Chevrolet Chevy Express G3500 (1996-2012) dk grn Wiring diagrams

27 28 2501 2500 44 43 COMPUTER DATA LINES SYSTEM DATA BUS (-) DATA BUS (+) 4.3L 4.3L/5.3L 4.8L/6.0L BATTERY BATTERY CURRENT SENSOR (4.3L/5.3L) BLK WIRE BODY CONTROL MODULE (BCM) (BEHIND LOWER RIGHT SIDE OF DASH) BRN WIRE CHARGE IND COMPUTER DATA LINES SYSTEM CURRENT SENSOR SIG DK GRN WIRE DRIVER INFORMATION CENTER (DIC) DISPLAY ENGINE CONTROL MODULE (ECM) (LEFT SIDE OF ENGINE COMPT) EXCEPT 4.3L FUSIBLE LINK 3 GENERATOR GENERATOR FIELD DUTY CYCLE SIG GENERATOR TURN ON SIG GMLAN SERIAL DATA GRY WIRE HOT W/ RUN/CRANK RELAY 15 ENERGIZED IPC FUSE 10 IGN VOLT INSTRUMENT PANEL CLUSTER (IPC) LOGIC LOW REF LOW SPEED GMLAN SERIAL DATA PNK WIRE ORG/ WIRE PNK WIRE POWER DISTRIBUTION SYSTEM RED WIRE SENS SIG STARTING CIRCUIT TAN WIRE TAN/BLK WIRE UNDERHOOD FUSE BLOCK (ON LEFT SIDE OF ENGINE COMPT) WHT WIRE

4.3L/ 5.3L 4.8L 6.0L AUTOMATIC TRANSMISSION AUTOMATIC TRANSMISSION INTERNAL MODE SWITCH (IMS) BATTERY BLK WIRE BLK/WHT WIRE BODY CONTROL MODULE (BCM) (BEHIND LOWER RIGHT SIDE OF DASH) GMLAN SERIAL DATA CHARGING CIRCUIT COMPUTER DATA LINES SYSTEM CONTROL SOLENOID VALVE ASSEMBLY CRNK RELAY 39 DATA BUS - DK GRN WIRE EXCEPT 4.3L 4.3L ENGINE CONTROL MODULE (ECM) (LEFT SIDE OF ENGINE COMPT) FUSIBLE LINK 2 GRY WIRE IGNITION SWITCH IGNITION VOLTAGE NCA WIRE OFF ORG/BLK WIRE PARK/ DATA NEUTRAL/ BUS (-) SIGNAL PARK/NEUTRAL POSITION (PNP) SWITCH PNK WIRE PPL RED WIRE RUN WIRE STARTER ENABLE RELAY CTRL STARTER MOTOR STRTR SOL FUSE 64 TAN WIRE TAN/BLK WIRE TRANSMISSION CONTROL MODULE (TCM) UNDERHOOD FUSE BLOCK (ON LEFT SIDE OF ENGINE COMPT) WHT WIRE YEL/BLK WIRE

ABS IND. AIR BAG IND BLK WIRE BLK/WHT WIRE BODY CONTROL MODULE (BCM) (BEHIND LOWER RIGHT SIDE OF DASH) BODY FUSE BLOCK (UNDER LEFT BODY FUSE BLOCK (UNDER LEFT FRONT SEAT) BRAKE IND BRN WIRE BRN/WHT WIRE CHARGE IND CMPS FUSE 19 COMPUTER DATA LINES SYSTEM CRUISE IND DIESEL DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/WHT WIRE DRIVER INFORMATION CENTER (DIC) DISPLAY ENGINE COMPT) ENGINE CONTROLS SYSTEM SUPPLEMENTAL RESTRAINTS SYSTEM ENGINE COOLANT TEMPERATURE GAUGE FRONT SEAT) FUEL GAUGE GMLAN SERIAL GRY/BLK WIRE HIGH BEAM IND HOT AT ALL TIMES HOT W/ RUN RELAY HOT W/ RUN/CRNK RELAY 15 ENERGIZED I/P CLUSTER FUSE 23 IGN VOLT IND CTRL IND LAMP (MIL) INSTRUMENT PANEL CLUSTER (IPC) IPC FUSE 10 LEFT TURN IND LIFTGATE AJAR SW SIG LF DOOR AJAR SW RR DOOR OPEN SW LR DOOR OPEN SW LOGIC LOW ENGINE OIL PRESSURE GAUGE LOW FUEL IND LOW OIL LOW STABILITY IND LT BLU WIRE LT GRN WIRE MALFUNCTION MIL CTRL NETWORK 3 ODOMETER PARK BRAKE SWITCH (UNDER LEFT SIDE OF DASH) PASS SEAT BELT PASSENGER SEAT BELT IND PNK WIRE PNK/BLK WIRE PPL PPL PNK WIRE PRESSURE IND PRND 321 RED/WHT WIRE RF DOOR AJAR SW RIGHT TURN IND SEAT BELT IND SECURITY IND SEO FUSE 27 SPEEDOMETER SUPPLEMENTAL RESTRAINTS SYSTEM SW SIG SWITCH SIG TAN/WHT WIRE TIRE PRESSURE IND TOW/HAUL IND TRACTION CONTROL IND UNDERHOOD FUSE BLOCK (ON LEFT SIDE OF VOLTS GAUGE W/ BRAKE WARNING INDICATOR SYSTEM W/ ODOMETER SECURITY WIRING PROVISION (SEO) W/O ODOMETER SECURITY WIRING PROVISION (SEO) WAIT TO START IND WHT WIRE YEL WIRE YEL/BLK WIRE

1589 2759 PPL 2759 1589 (OR 6049) 31 16 LOW REF SENS SIG PPL 4.3L 4.8L/5.3L/6.0L 6.6L 44 43 DATA BUS(-) DATA BUS(+) 50 41 36 35 SENS SIG 7 8 PPL 9 10 PPL BLK WIRE BLK/WHT WIRE BRN WIRE CARGO DOOR LATCH ASSEMBLY (W/ CARGO/PASSENGER) (IN RIGHT REAR CARGO DOOR) COMPUTER DATA LINES SYSTEM DK BLU WIRE DK BLU/WHT WIRE DK BLU/YEL WIRE DK GRN WIRE DK GRN/WHT WIRE DRIVER DOOR LATCH ASSEMBLY DRIVER INFORMATION CENTER (DIC) SWITCH ENGINE CONTROL MODULE (ECM) (LEFT SIDE OF ENGINE COMPT) GRY WIRE GRY/BLK WIRE ILLUMI- NATION LEFT REAR SIDE DOOR JAMB SWITCH (W/ LEFT REAR HINGED DOOR) LOW REF PASSENGER DOOR LATCH ASSEMBLY (AT REAR OF FRONT PASSENGER DOOR) PERSON- ALIZATION VEHICLE INFO PNK WIRE PNK/BLK WIRE PPL PPL 2 3 PPL PNK WIRE RIGHT REAR DOOR JAMB SWITCH (W/ CARGO/PASSENGER) SENS SIG SENS SIG LOW REF SET/ RESET SWITCH SIG TAN WIRE TAN/BLK WIRE TAN/WHT WIRE TRIP/ FUEL W/ BRAKE WARNING INDICATOR SYSTEM WATER IN-FUEL SENSOR WHT WIRE YEL WIRE YEL/BLK WIRE

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 LH AUDIO SIG (+) RH AUDIO SIG (+) 1 2 3 4 5 6 7 8 9 10 11 12 13 14 B+ LF MID OUT (+) RF MID OUT (+) 1959 1955 LR MID OUT (-) RR MID OUT (-) 2 1 8 LO REF 658 1782 VOICE SIG DRAIN WIRE HI SPD GMLAN ANTENNA IN BATT POSITIVE VOLT BLK/WHT WIRE BODY CONTROL MODULE (BCM) (BEHIND LOWER RIGHT SIDE OF DASH) BODY FUSE BLOCK (UNDER LEFT FRONT SEAT) BREAKOUT) BRN/WHT WIRE CELLULAR, DIGITAL RADIO ANTENNA CELLULAR/ NAVIGATION ANTENNA COAX COMPUTER DATA LINES SYSTEM CRUISE CONTROL SYSTEM CUTAWAY UPFITTER DIGITAL RADIO RECEIVER (LEFT SIDE OF DASH) DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE DRAIN WIRE GRY WIRE HOT AT ALL TIMES INFLATABLE RESTRAINT STEERING WHEEL MODULE COIL (AT TOP OF STEERING COLUMN) INFO LED DIMMING CTRL GND LF MID OUT (-) RF MID OUT (-) LEFT CARGO DOOR SPEAKER (IF EQUIPPED) LEFT FRONT SPEAKER LEFT REAR SPEAKER LH AUDIO SIG + RH AUDIO SIG + LO GMLAN SERIAL DATA LO REF LO SERIAL DATA LR MID OUT (+) RR MID OUT (+) LT BLU WIRE LT BLU/BLK WIRE LT GRN WIRE MUTE NCA WIRE ORG/ WIRE PASSENGER/ CARGO PNK WIRE RADIO RADIO ANTENNA RDO/ CHIME FUSE 20 RED/WHT WIRE RIGHT CARGO DOOR SPEAKER (IF EQUIPPED) RIGHT FRONT SPEAKER RIGHT REAR SPEAKER RIGHT STEERING WHEEL CONTROL SWITCH SEEK DOWN SEEK UP SOURCE STEERING WHEEL CTRL TAN WIRE TAN/BLK WIRE TAN/WHT WIRE USB CABLE USB CHARGE USB RECEPTACLE VEHICLE COMMUNICATION INTERFACE MODULE (VICM) (BELOW STEERING COLUMN) VOICE SIG VOL DOWN VOL UP W/ VEHICLE COMMUNICATION SYSTEM W/O VEHICLE COMMUNICATION SYSTEM WHT WIRE YEL WIRE

BANK 1 SENSOR 1 (IN EXHAUST PIPE, IN FRONT OF CATALYTIC CONVERTER) BANK 2 SENSOR 1 (IN EXHAUST PIPE, IN FRONT OF CATALYTIC CONVERTER) BLK WIRE BRN WIRE CAMSHAFT POSITION (CMP) SENSOR (FRONT OF ENGINE) CEN FIELD SIG CKP SENS SIG LOW REF DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/WHT WIRE ENGINE CONTROL MODULE (ECM) (LEFT SIDE OF ENGINE COMPT) ENGINE COOLANT TEMPERATURE (ECT) SENSOR (AT LEFT FRONT OF ENGINE) GEN ON SIG GRY WIRE GRY/BLK WIRE GRY/WHT WIRE HEATED OXYGEN INJ 1 CTRL ECT SENS SIG LOW REF INJ 2 CTRL INJ 3 CTRL INJ 4 CTRL INJ 7 CTRL KNOCK SENSOR (KS) 1 KNOCK SENSOR (KS) 2 KS 1 SIG KS 1 SIG KS 2 SIG KS 2 SIG LOW REF LOW REF LT BLU WIRE LT BLU/BLK WIRE LT GRN WIRE LT GRN/BLK WIRE MAP SENS SIG PPL ORG/ WIRE ORG/BLK WIRE PNK 5 6 WIRE PNK 7 8 9 10 11 12 13 14 WIRE PNK WIRE PNK/BLK WIRE PPL PPL INTAKE SOL INJ 8 CTRL INJ 5 CTRL INJ 6 CTRL PPL TP SENS 2 SIG CMP SENS SIG TP SENS 1 SIG LOW REF PPL/WHT WIRE PRE SENS SIG SOL CTRL STARTING/ CHARGING SYSTEM STARTING/CHARGING SYSTEM TAC MTR CTRL 2 TAC MTR CTRL 1 TAN WIRE TAN/WHT WIRE WHT GRY/ WIRE WHT WIRE WHT/BLK WIRE YEL WIRE YEL/BLK WIRE