Chevrolet Chevy Express G3500 (1996-2012) wht Wiring diagrams

ABS/TCC SWITCH ABS/TCS CLASS 2 SERIAL DATA YAW RATE SENSOR LO REF WHEEL POS SENS LOW REF ABS/VSES FUSE 48 AUXILIARY 1 FUSE 32 BLK WIRE BODY FUSE BLOCK (UNDER LEFT FRONT SEAT) BRAKE IN BRKS FUSE 11 BRN WIRE DEL TORQUE DK BLU WIRE DK GRN WIRE ELECTRONIC BRAKE CONTROL MODULE (EBCM) GRY WIRE HOT AT ALL TIMES HOT IN HOT IN RUN OR START IGN E FUSE 22 IGNITION 3 VOLT LATERAL ACCELEROMETER SIG LEFT FRONT WHEEL SPEED SENSOR (ON INSIDE OF LEFT FRONT WHEEL) LEFT REAR WHEEL SPEED SENSOR (AT LEFT REAR OF WHEEL HUB) LT BLU WIRE LT GRN WIRE LT GRN/BLK WIRE NCA WIRE ORG/BLK WIRE PNK 1 2 WIRE PNK WIRE POWER DISTRIBUTION SYSTEM POWERTRAIN CONTROL MODULE (PCM) (IN ENG COMPT, ON LEFT INNER FENDER) PPL PPL UNDERHOOD FUSE BLOCK (ON LEFT SIDE OF ENGINE COMPT) PPL/WHT WIRE PRECHARGE MOTOR LO BATTERY (+) GND PRECHARGE MOTOR HI PRECHARGE PUMP (AT LEFT FRONT OF FRAME RAIL) RED WIRE REQ TORQUE REQUEST TORQUE SIGNAL DELIVERED TORQUE SIGNAL RIGHT FRONT WHEEL SPEED SENSOR (ON INSIDE OF RIGHT FRONT WHEEL) RIGHT REAR WHEEL SPEED SENSOR (AT RIGHT REAR OF WHEEL HUB) RUN WIRE STOP LAMP SWITCH (BEHIND LEFT SIDE OF DASH, ABOVE BRAKE PEDAL) TAN WIRE TAN/BLK WIRE UNDERHOOD FUSE BLOCK (ON LEFT SIDE OF ENGINE COMPT) VEHICLE SPEED SENSOR (VSS) (ON RIGHT SIDE OF TRANSMISSION) VSES MOTOR VSS HIGH VSS LOW VSS OUTPUT WHT WIRE YEL WIRE YEL/BLK WIRE

1 2 6 8 20 21 22 23 24 40 42 47 48 51 62 63 GND TCC PWM CTRL PC SOL HI CTRL 1 8 17 18 19 20 24 27 GND AUTOMATIC TRANSMISSION INPUT SHAFT SPEED SENSOR BLK WIRE BLK/WHT WIRE BRN WIRE DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE ENGINE COOLANT TEMPERATURE SENSOR (ON LEFT SIDE OF ENGINE) FROM UNDERHOOD PASS- THROUGH GROMMET BREAKOUT) LT GRN WIRE GRY WIRE HOT AT ALL TIMES HOT IN ACCY, RUN, START HOT IN RUN, START IGN 0 FUSE 6 INSTRUMENT PANEL CLUSTER LT BLU WIRE LT BLU/WHT WIRE LT GRN WIRE ORG/ WIRE ORG/BLK WIRE PC SOL LO CTRL PPL FRONT LOW SIG FRONT HIGH SIG PCM BATT FUSE 2 PCM IGN 1 FUSE 38 PNK WIRE POWERTRAIN CONTROL MODULE (IN ENGINE COMPT, ON LEFT INNER FENDER) PPL PRNDL INDICATOR RANGE B RANGE C IGN B+ GND GND RED/WHT WIRE SERIAL DATA TAN WIRE TAN/BLK WIRE TAN/WHT WIRE THROTTLE POSITION SENSOR (ON LEFT SIDE OF THROTTLE BODY) TOW/ HAUL SWITCH TOW/HAUL INDICATOR TOW/HAUL SWITCH UNDER- HOOD FUSE BLOCK VEHICLE SPEED SENSOR WHT WIRE YEL WIRE YEL/BLK WIRE

1-2 SOL 2-3 SOL 3-2 SOL A/T FLUID PRESSURE MANUAL VALVE POSITION SWITCH AUTOMATIC TRANSMISSION BLK WIRE BLU WIRE BRN WIRE DK BLU WIRE GRY WIRE HOT IN RUN, START IGN E FUSE 22 LT BLU WIRE LT BLU/WHT WIRE LT GRN WIRE ORG/ WIRE ORG/BLK WIRE PC SOL VALVE PNK WIRE PPL RED WIRE REV STOP LAMP SWITCH (ABOVE BRAKE PEDAL) TAN (OR WHT) WIRE TAN WIRE TAN/BLK WIRE TCC PWM SOL TCC SOL TFT SENSOR UNDERHOOD FUSE BLOCK WHT WIRE YEL WIRE YEL/BLK WIRE

BLK WIRE BODY CONTROL MODULE (BEHIND LOWER RIGHT SIDE OF DASH) IGN VOLT BODY FUSE BLOCK (UNDER LEFT FRONT SEAT) BRN WIRE DK BLU WIRE DK GRN WIRE DRIVER WINDOW SWITCH HOT AT ALL TIMES LT BLU WIRE PASSENGER WINDOW SWITCH PWR WDO CIRCUIT BREAKER 2 RAP RELAY RIGHT DN SPLICE SPLICE BLOCK TAN WIRE UP DN UP DN LEFT WHT WIRE YEL WIRE

ANTENNA ANTENNA IN BLK WIRE BLK/WHT WIRE BLUNT CUT) CLASS 2 DATA COAX COMPUTER DATA LINES SYSTEM CUTAWAY UPFITTER DK BLU WIRE DK GRN WIRE HOT AT ALL TIMES LEFT FRONT DOOR SPEAKER LEFT REAR DOOR SPEAKER (IF EQUIPPED) LEFT REAR SPEAKER LF SPEAKER (+) LF SPEAKER (-) RR SPEAKER (-) RR SPEAKER (+) GROUND BATTERY LR SPEAKER + LR SPEAKER - RF SPEAKER - RF SPEAKER + LT BLU WIRE NOT USED ORG/ WIRE PASSENGER/ CARGO RADIO RADIO BAT FUSE 1 RED/WHT WIRE RIGHT FRONT DOOR SPEAKER RIGHT REAR DOOR SPEAKER (IF EQUIPPED) RIGHT REAR SPEAKER TAN WIRE UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPTARTMENT) WHT WIRE

ANTENNA ANTENNA IN BLK WIRE BLK/WHT WIRE BRN/WHT WIRE CLASS 2 DATA COAX COMPUTER DATA LINES SYSTEM DK BLU WIRE DK GRN WIRE HOT AT ALL TIMES INTERIOR LIGHTS SYSTEM DASH LMP DIM CNTRL LEFT FRONT DOOR SPEAKER LEFT REAR DOOR SPEAKER LEFT REAR SPEAKER LF SPEAKER (+) LF SPEAKER (-) RR SPEAKER (-) RR SPEAKER (+) GROUND BATTERY LT BLU WIRE LT GRN WIRE ORG/ WIRE PPL PPL REMOTE RAD VOLT PPL RSA SWITCH RADIO RADIO BAT FUSE 1 REAR SEAT AUDIO CONTROL RED/WHT WIRE REM RADIO SIG LR SPEAKER (+) LR SPEAKER (-) RF SPEAKER (-) RF SPEAKER (+) RIGHT FRONT DOOR SPEAKER RIGHT REAR DOOR SPEAKER RIGHT REAR SPEAKER TAN WIRE UNDERHOOD FUSE BLOCK (ON LEFT SIDE OF ENGINE COMPARTMENT) WHT WIRE

2500 2501 COMPUTER DATA LINES SYSTEM 28 27 43 44 66 46 HI SPD SER DATA (+) HI SPD SER DATA (-) AUTOMATIC TRANSMISSION AUTOMATIC TRANSMISSION (EXCEPT 4.3L, 5.3L) BLK WIRE BLK/WHT WIRE BODY CONTROL MODULE (BCM) (BEHIND LOWER RIGHT SIDE OF DASH) BRAKE BRAKE POS POS LOW SEN (-) (+) (-) (+) REF SIG BRAKE PEDAL POSITION SENSOR (TOP OF BRAKE PEDAL ASSEMBLY) BRK B+ BRN WIRE BRN/WHT WIRE COMPUTER DATA LINES SYSTEM CONTROL SOLENOID FUEL TEM SIG BRAKE APPLY SEN SIG LOW REF GM LAN HI SPD GRY WIRE HI SPD SER DATA + INTERNAL MODE SWITCH (IMS) MODULE (TCM) PARK/NEUTRAL POSITION (PNP) SWITCH RED WIRE SOL CTRL TAN WIRE TAN/BLK WIRE TAN/WHT WIRE TRANSMISSION CONTROL TRANSMISSION CONTROL MODULE (TCM) (6.6L:LEFT FRONT CORNER OF ENGINE COMPT) VALVE ASSEMBLY WHT WIRE YEL WIRE

AIR BAG OFF IND AIR BAG ON IND BLK/BLU WIRE BLK/WHT WIRE BRN WIRE BRN/WHT WIRE COMPUTER DATA LINES SYSTEM CONNECTOR BREAKOUT) PNK WIRE DK BLU/WHT WIRE DK GRN WIRE DRIVER SEAT BELT SWITCH DRIVER SEAT BELT BUCKLE FRT PRK LAMPS FUSE 4 GRY WIRE HEAVY DUTY HOT AT ALL TIMES BODY FUSE AIR BAG/ AOS BLOCK (UNDER FUSE 10 LEFT FRONT SEAT) HOT W/ PRK LAMPS RELAY HOT W/ RUN/ CRNK RELAY 15 ENERGIZED AIR BAG FUSE 28 INFLATABLE RESTRAINT SENSING, DIAGNOSTIC MODULE (SDM) (UNDER LEFT FRONT SEAT) INFLATABLE RESTRAINT STEERING WHEEL MODULE (IN STEERING WHEEL) INFLATABLE RESTRAINT STEERING WHEEL MODULE COIL (AT TOP OF STEERING COLUMN) IPC FUSE 10 LIGHT DUTY LO CTRL HI CTRL HI CTRL LO CTRL L LO CTRL L HI CTRL R HI CTRL R LO CTRL LOGIC LOW REFERENCE LOW SPD BATT GROUND LT BLU WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/BLK WIRE NCA WIRE ORG/ WIRE ORG/BLK WIRE PASSENGER SEAT BELT BUCKLE (W/O MANUAL SUPPRESSION SWITCH, RV/UPFITTER) PASSENGER SEAT BELT SWITCH PNK 1 1 1 1 1 1 1 1 1 1 1 1 LO CTRL HI CTRL HI CTRL LO CTRL WIRE PNK PNK WIRE PNK WIRE PNK/BLK WIRE PPL PPL/WHT WIRE RED WIRE RED/ WHT WIRE RED/WHT WIRE ROLLOVER HI SIG L SEAT BELT SW R SEAT BELT SW SENS SIG SHORTING BAR SHORTING SHORTING BAR BAR SUPPRESSION IND CTRL SW SIG TAN WIRE TAN/BLK WIRE TAN/WHT WIRE UNDERHOOD FUSE BLOCK (ON LEFT SIDE OF ENGINE COMPT) W/ MANUAL SUPPRESSION SWITCH W/O MANUAL SUPPRESSION SWITCH, RV/UPFITTER WHT WIRE WHT/BLK WIRE YEL WIRE YEL/BLK WIRE

AIR BAG IND AIR BAG OFF IND AIR BAG ON IND BLK/WHT WIRE BRN/WHT WIRE COMPUTER DATA LINES SYSTEM DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DRIVER SEAT BELT PRETENSIONER (LIGHT DUTY) (ON RIGHT SIDE OF LEFT FRONT SEAT) GRN DK WIRE GRN WIRE GRY WIRE HEAVY DUTY HI SIG IGN INFLATABLE RESTRAINT FRONT END SENSOR (ON LOWER CENTER OF RADIATOR SUPPORT) INFLATABLE RESTRAINT I/P MODULE (LIGHT DUTY) (BEHIND RIGHT SIDE OF DASH) INSTRUMENT PANEL CLUSTER (IPC) SEAT BELT IND LEFT FRONT INFLATABLE RESTRAINT LIGHT DUTY LO SPD LOGIC LT BLU WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/BLK WIRE NCA WIRE ORG/ WIRE ORG/BLK WIRE PASSENGER PASSENGER AIR BAG IND PASSENGER SEAT BELT IND PNK PNK WIRE PNK WIRE PNK/BLK WIRE PPL PPL/WHT WIRE RED/WHT WIRE RIGHT FRONT INFLATABLE RESTRAINT ROOF RAIL MODULE RIGHT REAR INFLATABLE RESTRAINT ROOF RAIL MODULE ROOF RAIL MODULE (LEFT SIDE OF HEADLINER) SHORTING BAR STAGE 1 INFLATABLE RESTRAINT I/P MODULE (BEHIND RIGHT SIDE OF DASH) TAN/BLK WIRE TAN/WHT WIRE W/ REAR HINGED DOOR W/ REAR SLIDING DOOR WHT WIRE WHT/ BLK WIRE WHT/BLK WIRE YEL WIRE YEL/BLK WIRE

1 14 5 SERIAL DATA BRAKE WARN IND CTRL PASSENGER SEAT BELT IND 19 15 16 ALARM ENABLE SIG HAZARD SW LEFT SIG HAZARD SW RIGHT SIG 2 59 28 60 SERIAL DATA LH SEAT BELT SW LOW REF RH SEAT BELT SW 8 17 PARK LAMP SIGNAL HEADLAMP SW OFF SIG AIR BAG FUSE 28 AUTO OFF 3 8 BATTERY BLK WIRE BLK/WHT WIRE BLU WIRE BODY CONTROL MODULE (BCM) (BEHIND LOWER RIGHT SIDE OF DASH) BODY FUSE BLOCK (UNDER LEFT FRONT SEAT) CHIME MODULE (W/O RADIO) (BEHIND LEFT CENTER OF DASH) CONNECTOR BREAKOUT) DATA LINK CONNECTOR (DLC) DK BLU/WHT WIRE DK GRN WIRE DRIVER DOOR LATCH ASSEMBLY (AT REAR OF DRIVER DOOR) DRIVER INFORMATION CENTER (DIC) DISPLAY DRIVER SEAT BELT BUCKLE DRIVER SEAT BELT SWITCH FUSE 22 GROUND GRY WIRE GRY/BLK WIRE HAZARD SWITCH HEAD PARK HEADLAMP, PANEL DIMMER SWITCH HOT AT ALL TIMES IGN SW IGNITION KEY SWITCH IGNITION SWITCH PNK WIRE INFLATABLE RESTRAINT SENSING, DIAGNOSTIC MODULE (SDM) (UNDER LEFT FRONT SEAT) INSTRUMENT PANEL CLUSTER (IPC) LEFT REAR DOOR JAMB SWITCH (W/ LEFT REAR HINGED DOOR) (AT LEFT "B" PILLAR) LEFT TURN LOGIC LT BLU WIRE LT BLU/BLK WIRE OFF ORG/ WIRE PARK BRAKE SWITCH (UNDER LEFT SIDE OF DASH) PARK BRK SW SIG PASSENGER AIR BAG IND PASSENGER DOOR LATCH ASSEMBLY (AT REAR OF FRONT PASSENGER DOOR) PASSENGER SEAT BELT BUCKLE (W/O MANUAL SUPPRESSION SWITCH, RV UPFITTER) PASSENGER SEAT BELT IND PASSENGER SEAT BELT SWITCH PNK IGN VOLT WIRE PNK PNK PNK PNK WIRE PNK PNK WIRE PNK WIRE PPL RADIO RDO/CHIME FUSE 20 RED WIRE RED/WHT WIRE RIGHT REAR DOOR JAMB SWITCH (CARGO/ PASSENGER) (AT RIGHT "B" PILLAR) RIGHT TURN RUN WIRE SEAT BELT IND LOW OIL PRESSURE IND TIRE PRESSURE IND SERIAL DATA SPLICE BLOCK SUPPLEMENTAL RESTRAINTS SYSTEM TAN WIRE TAN/WHT WIRE TURN SIGNAL/ MULTI-FUNCTION SWITCH W/ ELECTRIC SIDE DOOR LOCK CONTROL W/ MANUAL SUPPRESSION SWITCH W/O MANUAL SUPPRESSION SWITCH, RV UPFITTER W/O RADIO WHT WIRE YEL WIRE YEL/BLK WIRE