Chevrolet Cutaway G3500 (1997-2012) ppl pnk Wiring diagrams

ABS IND. AIR BAG IND BLK WIRE BLK/WHT WIRE BODY CONTROL MODULE (BCM) (BEHIND LOWER RIGHT SIDE OF DASH) BODY FUSE BLOCK (UNDER LEFT BODY FUSE BLOCK (UNDER LEFT FRONT SEAT) BRAKE IND BRN WIRE BRN/WHT WIRE CHARGE IND CMPS FUSE 19 COMPUTER DATA LINES SYSTEM CRUISE IND DIESEL DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/WHT WIRE DRIVER INFORMATION CENTER (DIC) ENGINE COMPT) ENGINE CONTROLS SYSTEM SUPPLEMENTAL RESTRAINTS SYSTEM ENGINE COOLANT TEMPERATURE GAUGE FRONT SEAT) FUEL GAUGE GMLAN SERIAL GRY/BLK WIRE HIGH BEAM IND HOT AT ALL TIMES HOT W/ RUN RELAY HOT W/ RUN/CRANK RELAY 15 ENERGIZED IGN VOLT IND CTRL IND LAMP (MIL) INSTRUMENT PANEL CLUSTER (IPC) IP CLSTR FUSE 10 IP CLSTR FUSE 23 LEFT TURN IND LIFTGATE AJAR SW SIG LF DOOR AJAR SW RR DOOR OPEN SW LR DOOR OPEN SW LOGIC LOW ENGINE OIL LOW ENGINE OIL PRESSURE GAUGE LOW TIRE PRESSURE IND LT BLU WIRE LT GRN WIRE MALFUNCTION MIL CTRL NETWORK 3 ODOMETER PARK BRAKE SWITCH (UNDER LEFT SIDE OF DASH) PASS SEAT BELT PNK WIRE PNK/BLK WIRE PPL PPL PNK WIRE PRESSURE IND RED/WHT WIRE RF DOOR AJAR SW RIGHT TURN IND SEAT BELT IND SECURITY IND SEO FUSE 27 SPEEDOMETER SUPPLEMENTAL RESTRAINTS SYSTEM SW SIG SWITCH SIG TAN/WHT WIRE TOW/HAUL IND TRACTION CONTROL IND UNDERHOOD FUSE BLOCK (ON LEFT SIDE OF VOLTS GAUGE W/ ODOMETER SECURITY WIRING PROVISION (SEO) W/O ODOMETER SECURITY WIRING PROVISION (SEO) WAIT TO START IND WHT WIRE YEL WIRE YEL/BLK WIRE

1589 2759 PPL 31 16 LOW REF SENS SIG PPL 4.3L 4.8L/5.3L/6.0L 6.6L 50 41 36 35 SENS SIG BLK WIRE BLK/WHT WIRE BRAKE BOOSTER FLUID FLOW ALARM SWITCH (W/ BRAKE WARNING INDICATOR) BRAKE BOOSTER FLUID PRESSURE ALARM SWITCH (IN POWER STEERING PUMP INLET HOSE) BRAKE FLUID LEVEL SWITCH (AT LEFT REAR OF ENGINE COMPT) BRAKE PRESSURE BRN WIRE CARGO DOOR LATCH ASSEMBLY (W/ CARGO/PASSENGER) (IN RIGHT REAR CARGO DOOR) COMPUTER DATA LINES SYSTEM DIFFERENTIAL SWITCH (ON BRAKE VALVE, NEAR FRONT OF EBCM) DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/WHT WIRE DRIVER DOOR LATCH ASSEMBLY (AT REAR OF DRIVER DOOR) DRIVER INFORMATION CENTER (DIC) SWITCH ENGINE CONTROL MODULE (ECM) (LEFT SIDE OF ENGINE COMPT) ENGINE CONTROLS SYSTEM ENGINE OIL LEVEL SWITCH (ON LEFT SIDE OF OIL PAN) ENGINE OIL PRESSURE (EOP) SENSOR (EXCEPT 6.6L: ON TOP REAR OF ENGINE) EXCEPT 5.3L 5.3L FUEL LEVEL SENSOR (ON LEFT FRAME FUEL PUMP, SENDER ASSEMBLY (ON FUEL TANK) GRY WIRE GRY/BLK WIRE ILLUMI- NATION IND CTRL LEFT REAR SIDE DOOR JAMB SWITCH (W/ HINGED) (AT LEFT "B" PILLAR) LIGHT DUTY LOW REF LT BLU/BLK WIRE PASSENGER DOOR LATCH ASSEMBLY (AT REAR OF FRONT PASSENGER DOOR) PERSON- ALIZATION PNK WIRE PNK/BLK WIRE PPL PPL HEAVY DUTY PPL PNK WIRE RAIL) RIGHT REAR SIDE DOOR JAMB SWITCH (W/ CARGO/PASSENGER) (AT RIGHT "B" PILLAR) SENS SIG LOW REF SET/ RESET SWITCH SIG DATA LINK RESISTOR 44 43 TAN WIRE TAN/BLK WIRE TAN/WHT WIRE TRIP/ FUEL VEHICLE INFO W/ BRAKE WARNING INDICATOR SYSTEM WATER IN-FUEL SENSOR WHT WIRE YEL WIRE YEL/BLK WIRE

2-3 SHIFT SOL 34 35 PNK WIRE 687 436 SHIFT SOLENOID OUTPUT AIR PUMP RELAY CNTRL VSS SIGNAL BLK WIRE BLK/WHT WIRE BLU WIRE BRN WIRE BRN/WHT WIRE CAMSHAFT POSITION SENSOR (PART OF DISTRIBUTOR, REAR TOP OF ENGINE) CANISTER VET SIG CMP RETURN FUEL LVL SIG OUT TCC SOL OUTPUT PPL CMP SIGNAL DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/WHT WIRE DK PNK WIRE EVAPORATIVE EMISSION CANISTER VENT VALVE (ON LEFT FRAME RAIL, NEAR FUEL TANK) GRN WIRE KNOCK SENS SIGNAL KNOCK SENSOR (TOP REAR OF ENGINE) LT BLU/BLK WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/WHT WIRE LT LT LT PPL MAP SENS SIGNAL IAT SIG ECT SIG TP SIG FUEL TANK PRESS SIG 472 410 NCA WIRE PNK 13 14 15 16 17 WIRE PNK PNK PPL PNK PNK 1 2 3 4 5 6 7 8 WIRE PNK PPL WIRE PNK WIRE PNK/BLK WIRE PPL PPL CKP LOW VSS LOW CSS SIG CKP SIG PPL PNK WIRE PPL PPL PPL/WHT WIRE RED/BLK WIRE SOLID STATE TAN WIRE TAN/BLK WIRE TAN/WHT WIRE TEMP SENS SIGNAL MAF SIGNAL IAC HIGH IAC LOW FUEL INJ 4 FUEL INJ 3 TRANS TRANS PNK PPL PNK WIRE VEHICLE CONTROL MODULE (VCM) (LEFT SIDE OF ENGINE COMPARTMENT) VEHICLE SPEED SENSOR (LEFT SIDE OF TRANSMISSION) WHT WIRE YEL WIRE YEL/BLK WIRE

18 19 20 21 22 23 PNK WIRE 7 8 9 10 11 12 PNK PNK PNK PNK WIRE AIR FUSE BLK WIRE BLK/WHT WIRE BLU WIRE BRN WIRE BRN/WHT WIRE DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE ECM-B FUSE FUEL LVL INPUT FUEL PUMP RELAY FUEL PUMP, SENDER (IN FUEL TANK UNDER REAR OF VEHICLE) SIG OUT SIG IN FUEL TANK PRESSURE SENSOR (IN FUEL TANK) GAUGES FUSE 4 GRN WIRE GRY WIRE HOT AT ALL TIMES HOT IN OFF, RUN OR START HOT IN RUN OR START I/P FUSE BLOCK INPUT INSTRUMENT CLUSTER LT BLU/WHT WIRE LT GRN WIRE MALFUNCTION INDICATOR LAMP (MIL) "SERVICE ENGINE SOON" MANIFOLD ABSOLUTE PRESSURE SENSOR (TOP RIGHT SIDE OF ENGINE) MASS AIRFLOW SENSOR (PART OF AIR INTAKE DUCT, TOP FRONT OF ENGINE) ODOMETER SPEEDOMETER/ ORG/ WIRE PNK 1 2 WIRE PNK PNK 1 2 3 4 5 6 7 8 9 10 11 WIRE PNK WIRE PPL PPL PNK WIRE RED WIRE RED/BLK WIRE SECONDARY AIR INJECTION REACTION PUMP CLUTCH SECONDARY AIR INJECTION REACTION PUMP RELAY SECONDARY AIR INJECTION REACTION SOLENOID SENSOR, BANK 2 SENSOR 1) TAN WIRE TAN/WHT WIRE THROTTLE POSITION SENSOR (ON SIDE OF THROTTLE BODY) TRANS FUSE 20 UNDERHOOD FUSE/RELAY CENTER WHT WIRE YEL WIRE YEL/BLK WIRE

18 19 20 21 22 23 PNK WIRE 420 1807 PPL PPL BRAKE SWITCH INPUT SERIAL DATA 5-VOLT REFERENCE A/C COMP CYCLING SW A/C COMPRESSOR ENABLE RELAY A/C REQUEST SIG AIR CONDITIONING SYSTEM AUTOMATIC TRANSMISSION INPUT SHAFT SPEED SENSOR BATTERY BATTERY RANGE SIG B RANGE SIG A BLK WIRE BLK/WHT WIRE BLU WIRE BRAKE FUSE 18 BRN WIRE BRN/WHT WIRE COIL CRUISE CONTROL MODULE (FRONT OF ENGINE COMPARTMENT NEAR LEFT FENDER) CRUISE CTRL SIG-ENG DATA LINK CONNECTOR (UNDER LEFT SIDE OF DASH) DISTRIBUTOR DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/WHT WIRE EGR VALVE CTRL ELECTRONIC BRAKE CONTROL MODULE (EBCM) (LEFT FRAME RAIL NEAR CENTER OF VEHICLE) FUEL PUMP RLY FEED 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 GRY WIRE HIGH VOLTAGE COIL WIRE HOT IN RUN I/P FUSE BLOCK IGNITION IGNITION COIL (TOP REAR OF ENGINE) IGNITION CONTROL MODULE (TOP RIGHT SIDE OF ENGINE, AT IGNITION COIL) LT BLU/BLK WIRE LT BLU/WHT WIRE ORG/ WIRE PCS HIGH INPUIT SPEED SENS LOW INPUT SPEED SENS HIGH IC CNTRL PCS LOW GROUND GROUND SENSOR GROUND PNK IGNITION WIRE PNK PNK 1 2 3 4 5 6 7 8 9 10 11 WIRE PNK WIRE PPL PPL 420 PPL PNK WIRE RADIO RANGE SIG C 5 VOLTS REFERENCE FUEL LVL MODULE RED WIRE RED/BLK WIRE SENSOR GROUND SERIAL DATA VSS SIGNAL SOLID STATE SPEED SENSOR INPUT CRUISE ENGAGED OUTPUT STOPLAMP SWITCH INPUT TAN/WHT WIRE TCC SIGNAL TCC/STOPLAMP SWITCH (BEHIND DASH, ON BRAKE PEDAL SUPPORT) UNDERHOOD FUSE/RELAY CENTER VEHICLE CONTROL MODULE (VCM) (LEFT SIDE OF ENGINE COMPARTMENT) VSS SIGNAL OUTPUT VSS SIGNAL OUTPUT MAL FUNC LP OUTPUT 389 419 WHT WIRE WHT/BLK WIRE YEL WIRE YEL/BLK WIRE

27 28 29 30 31 PPL 5 VOLT REF BLK WIRE BLU WIRE BRAKE FUSE 18 BRN WIRE BRN/WHT WIRE CMP SIG DK GRN WIRE DK GRN/WHT WIRE ELECTRONIC BRAKE CONTROL MODULE (LEFT FRAME RAIL, NEAR CENTER OF VEHICLE) GRN WIRE GRY WIRE HIGH RES SIG HOT AT ALL TIMES HOT IN HOT IN OFF, RUN OR START I/P FUSE BLOCK IGNITION TIMING STEPPER MOTOR (TOP FRONT OF ENGINE) LT BLU WIRE LT GRN WIRE OPTICAL FUEL/ TEMPERATURE SENSOR (TOP CENTER OF ENGINE, ON FUEL INJECTION PUMP) ORG/ WIRE ORG/BLK WIRE PNK PNK PPL 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 WIRE PNK WIRE PNK/BLK WIRE PPL PPL PNK WIRE RED WIRE RED/BLK WIRE RUN WIRE SENS GRD STOP FUSE 1 TAN WIRE TAN/BLK WIRE TCC/STOPLAMP SWITCH (BEHIND DASH, ON BRAKE PEDAL SUPPORT) TRANS FUSE 20 WHT WIRE YEL WIRE YEL/BLK WIRE

1786 5985 TRANSMISSIONS SYSTEM COMPUTER DATA LINES SYSTEM 2759 3108 2365 2931 6288 419 2927 2366 507 2366 3657 COOLING FANS SYSTEM 7493 2500 440 5991 2364 23 6141 6399 1439 COMPUTER DATA LINES SYSTEM AIR CONDITIONING SYSTEM APP SIG 1 5 VOLT REF 5 VOLT REF BLK WIRE BRN WIRE BRN/WHT WIRE COMPUTER DATA LINES SYSTEM 439 492 225 1272 COOLING FANS SYSTEM CRUISE/ETC/TCC BRK SIG CUTAWAY DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/WHT WIRE ENGINE CONTROL MODULE (ECM) (LEFT SIDE OF ENGINE COMPT) EXHAUST TEMPERATURE SENSOR 2 EXHAUST TEMPERATURE SENSOR 3 EXHAUST TEMPERATURE SENSOR 5 GRY WIRE GRY/BLK WIRE INJ HIGH CTRL A/C CLUTCH RLY CTRL LOW REF LOW REF LT BLU WIRE LT BLU/WHT WIRE LT GRN WIRE MASS AIR FLOW (MAF)/INTAKE AIR TEMP (IAT) SENSOR (ATTACHED TO AIR INTAKE DUCT) NCA WIRE ORG/ WIRE ORG/BLK WIRE PNK IGN 1 VOLT AIR FLOW SENS SIG GENERATOR TURN ON SIG LOW REF WIRE PNK PNK WIRE PNK WIRE PPL PPL PNK WIRE RED/WHT WIRE REDUCTANT PRESSURE SENSOR REDUCTANT PURGE SOLENOID VALVE STARTING/CHARGING SYSTEM STARTING/CHARGING SYSTEM 3101 6783 TAN WIRE TAN/BLK WIRE WHT WIRE WHT/ DK BLU WIRE WHT/BLK WIRE YEL WIRE YEL/BLK WIRE

A/C REFRIGERANT PRESSURE SENSOR ACCELERATOR PEDAL POSITION (APP) SENSOR (UNDER LEFT SIDE OF DASH) BLK WIRE BRN WIRE BRN/WHT WIRE COMPUTER DATA LINES SYSTEM CUTAWAY DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE EXHAUST AFTERTREATMENT FUEL INJECTOR GRY WIRE GRY/WHT WIRE HI SPD GMLAN SER DATA - IGN VOLT IND INSTRUMENT PANEL CLUSTER (IPC) LOGIC IND CTRL LOW ENGINE OIL PRESSURE IND LT BLU WIRE LT GRN WIRE MALFUNCTION INDICATOR LAMP MIL SER CTRL DATA NITROGEN OXIDES SENSOR 1 NITROGEN OXIDES SENSOR 2 ORG/WHT WIRE PNK PNK WIRE PNK WIRE PNK/BLK WIRE PPL PPL PNK WIRE PPL/WHT WIRE RED/WHT WIRE REDUCTANT INJECTOR REDUCTANT LINE HEATER REDUCTANT PUMP REDUCTANT SENSOR MODULE REDUCTANT TANK HEATER SENS 1 GND SENS 1 SPLY VOLT SENS 2 GND TAN WIRE TAN/BLK WIRE WAIT TO WHT/BLK WIRE YEL WIRE YEL/BLK WIRE

1786 5985 TRANSMISSIONS SYSTEM COMPUTER DATA LINES SYSTEM 2759 3108 7493 2500 440 5991 2364 23 6141 6399 1439 COMPUTER DATA LINES SYSTEM AIR CONDITIONING SYSTEM APP SIG 1 5 VOLT REF 5 VOLT REF BLK WIRE BREAKOUT TOWARDS INSTRUMENT PANEL CLUSTER) BRN WIRE BRN/WHT WIRE COMPUTER DATA LINES SYSTEM 439 492 225 1272 COOLING FANS SYSTEM CRUISE/ETC/TCC BRK SIG CUTAWAY DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/WHT WIRE ENGINE CONTROL MODULE (ECM) (LEFT SIDE OF ENGINE COMPT) EXHAUST TEMPERATURE SENSOR 2 EXHAUST TEMPERATURE SENSOR 3 (MIDDLE OF DIESEL PARTICULATE FILTER) EXHAUST TEMPERATURE SENSOR 4 GRY WIRE GRY/BLK WIRE INJ HIGH CTRL A/C CLUTCH RLY CTRL LOW REF LOW REF LT BLU WIRE LT BLU/WHT WIRE LT GRN WIRE MASS AIR FLOW (MAF)/INTAKE AIR TEMP (IAT) SENSOR (ATTACHED TO AIR INTAKE DUCT) NCA WIRE ORG/ WIRE ORG/BLK WIRE PNK IGN 1 VOLT AIR FLOW SENS SIG GENERATOR TURN ON SIG LOW REF WIRE PNK PNK WIRE PNK WIRE PPL PPL 28 29 PPL PNK WIRE RED/WHT WIRE STARTING/ CHARGING SYSTEM STARTING/CHARGING SYSTEM TAN WIRE TAN/BLK WIRE WHT LT BLU/ WIRE WHT WIRE WHT/ DK BLU WIRE WHT/BLK WIRE YEL WIRE YEL/BLK WIRE

A/C REFRIGERANT PRESSURE SENSOR ACCELERATOR PEDAL POSITION (APP) SENSOR (UNDER LEFT SIDE OF DASH) BLK WIRE BRN WIRE BRN/WHT WIRE COMPUTER DATA LINES SYSTEM CUTAWAY DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE GRY WIRE GRY/WHT WIRE HI SPD GMLAN SER DATA - IGN VOLT IND INSTRUMENT PANEL CLUSTER (IPC) LOGIC IND CTRL LOW ENGINE OIL PRESSURE IND LT BLU WIRE LT GRN WIRE MALFUNCTION INDICATOR LAMP MIL SER CTRL DATA NITROGEN OXIDES SENSOR 1 (TOP LEFT REAR SIDE OF ENGINE) NITROGEN OXIDES SENSOR 2 (MIDDLE OF DIESEL PARTICULATE FILTER) ORG/BLK WIRE ORG/WHT WIRE PNK PNK WIRE PNK WIRE PNK/BLK WIRE PPL PPL 28 29 PPL PNK WIRE PPL/WHT WIRE RED/WHT WIRE REDUCTANT LINE HEATER REDUCTANT SENSOR MODULE (ABOVE REDUCTANT TANK) REDUCTANT TANK HEATER SENS 1 GND SENS 1 SPLY VOLT SENS 2 GND TAN WIRE TAN/BLK WIRE WAIT TO WHT/BLK WIRE YEL WIRE YEL/BLK WIRE