Chevrolet Cutaway G3500 (1997-2012) dk blu Wiring diagrams

A/T ISS LO SIG ACC WAKEUP DATA BLK/WHT WIRE BRK SW FUSE 32 BRN WIRE COMPUTER DATA LINES SYSTEM DK BLU WIRE DK BLU/WHT WIRE GMLAN DATA (-) 2-3 SHIFT SOL GMLAN DATA (-) VSS LOW SIG PC SOL LOW CTRL GRY WIRE HOT AT ALL TIMES HOT W/ RUN/ CRANK RELAY 69 ENERGIZED HOT W/ RUN/ CRANK RELAY ENERGIZED LT BLU/WHT WIRE LT GRN WIRE LT GRN/BLK WIRE ORG/ WIRE ORG/BLK WIRE P/N PARK/NEUTRAL POSITION (PNP) SWITCH PNK WIRE POWER DISTRIBUTION SYSTEM PPL/WHT WIRE RED/WHT WIRE REPLICATED TOS SIG GMLAN DATA (+) GMLAN DATA (-) STOP LAMP SWITCH (BEHIND LEFT SIDE OF DASH, ABOVE BRAKE PEDAL) TAN WIRE TAN/BLK WIRE TAN/WHT WIRE TCM BATT FUSE 44 TCM IGN FUSE 47 TFP SW B SIG TFT SENS SIG TR SW A SIG LOW REF IGN VOLT BATT POS VOLT TFP SW C SIG TR SW B SIG TR SW C SIG TFP SW A SIG PNK WIRE TRANS FUSE 51 TRANSMISSION CONTROL MODULE (TCM) (LEFT FRONT CORNER OF ENGINE COMPT) UNDERHOOD FUSE BLOCK WHT WIRE YEL WIRE YEL/BLK WIRE

1-2 SHIFT SOLENOID VALVE 2-3 SHIFT SOLENOID VALVE 30 45 39 MIL CTRL TOS SIG 44 57 GMLAN (-) GMLAN (+) ACTUATOR SIG AUTOMATIC TRANSMISSION AUTOMATIC TRANSMISSION FLUID TEMPERATURE (TFT) SENSOR BLK WIRE BLK/WHT WIRE BODY CONTROL MODULE (BCM) (BEHIND LOWER RIGHT SIDE OF DASH) BRN WIRE BRN/WHT WIRE CLASS 2 CLASS 2 DATA COMPUTER DATA LINES SYSTEM DK BLU WIRE DK GRN WIRE ENGINE CONTROL MODULE (ECM) FLUID PRESSURE (TFP) MANUAL VALVE POSITION SWITCH GRY WIRE IGN INSTRUMENT PANEL CLUSTER (IPC) LOGIC LT BLU WIRE LT BLU/WHT WIRE LT GRN WIRE NCA WIRE ORG/ WIRE ORG/BLK WIRE PNK WIRE PPL PRESSURE CONTROL (PC) SOLENOID VALVE RED WIRE REV TAN WIRE TAN YEL/BLK WIRE TAN/BLK WIRE TORQUE CONVERTER CLUTCH (TCC) PULSE WIDTH MODULATION (PWM) SOLENOID VALVE TOW/ HAUL IND CLASS 2 TOW/HAUL SW TOW/HAUL SWITCH YEL WIRE YEL/BLK WIRE

2 3 11 13 DATA BUS (-) DATA BUS (+) 2 3 DATA BUS (+) DATA BUS (-) 2 3 SERIAL DATA SERIAL DATA 5 4 6 7 157 147 167 177 DATA BUS (+) DATA BUS (-) DATA BUS (-) DATA BUS (+) 6 5 DATA BUS (-) DATA BUS (+) 6.6L 4.8L, 5.3L, 6.0L 4.3L ACC WAKE UP SERIAL DATA DATA BUS (+) DATA BUS (-) BLK/WHT WIRE CHIME MODULE (BEHIND LEFT CENTER OF DASH) CUTAWAY DATA LINK CONNECTOR (DLC) (UNDER LEFT SIDE OF DASH) DATA LINK RESISTOR DIGITAL RADIO RECEIVER (S-BAND DIGITAL AUDIO SYSTEM) (LEFT SIDE OF DASH) DK BLU WIRE DK GRN WIRE ENGINE CONTROL MODULE (ECM) (LEFT SIDE OF ENGINE COMPT) HOT AT ALL TIMES INFLATABLE RESTRAINT SENSING, DIAGNOSTIC MODULE (SDM) (UNDER LEFT FRONT SEAT) INSTRUMENT PANEL CLUSTER (IPC) LIGHT DUTY W/O RECREATIONAL VEHICLE, UPFITTER SALES PACKAGE LT GRN WIRE LTR/DLC FUSE 73 NITROGEN OXIDES SENSOR 1 (TOP LEFT REAR SIDE OF ENGINE) NITROGEN OXIDES SENSOR 2 (MIDDLE OF DIESEL PARTICULATE FILTER) RADIO RED WIRE RED/WHT WIRE REDUCTANT SENSOR MODULE (ABOVE REDUCTANT TANK) REMOTE CONTROL DOOR LOCK RECEIVER (RCDLR) (IF EQUIPPED) (BEHIND CENTER OF DASH) SERIAL DATA SPLICE PACK TAN WIRE TAN/BLK WIRE UNDERHOOD FUSE BLOCK (ON LEFT SIDE OF ENGINE COMPT) W/O RADIO WHT WIRE

16 17 19 DATA BUS (-)) DATA BUS (+) DATA ENABLE 19 26 2501 2500 DATA BUS (-) DATA BUS (+) 2 12 DATA BUS (+) DATA BUS (-) DATA BUS (+) DATA BUS (-) 25 18 2500 2501 DATA BUS (+) DATA BUS (-) 4.8L 4.3L, 6.0L, 5.3L 4.8L 6.0L 5.3L 6.6L 6.6L 9 8 10 DATA BUS (-) DATA BUS (+) SERIAL DATA ACC WAKE UP SERIAL DATA 11 15 19 7 6 38 37 ACC WAKE UP SERIAL DATA PNK WIRE ACC WAKE-UP SERIAL DATA AUTOMATIC TRANSMISSION (6 SPEED A/T) BLK WIRE BODY CONTROL MODULE (BCM) (BEHIND LOWER CONTROL SOLENOID VALUE ASSEMBLY COOLANT HEATER (6.6L, W/ FUEL FIRED AUXILIARY HEATER) DATA BUS - DATA BUS - DATA BUS - DATA BUS+ DATA BUS+ DATA BUS- DATA BUS- DATA COMM ENABLE DATA ENABLE DATA BUS (+) DATA BUS (-) DATA BUS (-) DATA BUS (+) DK BLU WIRE DK GRN WIRE EXCEPT 5.3L EXCEPT AUXILIARY 5.3L 5.3L HEATER IGN DATA BUS (+) DATA BUS (-) LT BLU WIRE TAN WIRE TAN/BLK WIRE TRANSMISSION CONTROL MODULE (TCM) (4 SPEED A/T) VEHICLE COMMUNICATION INTERFACE MODULE (VCM) (BELOW STEERING COLUMN) W/ ACTIVE BRAKE CONTROL W/ FUEL FIRED AUXILIARY HEATER W/ FUEL W/O FUEL FIRED FIRED AUXILIARY HEATER W/ VECHILE COMMUNICATION SYSTEM W/O ACTIVE BRAKE CONTROL W/O FUEL FIRED AUXILIARY HEATER W/O VECHILE COMMUNICATION SYSTEM

21 19 69 14 71 CTRL SPD SIG CTRL SPD SIG SPEED SIG BLK WIRE BLK/WHT WIRE BRN/WHT WIRE COMPUTER DATA LINES SYSTEM COOLANT LEVEL SWITCH COOLING FAN ASSEMBLY (BEHIND RADIATOR) DK BLU WIRE DK GRN WIRE DRIVER INFORMATION CENTER (DIC) DISPLAY ENGINE CONTROL MODULE (ECM) ENGINE COOLANT GAUGE TEMPERATURE ENGINE COOLANT TEMPERATURE (ECT) SENSOR (TOP OF ENGINE, NEAR THERMOSTAT HOUSING) FAN CLTCH (EV) FUSE 63 GRY WIRE HOT W/ PWR/TRN RELAY 49 ENERGIZED INSTRUMENT PANEL CLUSTER (IPC) LOGIC LOW REF LOW SPD GMLAN SERIAL DATA LT GRN WIRE PNK WIRE SENS SIG LOW REF TAN WIRE UNDERHOOD FUSE BLOCK (ON LEFT SIDE OF ENGINE COMPT) WHT WIRE WHT/BLK WIRE YEL WIRE

1 18 25 COURTESY LP CTRL COURTESY LP CTRL DEFEAT SW SIG 149 (OR 690) 20 CM FROM RIGHT SUNSHADE BREAKOUT) BLK WIRE BLK/WHT WIRE BLU WIRE BODY CONTROL MODULE (BCM) (BEHIND LOWER RIGHT SIDE OF DASH) BODY FUSE BLOCK (UNDER LEFT FRONT SEAT) CARGO CARGO DOOR LATCH ASSEMBLY (IN RIGHT REAR CARGO DOOR) CARGO/PASSENGER COURTESY LP CTRL CTSY LP CTRL DK BLU WIRE DK BLU/WHT WIRE DOME DOME READING FL DOME RLY CTRL FRONT DOME/ READING LAMPS GRY WIRE GRY/BLK WIRE HEADLAMP, PANEL DIMMER SWITCH HOT AT ALL TIMES LEFT SUNSHADE LIFTGATE AJAR SW SIG MIDDLE DOME/ READING LAMPS ORG/ WIRE PASSENGER PASSENGER/CARGO W/O RV UPFITTER PNK/BLK WIRE PPL PROVISIONAL READING REAR DOME/ READING LAMPS (PASSENGER) DOME LAMP (CARGO) RED WIRE RIGHT SUNSHADE (ON UPPER RIGHT OF HEADLINER) TAN/WHT WIRE THE ENGINE BLOCK) UNDERHOOD FUSE BLOCK (ON LEFT SIDE OF ENGINE COMPT) UNDERHOOD LAMP UPFTR AUX 1 FUSE 36 (W/ CUTAWAY, AMBULANCE, RV UPFITTERS) UPFTR CTSY LAMPS FUSE 4 UPFTR CTSY LAMPS PCB RELAY (W/ AMBULANCE, RV UPFITTER) W/ COMMERCIAL TRADESMAN SALES PACKAGE, CARGO LAMP W/ CUTAWAY W/ CUTAWAY, CARGO W/O RV UPFITTER W/ LEFT, RIGHT SUNSHADE MIRROR W/ RV UPFITTER W/ RV UPFITTER, LEFT, RIGHT SUNSHADE MIRROR W/O RV UPFITTER W/O RV W/ RV UPFITTER UPFITTER WHT WIRE YEL/BLK WIRE

5.3L 5.3L EXCEPT 5.3L A/C REFRIGERANT PRESSURE SENSOR ACC SER DATA IGN VOLT BATT POS VOLT PNK WIRE ACCELERATOR PEDAL POSITION (APP) SENSOR (UNDER LEFT SIDE OF DASH) ANTI-LOCK BRAKES SYSTEM BANK 1 SENSOR 2 BANK 2 SENSOR 2 BLK LT BLU/ WIRE BLK WIRE BLK/WHT WIRE BRAKE PEDAL POSITION (BPP) SENSOR (TOP OF BRAKE PEDAL ASSEMBLY) BREAKOUT) BRK SENS SPLY BRK SW FUSE 13 BRN WIRE COMPUTER DATA LINES SYSTEM CUTAWAY DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE ECM BATT FUSE 19 ECM IGN/ GLOW PLUG MDL IGN FUSE 30 ENGINE CONTROL MODULE (ECM) (LEFT SIDE OF ENGINE COMPT) ENGINE COOLANT RADIATOR TEMPERATURE SENSORS FUEL PUMP, SENDER ASSEMBLY (ON FUEL TANK) FUEL TANK PRESSURE (FTP) SENSOR (ON FUEL TANK) GRY WIRE GRY/WHT WIRE HOT AT ALL TIMES HOT W/ RUN/ CRNK RELAY 15 ENERGIZED IAT SENS SIG LOW REF ECT SENS SIG LOW REF LOW REF PRESS SENS SIG PPL LT BLU WIRE LT BLU/ BLK WIRE LT BLU/BLK WIRE LT BLU/WHT WIRE LT GRN WIRE MAF SENS SIG LOW REF ORG/BLK WIRE ORG/WHT WIRE PNK (OR PNK) 5 6 7 WIRE PNK IGN VOLT WIRE PNK PPL 2 3 4 WIRE PNK WIRE PPL PPL FUEL LEVEL SENS PPL/WHT WIRE PRESS SENS SIG LOW REF PWR/TRN RLY CTRL RED/WHT WIRE RELAY CTRL START RLY CTRL STARTING/ CHARGING SYSTEM STOP LAMP SWITCH (BEHIND LEFT SIDE OF DASH, ABOVE BRAKE PEDAL) TAN WIRE TAN/BLK WIRE TAN/WHT WIRE TCC BRAKE SIG TOWARDS INSTRUMENT PANEL CLUSTER) TRANSMISSIONS SYSTEM UNDERHOOD FUSE BLOCK (ON LEFT SIDE OF ENGINE COMPT) VSS WHT WIRE WHT/BLK WIRE YEL WIRE YEL/BLK WIRE

BANK 1 SENSOR 1 (IN EXHAUST PIPE, IN FRONT OF CATALYTIC CONVERTER) BANK 2 SENSOR 1 (IN EXHAUST PIPE, IN FRONT OF CATALYTIC CONVERTER) BLK WIRE BRN WIRE CAMSHAFT POSITION (CMP) SENSOR (FRONT OF ENGINE) CEN FIELD SIG CKP SENS SIG LOW REF DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/WHT WIRE ENGINE CONTROL MODULE (ECM) (LEFT SIDE OF ENGINE COMPT) ENGINE COOLANT TEMPERATURE (ECT) SENSOR (AT LEFT FRONT OF ENGINE) GEN ON SIG GRY WIRE GRY/BLK WIRE GRY/WHT WIRE HEATED OXYGEN INJ 1 CTRL ECT SENS SIG LOW REF INJ 2 CTRL INJ 3 CTRL INJ 4 CTRL INJ 7 CTRL KNOCK SENSOR (KS) 1 KNOCK SENSOR (KS) 2 KS 1 SIG KS 1 SIG KS 2 SIG KS 2 SIG LOW REF LOW REF LT BLU WIRE LT BLU/BLK WIRE LT GRN WIRE LT GRN/BLK WIRE MAP SENS SIG PPL ORG/ WIRE ORG/BLK WIRE PNK 5 6 WIRE PNK 7 8 9 10 11 12 13 14 WIRE PNK WIRE PNK/BLK WIRE PPL PPL INTAKE SOL INJ 8 CTRL INJ 5 CTRL INJ 6 CTRL PPL TP SENS 2 SIG CMP SENS SIG TP SENS 1 SIG LOW REF PPL/WHT WIRE PRE SENS SIG SOL CTRL STARTING/ CHARGING SYSTEM STARTING/CHARGING SYSTEM TAC MTR CTRL 2 TAC MTR CTRL 1 TAN WIRE TAN/WHT WIRE WHT GRY/ WIRE WHT WIRE WHT/BLK WIRE YEL WIRE YEL/BLK WIRE

5.3L 5.3L EXCEPT 5.3L A/C REFRIGERANT PRESSURE SENSOR ACC SER DATA IGN VOLT BATT POS VOLT PNK WIRE ACCELERATOR PEDAL POSITION (APP) SENSOR (UNDER LEFT SIDE OF DASH) ANTI-LOCK BRAKES SYSTEM BANK 1 SENSOR 2 BANK 2 SENSOR 2 BLK LT BLU/ WIRE BLK WIRE BLK/WHT WIRE BRAKE PEDAL POSITION (BPP) SENSOR (TOP OF BRAKE PEDAL ASSEMBLY) BREAKOUT) BRK SENS SPLY BRK SW FUSE 13 BRN WIRE COMPUTER DATA LINES SYSTEM CUTAWAY DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE ECM BATT FUSE 19 ECM IGN/ GLOW PLUG MDL IGN FUSE 30 ENGINE CONTROL MODULE (ECM) (LEFT SIDE OF ENGINE COMPT) ENGINE COOLANT RADIATOR TEMPERATURE SENSORS FUEL PUMP, SENDER ASSEMBLY (ON FUEL TANK) FUEL TANK PRESSURE (FTP) SENSOR (ON FUEL TANK) GRY WIRE GRY/WHT WIRE HOT AT ALL TIMES HOT W/ RUN/ CRNK RELAY 15 ENERGIZED IAT SENS SIG LOW REF ECT SENS SIG LOW REF LOW REF PRESS SENS SIG PPL LT BLU WIRE LT BLU/ BLK WIRE LT BLU/BLK WIRE LT BLU/WHT WIRE LT GRN WIRE MAF SENS SIG LOW REF ORG/BLK WIRE ORG/WHT WIRE PNK (OR PNK) 5 6 7 WIRE PNK IGN VOLT WIRE PNK PPL 2 3 4 WIRE PNK WIRE PPL PPL FUEL LEVEL SENS PPL/WHT WIRE PRESS SENS SIG LOW REF PWR/TRN RLY CTRL RED/WHT WIRE RELAY CTRL START RLY CTRL STARTING/ CHARGING SYSTEM STOP LAMP SWITCH (BEHIND LEFT SIDE OF DASH, ABOVE BRAKE PEDAL) TAN WIRE TAN/BLK WIRE TAN/WHT WIRE TCC BRAKE SIG TOWARDS INSTRUMENT PANEL CLUSTER) TRANSMISSIONS SYSTEM UNDERHOOD FUSE BLOCK (ON LEFT SIDE OF ENGINE COMPT) VSS WHT WIRE WHT/BLK WIRE YEL WIRE YEL/BLK WIRE

BANK 1 SENSOR 1 (IN EXHAUST PIPE, IN FRONT OF CATALYTIC CONVERTER) BANK 2 SENSOR 1 (IN EXHAUST PIPE, IN FRONT OF CATALYTIC CONVERTER) BLK WIRE BRN WIRE CAMSHAFT POSITION (CMP) SENSOR (FRONT OF ENGINE) CEN FIELD SIG CKP SENS SIG LOW REF DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/WHT WIRE ENGINE CONTROL MODULE (ECM) (LEFT SIDE OF ENGINE COMPT) ENGINE COOLANT TEMPERATURE (ECT) SENSOR (AT LEFT FRONT OF ENGINE) GEN ON SIG GRY WIRE GRY/BLK WIRE GRY/WHT WIRE HEATED OXYGEN INJ 1 CTRL ECT SENS SIG LOW REF INJ 2 CTRL INJ 3 CTRL INJ 4 CTRL INJ 7 CTRL KNOCK SENSOR (KS) 1 KNOCK SENSOR (KS) 2 KS 1 SIG KS 1 SIG KS 2 SIG KS 2 SIG LOW REF LOW REF LT BLU WIRE LT BLU/BLK WIRE LT GRN WIRE LT GRN/BLK WIRE MAP SENS SIG PPL ORG/ WIRE ORG/BLK WIRE PNK 5 6 WIRE PNK 7 8 9 10 11 12 13 14 WIRE PNK WIRE PNK/BLK WIRE PPL PPL INTAKE SOL INJ 8 CTRL INJ 5 CTRL INJ 6 CTRL PPL TP SENS 2 SIG CMP SENS SIG TP SENS 1 SIG LOW REF PPL/WHT WIRE PRE SENS SIG SOL CTRL STARTING/ CHARGING SYSTEM STARTING/CHARGING SYSTEM TAC MTR CTRL 2 TAC MTR CTRL 1 TAN WIRE TAN/WHT WIRE WHT GRY/ WIRE WHT WIRE WHT/BLK WIRE YEL WIRE YEL/BLK WIRE