Chevrolet Cutaway G3500 (1997-2012) dk blu Wiring diagrams

2 6 3 1 CAN BUS HI LO REF CAN BUS LO 32 33 34 35 36 37 38 VEHICLE SPD SIG CAN BUS HI DATA 5.3L, 4.8L, 6.0L 4.3L ABS MDL FUSE 2 ABS MTR FUSE 1 BLK WIRE BLK/PPL WIRE BRK SW FUSE 13 BRN WIRE BRN/WHT WIRE COMPUTER DATA LINES SYSTEM DIESEL DIESEL GASOLINE DK BLU WIRE DK GRN WIRE ENGINE CONTROL MODULE (ECM) (LEFT SIDE OF ENGINE COMPT) FUSE 29 GASOLINE GRY WIRE GRY/BLK WIRE HI SPD GMLAN DATA + HI SPD GMLAN DATA + B+ HI SPD GMLAN DATA- HI SPD GMLAN DATA- GND HOT AT ALL TIMES HOT W/ RUN/CRNK RELAY 15 ENERGIZED IPC FUSE 10 LEFT FRONT WHEEL SPEED SENSOR (WSS) (ON INSIDE OF LEFT FRONT WHEEL) LEFT REAR WHEEL SPEED SENSOR (WSS) (AT LEFT REAR WHEEL HUB) LF WHEEL SPD SENS LOW REF LOW REF LOW REF RF WHEEL SPD SENS LT BLU WIRE LT BLU/WHT WIRE LT GRN WIRE ORG/ WIRE ORG/BLK WIRE PNK WIRE RED WIRE RED/BLK WIRE RED/WHT WIRE RIGHT FRONT WHEEL SPEED SENSOR (WSS) (ON INSIDE OF RIGHT FRONT WHEEL) SERIAL DATA ENABLE B+ STEERING ANGLE SENS CAN BUS LO DATA STOP LAMP SWITCH (BEHIND LEFT SIDE OF DASH, ABOVE BRAKE PEDAL) STR/WHL/ SNSR TAN WIRE TAN/BLK WIRE UNDERHOOD FUSE BLOCK (ON LEFT SIDE OF ENGINE COMPT) VEHICLE SPEED SIGNAL WHT WIRE WHT/BLK WIRE YAW, LATERAL ACCELERATION SENSOR (UNDER FRONT PASSENGER SEAT) YEL WIRE YEL/BLK WIRE

3 21 DIMMING CTRL TRACTION SW 6 16 TCC BRAKE SIG PRK BRK SW ABS IND. BLK WIRE BLK/WHT WIRE BODY CONTROL MODULE (BCM) (BEHIND LOWER RIGHT SIDE OF DASH) BRAKE BOOSTER FLUID FLOW ALARM SWITCH (IN POWER STEERING PUMP OUTLET HOSE) BRAKE FLUID LEVEL SWITCH (AT LEFT REAR OF ENGINE COMPT) BRAKE IND BRAKE PRESSURE DIFFERENTIAL SWITCH (ON BRAKE VALVE, NEAR FRONT OF EBCM) BRAKE WARNING INDICATOR CTRL BREAKOUT TOWARDS INSTRUMENT PANEL CLUSTER) BRK FLUID LEVEL SENSOR SIG BRN WIRE BRN/WHT WIRE COMPUTER DATA LINES SYSTEM DK BLU WIRE DK GRN WIRE GRY WIRE HEAVY DUTY IGN VOLT IGN VOLT STEERING SENS A STEERING SENS C INSTRUMENT PANEL CLUSTER (IPC) LIGHT DUTY LO SPD GMLAN LOGIC LOGIC STEERING WHEEL SPEED/ POSITION SENSOR (AT BASE OF STEERING COLUMN) LOW STABILITY IND LT BLU WIRE LT BLU/BLK WIRE LT BLU/WHT WIRE LT GRN WIRE ORG/BLK WIRE PARK BRAKE SWITCH (UNDER LEFT PNK 7 3 5 6 2 4 1 8 WIRE PNK WIRE PPL RIGHT REAR WHEEL SPEED SENSOR (WSS) (AT RIGHT REAR WHEEL HUB) SERIAL DATA SIDE OF DASH) STEERING SENS B TAN WIRE TAN/WHT WIRE TRACTION CONTROL SWITCH VDC IND WHT WIRE YEL WIRE

ABS IND. AIR BAG IND BLK WIRE BLK/WHT WIRE BODY CONTROL MODULE (BCM) (BEHIND LOWER RIGHT SIDE OF DASH) BODY FUSE BLOCK (UNDER LEFT BODY FUSE BLOCK (UNDER LEFT FRONT SEAT) BRAKE IND BRN WIRE BRN/WHT WIRE CHARGE IND CMPS FUSE 19 COMPUTER DATA LINES SYSTEM CRUISE IND DIESEL DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/WHT WIRE DRIVER INFORMATION CENTER (DIC) DISPLAY ENGINE COMPT) ENGINE CONTROLS SYSTEM SUPPLEMENTAL RESTRAINTS SYSTEM ENGINE COOLANT TEMPERATURE GAUGE FRONT SEAT) FUEL GAUGE GMLAN SERIAL GRY/BLK WIRE HIGH BEAM IND HOT AT ALL TIMES HOT W/ RUN RELAY HOT W/ RUN/CRNK RELAY 15 ENERGIZED I/P CLUSTER FUSE 23 IGN VOLT IND CTRL IND LAMP (MIL) INSTRUMENT PANEL CLUSTER (IPC) IPC FUSE 10 LEFT TURN IND LIFTGATE AJAR SW SIG LF DOOR AJAR SW RR DOOR OPEN SW LR DOOR OPEN SW LOGIC LOW ENGINE OIL PRESSURE GAUGE LOW FUEL IND LOW OIL LOW STABILITY IND LT BLU WIRE LT GRN WIRE MALFUNCTION MIL CTRL NETWORK 3 ODOMETER PARK BRAKE SWITCH (UNDER LEFT SIDE OF DASH) PASS SEAT BELT PASSENGER SEAT BELT IND PNK WIRE PNK/BLK WIRE PPL PPL PNK WIRE PRESSURE IND PRND 321 RED/WHT WIRE RF DOOR AJAR SW RIGHT TURN IND SEAT BELT IND SECURITY IND SEO FUSE 27 SPEEDOMETER SUPPLEMENTAL RESTRAINTS SYSTEM SW SIG SWITCH SIG TAN/WHT WIRE TIRE PRESSURE IND TOW/HAUL IND TRACTION CONTROL IND UNDERHOOD FUSE BLOCK (ON LEFT SIDE OF VOLTS GAUGE W/ BRAKE WARNING INDICATOR SYSTEM W/ ODOMETER SECURITY WIRING PROVISION (SEO) W/O ODOMETER SECURITY WIRING PROVISION (SEO) WAIT TO START IND WHT WIRE YEL WIRE YEL/BLK WIRE

1589 2759 PPL 2759 1589 (OR 6049) 31 16 LOW REF SENS SIG PPL 4.3L 4.8L/5.3L/6.0L 6.6L 44 43 DATA BUS(-) DATA BUS(+) 50 41 36 35 SENS SIG 7 8 PPL 9 10 PPL BLK WIRE BLK/WHT WIRE BRN WIRE CARGO DOOR LATCH ASSEMBLY (W/ CARGO/PASSENGER) (IN RIGHT REAR CARGO DOOR) COMPUTER DATA LINES SYSTEM DK BLU WIRE DK BLU/WHT WIRE DK BLU/YEL WIRE DK GRN WIRE DK GRN/WHT WIRE DRIVER DOOR LATCH ASSEMBLY DRIVER INFORMATION CENTER (DIC) SWITCH ENGINE CONTROL MODULE (ECM) (LEFT SIDE OF ENGINE COMPT) GRY WIRE GRY/BLK WIRE ILLUMI- NATION LEFT REAR SIDE DOOR JAMB SWITCH (W/ LEFT REAR HINGED DOOR) LOW REF PASSENGER DOOR LATCH ASSEMBLY (AT REAR OF FRONT PASSENGER DOOR) PERSON- ALIZATION VEHICLE INFO PNK WIRE PNK/BLK WIRE PPL PPL 2 3 PPL PNK WIRE RIGHT REAR DOOR JAMB SWITCH (W/ CARGO/PASSENGER) SENS SIG SENS SIG LOW REF SET/ RESET SWITCH SIG TAN WIRE TAN/BLK WIRE TAN/WHT WIRE TRIP/ FUEL W/ BRAKE WARNING INDICATOR SYSTEM WATER IN-FUEL SENSOR WHT WIRE YEL WIRE YEL/BLK WIRE

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 LH AUDIO SIG (+) RH AUDIO SIG (+) 1 2 3 4 5 6 7 8 9 10 11 12 13 14 B+ LF MID OUT (+) RF MID OUT (+) 1959 1955 LR MID OUT (-) RR MID OUT (-) 2 1 8 LO REF 658 1782 VOICE SIG DRAIN WIRE HI SPD GMLAN ANTENNA IN BATT POSITIVE VOLT BLK/WHT WIRE BODY CONTROL MODULE (BCM) (BEHIND LOWER RIGHT SIDE OF DASH) BODY FUSE BLOCK (UNDER LEFT FRONT SEAT) BREAKOUT) BRN/WHT WIRE CELLULAR, DIGITAL RADIO ANTENNA CELLULAR/ NAVIGATION ANTENNA COAX COMPUTER DATA LINES SYSTEM CRUISE CONTROL SYSTEM CUTAWAY UPFITTER DIGITAL RADIO RECEIVER (LEFT SIDE OF DASH) DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE DRAIN WIRE GRY WIRE HOT AT ALL TIMES INFLATABLE RESTRAINT STEERING WHEEL MODULE COIL (AT TOP OF STEERING COLUMN) INFO LED DIMMING CTRL GND LF MID OUT (-) RF MID OUT (-) LEFT CARGO DOOR SPEAKER (IF EQUIPPED) LEFT FRONT SPEAKER LEFT REAR SPEAKER LH AUDIO SIG + RH AUDIO SIG + LO GMLAN SERIAL DATA LO REF LO SERIAL DATA LR MID OUT (+) RR MID OUT (+) LT BLU WIRE LT BLU/BLK WIRE LT GRN WIRE MUTE NCA WIRE ORG/ WIRE PASSENGER/ CARGO PNK WIRE RADIO RADIO ANTENNA RDO/ CHIME FUSE 20 RED/WHT WIRE RIGHT CARGO DOOR SPEAKER (IF EQUIPPED) RIGHT FRONT SPEAKER RIGHT REAR SPEAKER RIGHT STEERING WHEEL CONTROL SWITCH SEEK DOWN SEEK UP SOURCE STEERING WHEEL CTRL TAN WIRE TAN/BLK WIRE TAN/WHT WIRE USB CABLE USB CHARGE USB RECEPTACLE VEHICLE COMMUNICATION INTERFACE MODULE (VICM) (BELOW STEERING COLUMN) VOICE SIG VOL DOWN VOL UP W/ VEHICLE COMMUNICATION SYSTEM W/O VEHICLE COMMUNICATION SYSTEM WHT WIRE YEL WIRE

5.3L 5.3L EXCEPT 5.3L A/C REFRIGERANT PRESSURE SENSOR ACC SER DATA IGN VOLT BATT POS VOLT PNK WIRE ACCELERATOR PEDAL POSITION (APP) SENSOR (UNDER LEFT SIDE OF DASH) ANTI-LOCK BRAKES SYSTEM BANK 1 SENSOR 2 BANK 2 SENSOR 2 BLK LT BLU/ WIRE BLK WIRE BLK/WHT WIRE BRAKE PEDAL POSITION (BPP) SENSOR (TOP OF BRAKE PEDAL ASSEMBLY) BREAKOUT) BRK SENS SPLY BRK SW FUSE 13 BRN WIRE COMPUTER DATA LINES SYSTEM CUTAWAY DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE ECM BATT FUSE 19 ECM IGN/ GLOW PLUG MDL IGN FUSE 30 ENGINE CONTROL MODULE (ECM) (LEFT SIDE OF ENGINE COMPT) ENGINE COOLANT RADIATOR TEMPERATURE SENSORS FUEL PUMP, SENDER ASSEMBLY (ON FUEL TANK) FUEL TANK PRESSURE (FTP) SENSOR (ON FUEL TANK) GRY WIRE GRY/WHT WIRE HOT AT ALL TIMES HOT W/ RUN/ CRNK RELAY 15 ENERGIZED IAT SENS SIG LOW REF ECT SENS SIG LOW REF LOW REF PRESS SENS SIG PPL LT BLU WIRE LT BLU/ BLK WIRE LT BLU/BLK WIRE LT BLU/WHT WIRE LT GRN WIRE MAF SENS SIG LOW REF ORG/BLK WIRE ORG/WHT WIRE PNK (OR PNK) 5 6 7 WIRE PNK IGN VOLT WIRE PNK PPL 2 3 4 WIRE PNK WIRE PPL PPL FUEL LEVEL SENS PPL/WHT WIRE PRESS SENS SIG LOW REF PWR/TRN RLY CTRL RED/WHT WIRE RELAY CTRL START RLY CTRL STARTING/ CHARGING SYSTEM STOP LAMP SWITCH (BEHIND LEFT SIDE OF DASH, ABOVE BRAKE PEDAL) TAN WIRE TAN/BLK WIRE TAN/WHT WIRE TCC BRAKE SIG TOWARDS INSTRUMENT PANEL CLUSTER) TRANSMISSIONS SYSTEM UNDERHOOD FUSE BLOCK (ON LEFT SIDE OF ENGINE COMPT) VSS WHT WIRE WHT/BLK WIRE YEL WIRE YEL/BLK WIRE

BANK 1 SENSOR 1 (IN EXHAUST PIPE, IN FRONT OF CATALYTIC CONVERTER) BANK 2 SENSOR 1 (IN EXHAUST PIPE, IN FRONT OF CATALYTIC CONVERTER) BLK WIRE BRN WIRE CAMSHAFT POSITION (CMP) SENSOR (FRONT OF ENGINE) CEN FIELD SIG CKP SENS SIG LOW REF DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/WHT WIRE ENGINE CONTROL MODULE (ECM) (LEFT SIDE OF ENGINE COMPT) ENGINE COOLANT TEMPERATURE (ECT) SENSOR (AT LEFT FRONT OF ENGINE) GEN ON SIG GRY WIRE GRY/BLK WIRE GRY/WHT WIRE HEATED OXYGEN INJ 1 CTRL ECT SENS SIG LOW REF INJ 2 CTRL INJ 3 CTRL INJ 4 CTRL INJ 7 CTRL KNOCK SENSOR (KS) 1 KNOCK SENSOR (KS) 2 KS 1 SIG KS 1 SIG KS 2 SIG KS 2 SIG LOW REF LOW REF LT BLU WIRE LT BLU/BLK WIRE LT GRN WIRE LT GRN/BLK WIRE MAP SENS SIG PPL ORG/ WIRE ORG/BLK WIRE PNK 5 6 WIRE PNK 7 8 9 10 11 12 13 14 WIRE PNK WIRE PNK/BLK WIRE PPL PPL INTAKE SOL INJ 8 CTRL INJ 5 CTRL INJ 6 CTRL PPL TP SENS 2 SIG CMP SENS SIG TP SENS 1 SIG LOW REF PPL/WHT WIRE PRE SENS SIG SOL CTRL STARTING/ CHARGING SYSTEM STARTING/CHARGING SYSTEM TAC MTR CTRL 2 TAC MTR CTRL 1 TAN WIRE TAN/WHT WIRE WHT GRY/ WIRE WHT WIRE WHT/BLK WIRE YEL WIRE YEL/BLK WIRE

5 VOLT REF ACT CTRL CLOSE ACT CTRL OPEN BLK/WHT WIRE BRK APLY SENS SIG BRN WIRE BRN/GRY WIRE BRN/WHT WIRE CAC TEMP SENS SIG CKP SENS SIG CMP SENS SIG CTRL CYL 2 CTRL CYL 3 CTRL CYL 5 CTRL CYL 8 DK BLU WIRE DK BLU/WHT WIRE DK BLU/YEL WIRE DK GRN WIRE DK GRN/WHT WIRE ECT SENS SIG EGR VALVE SENS SIG EGRT SENS 1 SPLY VOLT EGRT SENS 2 SPLY VOLT EGRV MTR HIGH SIG EGRV MTR LOW SIG EGT SENS 1 SIG ENGINE CONTROL MODULE (ECM) (LEFT SIDE OF ENGINE COMPT) EXHAUST TEMPERATURE SENSOR 1 FUEL TEMP 1 SIG FUEL TEMP SIG GRY WIRE GRY/BLK WIRE GRY/WHT WIRE INTAKE AIR VALVE LOW REF LOWER RIGHT FRONT OF ENGINE) LT GRN WIRE LT GRN/BLK WIRE LT GRN/WHT WIRE NCA WIRE OIL PRESSURE SENS SIG ORG/BLK WIRE PNK PNK WIRE PNK WIRE PNK/BLK WIRE POS SENS SIG POS SENS SIG 1 PPL/WHT WIRE PRESSURE SENS RTN PRESSURE SENS SIG PRESSURE SW SIG RED/WHT WIRE SENS SPLY VOLT TAN WIRE TAN/BLK WIRE TAN/WHT WIRE TEMP 1 RTN TEMP SENS RTN TEMP SENS SIG WATER IN FUEL SENS SIG WATER IN-FUEL SENSOR WHT WIRE WHT/BLK WIRE YEL WIRE YEL/BLK WIRE

BLK WIRE BLK/WHT WIRE BRK SW FUSE 13 BRN WIRE BRN/WHT WIRE CRANKSHAFT POSITION (CKP) SENSOR (NEXT TO CRANKSHAFT PULLEY) DIESEL FUEL PUMP FUSE 24 DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/WHT WIRE ECM BATT FUSE 19 ECM IGN/GLOW PLUG MDL IGN FUSE 30 ECM PWR/ TRN FUSE 45 EXHAUST GAS RECIRCULATION (EGR) TEMPERATURE SENSOR 2 EXHAUST GAS RECIRCULATION (EGR) VALVE (RIGHT SIDE OF ENGINE ABOVE 1 CYLINDER) FUEL FILTER PRESSURE SWITCH (TOP LEFT REAR SIDE OF ENGINE) FUEL HTR FUSE 71 FUEL INJECTOR 2 (ON LEFT SIDE OF ENGINE) FUEL INJECTOR 3 (ON RIGHT SIDE OF ENGINE) FUEL INJECTOR 5 (ON RIGHT SIDE OF ENGINE) FUEL INJECTOR 8 (ON LEFT SIDE OF ENGINE) FUEL PUMP RELAY GRY WIRE GRY/BLK WIRE GRY/WHT WIRE HOT AT ALL TIMES HOT W/ RUN/CRNK RELAY 15 ENERGIZED LOWER RIGHT FRONT OF ENGINE) LT BLU WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/WHT WIRE MAF/ CNSTR FUSE 64 NCA WIRE ORG/BLK WIRE PNK PNK WIRE PNK WIRE PNK/BLK WIRE PPL/WHT WIRE PWR/ TRN RELAY 49 RED/WHT WIRE TAN WIRE TAN/WHT WIRE UNDERHOOD FUSE BLOCK (ON LEFT SIDE OF ENGINE COMPT) WHT/BLK WIRE YEL WIRE

5 VOLT REF ANTI-LOCK BRAKES SYSTEM BLK WIRE BLK/WHT WIRE BRN WIRE BRN/WHT WIRE DFI VOLT CTRL CYL 4 DFI VOLT CTRL CYL 6 DFI VOLT CTRL CYL 7 DFI VOLT CTRL CYL 8 DK BLU WIRE ENGINE CONTROL MODULE (ECM) (LEFT SIDE OF ENGINE COMPT) ENGINE OIL PRESSURE (EOP) SENSOR (LOWER LEFT SIDE OF ENGINE) FUEL INJECTOR 1 (ON RIGHT SIDE OF ENGINE) FUEL INJECTOR 6 (ON LEFT SIDE OF ENGINE) GND SOL HIGH SIG GRY WIRE LOW REF LOWER RIGHT FRONT OF ENGINE) LT BLU WIRE LT BLU/WHT WIRE NCA WIRE ORG/BLK WIRE PNK WIRE PPL PPL/ WHT WIRE PPL/WHT WIRE SENS VOLT REF 5 VOLT REF TAN WIRE TAN/WHT WIRE TURBOCHARGER VANE POSITION SENSOR (ON TOP OF TURBOCHARGER) VEHICLE SPD SIG WHT WIRE WHT/ BLK WIRE YEL WIRE YEL/BLK WIRE