I/P FUSE BLOCK (DASH PANEL PROVIDED BY BODY BUILDER) (BODY BUILDER INSTALLED) IGN BUS INSTRUMENT CLUSTER MANUAL TRANSMISSION ORG/ WIRE P/B BOOSTER FLUID FLOW, PRESSURE ALARM PARK/ NEUTRAL POSITION (PNP), BACKUP LAMPS SWITCH PNK PNK WIRE PNK WIRE SEAT BELT ALARM INSTRUMENT CLUSTER THIS CAN PLUG INTO TORQUE CONVERTER CLUTCH (TCC), STOP LAMPS SWITCH TRANSMISSION CONTROL MODULE (TCM) FUEL INJECTION PUMP FUEL SHUT-OFF SOLENOID TURN SIGNAL FLASHER TURN-B/U FUSE VEHICLE CONTROL MODULE (VCM) VEHICLE SPEED SENSOR (VSS) BUFFER W/BRAKE WARNING INDICATOR SYSTEM

1 2 PNK WIRE 1-2 SHIFT SOLENOID 2-3 SHIFT SOLENOID 3 4 5 6 PNK PNK PNK WIRE AUTOMATIC TRANSMISSION (A/T) (IF EQUIPPED) (REAR OF ENGINE) BLK WIRE BLK/WHT WIRE BRN WIRE DK BLU WIRE ECM I FUSE ENG 1 FUSE FUEL INJECTOR NO.2 FUEL INJECTOR NO.1 FUEL INJECTOR NO.3 FUEL INJECTOR NO.4 FUEL INJECTOR NO.5 FUEL INJECTOR NO.6 GRY WIRE HEATED OXYGEN HEATED OXYGEN SENSOR HOT IN (ON) RUN, START (CRANK) I/P FUSE BLOCK (DASH PANEL PROVIDED BY BODY BUILDER) (BODY BUILDER INSTALLED) LT BLU WIRE LT BLU/BLK WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/BLK WIRE NCA WIRE PNK 7 8 9 10 WIRE PNK PNK PNK 2 3 4 5 WIRE PNK PNK PNK WIRE PNK PNK WIRE PNK WIRE PNK/BLK WIRE POST CONVERTOR (EXHAUST PIPE BEHIND CATALYTIC CONVERTER) PPL PPL/WHT WIRE PRE-CONVERTOR (RIGHT EXHAUST PIPE AHEAD OF CATALYTIC CONVERTER) PRESSURE CONTROL SOLENOID (PCS) RED WIRE RED/BLK WIRE TAN WIRE TAN/WHT WIRE TCC PWM SOLENOID TRANS FUSE TRANSMISSION FLUID TEMPERATURE (TFT) SENSOR (INTERNAL) TRANSMISSION RANGE (TR) PRESSURE SWITCH ASSEMBLY W/ A/T ONLY WHT WIRE YEL WIRE YEL/BLK WIRE

A/C COMPRESSOR HIGH PRESSURE CUT-OFF SWITCH (REAR OF A/C COMPRESSOR) A/T BLK WIRE BREAKOUT) BRN WIRE BRN/WHT WIRE DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE ENG-BAT FUSE FROM ECT SENSOR BREAKOUT) FROM TPS BREAKOUT) FUEL GAUGE FUEL PUMP SWITCH, ENGINE OIL PRESSURE GAUGE SENSOR (TOP LEFT REAR OF ENGINE) FUEL SENDER, FUEL PUMP (TOP OF FUEL TANK) GAUGES FUSE GROUND DISTRIBUTION SYSTEM GRY WIRE HOT AT ALL TIMES HOT IN (ON) RUN, START (CRANK) I/P FUSE BLOCK (DASH PANEL PROVIDED BY BODY BUILDER) (BODY BUILDER INSTALLED) INSTRUMENT CLUSTER LT BLU/WHT WIRE LT GRN WIRE M/T MANIFOLD ABSOLUTE PRESSURE (MAP) SENSOR (INTAKE MANIFOLD, REAR CENTER) MAP REF LO MASS AIR FLOW SENSOR (MAF) (AIR INTAKE SYSTEM BETWEEN AIR CLEANER, ENGINE) NCA WIRE OIL PRESS GAUGE ORG/ WIRE PNK PNK 2 3 4 5 6 7 8 9 WIRE PNK PNK PNK 2 3 4 5 WIRE PNK PNK WIRE PNK WIRE PPL RED WIRE RED/BLK WIRE REF LO TEMP REF THROTTLE POSITION (TP) SENSOR (INTAKE SYSTEM, LEFT SIDE) SENSOR BREAKOUT) SERVICE ENGINE SOON INDICATOR SPEEDO- METER TAN WIRE WHT WIRE YEL WIRE

1 2 3 PNK PNK WIRE 1-2 SHIFT SOLENOID 15 16 PPL 2-3 SHIFT SOLENOID AUTOMATIC TRANSMISSION (A/T) (IF EQUIPPED) (REAR OF ENGINE) BLK WIRE BLK/WHT WIRE BRN WIRE DK BLU WIRE DK BLU/WHT WIRE ECM 1 FUSE ENG 1 FUSE FUEL INJECTOR NO.1 FUEL INJECTOR NO.2 FUEL INJECTOR NO.3 FUEL INJECTOR NO.4 FUEL INJECTOR NO.5 FUEL INJECTOR NO.6 FUEL INJECTOR NO.7 FUEL INJECTOR NO.8 GRY WIRE HEATED OXYGEN SENSOR HOT IN (ON) RUN, START (CRANK) I/P FUSE BLOCK (DASH PANEL PROVIDED BY BODY BUILDER) (BODY BUILDER INSTALLED) LT BLU WIRE LT BLU/BLK WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/BLK WIRE NCA WIRE PNK 5 6 7 WIRE PNK PNK 28 29 WIRE PNK PNK PNK PNK 1 2 3 4 WIRE PNK PNK PNK WIRE PNK PNK WIRE PNK WIRE PNK/BLK WIRE POST CONVERTOR (LEFT EXHAUST PIPE BEHIND CATALYTIC CONVERTER) POST CONVERTOR (RIGHT EXHAUST PIPE BEHIND CATALYTIC CONVERTER) PPL PPL/ WHT WIRE PPL/WHT WIRE PRESSURE CONTROL SOLENOID (PCS) RED WIRE RED/BLK WIRE TAN WIRE TAN/ WHT WIRE TAN/WHT WIRE TCC PWM SOLENOID TRANSMISSION FLUID TEMPERATURE (TFT) SENSOR (INTERNAL) TRANSMISSION RANGE (TR) PRESSURE SWITCH ASSEMBLY WHT WIRE YEL WIRE YEL/BLK WIRE

A/C COMPRESSOR HIGH PRESSURE CUT-OFF SWITCH (REAR OF A/C COMPRESSOR) BLK WIRE BREAKOUT) BRN WIRE BRN/WHT WIRE DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE ENG-BAT FUSE FROM ECT SENSOR BREAKOUT) FROM MAF SENSOR BREAKOUT) FROM TP SENSOR BREAKOUT) FUEL PUMP SWITCH, ENGINE OIL PRESSURE GAUGE SENSOR (TOP LEFT REAR OF ENGINE) FUEL SENDER, FUEL PUMP (TOP OF FUEL TANK) GAUGES FUSE GRY WIRE HOT AT ALL TIMES HOT IN (ON) RUN, START (CRANK) I/P FUSE BLOCK (DASH PANEL PROVIDED BY BODY BUILDER) (BODY BUILDER INSTALLED) INSTRUMENT CLUSTER LT BLU/WHT WIRE LT GRN WIRE M/T A/T MANIFOLD ABSOLUTE PRESSURE (MAP) SENSOR (INTAKE MANIFOLD, REAR CENTER) MAP MASS AIR FLOW (MAF) SENSOR (AIR INTAKE SYSTEM BETWEEN AIR CLEANER, ENGINE) NCA WIRE OIL PRESS GAUGE FUEL GAUGE ORG/ WIRE PNK 5 6 7 WIRE PNK PNK PNK PNK 1 2 3 4 WIRE PNK PNK WIRE PNK WIRE PPL RED WIRE RED/BLK WIRE REF LO REF LO TEMP REF THROTTLE POSITION (TP) SENSOR (INTAKE SYSTEM, LEFT SIDE) SERVICE ENGINE SOON INDICATOR SPEEDO- METER TAN WIRE TRANS FUSE WHT WIRE YEL WIRE

389 419 VSS OUTPUT MIL CTRL 900 900 SERVICE CIRCUIT POWER SERVICE CIRCUIT POWER A/C REQUEST SIG A/T INPUT SPEED SENSOR (TRANSMISSION, LEFT FRONT) A/T M/T PPL ANTI- LOCK BRAKES SYSTEM PPL BLK WIRE BLK/WHT WIRE BRN WIRE BRN/WHT WIRE CLUTCH PEDAL POSITION SWITCH (LEFT SIDE OF BRAKE PEDAL BRACKET) CLUTCH SIG CYLINDER NO.1 CYLINDER NO.4 CYLINDER NO.5 CYLINDER NO.3 CYLINDER NO.6 CYLINDER NO.7 CYLINDER NO.2 CYLINDER NO.8 DISTRIBUTOR (TOP REAR OF ENGINE) DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/WHT WIRE ECM BAT FUSE EVAP CAN PURGE SW SIG PCS SOL (LO) SYSTEM GND SYSTEM GND GND FUEL PUMP PRIME CONNECTOR (TAPED TO FUEL PUMP RELAY BREAKOUT) FUEL PUMP RELAY (ENGINE BULKHEAD RELAY BRACKET UNDER BATTERY JUNCTION BLOCK) GROUND GRY WIRE HIGH VOLTAGE COIL WIRE HOT AT ALL TIMES HOT IN ON, RUN I-3 FUSE I/P FUSE BLOCK (DASH PANEL PROVIDED BY BODY BUILDER) (BODY BUILDER INSTALLED) IGN FEED IGN FEED RANGE SIG "B" RANGE SIG "A" IGNITION COIL (BRACKET AT TOP EDGE OF RIGHT CYLINDER HEAD) IGNITION FEED LT BLU/WHT WIRE ORG/ WIRE PCS SOL (HI) INPUT SPD SENS SIG INPUT SPD SENS RTN TIMING CTRL SIG PNK IGN FEED WIRE PNK PNK WIRE PNK WIRE PPL PPL FROM LEFT BULKHEAD GROMMET) PPL PPL 420 1807 BRAKE SIG SERIAL DATA RANGE SIG "C" RED WIRE RED/ BLK WIRE RED/BLK WIRE SHIFT INTERLOCK SYSTEM SPARK PLUGS TIMING CONTROL RETURN TIMING CONTROL SIGNAL) VEHICLE CONTROL MODULE (VCM) (VCM BRACKET BOLTED TO LEFT RADIATOR SUPPORT) WHT WIRE WHT/ DK BLU WIRE WHT/BLK WIRE

AUTOMATIC TRANSMISSION BLK WIRE BLK/WHT WIRE BREAKOUT FOR EGR, TOWARD RELAYS) BREAKOUT FOR LEFT FRONT WHEEL SPEED SENSOR, TOWARD ENG) BRN WIRE DK BLU WIRE DK BLU/WHT WIRE ECM 1 FUSE ENG 1 FUSE FLUID TEMPERATURE SENSOR (INTERNAL) FORCE MOTOR FUEL INJ. NO.1 FUEL INJ. NO.2 FUEL INJ. NO.3 FUEL INJ. NO.5 FUEL INJ. NO.4 FUEL INJ. NO.6 FUEL INJ. NO.7 FUEL INJ. NO.8 GRY WIRE HEATED OXYGEN SENSOR NO.2 (ON LEFT EXHAUST PIPE AHEAD OF CATALYTIC CONVERTER) HEATED OXYGEN SENSOR NO.3 (ON RIGHT EXHAUST PIPE BEHIND OF CATALYTIC CONVERTER) HEATED OXYGEN SENSOR NO.4 (ON LEFT EXHAUST PIPE BEHIND OF CATALYTIC CONVERTER) HOT IN RUN OR START (CRANK) I/P FUSE BLOCK (MOUNTED ON THE I/P) IGNITION LINEAR EGR SOLENOID VALVE (ON LEFT SIDE OF INTAKE PLENUM) LT BLU WIRE LT BLU/BLK WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/BLK WIRE NCA WIRE PNK 11 12 WIRE PNK PNK 2 3 WIRE PNK PNK PNK 1 2 3 WIRE PNK PNK WIRE PNK WIRE PNK/BLK WIRE PPL PPL/ WHT WIRE PPL/WHT WIRE RED WIRE RED/BLK WIRE SOLENOID 1-2 SOLENOID 2-3 SWITCH PRESSURE TAN WIRE TAN/ WHT WIRE TAN/WHT WIRE TCC SOLENOID WHT LT BLU/ WIRE WHT PPL/ WIRE WHT TAN/ WIRE WHT WIRE YEL WIRE YEL/BLK WIRE