Instrument cluster circuit for Chevrolet Chevy Express G3500 (1996-2012)

23 3 SERIAL DATA BELT SW 7 63 5 VOLT REF LOW REF ABS IND. AIR BAG IND BATTERY IND BLK WIRE BLK/WHT WIRE BODY CONTROL MODULE (BCM) (LOWER RIGHT SIDE OF DASH) BRAKE IND BRAKE WARNING IND CONTROL BATT VOLTAGE GROUND GROUND IGN VOLTAGE SERIAL DATA BRN WIRE BRN/WHT WIRE CHECK GAGES IND. CLASS 2 (BCM) CLASS 2 (EBCM) CLASS 2 (PCM) CLASS 2 (SDM) COMPUTER DATA LINES SYSTEM CRUISE IND DIMMING DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DRL IND ECT SENS ENGINE CONTROLS SYSTEM ENGINE COOLANT TEMP ENGINE COOLANT TEMPERATURE SENSOR (LEFT SIDE OF ENGINE) ENGINE OIL LEVEL SWITCH (4.8L, 5.3L, 6.0L) (RIGHT SIDE OF OIL PAN) ENGINE OIL PRESSURE SENSOR (TOP REAR OF ENGINE) FUEL GAUGE FUEL PUMP/ SENDER ASSEMBLY (IN FUEL TANK) GROUND GRY WIRE HIGH BEAM IND HOT AT ALL TIMES HOT IN RUN OR START IGN IGN CLASS 2 (PCM) IGN CLASS 2 (PCM) IGN CLASS 2 (PCM) IGN CLASS 2 (PCM) IGN VOLT SIG IGN E FUSE 22 ILLUMINATION (6 BULBS) INFLATABLE RESTRAINT SENSING, DIAGNOSTIC MODULE (UNDER LEFT FRONT SEAT) INSTRUMENT PANEL CLUSTER IPC FUSE 31 LCD DISPLAY 000000 TRIP LEFT FRONT SEAT BELT SWITCH (IN LEFT FRONT SEAT BELT LATCH) LEFT TURN IND LH FRT TURN SIG SUP VOLT LOW REF LT BLU WIRE LT BLU/BLK WIRE LT BLU/WHT WIRE LT GRN WIRE MALFUNCTION IND LAMP MIL CTRL MIL SIGNAL OFF OIL PRESS OIL PRESS (RIGHT REAR OF ENGINE) OIL PRESSURE OIL PRESSURE IND P R N D 3 2 1 PARK BRAKE PARK BRAKE SWITCH (UNDER LEFT SIDE OF DASH) PNK WIRE POWER BRAKE BOOSTER FLUID PRESSURE ALARM SWITCH (IN BOOSTER INLET HOSE) POWERTRAIN CONTROL MODULE (IN ENGINE COMPT, ON LEFT INNER FENDER) PPL FUEL LEVEL RED/WHT WIRE RH FRT TURN SIG SUP VOLT RIGHT TURN IND SEAT BELT IND SECURITY IND SERIAL DATA SPEEDOMETER SPLICE PACK TAN WIRE TAN/WHT WIRE TOW/HAUL IND TRACTION CONTROL IND'S TRIP RESET SWITCH TRIP RESET SWN SIGNAL GROUND UNDERHOOD FUSE BLOCK (IN ENGINE COMPT, ATTACHED TO LEFT FRONT FENDER) VOLTMETER W/ PWR SEAT W/O PWR SEAT YEL WIRE

ABS IND. AIR BAG IND BLK WIRE BLK/WHT WIRE BODY CONTROL MODULE (BCM) (BEHIND LOWER RIGHT SIDE OF DASH) BODY FUSE BLOCK (UNDER LEFT BODY FUSE BLOCK (UNDER LEFT FRONT SEAT) BRAKE IND BRN WIRE BRN/WHT WIRE CHARGE IND CMPS FUSE 19 COMPUTER DATA LINES SYSTEM CRUISE IND DIESEL DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/WHT WIRE DRIVER INFORMATION CENTER (DIC) ENGINE COMPT) ENGINE CONTROLS SYSTEM SUPPLEMENTAL RESTRAINTS SYSTEM ENGINE COOLANT TEMPERATURE GAUGE FRONT SEAT) FUEL GAUGE GMLAN SERIAL GRY/BLK WIRE HIGH BEAM IND HOT AT ALL TIMES HOT W/ RUN RELAY HOT W/ RUN/CRANK RELAY 15 ENERGIZED IGN VOLT IND CTRL IND LAMP (MIL) INSTRUMENT PANEL CLUSTER (IPC) IP CLSTR FUSE 10 IP CLSTR FUSE 23 LEFT TURN IND LIFTGATE AJAR SW SIG LF DOOR AJAR SW RR DOOR OPEN SW LR DOOR OPEN SW LOGIC LOW ENGINE OIL LOW ENGINE OIL PRESSURE GAUGE LOW TIRE PRESSURE IND LT BLU WIRE LT GRN WIRE MALFUNCTION MIL CTRL NETWORK 3 ODOMETER PARK BRAKE SWITCH (UNDER LEFT SIDE OF DASH) PASS SEAT BELT PNK WIRE PNK/BLK WIRE PPL PPL PNK WIRE PRESSURE IND RED/WHT WIRE RF DOOR AJAR SW RIGHT TURN IND SEAT BELT IND SECURITY IND SEO FUSE 27 SPEEDOMETER SUPPLEMENTAL RESTRAINTS SYSTEM SW SIG SWITCH SIG TAN/WHT WIRE TOW/HAUL IND TRACTION CONTROL IND UNDERHOOD FUSE BLOCK (ON LEFT SIDE OF VOLTS GAUGE W/ ODOMETER SECURITY WIRING PROVISION (SEO) W/O ODOMETER SECURITY WIRING PROVISION (SEO) WAIT TO START IND WHT WIRE YEL WIRE YEL/BLK WIRE

ABS IND. AIR BAG IND BLK WIRE BLK/WHT WIRE BODY CONTROL MODULE (BCM) (BEHIND LOWER RIGHT SIDE OF DASH) BODY FUSE BLOCK (UNDER LEFT BODY FUSE BLOCK (UNDER LEFT FRONT SEAT) BRAKE IND BRN WIRE BRN/WHT WIRE CHARGE IND CMPS FUSE 19 COMPUTER DATA LINES SYSTEM CRUISE IND DIESEL DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/WHT WIRE DRIVER INFORMATION CENTER (DIC) DISPLAY ENGINE COMPT) ENGINE CONTROLS SYSTEM SUPPLEMENTAL RESTRAINTS SYSTEM ENGINE COOLANT TEMPERATURE GAUGE FRONT SEAT) FUEL GAUGE GMLAN SERIAL GRY/BLK WIRE HIGH BEAM IND HOT AT ALL TIMES HOT W/ RUN RELAY HOT W/ RUN/CRNK RELAY 15 ENERGIZED I/P CLUSTER FUSE 23 IGN VOLT IND CTRL IND LAMP (MIL) INSTRUMENT PANEL CLUSTER (IPC) IPC FUSE 10 LEFT TURN IND LIFTGATE AJAR SW SIG LF DOOR AJAR SW RR DOOR OPEN SW LR DOOR OPEN SW LOGIC LOW ENGINE OIL PRESSURE GAUGE LOW FUEL IND LOW OIL LOW STABILITY IND LT BLU WIRE LT GRN WIRE MALFUNCTION MIL CTRL NETWORK 3 ODOMETER PARK BRAKE SWITCH (UNDER LEFT SIDE OF DASH) PASS SEAT BELT PASSENGER SEAT BELT IND PNK WIRE PNK/BLK WIRE PPL PPL PNK WIRE PRESSURE IND PRND 321 RED/WHT WIRE RF DOOR AJAR SW RIGHT TURN IND SEAT BELT IND SECURITY IND SEO FUSE 27 SPEEDOMETER SUPPLEMENTAL RESTRAINTS SYSTEM SW SIG SWITCH SIG TAN/WHT WIRE TIRE PRESSURE IND TOW/HAUL IND TRACTION CONTROL IND UNDERHOOD FUSE BLOCK (ON LEFT SIDE OF VOLTS GAUGE W/ BRAKE WARNING INDICATOR SYSTEM W/ ODOMETER SECURITY WIRING PROVISION (SEO) W/O ODOMETER SECURITY WIRING PROVISION (SEO) WAIT TO START IND WHT WIRE YEL WIRE YEL/BLK WIRE

1589 2759 PPL 31 16 LOW REF SENS SIG PPL 4.3L 4.8L/5.3L/6.0L 6.6L 50 41 36 35 SENS SIG BLK WIRE BLK/WHT WIRE BRAKE BOOSTER FLUID FLOW ALARM SWITCH (W/ BRAKE WARNING INDICATOR) BRAKE BOOSTER FLUID PRESSURE ALARM SWITCH (IN POWER STEERING PUMP INLET HOSE) BRAKE FLUID LEVEL SWITCH (AT LEFT REAR OF ENGINE COMPT) BRAKE PRESSURE BRN WIRE CARGO DOOR LATCH ASSEMBLY (W/ CARGO/PASSENGER) (IN RIGHT REAR CARGO DOOR) COMPUTER DATA LINES SYSTEM DIFFERENTIAL SWITCH (ON BRAKE VALVE, NEAR FRONT OF EBCM) DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/WHT WIRE DRIVER DOOR LATCH ASSEMBLY (AT REAR OF DRIVER DOOR) DRIVER INFORMATION CENTER (DIC) SWITCH ENGINE CONTROL MODULE (ECM) (LEFT SIDE OF ENGINE COMPT) ENGINE CONTROLS SYSTEM ENGINE OIL LEVEL SWITCH (ON LEFT SIDE OF OIL PAN) ENGINE OIL PRESSURE (EOP) SENSOR (EXCEPT 6.6L: ON TOP REAR OF ENGINE) EXCEPT 5.3L 5.3L FUEL LEVEL SENSOR (ON LEFT FRAME FUEL PUMP, SENDER ASSEMBLY (ON FUEL TANK) GRY WIRE GRY/BLK WIRE ILLUMI- NATION IND CTRL LEFT REAR SIDE DOOR JAMB SWITCH (W/ HINGED) (AT LEFT "B" PILLAR) LIGHT DUTY LOW REF LT BLU/BLK WIRE PASSENGER DOOR LATCH ASSEMBLY (AT REAR OF FRONT PASSENGER DOOR) PERSON- ALIZATION PNK WIRE PNK/BLK WIRE PPL PPL HEAVY DUTY PPL PNK WIRE RAIL) RIGHT REAR SIDE DOOR JAMB SWITCH (W/ CARGO/PASSENGER) (AT RIGHT "B" PILLAR) SENS SIG LOW REF SET/ RESET SWITCH SIG DATA LINK RESISTOR 44 43 TAN WIRE TAN/BLK WIRE TAN/WHT WIRE TRIP/ FUEL VEHICLE INFO W/ BRAKE WARNING INDICATOR SYSTEM WATER IN-FUEL SENSOR WHT WIRE YEL WIRE YEL/BLK WIRE

1589 2759 PPL 2759 1589 (OR 6049) 31 16 LOW REF SENS SIG PPL 4.3L 4.8L/5.3L/6.0L 6.6L 44 43 DATA BUS(-) DATA BUS(+) 50 41 36 35 SENS SIG 7 8 PPL 9 10 PPL BLK WIRE BLK/WHT WIRE BRN WIRE CARGO DOOR LATCH ASSEMBLY (W/ CARGO/PASSENGER) (IN RIGHT REAR CARGO DOOR) COMPUTER DATA LINES SYSTEM DK BLU WIRE DK BLU/WHT WIRE DK BLU/YEL WIRE DK GRN WIRE DK GRN/WHT WIRE DRIVER DOOR LATCH ASSEMBLY DRIVER INFORMATION CENTER (DIC) SWITCH ENGINE CONTROL MODULE (ECM) (LEFT SIDE OF ENGINE COMPT) GRY WIRE GRY/BLK WIRE ILLUMI- NATION LEFT REAR SIDE DOOR JAMB SWITCH (W/ LEFT REAR HINGED DOOR) LOW REF PASSENGER DOOR LATCH ASSEMBLY (AT REAR OF FRONT PASSENGER DOOR) PERSON- ALIZATION VEHICLE INFO PNK WIRE PNK/BLK WIRE PPL PPL 2 3 PPL PNK WIRE RIGHT REAR DOOR JAMB SWITCH (W/ CARGO/PASSENGER) SENS SIG SENS SIG LOW REF SET/ RESET SWITCH SIG TAN WIRE TAN/BLK WIRE TAN/WHT WIRE TRIP/ FUEL W/ BRAKE WARNING INDICATOR SYSTEM WATER IN-FUEL SENSOR WHT WIRE YEL WIRE YEL/BLK WIRE

4.3L 4.8L/5.3L/6.0L 6.6L 4.3L, 4.8L, 6.0L 5.3L (VIN G) 6.0L (VIN B) 7 8 PPL 9 10 PPL ALTERNATIVE FUEL TANK PRESSURE SENSOR BLK WIRE BRAKE BOOSTER FLUID FLOW ALARM SWITCH (IN POWER STEERING PUMP OUTLET HOSE) BRAKE BOOSTER FLUID PRESSURE ALARM SWITCH (IN POWER STEERING PUMP INLET HOSE) BRAKE FLUID LEVEL SWITCH (AT LEFT REAR OF ENGINE COMPT) BRAKE PRESSURE DIFFERENTIAL SWITCH (ON BRAKE VALVE, NEAR FRONT OF EBCM) BRN WIRE CNG CONTROL MODULE (6.0L(VIN B)) (FORWARD OF LEFT REAR SPRING ON FRAME) CNG FUEL VEHICLE ENGINE CONTROLS SYSTEM ENGINE OIL LEVEL SWITCH (ON LEFT SIDE OF OIL PAN) ENGINE OIL PRESSURE (EOP) SENSOR (EXCEPT 6.6L: ON TOP REAR OF ENGINE) FUEL LEVEL SENSOR (ON LEFT FRAME FUEL PUMP, SENDER ASSEMBLY (ON FUEL TANK) GRN WIRE GRY WIRE HEAVY DUTY LIGHT DUTY LOW REF LPG CONTROL MODULE (6.0L(VIN B)) (ON TANK CONTROL BOX) LPG FUEL VEHICLE W/ 3 TANK LPG FUEL VEHICLE W/ 4 TANK LT BLU/BLK WIRE PPL PPL 2 3 PPL FUEL PUMP RELAY SIG PPL SENSING PRESSING PRIMARY FUEL LEVEL SENSOR PRIMARY SIG FUEL SENDER RAIL) RED WIRE SECONDARY FUEL LEVEL SENSOR SECONDARY SIG FUEL SENDER TAN WIRE TAN/WHT WIRE W/ BRAKE WARNING INDICATOR SYSTEM WHT WIRE