Chevrolet Chevy Express G3500 (1996-2012) pnk Wiring diagrams

BLK/WHT WIRE BODY CONTROL MODULE (BCM) (BEHIND LOWER RIGHT SIDE OF DASH) CHIME MODULE (BEHIND CENTER OF DASH) DATA CLSS 2 DATA LINK CONNECTOR (DLC) (UNDER LEFT SIDE OF DASH) DK BLU WIRE DK GRN WIRE GRY WIRE HOT AT ALL TIMES INFLATABLE RESTRAINT SENSING, DIAGNOSTIC MODULE (SDM) (UNDER LEFT FRONT SEAT) INSTRUMENT PANEL CLUSTER LT BLU WIRE LT GRN WIRE LTR FUSE 30 PNK WIRE POWER DISTRIBUTION SYSTEM POWERTRAIN CONTROL MODULE (PCM) (IN ENGINE COMPT, ON LEFT INNER FENDER) PPL RADIO RED/WHT WIRE REMOTE CONTROL DOOR LOCK RECEIVER (BEHIND CENTER OF DASH) SPLICE UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT) UNDERHOOD PASS- THROUGH GROMMET BREAKOUT) VEHICLE COMMUNICATIONS INTERFACE MODULE (VCIM) (BELOW STEERING COLUMN) W/O ACTIVE HANDLING W/ ACTIVE HANDLING W/O RADIO WHT WIRE YEL WIRE

BLK WIRE BODY FUSE BLOCK (BELOW LEFT FRONT SEAT) CLASS 2 CLASS 2 (PCM) DATA COMPUTER DATA LINES SYSTEM CRUISE IND DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE GRN WIRE GROUND GRY WIRE GRY/BLK WIRE HOT AT ALL TIMES HOT IN RUN, START IGN IGN E FUSE 22 INSTRUMENT PANEL CLUSTER LT BLU WIRE NCA WIRE ON CRUISE CONTROL ON/OFF SWITCH OFF ON OFF ORG/BLK WIRE PCM IGN 1 FUSE 38 PNK WIRE POWERTRAIN CONTROL MODULE (PCM) (IN ENGINE COMPT, ON LEFT INNER FENDER) PPL PPL VSS LOW RED/WHT WIRE RESUME/ ACCEL RESUME/ACCEL SET/ COAST STOP LP FUSE 7 STOP/ CHMSL FUSE 8 STOPLAMP SWITCH (ABOVE BRAKE PEDAL) THROTTLE ACTUATOR CONTROL (TAC) MODULE (AT LEFT REAR OF ENGINE COMPARTMENT) TURN SIGNAL/ MULTIFUNCTION SWITCH UART SERIAL DATA UART SERIAL DATA UART SERIAL DATA UART SERIAL DATA SERIAL DATA 14 58 UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT) VEHICLE SPEED SENSOR (VSS) (ON RIGHT SIDE OF TRANSMISSION) VSS HIGH WHT WIRE YEL WIRE

88 CM FROM RIGHT DOME FLUORESCENT WORK LAMP CONNECTOR BREAKOUT) ACCESS PANEL LEFT SIDE FRONT RELAY CONTROL ACCESS PANEL LEFT SIDE REAR RELAY CONTROL ACCESS PANEL RIGHT SIDE REAR RELAY CONTROL BETWEEN LEFT SIDE FRONT ACCESS PANEL ACTUATORS) BETWEEN LEFT SIDE REAR ACCESS PANEL ACTUATORS) BLK WIRE BODY CONTROL MODULE (BEHIND LOWER RIGHT SIDE OF DASH) HOT AT ALL TIMES LEFT FRONT ACCESS PANEL RELAY 5 LEFT FRONT SIDE FRONT ACCESS PANEL ACTUATOR (BEHIND LEFT FRONT ACCESS PANEL) LEFT FRONT SIDE REAR ACCESS PANEL ACTUATOR (BEHIND LEFT FRONT ACCESS PANEL) LEFT REAR ACCESS PANEL RELAY 1 LEFT REAR SIDE FRONT ACCESS PANEL ACTUATOR LEFT REAR SIDE REAR ACCESS PANEL ACTUATOR (BEHIND LEFT REAR ACCESS PANEL) LT BLU WIRE LT GRN WIRE ORG/ WIRE PANEL ACTUATOR FUSE 3 PNK WIRE REAR FUSE BLOCK (ON LEFT "B" PILLAR) RIGHT ACCESS PANEL RELAY 6 RIGHT SIDE FRONT ACCESS PANEL ACTUATOR (BEHIND RIGHT FRONT ACCESS PANEL) RIGHT SIDE REAR ACCESS PANEL ACTUATOR (BEHIND RIGHT REAR ACCESS PANEL) TAN WIRE TAN/BLK WIRE

54 49 22 33 (DIESEL) (GASOLINE) ABS PUMP ABS/TCC SW ABS/VSES FUSE 48 ANTI-LOCK IND BLK WIRE BODY FUSE BLOCK (UNDER LEFT FRONT SEAT) BRAKE FLUID LEVEL SW IN LEFT FRONT SENSOR (+) RIGHT FRONT SENSOR (-) VSS INPUT BRAKE FLUID LEVEL SWITCH (HEAVY DUTY) (ON BRAKE MASTER CYLINDER RESERVOIR) BRAKE IND BRKS FUSE 11 BRN WIRE CRUISE CONTROL SYSTEM DIESEL DK GRN WIRE GAS GRY WIRE HOT AT ALL TIMES HOT IN RUN HOT IN RUN OR START IGN E FUSE 22 INSTRUMENT PANEL CLUSTER LEFT FRONT SENSOR (-) RIGHT FRONT SENSOR (+) BRAKE INPUT LEFT FRONT WHEEL SPEED SENSOR (ON INSIDE OF LEFT FRONT WHEEL) LOGIC LT BLU WIRE PNK WIRE PPL PPL DATA LINK CONNECTOR (DLC) (UNDER LEFT SIDE OF DASH) RED/BLK WIRE RIGHT FRONT WHEEL SPEED SENSOR (ON INSIDE OF RIGHT FRONT WHEEL) SERIAL DATA IGNITION STOP LAMP SWITCH (BEHIND LEFT SIDE OF DASH, ABOVE BRAKE PEDAL) TAN WIRE TCC BRAKE SW TRANSMISSION CONTROL MODULE (TCM) (LEFT FRONT CORNER OF ENG COMPT) UNDERHOOD FUSE BLOCK (ON LEFT SIDE OF ENG COMPT) VEHICLE SPEED SENSOR (VSS) VSS HIGH VSS LOW VSS OUTPUT YEL WIRE YEL/BLK WIRE

ABS IND. BLK WIRE BLK/WHT WIRE BRAKE FLUID LEVEL SWITCH (ON BRAKE MASTER CYLINDER RESERVOIR) BRAKE IND BRAKE PRESSURE DIFFERENTIAL SWITCH (ON BRAKE VALVE, NEAR FRONT OF EBCM) BRN WIRE CAUTION IND DATA LINK CONNECTOR (DLC) (UNDER LEFT SIDE OF DASH) DK BLU WIRE DK GRN WIRE GROUND GRY WIRE HEAVY DUTY HOT IN RUN OR START IGN 3 VOLTAGE INSTRUMENT PANEL CLUSTER LIGHT DUTY LOGIC LOW REF LT BLU WIRE LT GRN WIRE LT GRN/BLK WIRE NOT READY IND ORG/BLK WIRE PCM IGN 1 FUSE 38 PNK 1 2 WIRE PNK WIRE PPL SENSOR SELF TEST SIG CIR STEERING WHEEL POS MARKER PULSE SIG STEERING WHEEL POSITION SENS SIG 1 STEERING WHEEL POSITION SIG A STEERING WHEEL POSITION SIG B STEERING WHEEL SPEED/ POSITION SENSOR (AT BASE OF STEERING COLUMN) TRACTION CONTROL SWITCH UNDERHOOD FUSE BLOCK (ON LEFT SIDE OF ENGINE COMPT) WHT WIRE YAW RATE FREQUENCY YAW, LATERAL ACCELERATION SENSOR (UNDER FRONT PASSENGER SEAT) YEL WIRE

AMB AIR TEMP SENS SIG LOW REF AMB LGHT SENSOR REAR LGHT SENSOR AMBIENT AIR TEMPERATURE SENSOR (BEHIND FRONT GRILLE, ON RADIATOR SUPPORT) BACKUP LAMP PWR BLK WIRE BODY CONTROL MODULE (BEHIND LOWER RIGHT SIDE OF DASH) ELECTRO- CHROMIC EXTERIOR LIGHTS SYSTEM (W/ PASSENGER/ CARGO) GRN WIRE GROUND HOT IN RUN AND START IGN 1 VLT INSIDE REARVIEW MIRROR ISRVM FUSE 26 LOGIC BACKUP LAMP PWR LT GRN WIRE PNK WIRE SELECTOR SW TAN WIRE UNDERHOOD FUSE BLOCK (ON LEFT SIDE OF ENGINE COMPT) WHT WIRE

BLK WIRE BODY FUSE BLOCK (BELOW LEFT FRONT SEAT) CLASS 2 CLASS 2 (PCM) DATA COMPUTER DATA LINES SYSTEM CRUISE IND DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE GRN WIRE GROUND GRY WIRE GRY/BLK WIRE HOT AT ALL TIMES HOT IN RUN, START IGN IGN E FUSE 22 INSTRUMENT PANEL CLUSTER LT BLU WIRE NCA WIRE ON CRUISE CONTROL ON/OFF SWITCH OFF ON OFF ORG/BLK WIRE PCM IGN 1 FUSE 38 PNK WIRE POWERTRAIN CONTROL MODULE (PCM) (IN ENGINE COMPT, ON LEFT INNER FENDER) PPL PPL VSS LOW RED/WHT WIRE RESUME/ ACCEL RESUME/ACCEL SET/ COAST STOP LP FUSE 7 STOP/ CHMSL FUSE 8 STOPLAMP SWITCH (ABOVE BRAKE PEDAL) THROTTLE ACTUATOR CONTROL (TAC) MODULE (AT LEFT REAR OF ENGINE COMPARTMENT) TURN SIGNAL/ MULTIFUNCTION SWITCH UART SERIAL DATA UART SERIAL DATA UART SERIAL DATA UART SERIAL DATA SERIAL DATA 14 58 UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT) VEHICLE SPEED SENSOR (VSS) (ON RIGHT SIDE OF TRANSMISSION) VSS HIGH WHT WIRE YEL WIRE

BLK WIRE BLU WIRE BODY FUSE BLOCK (BELOW LEFT FRONT SEAT) CARGO/ PASSENGER CLASS 2 CRUISE IND CLASS 2 (PCM) DATA COMPUTER DATA LINES SYSTEM CRUISE CONTROL MODULE (NEAR BRAKE FLUID RESERVOIR) CUTAWAY DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE GRN WIRE GRY WIRE GRY/BLK WIRE HOT AT ALL TIMES HOT IN RUN, START IGN IGN E FUSE 22 INSTRUMENT PANEL CLUSTER LT BLU WIRE LT BLU/BLK WIRE NCA WIRE ON CRUISE CONTROL ON/OFF SWITCH OFF ON OFF PCM IGN 1 FUSE 38 PNK 17 (OR 1320) WIRE PNK WIRE POWERTRAIN CONTROL MODULE (PCM) (IN ENGINE COMPT, ON LEFT INNER FENDER) PPL PPL VSS LOW RED/WHT WIRE RESUME/ ACCEL RESUME/ACCEL SERIAL DATA SET/ COAST SPEED SIGNAL AUTO CRUISE INHIBIT SIG VSS HIGH 13 37 STOP LP FUSE 7 STOP/ CHMSL FUSE 8 STOPLAMP SWITCH (ABOVE BRAKE PEDAL) TURN SIGNAL/ MULTIFUNCTION SWITCH UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT) VEHICLE SPEED SENSOR (VSS) (ON RIGHT SIDE OF TRANSMISSION) WHT (OR LT BLU) WIRE WHT WIRE YEL WIRE

12 13 34 28 27 25 8 65 43 44 59 36 63 66 46 PRESS SENS LOW REF 19 21 69 14 71 CTRL SPD SIG CTRL SPD SIG SPEED SIG 21 22 58 4 24 40 SENS SIG LOW REF 6.6L 4.3L 4.8L, 5.3L, 6.0L A/C CMPRSR FUSE 18 A/C CMPRSR RELAY 40 A/C COMPRESSOR CLUTCH A/C REFRIGERANT PRESSURE SENSOR A/C SERIAL REQUEST DATA SIG BLK WIRE BODY CONTROL MODULE (BCM) (BEHIND LOWER RIGHT SIDE OF DASH) BRN/WHT WIRE CLUTCH RLY CTRL COMPUTER DATA LINES SYSTEM COOLING FAN ASSEMBLY (6.6L) (BEHIND RADIATOR) DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE ENGINE CONTROL MODULE (ECM) ENGINE COOLANT TEMPERATURE (ECT) SENSOR FAN CLTCH (EV) FUSE 63 GMLAN - GMLAN + GMLAN DATA GRY WIRE HOT AT ALL TIMES HOT W/ PWR/TRN RELAY 49 ENERGIZED LOW REF LT BLU WIRE LT GRN WIRE OF ENGINE) ORG/BLK WIRE PNK WIRE REF SIDE OF ENGINE COMPT) TAN WIRE TAN/BLK WIRE UNDERHOOD FUSE BLOCK (ON LEFT W/ AUXILIARY FUEL FIRED HEATER W/O AUXILIARY FUEL FIRED HEATER WHT (OR RED) WIRE WHT/BLK WIRE YEL WIRE

19 21 69 14 71 CTRL SPD SIG CTRL SPD SIG SPEED SIG 24 40 58 4 21 22 SENS SIG LOW REF 59 36 63 66 46 25 8 65 43 44 12 13 34 28 27 PRESS SENS LOW REF 6.6L 4.3L 4.8L, 5.3L, 6.0L A/C CMPRSR FUSE 18 A/C CMPRSR RELAY 40 A/C COMPRESSOR CLUTCH A/C REFRIGERANT PRESSURE SENSOR A/C SERIAL REQUEST DATA SIG BLK WIRE BODY CONTROL MODULE (BCM) (BEHIND LOWER RIGHT SIDE OF DASH) BRN/WHT WIRE CLUTCH RLY CTRL COMPUTER DATA LINES SYSTEM COOLING FAN ASSEMBLY (6.6L) (BEHIND RADIATOR) DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE ENGINE CONTROL MODULE (ECM) ENGINE COOLANT TEMPERATURE (ECT) SENSOR FAN CLTCH (EV) FUSE 63 GMLAN - GMLAN + GMLAN DATA GRY WIRE HOT AT ALL TIMES HOT W/ PWR/TRN RELAY 49 ENERGIZED LOW REF LT BLU WIRE LT GRN WIRE OF ENGINE) ORG/BLK WIRE PNK WIRE REF SIDE OF ENGINE COMPT) TAN WIRE TAN/BLK WIRE UNDERHOOD FUSE BLOCK (ON LEFT W/ AUXILIARY FUEL FIRED HEATER W/O AUXILIARY FUEL FIRED HEATER W/O AUXILIARY FUEL FIRED HEATER W/ AUXILIARY FUEL FIRED HEATER WHT/BLK WIRE YEL WIRE