Chevrolet Chevy Express G3500 (1996-2012) blk Wiring diagrams

1-2 SHIFT SOLENOID VALVE 2-3 SHIFT SOLENOID VALVE 27 28 GMLAN (-) GMLAN (+) 68 71 1 MIL CTRL TOS SIG ACTUATOR SIG AUTOMATIC TRANSMISSION BLK WIRE BLK/WHT WIRE BODY CONTROL MODULE (BCM) (BEHIND LOWER RIGHT SIDE OF DASH) BRN WIRE BRN/WHT WIRE CLASS 2 CLASS 2 DATA COMPUTER DATA LINES SYSTEM DK BLU WIRE DK GRN WIRE ENGINE CONTROL MODULE (ECM) (LEFT SIDE OF ENGINE COMPT) FLUID PRESSURE (TFP) MANUAL VALVE POSITION SWITCH GRY WIRE IGN IGN LOGIC INSTRUMENT PANEL CLUSTER (IPC) LT BLU WIRE LT BLU/WHT WIRE LT GRN WIRE NCA WIRE ORG/ WIRE ORG/BLK WIRE PNK WIRE PPL RED WIRE REV TAN WIRE TAN/BLK WIRE TORQUE CONVERTER CLUTCH (TCC) PULSE WIDTH MODULATION (PWM) SOLENOID VALVE TOW/ HAUL IND CLASS 2 TOW/HAUL SW TOW/HAUL SWITCH YEL WIRE YEL/BLK WIRE

27 28 2501 2500 44 43 COMPUTER DATA LINES SYSTEM DATA BUS (-) DATA BUS (+) 4.3L 4.3L/5.3L 4.8L/6.0L BATTERY BATTERY CURRENT SENSOR (4.3L/5.3L) BLK WIRE BODY CONTROL MODULE (BCM) (BEHIND LOWER RIGHT SIDE OF DASH) BRN WIRE CHARGE IND COMPUTER DATA LINES SYSTEM CURRENT SENSOR SIG DK GRN WIRE DRIVER INFORMATION CENTER (DIC) ENGINE CONTROL MODULE (ECM) (LEFT SIDE OF ENGINE COMPT) EXCEPT 4.3L FUSIBLE LINK 3 GENERATOR GENERATOR FIELD DUTY CYCLE SIG GENERATOR TURN ON SIG GMLAN SERIAL DATA GRY WIRE HOT W/ RUN/CRANK RELAY ENERGIZED IGN VOLT INSTRUMENT PANEL CLUSTER (IPC) IP CLSTR FUSE 30 LOGIC LOW REF LOW SPEED GMLAN SERIAL DATA PNK WIRE ORG/ WIRE PNK WIRE POWER DISTRIBUTION SYSTEM RED WIRE SENS SIG STARTING CIRCUIT TAN WIRE TAN/BLK WIRE UNDERHOOD FUSE BLOCK (ON LEFT SIDE OF ENGINE COMPT) WHT WIRE

BATTERY BLK WIRE BLK/WHT WIRE BODY CONTROL MODULE (BCM) (BEHIND LOWER RIGHT SIDE OF DASH) GMLAN SERIAL DATA CHARGING CIRCUIT COMPUTER DATA LINES SYSTEM CRNK RELAY 73 DATA BUS - DK GRN WIRE ENGINE CONTROL MODULE (ECM) (LEFT SIDE OF ENGINE COMPT) EXCEPT 4.3L 4.3L 28 43 FUSIBLE LINK 2 IGNITION LOCK CYLINDER IGNITION SWITCH IGNITION VOLTAGE OF ENGINE COMPT) OFF ORG/BLK WIRE PARK/NEUTRAL POSITION (PNP) SWITCH (ON LEFT SIDE OF TRANSMISSION) P/N PNK WIRE PPL RED WIRE RUN WIRE STARTER ENABLE RELAY CTRL STARTER MOTOR STRTR SOL FUSE 64 TAN WIRE TAN/BLK WIRE UNDERHOOD FUSE BLOCK (ON LEFT SIDE WHT WIRE YEL/BLK WIRE

1-2 SHIFT SOLENOID VALVE 2-3 SHIFT SOLENOID VALVE 27 28 GMLAN (-) GMLAN (+) 68 71 1 MIL CTRL TOS SIG ACTUATOR SIG AUTOMATIC TRANSMISSION BLK WIRE BLK/WHT WIRE BODY CONTROL MODULE (BCM) (BEHIND LOWER RIGHT SIDE OF DASH) BRN WIRE BRN/WHT WIRE CLASS 2 CLASS 2 DATA COMPUTER DATA LINES SYSTEM DK BLU WIRE DK GRN WIRE ENGINE CONTROL MODULE (ECM) (LEFT SIDE OF ENGINE COMPT) FLUID PRESSURE (TFP) MANUAL VALVE POSITION SWITCH GRY WIRE IGN IGN LOGIC INSTRUMENT PANEL CLUSTER (IPC) LT BLU WIRE LT BLU/WHT WIRE LT GRN WIRE NCA WIRE ORG/ WIRE ORG/BLK WIRE PNK WIRE PPL RED WIRE REV TAN WIRE TAN/BLK WIRE TORQUE CONVERTER CLUTCH (TCC) PULSE WIDTH MODULATION (PWM) SOLENOID VALVE TOW/ HAUL IND CLASS 2 TOW/HAUL SW TOW/HAUL SWITCH YEL WIRE YEL/BLK WIRE

1-2 SHIFT SOLENOID VALVE 2-3 SHIFT SOLENOID VALVE 30 45 39 MIL CTRL TOS SIG 44 57 GMLAN (-) GMLAN (+) ACTUATOR SIG AUTOMATIC TRANSMISSION AUTOMATIC TRANSMISSION FLUID TEMPERATURE (TFT) SENSOR BLK WIRE BLK/WHT WIRE BODY CONTROL MODULE (BCM) (BEHIND LOWER RIGHT SIDE OF DASH) BRN WIRE BRN/WHT WIRE CLASS 2 CLASS 2 DATA COMPUTER DATA LINES SYSTEM DK BLU WIRE DK GRN WIRE ENGINE CONTROL MODULE (ECM) FLUID PRESSURE (TFP) MANUAL VALVE POSITION SWITCH GRY WIRE IGN INSTRUMENT PANEL CLUSTER (IPC) LOGIC LT BLU WIRE LT BLU/WHT WIRE LT GRN WIRE NCA WIRE ORG/ WIRE ORG/BLK WIRE PNK WIRE PPL PRESSURE CONTROL (PC) SOLENOID VALVE RED WIRE REV TAN WIRE TAN YEL/BLK WIRE TAN/BLK WIRE TORQUE CONVERTER CLUTCH (TCC) PULSE WIDTH MODULATION (PWM) SOLENOID VALVE TOW/ HAUL IND CLASS 2 TOW/HAUL SW TOW/HAUL SWITCH YEL WIRE YEL/BLK WIRE

16 17 19 DATA BUS (-)) DATA BUS (+) DATA ENABLE 19 26 2501 2500 DATA BUS (-) DATA BUS (+) 2 12 DATA BUS (+) DATA BUS (-) DATA BUS (+) DATA BUS (-) 25 18 2500 2501 DATA BUS (+) DATA BUS (-) 4.8L 4.3L, 6.0L, 5.3L 4.8L 6.0L 5.3L 6.6L 6.6L 9 8 10 DATA BUS (-) DATA BUS (+) SERIAL DATA ACC WAKE UP SERIAL DATA 11 15 19 7 6 38 37 ACC WAKE UP SERIAL DATA PNK WIRE ACC WAKE-UP SERIAL DATA AUTOMATIC TRANSMISSION (6 SPEED A/T) BLK WIRE BODY CONTROL MODULE (BCM) (BEHIND LOWER CONTROL SOLENOID VALUE ASSEMBLY COOLANT HEATER (6.6L, W/ FUEL FIRED AUXILIARY HEATER) DATA BUS - DATA BUS - DATA BUS - DATA BUS+ DATA BUS+ DATA BUS- DATA BUS- DATA COMM ENABLE DATA ENABLE DATA BUS (+) DATA BUS (-) DATA BUS (-) DATA BUS (+) DK BLU WIRE DK GRN WIRE EXCEPT 5.3L EXCEPT AUXILIARY 5.3L 5.3L HEATER IGN DATA BUS (+) DATA BUS (-) LT BLU WIRE TAN WIRE TAN/BLK WIRE TRANSMISSION CONTROL MODULE (TCM) (4 SPEED A/T) VEHICLE COMMUNICATION INTERFACE MODULE (VCM) (BELOW STEERING COLUMN) W/ ACTIVE BRAKE CONTROL W/ FUEL FIRED AUXILIARY HEATER W/ FUEL W/O FUEL FIRED FIRED AUXILIARY HEATER W/ VECHILE COMMUNICATION SYSTEM W/O ACTIVE BRAKE CONTROL W/O FUEL FIRED AUXILIARY HEATER W/O VECHILE COMMUNICATION SYSTEM

21 19 69 14 71 CTRL SPD SIG CTRL SPD SIG SPEED SIG BLK WIRE BLK/WHT WIRE BRN/WHT WIRE COMPUTER DATA LINES SYSTEM COOLANT LEVEL SWITCH COOLING FAN ASSEMBLY (BEHIND RADIATOR) DK BLU WIRE DK GRN WIRE DRIVER INFORMATION CENTER (DIC) DISPLAY ENGINE CONTROL MODULE (ECM) ENGINE COOLANT GAUGE TEMPERATURE ENGINE COOLANT TEMPERATURE (ECT) SENSOR (TOP OF ENGINE, NEAR THERMOSTAT HOUSING) FAN CLTCH (EV) FUSE 63 GRY WIRE HOT W/ PWR/TRN RELAY 49 ENERGIZED INSTRUMENT PANEL CLUSTER (IPC) LOGIC LOW REF LOW SPD GMLAN SERIAL DATA LT GRN WIRE PNK WIRE SENS SIG LOW REF TAN WIRE UNDERHOOD FUSE BLOCK (ON LEFT SIDE OF ENGINE COMPT) WHT WIRE WHT/BLK WIRE YEL WIRE

11 12 LPS DIMMER SW SIG DIMMING VOLT REF 2 15 HEAD 8 17 PARK LAMPS SIG HEADLAMPS OFF SIG AUXILIARY BLOWER MOTOR SWITCH BATTERY POS VOLT BCM 3 FUSE 26 BLK WIRE BLK/WHT WIRE BODY CONTROL MODULE (BCM) (BEHIND LOWER RIGHT SIDE OF DASH) BODY FUSE BLOCK (UNDER LEFT FRONT SEAT) BRN WIRE BRN/WHT WIRE CONNECTOR CONTROL DIMMING CTRL DK GRN WIRE DRIVER DOOR LOCK SWITCH DRIVER INFORMATION CENTER (DIC) SWITCH DRIVER WINDOW SWITCH FRONT AUXILIARY HVAC CONTROL ASSEMBLY HEADLAMP, PANEL DIMMER SWITCH HOT AT ALL TIMES HVAC CONTROL ASSEMBLY IN FRONT HEADLINER HARNESS, 21 CM INFLATABLE RESTRAINT I/P MODULE DISABLE SWITCH (W/ MANUAL SUPPRESSION) LEFT STEERING WHEEL CONTROL SWITCH LPS DIMMING CTRL LT BLU WIRE OFF AUTO PARK ORG/ WIRE ORG/WHT WIRE PASSENGER DOOR LOCK (W/ POWER SWITCH MIRRORS, POWER WINDOWS) PASSENGER WINDOW SWITCH PNK CONTROL PNK WIRE PNK PNK W/O REDUNDANT RADIO STEERING WHEEL WIRE PNK WIRE RADIO RED WIRE RED/WHT WIRE RIGHT STEERING WHEEL CONTROL SWITCH STR WHL SNSR FUSE 17 TRACTION CONTROL SWITCH (TCS) (W/ ACTIVE BRAKE CONTROL) UNDERHOOD FUSE BLOCK (ON LEFT SIDE OF ENGINE COMPT) W/ AUTOMATIC CRUISE CONTROL, REDUNDANT RADIO STEERING WHEEL CONTROL W/ AUTOMATIC ELECTRONIC CRUISE CONTROL W/ AUXILIARY HEATER W/O REAR A/C W/ ELECTRIC SIDE DOOR LOCK W/ ELECTRIC TOW/HAUL SWITCH SIDE DOOR LOCK W/ POWER OPERATED WINDOW W/ REAR W/O REAR AUXILIARY AUXILIARY CONTROLS CONTROLS W/ REDUNDANT RADIO STEERING WHEEL W/ RV UPFITTER W/O RADIO PROVISIONS W/O RV UPFITTER WHT WIRE YEL WIRE

1 18 25 COURTESY LP CTRL COURTESY LP CTRL DEFEAT SW SIG 149 (OR 690) 20 CM FROM RIGHT SUNSHADE BREAKOUT) BLK WIRE BLK/WHT WIRE BLU WIRE BODY CONTROL MODULE (BCM) (BEHIND LOWER RIGHT SIDE OF DASH) BODY FUSE BLOCK (UNDER LEFT FRONT SEAT) CARGO CARGO DOOR LATCH ASSEMBLY (IN RIGHT REAR CARGO DOOR) CARGO/PASSENGER COURTESY LP CTRL CTSY LP CTRL DK BLU WIRE DK BLU/WHT WIRE DOME DOME READING FL DOME RLY CTRL FRONT DOME/ READING LAMPS GRY WIRE GRY/BLK WIRE HEADLAMP, PANEL DIMMER SWITCH HOT AT ALL TIMES LEFT SUNSHADE LIFTGATE AJAR SW SIG MIDDLE DOME/ READING LAMPS ORG/ WIRE PASSENGER PASSENGER/CARGO W/O RV UPFITTER PNK/BLK WIRE PPL PROVISIONAL READING REAR DOME/ READING LAMPS (PASSENGER) DOME LAMP (CARGO) RED WIRE RIGHT SUNSHADE (ON UPPER RIGHT OF HEADLINER) TAN/WHT WIRE THE ENGINE BLOCK) UNDERHOOD FUSE BLOCK (ON LEFT SIDE OF ENGINE COMPT) UNDERHOOD LAMP UPFTR AUX 1 FUSE 36 (W/ CUTAWAY, AMBULANCE, RV UPFITTERS) UPFTR CTSY LAMPS FUSE 4 UPFTR CTSY LAMPS PCB RELAY (W/ AMBULANCE, RV UPFITTER) W/ COMMERCIAL TRADESMAN SALES PACKAGE, CARGO LAMP W/ CUTAWAY W/ CUTAWAY, CARGO W/O RV UPFITTER W/ LEFT, RIGHT SUNSHADE MIRROR W/ RV UPFITTER W/ RV UPFITTER, LEFT, RIGHT SUNSHADE MIRROR W/O RV UPFITTER W/O RV W/ RV UPFITTER UPFITTER WHT WIRE YEL/BLK WIRE

12 CM FROM LEFT FRONT DOME FLUORESCENT WORK LAMP CONNECTOR) BLK WIRE BLU WIRE DK BLU/WHT WIRE DOME FLUORESCENT WORK LAMPS DRIVER DOOR LATCH ASSEMBLY (AT REAR OF DRIVER DOOR) FRONT CARGO FLUORESCENT WORK LAMP FUSE 2 GRY WIRE GRY/BLK WIRE LEFT FRONT ACCESS PANEL FLUORESCENT WORK LAMP LEFT REAR ACCESS PANEL FLUORESCENT WORK LAMP LEFT REAR DOOR JAMB SWITCH (W/ LEFT REAR HINGED DOOR) (AT LEFT "B" PILLAR) ORG/ WIRE PACKAGE, CARGO LAMP) DOME FLUORESCENT WORK LAMPS RELAY PASSENGER DOOR LATCH ASSEMBLY (AT REAR OF FRONT PASSENGER DOOR) REAR CARGO FLUORESCENT WORK LAMP REAR FUSE BLOCK (ON LEFT "B" PILLAR) RED WIRE RIGHT ACCESS PANEL FLUORESCENT WORK LAMP RIGHT REAR DOOR JAMB SWITCH (CARGO/ PASSENGER) (AT RIGHT "B" PILLAR) TAN/WHT WIRE WHT WIRE YEL WIRE YEL/BLK WIRE