Chevrolet Cutaway G3500 (1997-2012) run Wiring diagrams

AIRBAG FUSE 37 BANK 1 SENSOR 1 BANK 1 SENSOR 2 BANK 2 SENSOR 1 BANK 2 SENSOR 2 BRN WIRE BTSI/BU FUSE 36 SPARE FUSE 35 CRUISE CONTROL MODULE (IF EQUIPPED) THROTTLE ACTUATOR CONTROL MODULE CTSY LP RELAY 26 (RV/UPFITTER) CTSY LP/SEO FUSE 3 DK GRN WIRE FR PRK FUSE 22 FROM UNDERHOOD FUSE BLOCK (IGN A FUSE 49) (DIAGRAM 2 OF 6) FROM UNDERHOOD FUSE BLOCK (IGN B, FUSE 52) (DIAGRAM 2 OF 6) FUSE 39 FUSE 40 HEATED OXYGEN SENSOR HEATED OXYGEN SENSOR HEAVY DUTY IGNITION SWITCH INFLATABLE RESTRAINT I/P MODULE DISABLE SWITCH (HEAVY DUTY) INFLATABLE RESTRAINT PASSENGER AIRBAG OFF/ON INDICATOR INFLATABLE RESTRAINT PASSENGER PRESENCE SYSTEM (PPS) MODULE (LIGHT DUTY) INFLATABLE RESTRAINT SENSING, DIAGNOSTIC MODULE ISRVM FUSE 26 LEFT FRONT MARKER LAMP LEFT FRONT PARK/TURN SIGNAL LAMP LICENSE LAMP LIGHT DUTY LOCK LT GRN WIRE LT GRN/BLK WIRE NCA WIRE ORG/ WIRE PARK PARK LP RELAY 29 PARK/ NEUTRAL POSITION (PNP) SWITCH REVERSE PCM IGN 1 FUSE 38 PNK WIRE RED/BLK WIRE RIGHT FRONT PARK/TURN SIGNAL LAMP RIGHT FRONT MARKER LAMP RIGHT TAIL/STOP, TURN SIGNAL LAMP LEFT TAIL/STOP, TURN SIGNAL LAMP RR PRK FUSE 20 LR PRK FUSE 18 RUN WIRE SPARE FUSE 25 STEERING WHEEL SPEED/ POSITION SENSOR STOP LAMP SWITCH (BLUNT CUT) (NOT USED) TBC IGN 1 FUSE 24 TO BODY FUSE BLOCK (AUXILIARY 1 FUSE 32) (DIAGRAM 5 OF 6) TO BODY FUSE BLOCK (BRK FUSE 11) (DIAGRAM 5 OF 6) TO UNDERHOOD FUSE BLOCK (CRANK FUSE 27) (DIAGRAM 4 OF 6) TO UNDERHOOD FUSE BLOCK (ENG 2 FUSE 21) (DIAGRAM 4 OF 6) TO UNDERHOOD FUSE BLOCK (IGN O FUSE 6) (DIAGRAM 4 OF 6) TO UNDERHOOD FUSE BLOCK (TBC ACC FUSE 46) (DIAGRAM 4 OF 6) TRAILER WIRING CUTAWAY TRLR BU FUSE 5 BTSI FUSE 28 TRLR PRK FUSE 21 UPFTR PRK FUSE 16 UNDERHOOD FUSE BLOCK WHT WIRE YEL WIRE

BLK WIRE CRANK FUSE 27 CRANK VOLT DK GRN WIRE ENG 1 FUSE 23 FUSIBLE LINK 2 GENERATOR HOT AT ALL TIMES IGN A FUSE 49 IGN B FUSE 52 IGNITION SWITCH LEFT BATTERY LOCK PARK/NEUTRAL POSITION SWITCH (ON LEFT SIDE OF TRANSMISSION) PNK WIRE POWER DISTRIBUTION SYSTEM POWERTRAIN CONTROL MODULE (PCM) (IN ENG COMPT, ON LEFT INNER FENDER) PPL RED WIRE RED/BLK WIRE RUN WIRE STARTER ENABLE RELAY CTRL STARTER MOTOR STARTER RELAY 61 UNDERHOOD FUSE BLOCK (ON LEFT SIDE OF ENG COMPT) YEL WIRE YEL/BLK WIRE

AIRBAG FUSE 37 BRN WIRE BTSI/BU FUSE 36 CTSY LP RELAY 26 (RV/UPFITTER) CTSY LP/SEO FUSE 3 DK GRN WIRE ECM/TCM/ GLOW PLUG FUSE 38 ENGINE CONTROL MODULE (ECM) FR PRK FUSE 22 FROM UNDERHOOD FUSE BLOCK (IGN A FUSE 49) (DIAGRAM 2 OF 6) FROM UNDERHOOD FUSE BLOCK (IGN B, FUSE 52) (DIAGRAM 2 OF 6) FUEL HEATER FUEL HTR FUSE 25 GLOW PLUG CONTROL MODULE (GPCM) HEAVY DUTY IGNITION SWITCH INFLATABLE RESTRAINT I/P MODULE DISABLE SWITCH (HEAVY DUTY) INFLATABLE RESTRAINT PASSENGER AIRBAG OFF/ON INDICATOR INFLATABLE RESTRAINT PASSENGER PRESENCE SYSTEM (PPS) MODULE (LIGHT DUTY) INFLATABLE RESTRAINT SENSING, DIAGNOSTIC MODULE INSIDE REARVIEW MIRROR (W/ TEMP DISPLAY) BODY CONTROL MODULE (BCM) ISRVM FUSE 26 LEFT FRONT MARKER LAMP LEFT FRONT PARK/TURN SIGNAL LAMP LEFT TAIL/STOP, TURN SIGNAL LAMP RIGHT TAIL/STOP, TURN SIGNAL LAMP LICENSE LAMP LIGHT DUTY LOCK LT GRN WIRE LT GRN/BLK WIRE NOT USED NOT USED ORG/ WIRE PARK PARK LP RELAY 29 PARK/ NEUTRAL POSITION (PNP) SWITCH PNK WIRE RED/BLK WIRE REVERSE RIGHT FRONT MARKER LAMP RIGHT FRONT PARK/TURN SIGNAL LAMP RR PRK FUSE 20 LR PRK FUSE 18 RUN WIRE SPARE FUSE 35 SPARE FUSE 39 SPARE FUSE 40 STEERING WHEEL SPEED/ POSITION SENSOR STOP LAMP SWITCH TBC IGN 1 FUSE 24 TO BODY FUSE BLOCK (AUXILIARY 1 FUSE 32) (DIAGRAM 5 OF 6) TO BODY FUSE BLOCK (BRK FUSE 11) (DIAGRAM 5 OF 6) TO UNDERHOOD FUSE BLOCK (CRANK FUSE 27) (DIAGRAM 4 OF 6) TO UNDERHOOD FUSE BLOCK (IGN O FUSE 6) (DIAGRAM 4 OF 6) TO UNDERHOOD FUSE BLOCK (SPARE FUSE 21) (DIAGRAM 4 OF 6) TO UNDERHOOD FUSE BLOCK (TBC ACC FUSE 46) (DIAGRAM 4 OF 6) TRAILER WIRING CUTAWAY TRANSMISSION CONTROL MODULE (TCM) TRLR BU FUSE 5 BTSI FUSE 28 TRLR PRK FUSE 21 UPFTR PRK FUSE 16 UNDERHOOD FUSE BLOCK WHT WIRE YEL WIRE

ABS/TCC SWITCH ABS/TCS CLASS 2 SERIAL DATA YAW RATE SENSOR LO REF WHEEL POS SENS LOW REF ABS/VSES FUSE 48 AUXILIARY 1 FUSE 32 BLK WIRE BODY FUSE BLOCK (UNDER LEFT FRONT SEAT) BRAKE IN BRKS FUSE 11 BRN WIRE DEL TORQUE DK BLU WIRE DK GRN WIRE ELECTRONIC BRAKE CONTROL MODULE (EBCM) GRY WIRE HOT AT ALL TIMES HOT IN HOT IN RUN OR START IGN E FUSE 22 IGNITION 3 VOLT LATERAL ACCELEROMETER SIG LEFT FRONT WHEEL SPEED SENSOR (ON INSIDE OF LEFT FRONT WHEEL) LEFT REAR WHEEL SPEED SENSOR (AT LEFT REAR OF WHEEL HUB) LT BLU WIRE LT GRN WIRE LT GRN/BLK WIRE NCA WIRE ORG/BLK WIRE PNK 1 2 WIRE PNK WIRE POWER DISTRIBUTION SYSTEM POWERTRAIN CONTROL MODULE (PCM) (IN ENG COMPT, ON LEFT INNER FENDER) PPL PPL UNDERHOOD FUSE BLOCK (ON LEFT SIDE OF ENGINE COMPT) PPL/WHT WIRE PRECHARGE MOTOR LO BATTERY (+) GND PRECHARGE MOTOR HI PRECHARGE PUMP (AT LEFT FRONT OF FRAME RAIL) RED WIRE REQ TORQUE REQUEST TORQUE SIGNAL DELIVERED TORQUE SIGNAL RIGHT FRONT WHEEL SPEED SENSOR (ON INSIDE OF RIGHT FRONT WHEEL) RIGHT REAR WHEEL SPEED SENSOR (AT RIGHT REAR OF WHEEL HUB) RUN WIRE STOP LAMP SWITCH (BEHIND LEFT SIDE OF DASH, ABOVE BRAKE PEDAL) TAN WIRE TAN/BLK WIRE UNDERHOOD FUSE BLOCK (ON LEFT SIDE OF ENGINE COMPT) VEHICLE SPEED SENSOR (VSS) (ON RIGHT SIDE OF TRANSMISSION) VSES MOTOR VSS HIGH VSS LOW VSS OUTPUT WHT WIRE YEL WIRE YEL/BLK WIRE

1 2 PNK IGN VOLT WIRE 149 (OR 690) AMBIENT LIGHT SENS SIG HDLP ON SIG ANTI-LOCK BRAKES SYSTEM EXTERIOR LIGHTS SYSTEM ANTI-THEFT SYSTEM INSTRUMENT CLUSTER SYSTEM BCM 7 FUSE 8 BODY CONTROL MODULE (BCM) (BEHIND LOWER RIGHT SIDE OF DASH) BRN WIRE BRN/WHT WIRE CHMSL CTRL CONTROL SYSTEMS COURTESY LAMP CTRL CRUISE CONTROL SYSTEM CRUISE CONTROL, SOUND SYSTEMS CRUISE CTRL SW SIG CURRENT SENS SIG LO REF IGN VOLT DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DOOR LOCKS, ANTI-THEFT SYSTEMS DOOR LOCKS, ANTI-THEFT SYSTEMS AIR CONDITIONING SYSTEM DRV DOOR LOCK SW UNLOCK SIG DRV DOOR LOCK SW LOCK SIG DRV DR LOCK RLY UNLOCK CTRL DRV DR LOCK RLY UNLOCK CTRL PASS DOOR LOCK SW LOCK CTRL GRY WIRE GRY/BLK WIRE HDLP LOW BEAM RLY CTRL PARK LAMP CTRL HDLP OFF SIG COURTESY LAMPS CTRL HEADLIGHTS SYSTEM HEADLIGHTS SYSTEM EXTERIOR LIGHTS SYSTEM HEADLIGHTS SYSTEM EXTERIOR LIGHTS SYSTEM TRANSMISSIONS SYSTEM HEADLIGHTS SYSTEM INTERIOR LIGHTS SYSTEM HORN RLY CTRL HORNS SYSTEM HOT AT ALL TIMES IGN VOLT IGNITION SWITCH KEY-IN SWITCH LF DOOR OPEN SW SIG A/C REQUEST SIGNAL LF TURN SIG LAMP CTRL STOP LAMPS CTRL TCC BRAKE SIG LIFTGATE AJAR SW SIG LOW REF WIPER LOW SW SIG LT BLU WIRE LT BLU/WHT WIRE LT GRN WIRE OFF ORG/ WIRE ORG/BLK WIRE PARK LAMPS SIG PASS DOOR LOCK SW LOCK CTRL PNK 12 VOLT REF WIRE PNK IGN VOLT L TURN HAZ SW SIG R TURN HAZ SW SIG WIRE PNK WIRE PNK/BLK WIRE PNK/WHT WIRE POWER DISTRIBUTION SYSTEM PPL PPL DEFEAT SW SIG PPL HOOD CLD SW SIG PARK BRAKE SW SIG REAR ACCESS OPEN SW SIG RED/WHT WIRE RF DOOR AJAR SW SIG PASS DR LOCK SW UNLOCK CTRL LF DOOR AJAR SW SIG RR DOOR OPEN SW SIG LR DOOR OPEN SW SIG RF DOOR OPEN SW SIG RUN WIRE STARTING/ CHARGING SYSTEM TAN WIRE TAN/BLK WIRE TAN/WHT WIRE TRACTION CTRL SW SIG BACKUP LAMP RLY CTRL UNDERHOOD FUSE BLOCK (ON LEFT SIDE OF ENGINE COMPT) WHT WIRE WIPER SW SIG 2 FRONT WIND WIPER SW HI SIG WIPER/WASHER SYSTEM WIPER/WASHER SYSTEM SOUND, CRUISE YEL WIRE YEL/BLK WIRE

A/C HIGH PRESSURE SWITCH AUXILIARY AIR TEMPERATURE ACTUATOR AUXILIARY MODE ACTUATOR (LEFT REAR OF PASSENGER COMPT) BLK WIRE BLOW FUSE 51 BLOWER MOTOR (RIGHT REAR OF ENGINE COMPT) BLOWER MOTOR RESISTOR ASSEMBLY (RIGHT REAR OF ENGINE COMPT) BODY FUSE BLOCK (BELOW LEFT FRONT SEAT) BRN WIRE BRN/WHT WIRE DEFOGGER SYSTEM DK BLU WIRE DK GRN/WHT WIRE FRONT AUXILIARY HVAC CONTROL ASSEMBLY (IF EQUIPPED) GRY WIRE HOT AT ALL TIMES HOT IN HVAC 1 FUSE 9 HVAC CONTROL ASSEMBLY HVAC FUSE 10 LOGIC LT BLU WIRE LT GRN WIRE MED OFF OFF MAX NORM BI-LEV ORG/ WIRE PPL R DEFOG IND GROUND ING 3 BATTERY RED WIRE RED/BLK WIRE RED/WHT WIRE RR BLOWER FUSE 13 RUN WIRE TAN WIRE UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT) VENT HEAT HEAT/DEF DEF VENT HEAT HEAT/DEF DEF OFF MAX NORM BI-LEV WHT WIRE YEL WIRE

A/C HIGH PRESSURE SWITCH AUXILIARY HVAC CONTROL PROCESSOR (BEHIND AUXILIARY HVAC ASSEMBLY, IN HEADLINER) BLK WIRE BLOW FUSE 51 BLOWER MOTOR (RIGHT REAR OF ENGINE COMPT) BLOWER MOTOR RESISTOR ASSEMBLY (RIGHT REAR OF ENGINE COMPT) BODY FUSE BLOCK (BELOW LEFT FRONT SEAT) BREAKOUT) BREAKOUT) (W/O RV UPFITTER OPTION: IN FRONT HEADLINER HARN, BRN WIRE BRN/WHT WIRE DEFOGGER SYSTEM DK BLU WIRE DK GRN/WHT WIRE EXCEPT RV FRONT AUXILIARY HVAC CONTROL ASSEMBLY GRY WIRE HOT AT ALL TIMES HOT IN HVAC 1 FUSE 9 HVAC CONTROL ASSEMBLY HVAC FUSE 10 LOGIC LT BLU WIRE LT GRN WIRE MED OFF OFF LO MED HI OFF MAX NORM BI-LEV ORG/ WIRE PNK/BLK WIRE PPL PPL/WHT WIRE R DEFOG IND GROUND ING 3 BATTERY REAR REAR AUXILIARY HVAC CONTROL ASSEMBLY RED WIRE RED/BLK WIRE RED/WHT WIRE RR BLOWER FUSE 13 RUN WIRE TAN WIRE UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT) VENT HEAT HEAT/DEF DEF VENT HEAT HEAT/DEF DEF OFF MAX NORM BI-LEV WHT WIRE YEL WIRE

BANK 1 SENSOR 1 BANK 1 SENSOR 2 BANK 2 SENSOR 1 BANK 2 SENSOR 2 BLUNT CUT) BODY FUSE BLOCK BRN WIRE BTSI/BU FUSE 36 SPARE FUSE 25 CRUISE CONTROL MODULE (IF EQUIPPED) CTSY LP RELAY (RV/UPFITTER) CTSY LP/SEO FUSE 3 CUTAWAY DK GRN WIRE FR PRK FUSE 22 FROM BODY FUSE BLOCK (AUXILIARY 2 FUSE 33) (DIAGRAM 2 OF 6) FROM UNDERHOOD FUSE BLOCK (IGN A FUSE 49) (DIAGRAM 2 OF 6) FROM UNDERHOOD FUSE BLOCK (IGN B, FUSE 52) (DIAGRAM 2 OF 6) FUSE 39 FUSE 40 HEATED OXYGEN SENSOR HEATED OXYGEN SENSOR IGNITION SWITCH INFLATABLE RESTRAINT I/P MODULE DISABLE SWITCH (HEAVY DUTY) INFLATABLE RESTRAINT SENSING, DIAGNOSTIC MODULE INSIDE REARVIEW MIRROR (W/ TEMP DISPLAY) BODY CONTROL MODULE (BCM) ISRV FUSE 26 LEFT FRONT MARKER LAMP LEFT FRONT PARK/TURN SIGNAL LAMP LICENSE LAMP LOCK LOCK OFF LT GRN WIRE LT GRN/BLK WIRE NCA WIRE OFF ORG/ WIRE PARK PARK LP RELAY PARK/ NEUTRAL POSITION (PNP) SWITCH PCM IGN 1 FUSE 38 PNK WIRE POWERTRAIN CONTROL MODULE (PCM) RED/BLK WIRE REVERSE RIGHT FRONT MARKER LAMP RIGHT FRONT PARK/TURN SIGNAL LAMP RIGHT TAIL/STOP, TURN SIGNAL LAMP LEFT TAIL/STOP, TURN SIGNAL LAMP RIGHT TAILLAMP ASSEMBLY LEFT TAILLAMP ASSEMBLY RR PRK FUSE 20 LR PRK FUSE 18 RUN WIRE SIR FUSE 37 SPARE FUSE 35 STOP LAMP SWITCH (BLUNT CUT) (NOT USED) TBC IGN 1 FUSE 24 TO BODY FUSE BLOCK (AUXILIARY 1 FUSE 32) (DIAGRAM 5 OF 6) TO BODY FUSE BLOCK (BRKS FUSE 11) (DIAGRAM 5 OF 6) TO UNDERHOOD FUSE BLOCK (CRANK FUSE 27) (DIAGRAM 4 OF 6) TO UNDERHOOD FUSE BLOCK (ENG 2 FUSE 21) (DIAGRAM 4 OF 6) TO UNDERHOOD FUSE BLOCK (IGN O FUSE 6) (DIAGRAM 4 OF 6) TO UNDERHOOD FUSE BLOCK (TBC ACC FUSE 46) (DIAGRAM 4 OF 6) TRAILER WIRING TRAILER WIRING CUTAWAY TRLR BU FUSE 5 BTSI FUSE 28 TRLR PRK FUSE 21 UPFTR PRK FUSE 16 UNDERHOOD FUSE BLOCK WHT WIRE YEL WIRE

1 14 5 SERIAL DATA BRAKE WARN IND CTRL PASSENGER SEAT BELT IND 19 15 16 ALARM ENABLE SIG HAZARD SW LEFT SIG HAZARD SW RIGHT SIG 2 59 28 60 SERIAL DATA LH SEAT BELT SW LOW REF RH SEAT BELT SW 8 17 PARK LAMP SIGNAL HEADLAMP SW OFF SIG AIR BAG FUSE 28 AUTO OFF 3 8 BATTERY BLK WIRE BLK/WHT WIRE BLU WIRE BODY CONTROL MODULE (BCM) (BEHIND LOWER RIGHT SIDE OF DASH) BODY FUSE BLOCK (UNDER LEFT FRONT SEAT) CHIME MODULE (W/O RADIO) (BEHIND LEFT CENTER OF DASH) CONNECTOR BREAKOUT) DATA LINK CONNECTOR (DLC) DK BLU/WHT WIRE DK GRN WIRE DRIVER DOOR LATCH ASSEMBLY (AT REAR OF DRIVER DOOR) DRIVER INFORMATION CENTER (DIC) DISPLAY DRIVER SEAT BELT BUCKLE DRIVER SEAT BELT SWITCH FUSE 22 GROUND GRY WIRE GRY/BLK WIRE HAZARD SWITCH HEAD PARK HEADLAMP, PANEL DIMMER SWITCH HOT AT ALL TIMES IGN SW IGNITION KEY SWITCH IGNITION SWITCH PNK WIRE INFLATABLE RESTRAINT SENSING, DIAGNOSTIC MODULE (SDM) (UNDER LEFT FRONT SEAT) INSTRUMENT PANEL CLUSTER (IPC) LEFT REAR DOOR JAMB SWITCH (W/ LEFT REAR HINGED DOOR) (AT LEFT "B" PILLAR) LEFT TURN LOGIC LT BLU WIRE LT BLU/BLK WIRE OFF ORG/ WIRE PARK BRAKE SWITCH (UNDER LEFT SIDE OF DASH) PARK BRK SW SIG PASSENGER AIR BAG IND PASSENGER DOOR LATCH ASSEMBLY (AT REAR OF FRONT PASSENGER DOOR) PASSENGER SEAT BELT BUCKLE (W/O MANUAL SUPPRESSION SWITCH, RV UPFITTER) PASSENGER SEAT BELT IND PASSENGER SEAT BELT SWITCH PNK IGN VOLT WIRE PNK PNK PNK PNK WIRE PNK PNK WIRE PNK WIRE PPL RADIO RDO/CHIME FUSE 20 RED WIRE RED/WHT WIRE RIGHT REAR DOOR JAMB SWITCH (CARGO/ PASSENGER) (AT RIGHT "B" PILLAR) RIGHT TURN RUN WIRE SEAT BELT IND LOW OIL PRESSURE IND TIRE PRESSURE IND SERIAL DATA SPLICE BLOCK SUPPLEMENTAL RESTRAINTS SYSTEM TAN WIRE TAN/WHT WIRE TURN SIGNAL/ MULTI-FUNCTION SWITCH W/ ELECTRIC SIDE DOOR LOCK CONTROL W/ MANUAL SUPPRESSION SWITCH W/O MANUAL SUPPRESSION SWITCH, RV UPFITTER W/O RADIO WHT WIRE YEL WIRE YEL/BLK WIRE

BLK WIRE BODY FUSE BLOCK (UNDER LEFT FRONT SEAT) BRK FUSE 11 BRN WIRE CRANKSHAFT POSITION (CKP) SENSOR (NEXT TO CRANKSHAFT PULLEY) DK BLU WIRE DK GRN WIRE FUEL PUMP (LEFT CENTER INNER FRAME RAIL) GRY WIRE GRY/BLK WIRE HIGH IDLE SWITCH HOT IN LT GRN WIRE LT GRN/BLK WIRE MANIFOLD ABSOLUTE PRESSURE (MAP) SENSOR (ATTACHED TO INTAKE MANIFOLD TUBE) NCA WIRE ORG/ WIRE ORG/BLK WIRE PNK WIRE PPL 11 12 PPL 20 21 PPL/WHT WIRE RED WIRE RED/WHT WIRE RUN WIRE TAN WIRE TURBOCHANGER VANE POSITION SENSOR (TOP OF TURBOCHARGER) WHT/BLK WIRE YEL WIRE