Chevrolet Cutaway G3500 (1997-2012) yel Wiring diagrams

BLK/WHT WIRE BODY CONTROL MODULE (BCM) (BEHIND LOWER RIGHT SIDE OF DASH) CHIME MODULE (BEHIND CENTER OF DASH) DATA CLSS 2 DATA LINK CONNECTOR (DLC) (UNDER LEFT SIDE OF DASH) DK BLU WIRE DK GRN WIRE GRY WIRE HOT AT ALL TIMES INFLATABLE RESTRAINT SENSING, DIAGNOSTIC MODULE (SDM) (UNDER LEFT FRONT SEAT) INSTRUMENT PANEL CLUSTER LT BLU WIRE LT GRN WIRE LTR FUSE 30 PNK WIRE POWER DISTRIBUTION SYSTEM POWERTRAIN CONTROL MODULE (PCM) (IN ENGINE COMPT, ON LEFT INNER FENDER) PPL RADIO RED/WHT WIRE REMOTE CONTROL DOOR LOCK RECEIVER (BEHIND CENTER OF DASH) SPLICE UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT) UNDERHOOD PASS- THROUGH GROMMET BREAKOUT) VEHICLE COMMUNICATIONS INTERFACE MODULE (VCIM) (BELOW STEERING COLUMN) W/O ACTIVE HANDLING W/ ACTIVE HANDLING W/O RADIO WHT WIRE YEL WIRE

BLK WIRE BODY FUSE BLOCK (BELOW LEFT FRONT SEAT) CLASS 2 CLASS 2 (PCM) DATA COMPUTER DATA LINES SYSTEM CRUISE IND DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE GRN WIRE GROUND GRY WIRE GRY/BLK WIRE HOT AT ALL TIMES HOT IN RUN, START IGN IGN E FUSE 22 INSTRUMENT PANEL CLUSTER LT BLU WIRE NCA WIRE ON CRUISE CONTROL ON/OFF SWITCH OFF ON OFF ORG/BLK WIRE PCM IGN 1 FUSE 38 PNK WIRE POWERTRAIN CONTROL MODULE (PCM) (IN ENGINE COMPT, ON LEFT INNER FENDER) PPL PPL VSS LOW RED/WHT WIRE RESUME/ ACCEL RESUME/ACCEL SET/ COAST STOP LP FUSE 7 STOP/ CHMSL FUSE 8 STOPLAMP SWITCH (ABOVE BRAKE PEDAL) THROTTLE ACTUATOR CONTROL (TAC) MODULE (AT LEFT REAR OF ENGINE COMPARTMENT) TURN SIGNAL/ MULTIFUNCTION SWITCH UART SERIAL DATA UART SERIAL DATA UART SERIAL DATA UART SERIAL DATA SERIAL DATA 14 58 UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT) VEHICLE SPEED SENSOR (VSS) (ON RIGHT SIDE OF TRANSMISSION) VSS HIGH WHT WIRE YEL WIRE

BLK WIRE BLU WIRE BODY FUSE BLOCK (BELOW LEFT FRONT SEAT) CARGO/ PASSENGER CLASS 2 CRUISE IND CLASS 2 (PCM) DATA COMPUTER DATA LINES SYSTEM CRUISE CONTROL MODULE (NEAR BRAKE FLUID RESERVOIR) CUTAWAY DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE GRN WIRE GRY WIRE GRY/BLK WIRE HOT AT ALL TIMES HOT IN RUN, START IGN IGN E FUSE 22 INSTRUMENT PANEL CLUSTER LT BLU WIRE LT BLU/BLK WIRE NCA WIRE ON CRUISE CONTROL ON/OFF SWITCH OFF ON OFF PCM IGN 1 FUSE 38 PNK 17 (OR 1320) WIRE PNK WIRE POWERTRAIN CONTROL MODULE (PCM) (IN ENGINE COMPT, ON LEFT INNER FENDER) PPL PPL VSS LOW RED/WHT WIRE RESUME/ ACCEL RESUME/ACCEL SERIAL DATA SET/ COAST SPEED SIGNAL AUTO CRUISE INHIBIT SIG VSS HIGH 13 37 STOP LP FUSE 7 STOP/ CHMSL FUSE 8 STOPLAMP SWITCH (ABOVE BRAKE PEDAL) TURN SIGNAL/ MULTIFUNCTION SWITCH UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT) VEHICLE SPEED SENSOR (VSS) (ON RIGHT SIDE OF TRANSMISSION) WHT (OR LT BLU) WIRE WHT WIRE YEL WIRE

BLK/WHT WIRE BODY CONTROL MODULE (BCM) (BEHIND LOWER RIGHT SIDE OF DASH) CHIME MODULE (BEHIND CENTER OF DASH) COOLANT HEATER (ATTACHED TO LEFT INNER FRAME RAIL) DATA CLSS 2 DATA LINK CONNECTOR (DLC) (UNDER LEFT SIDE OF DASH) DK BLU WIRE DK GRN WIRE ENGINE CONTROL MODULE (ECM) (IN ENGINE COMPT, ON LEFT INNER FENDER) ENGINE CONTROL MODULE (ECM) (LEFT SIDE OF ENGINE COMPT) GLOW PLUG CONTROL MODULE (GPCM) (LEFT REAR OF ENGINE) GRY WIRE HI SPD GMLAN SERIAL DATA HOT AT ALL TIMES INFLATABLE RESTRAINT SENSING, DIAGNOSTIC MODULE (SDM) (UNDER LEFT FRONT SEAT) INSTRUMENT PANEL CLUSTER LT BLU WIRE LT GRN WIRE LTR FUSE 30 NCA WIRE PNK DATA CLSS 2 WIRE POWER DISTRIBUTION SYSTEM PPL RADIO RED/WHT WIRE REMOTE CONTROL DOOR LOCK RECEIVER (BEHIND CENTER OF DASH) SPLICE TAN WIRE TAN/BLK WIRE TAN/WHT WIRE TRANSMISSION CONTROL MODULE (TCM) (ON RIGHT FRAME RAIL) UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT) UNDERHOOD PASS- THROUGH GROMMET BREAKOUT) VEHICLE COMMUNICATIONS INTERFACE MODULE (VCIM) (BELOW STEERING COLUMN) W/ AUXILIARY HEATER W/O ACTIVE HANDLING W/ ACTIVE HANDLING W/O AUXILIARY HEATER W/O RADIO WHT WIRE YEL WIRE

40 21 STOPLAMP SW INPUT IGNITION 44 57 22 54 2 4 6 HI SPD GMLAN + HI SPD GMLAN - TCC BRK SW VSS 61 34 10 CRUISE ON INPUT SET/COAST SIG RESUME/ACCEL SIG ANTI-LOCK BRAKE SYSTEM BLK WIRE BLK/WHT WIRE BODY FUSE BLOCK (UNDER LEFT FRONT SEAT) CLASS 2 CLASS 2 (PCM) DATA COMPUTER DATA LINES SYSTEM CRUISE IND DK BLU WIRE ECM/TCM GLO PLUG MDL FUSE 38 ENGINE CONTROL MODULE (ECM) FOH/ECM TCM BATT FUSE 2 GROUND GROUND GROUND 1551 1551 GRY WIRE GRY/BLK WIRE HOT AT ALL TIMES HOT IN RUN, START IGN IGN E FUSE 22 INSTRUMENT PANEL CLUSTER LT BLU WIRE NCA WIRE ON CRUISE CONTROL ON/OFF SWITCH OFF ON OFF PNK WIRE PPL PPL 420 1827 PPL VSS LOW RED/WHT WIRE RESUME/ ACCEL RESUME/ACCEL SET/ COAST STOP LP FUSE 7 STOP/ CHMSL FUSE 8 STOPLAMP SWITCH (ABOVE BRAKE PEDAL) TAN WIRE TAN/BLK WIRE TRANSMISSION CONTROL MODULE (TCM) (LEFT FRONT CORNER OF ENGINE COMPT) TURN SIGNAL/ MULTIFUNCTION SWITCH UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT) VEHICLE SPEED SENSOR (VSS) (ON RIGHT SIDE OF TRANSMISSION) WHT WIRE YEL WIRE YEL/BLK WIRE

54 49 22 33 (DIESEL) (GASOLINE) ABS PUMP ABS/TCC SW ABS/VSES FUSE 48 ANTI-LOCK IND BLK WIRE BODY FUSE BLOCK (UNDER LEFT FRONT SEAT) BRAKE FLUID LEVEL SW IN LEFT FRONT SENSOR (+) RIGHT FRONT SENSOR (-) VSS INPUT BRAKE FLUID LEVEL SWITCH (HEAVY DUTY) (ON BRAKE MASTER CYLINDER RESERVOIR) BRAKE IND BRKS FUSE 11 BRN WIRE CRUISE CONTROL SYSTEM DIESEL DK GRN WIRE GAS GRY WIRE HOT AT ALL TIMES HOT IN RUN HOT IN RUN OR START IGN E FUSE 22 INSTRUMENT PANEL CLUSTER LEFT FRONT SENSOR (-) RIGHT FRONT SENSOR (+) BRAKE INPUT LEFT FRONT WHEEL SPEED SENSOR (ON INSIDE OF LEFT FRONT WHEEL) LOGIC LT BLU WIRE PNK WIRE PPL PPL DATA LINK CONNECTOR (DLC) (UNDER LEFT SIDE OF DASH) RED/BLK WIRE RIGHT FRONT WHEEL SPEED SENSOR (ON INSIDE OF RIGHT FRONT WHEEL) SERIAL DATA IGNITION STOP LAMP SWITCH (BEHIND LEFT SIDE OF DASH, ABOVE BRAKE PEDAL) TAN WIRE TCC BRAKE SW TRANSMISSION CONTROL MODULE (TCM) (LEFT FRONT CORNER OF ENG COMPT) UNDERHOOD FUSE BLOCK (ON LEFT SIDE OF ENG COMPT) VEHICLE SPEED SENSOR (VSS) VSS HIGH VSS LOW VSS OUTPUT YEL WIRE YEL/BLK WIRE

ABS IND. BLK WIRE BLK/WHT WIRE BRAKE FLUID LEVEL SWITCH (ON BRAKE MASTER CYLINDER RESERVOIR) BRAKE IND BRAKE PRESSURE DIFFERENTIAL SWITCH (ON BRAKE VALVE, NEAR FRONT OF EBCM) BRN WIRE CAUTION IND DATA LINK CONNECTOR (DLC) (UNDER LEFT SIDE OF DASH) DK BLU WIRE DK GRN WIRE GROUND GRY WIRE HEAVY DUTY HOT IN RUN OR START IGN 3 VOLTAGE INSTRUMENT PANEL CLUSTER LIGHT DUTY LOGIC LOW REF LT BLU WIRE LT GRN WIRE LT GRN/BLK WIRE NOT READY IND ORG/BLK WIRE PCM IGN 1 FUSE 38 PNK 1 2 WIRE PNK WIRE PPL SENSOR SELF TEST SIG CIR STEERING WHEEL POS MARKER PULSE SIG STEERING WHEEL POSITION SENS SIG 1 STEERING WHEEL POSITION SIG A STEERING WHEEL POSITION SIG B STEERING WHEEL SPEED/ POSITION SENSOR (AT BASE OF STEERING COLUMN) TRACTION CONTROL SWITCH UNDERHOOD FUSE BLOCK (ON LEFT SIDE OF ENGINE COMPT) WHT WIRE YAW RATE FREQUENCY YAW, LATERAL ACCELERATION SENSOR (UNDER FRONT PASSENGER SEAT) YEL WIRE

397 552 5929 CRUISE CONTROL SYSTEM BLK WIRE BLK/WHT WIRE BRN WIRE BRN/WHT WIRE CAMSHAFT POSITION SENSOR (FRONT OF ENGINE) COOLANT LEV SIG HI IDLE SW COOLANT LEVEL SWITCH CRUISE CONTROL SYSTEM CRUISE ON LOW REF LOW REF CRUISE SET DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE EGR VAL POS SIG ECT SENSOR SIG ENGINE CONTROL MODULE (ECM) ENGINE COOLANT TEMPERATURE (ECT) SENSOR (TOP OF ENGINE, NEAR THERMOSTAT HOUSING) ENGINE OIL LEVEL SWITCH (LEFT SIDE OF OIL PAN) FUEL PRESS INJ + GROUP 2 GRY WIRE GRY/BLK WIRE IAT SENSOR 2 SIG IAT SENSOR SIG LOW REF LOW REF CMP SENSOR SIG LOW REF CRANK VOLT PPL LOW REF TUR VANE POS INJ + GROUP 3 INJ 5 INJ 4 LT BLU WIRE LT BLU/BLK WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/WHT WIRE NCA WIRE OIL LEVEL SW SIG CRUISE RESUME LOW REF OIL PRESS SIG ORG/ WIRE ORG/BLK WIRE PARTIAL PNK WIRE PNK/BLK WIRE PPL PPL/WHT WIRE STARTING/CHARGING SYSTEM TAN WIRE TAN/WHT WIRE WHT WIRE YEL WIRE YEL/BLK WIRE

ACCELERATOR PEDAL POSITION (APP) SENSOR (UNDER LEFT SIDE OF DASH) BLK WIRE BRN WIRE COMPUTER DATA LINES STSYEM DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE FUSIBLE LINK 1 GLOW PLUG 1 GLOW PLUG 2 GLOW PLUG 3 GLOW PLUG 4 GLOW PLUG 5 GLOW PLUG 6 GLOW PLUG 7 GLOW PLUG 8 GLOW PLUGS GMLAN DATA GRD GRY WIRE GRY/BLK WIRE HOT AT ALL TIMES IAH COMM 1 IAH COMM 2 IAH CURRENT SIG IAH SIG IAH TEMP SIG IAH VOLT SIG IGN 0 IGN 1 LT BLU WIRE LT BLU/BLK WIRE LT GRN WIRE LT GRN/BLK WIRE ORG/ WIRE ORG/BLK WIRE PNK WIRE PNK/BLK WIRE PPL PPL/WHT WIRE RED WIRE TAN WIRE TAN/BLK WIRE TAN/WHT WIRE WATER IN-FUEL SENSOR WHT WIRE WHT/BLK WIRE WHT/DK GRN WIRE WHT/LT GRN WIRE WHT/RED WIRE WHT/YEL WIRE YEL WIRE YEL/BLK WIRE

8 9 10 11 12 PNK WIRE A/C REQ SIG A/C SYSTEM BLK WIRE BRN WIRE CKP SENSOR SIG DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/WHT WIRE ECM/TCM GLOW PLUG CNTRL MDL IGN 1 FUSE 38 ENG 1 FUSE 23 ENGINE CONTROL MODULE (ECM) FRP SENSOR SIG FUSIBLE LINK 4 GRY WIRE GRY/BLK WIRE HOT AT ALL TIMES HOT IN ACC, RUN, START HOT IN RUN, START IGN 0 FUSE 6 IGN 1 IGN E FUSE 22 INJ 1 INJ 2 INTAKE AIR TEMPERATURE (IAT) SENSOR 2 (AT FRONT OF TURBOCHARGER) LOW REF LT BLU WIRE LT BLU/BLK WIRE LT GRN WIRE LT GRN/BLK WIRE ORG/ WIRE ORG/BLK WIRE PNK 22 23 24 WIRE PNK WIRE PNK/BLK WIRE PPL PPL 25 26 27 28 29 30 PPL/WHT WIRE RED WIRE RED/WHT WIRE STOPLAMP SWITCH (ABOVE BRAKE PEDAL) TAN WIRE TAN/WHT WIRE TUR VAN POS UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT) WHT WIRE WHT/BLK WIRE YEL WIRE YEL/BLK WIRE