Chevrolet Chevy Express H1500 (2003-2012) lt grn Wiring diagrams

37 38 GMLAN HI-SPD (-) GMLAN HI-SPD (+) 38 37 GMLAN HI-SPD (+) GMLAN HI-SPD (-) 39 23 46 29 RANGE SW - P RANGE SW - C RANGE SW - B RANGE SW - A 72 32 RANGE SW - B RANGE SW - A BACKUP LAMP (LEFT) BACKUP LAMP- RIGHT BKUP LAMP SUPPLY BLK WIRE BLK/WHT WIRE BODY CONTROL MODULE (BEHIND LOWER RIGHT SIDE OF DASH) CLASS 2 DATA COMPUTER DATA LINES SYSTEM CUTAWAY DIESEL DK GRN WIRE ENGINE CONTROL MODULE (LEFT FRONT SIDE OF ENGINE COMPARTMENT) GAS GROUND GRY WIRE HOT AT ALL TIMES LT GRN WIRE MIRRORS SYSTEM PARK/NEUTRAL POSITION SWITCH (ON LEFT SIDE OF TRANSMISSION) PASSENGER/ CARGO POWERTRAIN CONTROL MODULE (IN ENGINE COMPT, ON LEFT INNER FENDER) RANGE SW - C RANGE SW P RED WIRE RED/WHT WIRE TAIL/STOP, TURN SIGNAL LAMP (LEFT) TAIL/STOP, TURN SIGNAL LAMP (RIGHT) TAN WIRE TAN/BLK WIRE TAN/WHT WIRE TBC 2 FUSE 18 TRANSMISSION CONTROL MODULE (LEFT FRONT CORNER OF ENGINE COMPARTMENT) UNDERHOOD FUSE BLOCK (ON LEFT SIDE OF ENGINE COMPARTMENT) WHT WIRE YEL WIRE

AUXILIARY 1 FUSE 32 BLK WIRE BODY CONTROL MODULE (BCM) (BEHIND LOWER RIGHT SIDE OF DASH) BODY FUSE BLOCK (UNDER LEFT FRONT SEAT) CARGO CARGO DOOR LATCH ASSEMBLY CTSY CTSY LPS SUPPLY BATTERY DK BLU/WHT WIRE DOME DOME DEFEAT DOME HNDL DOOR OPEN SW SIG REAR DOOR AJAR CTSY LAMPS ON SIG LF DOOR SW SIG DRIVER DOOR LATCH ASSEMBLY FL WORK LMP SIG FL WORK LMP CTRL GRY/BLK WIRE HEADLAMP AND PANEL DIMMER SWITCH HNDL HOT AT ALL TIMES LEFT REAR DOOR JAMB SWITCH LT GRN WIRE NOT USED ORG/ WIRE PASSENGER DOOR LATCH ASSEMBLY POWER PPL PPL DEFEAT SW SIG REAR DOME LAMP RED WIRE RED/WHT WIRE RIGHT REAR DOOR JAMB SWITCH TAN WIRE TBC 2 FUSE 18 UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT) W/ POWER DOOR LOCKS W/O POWER DOOR LOCKS YEL/BLK WIRE

12 CM FROM LEFT FRONT DOME FLUORESCENT WORK LAMP CONNECTOR) AUXILIARY 1 FUSE 32 BLK WIRE BODY CONTROL MODULE (BCM) (BEHIND LOWER RIGHT SIDE OF DASH) BODY FUSE BLOCK (UNDER LEFT FRONT SEAT) CARGO DOOR LATCH ASSEMBLY CTSY CTSY LP RELAY 26 CTSY LP/ SEO FUSE 3 CTSY LPS SUPPLY BATTERY DK BLU WIRE DK BLU/WHT WIRE DOME DOME DEFEAT DOME FLOUR- ESCENT FUSE 2 DOME FLUORESCENT WORK LAMP 1 DOME FLUORESCENT WORK LAMP 2 DOME FLUORESCENT WORK LAMP RELAY (AT LEFT "B" PILLAR) DOME HNDL DOOR OPEN SW SIG REAR DOOR AJAR CTSY LAMPS ON SIG REAR DOOR SW SIG DRIVER DOOR LATCH ASSEMBLY FL DOME LP SIG FL DOME RLY CTRL GRY/BLK WIRE HEADLAMP AND PANEL DIMMER SWITCH HNDL HOT AT ALL TIMES LEFT FRONT DOME FLUORESCENT WORK LAMP LEFT REAR DOME FLUORESCENT WORK LAMP LEFT REAR DOOR JAMB SWITCH LEFT VANITY MIRROR LAMP LT GRN WIRE NOT USED ORG/ WIRE PASSENGER DOOR LATCH ASSEMBLY POWER PPL PPL DEFEAT SW SIG PROVISIONAL REAR FUSE BLOCK (ON LEFT "B" PILLAR) RED WIRE RED/WHT WIRE RIGHT DOME FLUORESCENT WORK LAMP RIGHT REAR DOOR JAMB SWITCH RIGHT VANITY MIRROR LAMP TAN WIRE TBC 2 FUSE 18 UNDERHOOD LAMP VANITY MIRROR LAMP CONNECTOR BREAKOUT) WHT WIRE YEL/BLK WIRE

BATTERY POSITIVE VOLTAGE BLK WIRE BLU WIRE BRN WIRE BTSI BCK/UP FUSE 36 DK BLU WIRE DK DK LT DK GRN WIRE FUSE BLOCK- UNDERHOOD (ON LEFT SIDE OF ENGINE COMPARTMENT) FUSE BLOCK- UNDERHOOD (ON LEFT SIDE OF ENGINE COMPARTMENT) RT DRL/ TURN FUSE 9 GRN WIRE GROUND HAZRD FUSE 14 HOT AT ALL TIMES HOT IN RUN OR START IGN E FUSE 22 LT BLU WIRE LT DRL/ TURN FUSE 10 LT REAR STOP/ TRN FUSE 3 TRLR STOP/ TRN FUSE 17 LT GRN WIRE MARKER LAMP (LF) MARKER LAMP (RF) ORG/ WIRE PARK/ TURN SIGNAL LAMP (LF) PARK/ TURN SIGNAL LAMP-RF PARK/NEUTRAL POSITION SWITCH (ON LEFT SIDE OF TRANSMISSION) PNK 8 9 WIRE PNK WIRE RED WIRE RED/WHT WIRE RT REAR STOP/ TRN FUSE 4 STOP LAMP FUSE 7 STOP LAMP SWITCH (ABOVE BRAKE PEDAL) TRAILER AUXILIARY SUPPLY VOLTAGE TRAILER BACKUP LAMPS SUPPLY VOLTAGE TRAILER PARK LAMPS SUPPLY VOLTAGE TRAILER STOP/ TURN RELAY- LEFT TRAILER STOP/ TURN RELAY- RIGHT TRAILER WIRING (BLUNT CUT) TRLR BCK/UP FUSE 5 TRLR FUSE 13 TRLR FUSE 50 WHT WIRE YEL WIRE

23 3 SERIAL DATA BELT SW 7 63 5 VOLT REF LOW REF ABS IND. AIR BAG IND BATTERY IND BLK WIRE BLK/WHT WIRE BODY CONTROL MODULE (BCM) (LOWER RIGHT SIDE OF DASH) BRAKE IND BRAKE WARNING IND CONTROL BATT VOLTAGE GROUND GROUND IGN VOLTAGE SERIAL DATA BRN WIRE BRN/WHT WIRE CHECK GAGES IND. CLASS 2 (BCM) CLASS 2 (EBCM) CLASS 2 (PCM) CLASS 2 (SDM) COMPUTER DATA LINES SYSTEM CRUISE IND DIMMING DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DRL IND ECT SENS ENGINE CONTROLS SYSTEM ENGINE COOLANT TEMP ENGINE COOLANT TEMPERATURE SENSOR (LEFT SIDE OF ENGINE) ENGINE OIL LEVEL SWITCH (4.8L, 5.3L, 6.0L) (RIGHT SIDE OF OIL PAN) ENGINE OIL PRESSURE SENSOR (TOP REAR OF ENGINE) FUEL GAUGE FUEL PUMP/ SENDER ASSEMBLY (IN FUEL TANK) GROUND GRY WIRE HIGH BEAM IND HOT AT ALL TIMES HOT IN RUN OR START IGN IGN CLASS 2 (PCM) IGN CLASS 2 (PCM) IGN CLASS 2 (PCM) IGN CLASS 2 (PCM) IGN VOLT SIG IGN E FUSE 22 ILLUMINATION (6 BULBS) INFLATABLE RESTRAINT SENSING, DIAGNOSTIC MODULE (UNDER LEFT FRONT SEAT) INSTRUMENT PANEL CLUSTER IPC FUSE 31 LCD DISPLAY 000000 TRIP LEFT FRONT SEAT BELT SWITCH (IN LEFT FRONT SEAT BELT LATCH) LEFT TURN IND LH FRT TURN SIG SUP VOLT LOW REF LT BLU WIRE LT BLU/BLK WIRE LT BLU/WHT WIRE LT GRN WIRE MALFUNCTION IND LAMP MIL CTRL MIL SIGNAL OFF OIL PRESS OIL PRESS (RIGHT REAR OF ENGINE) OIL PRESSURE OIL PRESSURE IND P R N D 3 2 1 PARK BRAKE PARK BRAKE SWITCH (UNDER LEFT SIDE OF DASH) PNK WIRE POWER BRAKE BOOSTER FLUID PRESSURE ALARM SWITCH (IN BOOSTER INLET HOSE) POWERTRAIN CONTROL MODULE (IN ENGINE COMPT, ON LEFT INNER FENDER) PPL FUEL LEVEL RED/WHT WIRE RH FRT TURN SIG SUP VOLT RIGHT TURN IND SEAT BELT IND SECURITY IND SERIAL DATA SPEEDOMETER SPLICE PACK TAN WIRE TAN/WHT WIRE TOW/HAUL IND TRACTION CONTROL IND'S TRIP RESET SWITCH TRIP RESET SWN SIGNAL GROUND UNDERHOOD FUSE BLOCK (IN ENGINE COMPT, ATTACHED TO LEFT FRONT FENDER) VOLTMETER W/ PWR SEAT W/O PWR SEAT YEL WIRE

AIRBAG FUSE 37 BANK 1 SENSOR 1 BANK 1 SENSOR 2 BANK 2 SENSOR 1 BANK 2 SENSOR 2 BRN WIRE BTSI/BU FUSE 36 SPARE FUSE 35 CRUISE CONTROL MODULE (IF EQUIPPED) THROTTLE ACTUATOR CONTROL MODULE CTSY LP RELAY 26 (RV/UPFITTER) CTSY LP/SEO FUSE 3 DK GRN WIRE FR PRK FUSE 22 FROM UNDERHOOD FUSE BLOCK (IGN A FUSE 49) (DIAGRAM 2 OF 6) FROM UNDERHOOD FUSE BLOCK (IGN B, FUSE 52) (DIAGRAM 2 OF 6) FUSE 39 FUSE 40 HEATED OXYGEN SENSOR HEATED OXYGEN SENSOR HEAVY DUTY IGNITION SWITCH INFLATABLE RESTRAINT I/P MODULE DISABLE SWITCH (HEAVY DUTY) INFLATABLE RESTRAINT PASSENGER AIRBAG OFF/ON INDICATOR INFLATABLE RESTRAINT PASSENGER PRESENCE SYSTEM (PPS) MODULE (LIGHT DUTY) INFLATABLE RESTRAINT SENSING, DIAGNOSTIC MODULE ISRVM FUSE 26 LEFT FRONT MARKER LAMP LEFT FRONT PARK/TURN SIGNAL LAMP LICENSE LAMP LIGHT DUTY LOCK LT GRN WIRE LT GRN/BLK WIRE NCA WIRE ORG/ WIRE PARK PARK LP RELAY 29 PARK/ NEUTRAL POSITION (PNP) SWITCH REVERSE PCM IGN 1 FUSE 38 PNK WIRE RED/BLK WIRE RIGHT FRONT PARK/TURN SIGNAL LAMP RIGHT FRONT MARKER LAMP RIGHT TAIL/STOP, TURN SIGNAL LAMP LEFT TAIL/STOP, TURN SIGNAL LAMP RR PRK FUSE 20 LR PRK FUSE 18 RUN WIRE SPARE FUSE 25 STEERING WHEEL SPEED/ POSITION SENSOR STOP LAMP SWITCH (BLUNT CUT) (NOT USED) TBC IGN 1 FUSE 24 TO BODY FUSE BLOCK (AUXILIARY 1 FUSE 32) (DIAGRAM 5 OF 6) TO BODY FUSE BLOCK (BRK FUSE 11) (DIAGRAM 5 OF 6) TO UNDERHOOD FUSE BLOCK (CRANK FUSE 27) (DIAGRAM 4 OF 6) TO UNDERHOOD FUSE BLOCK (ENG 2 FUSE 21) (DIAGRAM 4 OF 6) TO UNDERHOOD FUSE BLOCK (IGN O FUSE 6) (DIAGRAM 4 OF 6) TO UNDERHOOD FUSE BLOCK (TBC ACC FUSE 46) (DIAGRAM 4 OF 6) TRAILER WIRING CUTAWAY TRLR BU FUSE 5 BTSI FUSE 28 TRLR PRK FUSE 21 UPFTR PRK FUSE 16 UNDERHOOD FUSE BLOCK WHT WIRE YEL WIRE

1 2 3 4 BATTERY B+ SERIAL DATA PNK WIRE BLK WIRE BLK/WHT WIRE BODY CONTROL MODULE (BEHIND LOWER RIGHT SIDE OF DASH) BODY FUSE BLOCK (UNDER LEFT FRONT SEAT) CARGO DOOR LATCH ASSEMBLY CARGO UNLK FUSE 5 CARGO UNLK RELAY 27 DK BLU WIRE DOOR LKS FUSE 15 DOOR LKS RELAY 30 DOOR LOCK CTRL UNLOCK CTRL DRIVER DOOR LATCH ASSEMBLY DRIVER DOOR LOCK SWITCH DRV LKS FUSE 7 DRV UNLK RELAY 28 FRONT PASSENGER DOOR LATCH ASSEMBLY FRONT PASSENGER DOOR LOCK SWITCH GROUND GRY WIRE HOT AT ALL TIMES INSTRUMENT PANEL CLUSTER LEFT REAR SIDE DOOR LOCK ACTUATOR LEFT SIDE DOOR CONTACT PLATE (LEFT "B" PILLAR) LT BLU WIRE LT GRN WIRE PASS UNLK RELAY 31 REAR CARGO DOOR LOCK SWITCH RED/WHT WIRE REMOTE CONTROL DOOR LOCK RECEIVER (BEHIND CENTER OF DASH) RIGHT REAR SIDE DOOR LOCK ACTUATOR RIGHT SIDE DOOR CONTACT PLATE (RIGHT "B" PILLAR) SERIAL DATA SERIAL DATA UNLOCK RLY CTRL SW UNLOCK CTRL SW LOCK CTRL RELEASE RLY CTRL SPLICE SPLICE PACK TAN WIRE TAN/BLK WIRE UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT) RFA FUSE 20 WHT WIRE

BLK WIRE BODY FUSE BLOCK (UNDER LEFT FRONT SEAT) BRN/WHT WIRE DEFOGGER SYSTEM DK BLU/WHT WIRE DRIVER OUTSIDE REARVIEW MIRROR (IN DRIVER DOOR) DRIVER PASSENGER EXTERIOR LIGHTS DEFOGGER SYSTEM SYSTEM HOT AT ALL TIMES LT BLU/WHT WIRE LT GRN WIRE NCA WIRE ORG/ WIRE ORG/WHT WIRE OSRVM SW FUSE 9 OUTSIDE REARVIEW MIRROR SWITCH PASSENGER OUTSIDE REARVIEW MIRROR (IN RIGHT FRONT PASSENGER DOOR) PPL/WHT WIRE RED/WHT WIRE RL (+) UP DN UP DN UP UP/DN WHT WIRE YEL WIRE

ALL- DOWN ALL-UP BACK BLK WIRE BODY FUSE BLOCK (UNDER LEFT FRONT SEAT) DK BLU WIRE DK GRN WIRE DOWN DRIVER SEAT ADJUSTER MOTOR ASSEMBLY DRIVER SEAT ADJUSTER SWITCH ENTIRE SEAT FOR- WARD FRONT DOWN FRONT UP FRONT VERTICAL HORIZONTAL HOT AT ALL TIMES PWR SEATS CIRCUIT BREAKER 1 LT BLU WIRE LT GRN WIRE NCA WIRE PASSENGER SEAT ADJUSTER MOTOR ASSEMBLY PASSENGER SEAT ADJUSTER SWITCH REAR DOWN REAR DOWN DOWN REAR UP REAR UP UP REAR VERTICAL RED/WHT WIRE TAN WIRE YEL WIRE

ANTENNA ANTENNA IN BLK WIRE BLK/WHT WIRE BRN/WHT WIRE CLASS 2 DATA COAX COMPUTER DATA LINES SYSTEM DK BLU WIRE DK GRN WIRE HOT AT ALL TIMES INTERIOR LIGHTS SYSTEM DASH LMP DIM CNTRL LEFT FRONT DOOR SPEAKER LEFT REAR DOOR SPEAKER LEFT REAR SPEAKER LF SPEAKER (+) LF SPEAKER (-) RR SPEAKER (-) RR SPEAKER (+) GROUND BATTERY LT BLU WIRE LT GRN WIRE ORG/ WIRE PPL PPL REMOTE RAD VOLT PPL RSA SWITCH RADIO RADIO BAT FUSE 1 REAR SEAT AUDIO CONTROL RED/WHT WIRE REM RADIO SIG LR SPEAKER (+) LR SPEAKER (-) RF SPEAKER (-) RF SPEAKER (+) RIGHT FRONT DOOR SPEAKER RIGHT REAR DOOR SPEAKER RIGHT REAR SPEAKER TAN WIRE UNDERHOOD FUSE BLOCK (ON LEFT SIDE OF ENGINE COMPARTMENT) WHT WIRE