Chevrolet Cutaway G3500 (1997-2012) tan Wiring diagrams

AUTOMATIC TRANSMISSION AUTOMATIC TRANSMISSION ASSEMBLY (6 SPEED A/T) AUTOMATIC TRANSMISSION INTERNAL MODE SWITCH (IMS) AUX/TRLR BCK/UP FUSE 26 BACKUP ALARM (REAR OF VEHICLE ON FRAME) BCK/UP LAMP PCB RELAY BLK WIRE BLK/WHT WIRE BODY CONTROL MODULE (BCM) (BEHIND LOWER RIGHT SIDE OF DASH) BODY FUSE BLOCK (UNDER LEFT BUS-DATA COMPUTER DATA LINES SYSTEM CONTROL SOLENOID VALVE ASSEMBLY DATA BUS - DK BLU WIRE FRONT SEAT) GMLAN HI SPD GRN WIRE GRY WIRE HI SPD GMLAN DATA BUS - HI SPD GMLAN SERIAL DATA BUS + HOT AT ALL TIMES LEFT BACKUP LAMP (CARGO/ PASSENGER) LEFT TAIL/ STOP/ TURN SIGNAL LAMP LT GRN WIRE NCA WIRE PARK/NEUTRAL POSITION (PNP) SWITCH PROVISIONAL RED WIRE RELAY CTRL RIGHT BACKUP LAMP (CARGO/ PASSENGER) RIGHT TAIL/ STOP/ TURN SIGNAL LAMP SIG A SIG B SIG C TAIL LAMP BCK/UP FUSE 27 TAN WIRE TAN/BLK WIRE TAN/WHT WIRE TRAILER CONNECTOR (IF EQUIPPED) TRANS RNG SW SIG A TRANS RNG SW SIG B TRANS- MISSION CONTROL MODULE (TCM) TRANSMISSION CONTROL MODULE (TCM) (4 SPEED A/T) UNDERHOOD FUSE BLOCK W/ ELECTRICAL BACKUP CUTAWAY ALARM YEL WIRE

1 18 25 COURTESY LP CTRL COURTESY LP CTRL DEFEAT SW SIG 149 (OR 690) 16 17 DATA BUS+ DATA BUS- 20 CM FROM RIGHT SUNSHADE BREAKOUT) 2500 2501 COMPUTER DATA LINES SYSTEM BLK WIRE BLK/WHT WIRE BODY CONTROL MODULE (BCM) (BEHIND LOWER RIGHT SIDE OF DASH) BODY FUSE BLOCK (UNDER LEFT FRONT SEAT) CARGO CARGO DOOR LATCH ASSEMBLY (IN RIGHT REAR CARGO DOOR) CARGO/PASSENGER COURTESY LP CTRL CTSY LP CTRL DK BLU WIRE DK BLU/WHT WIRE DOME DOME READING FL DOME RLY CTRL FRONT DOME/ READING LAMPS GRY WIRE GRY/BLK WIRE HEADLAMP, PANEL DIMMER SWITCH HOT AT ALL TIMES LEFT SUNSHADE LIFTGATE AJAR SW SIG LOWER RIGHT "B" MIDDLE DOME/ READING LAMPS ORG/ WIRE PASSENGER PASSENGER/CARGO W/O RV UPFITTER PNK/BLK WIRE PPL PROVISIONAL READING REAR DOME/ READING LAMPS (PASSENGER) DOME LAMP (CARGO) RED WIRE RIGHT SUNSHADE (ON UPPER RIGHT OF HEADLINER) SPLICE BLOCK TAN WIRE TAN/BLK WIRE TAN/WHT WIRE THE ENGINE BLOCK) (4.3L: RIGHT REAR OF ENGINE) UNDERHOOD FUSE BLOCK (ON LEFT SIDE OF ENGINE COMPT) UNDERHOOD LAMP UPFTR AUX 1 UPFTR CTSY UPFTR CTSY LAMP W/ COMMERCIAL TRADESMAN SALES PACKAGE, CARGO LAMP W/ CUTAWAY W/ CUTAWAY, CARGO W/O RV UPFITTER W/ LEFT, RIGHT SUNSHADE MIRROR W/ RV UPFITTER W/ RV UPFITTER, LEFT, RIGHT SUNSHADE MIRROR W/O RV UPFITTER W/O RV W/ RV UPFITTER UPFITTER WHT WIRE YEL/BLK WIRE

19 16 15 ALARM ENABLE SIG HAZARD SW SIG HAZARD SW SIG 2 1 3 5 B+ B+ B+ RF TURN SIG LP CTRL 2 1 RR TURN SIG LP CTRL LR TURN SIG LP CTRL 5 6 4 STOP LAMPS CTRL BRAKE SIG LF TURN SIG LP CTRL AUX PRK LAMP FUSE 3 BCM 6 FUSE 72 BLK WIRE BLK/WHT WIRE BLU WIRE BODY CONTROL MODULE (BCM) (BEHIND LOWER RIGHT SIDE OF DASH) BODY FUSE BLOCK BRN WIRE CARGO/ PASSENGER CENTER HIGH MOUNTED STOP LAMP (CHMSL) CHMSL CTRL CUTAWAY DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DRIVER OUTSIDE REARVIEW FRT PRK LAMP FUSE 4 FUSE 26 FUSE 7 GROUND DISTRIBUTION SYSTEM HAZARD SWITCH HOT AT ALL TIMES UNDER- HOOD FUSE BLOCK (ON LEFT SIDE OF ENGINE COMPT) LEFT LEFT TAIL/STOP, TURN SIGNAL LAMP LICENSE LAMP LT BLU WIRE LT BLU/WHT WIRE LT REAR PARK LAMP FUSE 8 MEGA FUSE MIRROR (IN DRIVER DOOR) MIRROR (IN RIGHT FRONT PASSENGER DOOR) NCA WIRE PARK LAMP CTRL PARK LAMPS SIG PASSENGER OUTSIDE REARVIEW PRK LAMP RELAY PROVISIONAL RED WIRE RED/WHT WIRE RIGHT RIGHT TAIL/STOP, TURN SIGNAL LAMP RT REAR PRK LAMP FUSE 7 SPLICE SUPPLEMENTAL RESTRAINTS SYSTEM TAN WIRE TRAILER TOW CIRCUIT TRLR PRK LAMP FUSE 5 TURN SIGNAL/ MULTI-FUNCTION SWITCH UPFTR PARK LAMP FUSE 6 W/ AMBULANCE, RECREATIONAL VEHICLE SALES PACKAGE W/ FOLDING MIRRORS RADIO BREAKOUT) W/O REAR WINDOW DEFOGGER WHT WIRE YEL WIRE

1 2 3 4 BATTERY B+ SERIAL DATA BLK WIRE BLK/WHT WIRE BODY CONTROL MODULE (BCM) (BEHIND LOWER RIGHT SIDE OF DASH) CARGO DR UNLCK FUSE 33 CARGO DR UNLCK PCB RELAY CHIME MODULE (BEHIND LEFT CENTER OF DASH) COMPUTER DATA LINES SYSTEM DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DRV DR UNLCK FUSE 36 DRVR DR UNLCK PCB RELAY FRT DR LCK FUSE 31 FRT PASS DR UNLCK FUSE 34 FRT REAR PASS DR UNLCK PCB FTR REAR DR LCK PCB GROUND GRY WIRE GRY/BLK WIRE HOT AT ALL TIMES HOT AT ALL TIMES BODY FUSE BLOCK (UNDER LEFT FRONT SEAT) LEFT REAR SIDE DOOR JAM SWITCH (W/ HINGED DOOR) (AT LEFT "B" PILLAR) LIFTGATE AJAR SW SIG LO SPD GMLAN SERIAL DATA LO SPD SERIAL DATA LT BLU WIRE LT GRN WIRE ORG/BLK WIRE PNK/BLK WIRE RADIO REAR DR LCK FUSE 32 REAR OPEN SW REAR PASS DR UNLCK FUSE 35 RED/WHT WIRE REMOTE CONTROL DOOR LOCK RECEIVER (RCDLR) (BEHIND CENTER OF DASH) RFA/TPM FUSE 21 RIGHT REAR SIDE DOOR JAM SWITCH (W/ CARGO PASSENGER) (AT RIGHT "B" PILLAR) TAN WIRE TAN/BLK WIRE TAN/WHT WIRE W/ COMMERCIAL TRADESMAN W/ HINGED DOOR W/O COMMERCIAL TRADESMAN YEL WIRE YEL/BLK WIRE

10 8 9 LO SPD GMLAN HI SPD GMLAN+ BACKUP LAMPS CIRCUIT BLK WIRE BODY CONTROL MODULE (BCM) (BEHIND LOWER RIGHT SIDE OF DASH) BODY FUSE BLOCK (UNDER LEFT FRONT SEAT) BRN WIRE COMPUTER DATA LINES SYSTEM DK BLU WIRE DK GRN WIRE EXCEPT 5.3L W/ BACKUP ALARM HI SPD GMLAN HOT AT ALL TIMES HOT W/ PRK LAMP LT GRN WIRE LT STOP/ TRN TRLR FUSE 21 LT TRAILER TURN SIGNAL LAMP ORG/ WIRE RED WIRE RED/BLK WIRE RT STOP/ TRN TRLR FUSE 3 RT TRAILER TURN SIGNAL LAMP TAN WIRE TAN/BLK WIRE TRAILER CONNECTOR TRAILER PROVISION (BLUNT CUT) TRLR LT STOP/TRN PCB RELAY TRLR PRK LAMP FUSE 13 TRLR RT STOP/TRN PCB RELAY TRLR WRG FUSE 11 TRLR WRG FUSE 42 UNDERHOOD FUSE BLOCK (ON LEFT SIDE OF ENGINE COMPT) WHT WIRE WHT(OR BLK) WIRE YEL WIRE

1745 1746 844 877 2705 INJ 2 CTRL INJ 3 CTRL INJ 4 CTRL INJ 7 CTRL 2199 469 LOW REF LOW REF 23 1174 STARTING/CHARGING SYSTEM CEN FIELD SIG OIL SW SIG LOW REF LOW REF 486 6265 485 6266 PPL TP SENS 2 SIG CMP SENS SIG TP SENS 1 SIG LOW REF 6271 6272 CKP SENS SIG LOW REF BANK 1 SENSOR 1 (IN EXHAUST PIPE, IN FRONT OF CATALYTIC CONVERTER) BANK 2 SENSOR 1 (IN EXHAUST PIPE, IN FRONT OF CATALYTIC CONVERTER) BLK WIRE BLK/WHT WIRE BRN WIRE DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/WHT WIRE ENGINE CONTROL MODULE (ECM) (LEFT SIDE OF ENGINE COMPT) ENGINE COOLANT TEMPERATURE (ECT) SENSOR (AT LEFT FRONT OF ENGINE) ENGINE OIL LEVEL (EOL) SWITCH (ON RIGHT SIDE OF OIL PAN) GEN ON SIG GRY WIRE GRY/BLK WIRE GRY/WHT WIRE HEATED OXYGEN INJ 1 CTRL ECT SENS SIG LOW REF KS 1 SIG KS 1 SIG KS 2 SIG KS 2 SIG LT BLU WIRE LT BLU/BLK WIRE LT GRN WIRE LT GRN/BLK WIRE MAP SENS SIG PPL ORG/ WIRE ORG/BLK WIRE PNK 5 6 WIRE PNK 7 8 9 10 11 12 13 14 WIRE PNK WIRE PNK/BLK WIRE PPL PPL INTAKE SOL INJ 8 CTRL INJ 5 CTRL INJ 6 CTRL PPL/WHT WIRE PRE SENS SIG SOL CTRL STARTING/ CHARGING SYSTEM TAC MTR CTRL 2 TAC MTR CTRL 1 TAN WIRE TAN/WHT WIRE WHT GRY/ WIRE WHT WIRE WHT/BLK WIRE YEL WIRE YEL/BLK WIRE

A/C REFRIGERANT PRESSURE SENSOR ACC SER DATA IGN VOLT BATT POS VOLT PNK WIRE ACCELERATOR PEDAL POSITION (APP) SENSOR (UNDER LEFT SIDE OF DASH) ANTI-LOCK BRAKES SYSTEM BANK 1 SENSOR 2 BANK 2 SENSOR 2 BLK WIRE BLK/WHT WIRE BREAKOUT) BRK SW FUSE 32 BRN WIRE COMPUTER DATA LINES SYSTEM DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE ECM BATT FUSE 54 ECM IGN FUSE 48 ENGINE CONTROL MODULE (ECM) (LEFT SIDE OF ENGINE COMPT) FUEL PUMP, SENDER ASSEMBLY (ON FUEL TANK) GMLAN DATA- GMLAN DATA+ APP SENS 1 SIG LOW REF LOW REF APP SENS 2 SIG GRY WIRE GRY/WHT WIRE HOT AT ALL TIMES HOT W/ RUN/ CRNK RELAY 69 ENERGIZED IAT SENS SIG LOW REF LT BLU WIRE LT BLU/WHT WIRE MAF SENS SIG NCA WIRE ORG/BLK WIRE ORG/WHT WIRE PNK (OR PNK) 5 6 7 WIRE PNK IGN VOLT WIRE PNK PPL 2 3 4 WIRE PNK WIRE PPL PPL FUEL LEVEL SENS PPL LOW REF PRESS SENS SIG PPL/WHT WIRE PRESS SENS SIG LOW REF PWR/TRN RLY CTRL RED/WHT WIRE RELAY CTRL START RLY CTRL STARTING/CHARGING SYSTEM STOP LAMP SWITCH (BEHIND LEFT SIDE OF DASH, ABOVE BRAKE PEDAL) TAN WIRE TAN/BLK WIRE TAN/WHT WIRE TCC BRAKE SIG TRANSMISSIONS SYSTEM UNDERHOOD FUSE BLOCK (ON LEFT SIDE OF ENGINE COMPT) VSS WHT/BLK WIRE YEL WIRE YEL/BLK WIRE

& IGNITION COIL/MODULE 7) 1 2 3 PNK WIRE 1 2 3 PPL BARE BLK WIRE BLUNT CUT) BRN WIRE COMPUTER DATA DK GRN WIRE DK GRN/WHT WIRE FCSM BATT FUSE 15 FSCM IGN FUSE 11 GMLAN DATA GRY WIRE HOT AT ALL TIMES HOT W/ RUN/ CRNK RELAY 69 ENERGIZED IGN VOLT IGNITION COIL/MODULE 1 IGNITION COIL/MODULE 3 IGNITION COIL/MODULE 5 LINES SYSTEM LOW REF LT BLU WIRE NCA WIRE ORG/ WIRE PNK PNK PNK PNK PNK PNK PNK PNK PNK 4 5 6 7 8 9 10 11 12 WIRE PNK PNK PPL PPL 15 16 17 18 19 20 21 22 23 24 WIRE PNK WIRE POWER DISTRIBUTION PPL PPL 16 17 18 PUMP CTRL RED WIRE RED/WHT WIRE RELAY CTRL SENS SIG SERIAL DATA SPARK PLUG SYSTEM TAN WIRE TAN/BLK WIRE UNDERHOOD FUSE BLOCK (ON LEFT SIDE OF ENGINE COMPT)

& IGNITION COIL/MODULE 8) 1 2 3 PPL BLK WIRE BRN WIRE DK BLU/WHT WIRE DK GRN WIRE ENGINE OIL PRESSURE (EOP) SENSOR (ON TOP REAR OF ENGINE) FUEL INJECTOR 1 FUEL INJECTOR 2 FUEL INJECTOR 3 FUEL INJECTOR 4 FUEL INJECTOR 5 FUEL INJECTOR 6 FUEL INJECTOR 7 FUEL INJECTOR 8 FUEL RAIL PRESSURE (FPR) SENSOR GRY WIRE IGNITION COIL/MODULE 2) IGNITION COIL/MODULE 4 IGNITION COIL/MODULE 6 LT BLU WIRE LT BLU/BLK WIRE LT GRN WIRE LT GRN/BLK WIRE NCA WIRE ORG/BLK WIRE PNK 5 6 WIRE PNK 7 8 9 10 11 12 13 14 WIRE PNK PNK PNK PNK PNK PNK PNK PNK PNK 4 5 6 7 8 9 10 11 12 WIRE PNK WIRE PNK/BLK WIRE PPL PPL 16 17 18 RED WIRE SPARK PLUG TAN WIRE TAN/WHT WIRE YEL/BLK WIRE

1745 1746 844 877 2705 INJ 2 CTRL INJ 3 CTRL INJ 4 CTRL INJ 7 CTRL 2199 469 LOW REF LOW REF 23 1174 STARTING/CHARGING SYSTEM CEN FIELD SIG OIL SW SIG LOW REF LOW REF 486 6265 485 6266 PPL TP SENS 2 SIG CMP SENS SIG TP SENS 1 SIG LOW REF 6271 6272 CKP SENS SIG LOW REF BANK 1 SENSOR 1 (IN EXHAUST PIPE, IN FRONT OF CATALYTIC CONVERTER) BANK 2 SENSOR 1 (IN EXHAUST PIPE, IN FRONT OF CATALYTIC CONVERTER) BLK WIRE BLK/WHT WIRE BRN WIRE DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/WHT WIRE ENGINE CONTROL MODULE (ECM) (LEFT SIDE OF ENGINE COMPT) ENGINE COOLANT TEMPERATURE (ECT) SENSOR (AT LEFT FRONT OF ENGINE) ENGINE OIL LEVEL (EOL) SWITCH (ON RIGHT SIDE OF OIL PAN) GEN ON SIG GRY WIRE GRY/BLK WIRE GRY/WHT WIRE HEATED OXYGEN INJ 1 CTRL ECT SENS SIG LOW REF KS 1 SIG KS 1 SIG KS 2 SIG KS 2 SIG LT BLU WIRE LT BLU/BLK WIRE LT GRN WIRE LT GRN/BLK WIRE MAP SENS SIG PPL ORG/ WIRE ORG/BLK WIRE PNK 5 6 WIRE PNK 7 8 9 10 11 12 13 14 WIRE PNK WIRE PNK/BLK WIRE PPL PPL INTAKE SOL INJ 8 CTRL INJ 5 CTRL INJ 6 CTRL PPL/WHT WIRE PRE SENS SIG SOL CTRL STARTING/ CHARGING SYSTEM TAC MTR CTRL 2 TAC MTR CTRL 1 TAN WIRE TAN/WHT WIRE WHT GRY/ WIRE WHT WIRE WHT/BLK WIRE YEL WIRE YEL/BLK WIRE