Chevrolet Chevy Express G2500 (1996-2012) mil ctrl Wiring diagrams

23 3 SERIAL DATA BELT SW 7 63 5 VOLT REF LOW REF ABS IND. AIR BAG IND BATTERY IND BLK WIRE BLK/WHT WIRE BODY CONTROL MODULE (BCM) (LOWER RIGHT SIDE OF DASH) BRAKE IND BRAKE WARNING IND CONTROL BATT VOLTAGE GROUND GROUND IGN VOLTAGE SERIAL DATA BRN WIRE BRN/WHT WIRE CHECK GAGES IND. CLASS 2 (BCM) CLASS 2 (EBCM) CLASS 2 (PCM) CLASS 2 (SDM) COMPUTER DATA LINES SYSTEM CRUISE IND DIMMING DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DRL IND ECT SENS ENGINE CONTROLS SYSTEM ENGINE COOLANT TEMP ENGINE COOLANT TEMPERATURE SENSOR (LEFT SIDE OF ENGINE) ENGINE OIL LEVEL SWITCH (4.8L, 5.3L, 6.0L) (RIGHT SIDE OF OIL PAN) ENGINE OIL PRESSURE SENSOR (TOP REAR OF ENGINE) FUEL GAUGE FUEL PUMP/ SENDER ASSEMBLY (IN FUEL TANK) GROUND GRY WIRE HIGH BEAM IND HOT AT ALL TIMES HOT IN RUN OR START IGN IGN CLASS 2 (PCM) IGN CLASS 2 (PCM) IGN CLASS 2 (PCM) IGN CLASS 2 (PCM) IGN VOLT SIG IGN E FUSE 22 ILLUMINATION (6 BULBS) INFLATABLE RESTRAINT SENSING, DIAGNOSTIC MODULE (UNDER LEFT FRONT SEAT) INSTRUMENT PANEL CLUSTER IPC FUSE 31 LCD DISPLAY 000000 TRIP LEFT FRONT SEAT BELT SWITCH (IN LEFT FRONT SEAT BELT LATCH) LEFT TURN IND LH FRT TURN SIG SUP VOLT LOW REF LT BLU WIRE LT BLU/BLK WIRE LT BLU/WHT WIRE LT GRN WIRE MALFUNCTION IND LAMP MIL CTRL MIL SIGNAL OFF OIL PRESS OIL PRESS (RIGHT REAR OF ENGINE) OIL PRESSURE OIL PRESSURE IND P R N D 3 2 1 PARK BRAKE PARK BRAKE SWITCH (UNDER LEFT SIDE OF DASH) PNK WIRE POWER BRAKE BOOSTER FLUID PRESSURE ALARM SWITCH (IN BOOSTER INLET HOSE) POWERTRAIN CONTROL MODULE (IN ENGINE COMPT, ON LEFT INNER FENDER) PPL FUEL LEVEL RED/WHT WIRE RH FRT TURN SIG SUP VOLT RIGHT TURN IND SEAT BELT IND SECURITY IND SERIAL DATA SPEEDOMETER SPLICE PACK TAN WIRE TAN/WHT WIRE TOW/HAUL IND TRACTION CONTROL IND'S TRIP RESET SWITCH TRIP RESET SWN SIGNAL GROUND UNDERHOOD FUSE BLOCK (IN ENGINE COMPT, ATTACHED TO LEFT FRONT FENDER) VOLTMETER W/ PWR SEAT W/O PWR SEAT YEL WIRE

ABS IND. AIR BAG IND BLK WIRE BLK/WHT WIRE BODY CONTROL MODULE (BCM) (BEHIND LOWER RIGHT SIDE OF DASH) BODY FUSE BLOCK (UNDER LEFT BODY FUSE BLOCK (UNDER LEFT FRONT SEAT) BRAKE IND BRN WIRE BRN/WHT WIRE CHARGE IND CMPS FUSE 19 COMPUTER DATA LINES SYSTEM CRUISE IND DIESEL DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/WHT WIRE DRIVER INFORMATION CENTER (DIC) ENGINE COMPT) ENGINE CONTROLS SYSTEM SUPPLEMENTAL RESTRAINTS SYSTEM ENGINE COOLANT TEMPERATURE GAUGE FRONT SEAT) FUEL GAUGE GMLAN SERIAL GRY/BLK WIRE HIGH BEAM IND HOT AT ALL TIMES HOT W/ RUN RELAY HOT W/ RUN/CRANK RELAY 15 ENERGIZED IGN VOLT IND CTRL IND LAMP (MIL) INSTRUMENT PANEL CLUSTER (IPC) IP CLSTR FUSE 10 IP CLSTR FUSE 23 LEFT TURN IND LIFTGATE AJAR SW SIG LF DOOR AJAR SW RR DOOR OPEN SW LR DOOR OPEN SW LOGIC LOW ENGINE OIL LOW ENGINE OIL PRESSURE GAUGE LOW TIRE PRESSURE IND LT BLU WIRE LT GRN WIRE MALFUNCTION MIL CTRL NETWORK 3 ODOMETER PARK BRAKE SWITCH (UNDER LEFT SIDE OF DASH) PASS SEAT BELT PNK WIRE PNK/BLK WIRE PPL PPL PNK WIRE PRESSURE IND RED/WHT WIRE RF DOOR AJAR SW RIGHT TURN IND SEAT BELT IND SECURITY IND SEO FUSE 27 SPEEDOMETER SUPPLEMENTAL RESTRAINTS SYSTEM SW SIG SWITCH SIG TAN/WHT WIRE TOW/HAUL IND TRACTION CONTROL IND UNDERHOOD FUSE BLOCK (ON LEFT SIDE OF VOLTS GAUGE W/ ODOMETER SECURITY WIRING PROVISION (SEO) W/O ODOMETER SECURITY WIRING PROVISION (SEO) WAIT TO START IND WHT WIRE YEL WIRE YEL/BLK WIRE

ABS IND. AIR BAG IND BLK WIRE BLK/WHT WIRE BODY CONTROL MODULE (BCM) (BEHIND LOWER RIGHT SIDE OF DASH) BODY FUSE BLOCK (UNDER LEFT BODY FUSE BLOCK (UNDER LEFT FRONT SEAT) BRAKE IND BRN WIRE BRN/WHT WIRE CHARGE IND CMPS FUSE 19 COMPUTER DATA LINES SYSTEM CRUISE IND DIESEL DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/WHT WIRE DRIVER INFORMATION CENTER (DIC) DISPLAY ENGINE COMPT) ENGINE CONTROLS SYSTEM SUPPLEMENTAL RESTRAINTS SYSTEM ENGINE COOLANT TEMPERATURE GAUGE FRONT SEAT) FUEL GAUGE GMLAN SERIAL GRY/BLK WIRE HIGH BEAM IND HOT AT ALL TIMES HOT W/ RUN RELAY HOT W/ RUN/CRNK RELAY 15 ENERGIZED I/P CLUSTER FUSE 23 IGN VOLT IND CTRL IND LAMP (MIL) INSTRUMENT PANEL CLUSTER (IPC) IPC FUSE 10 LEFT TURN IND LIFTGATE AJAR SW SIG LF DOOR AJAR SW RR DOOR OPEN SW LR DOOR OPEN SW LOGIC LOW ENGINE OIL PRESSURE GAUGE LOW FUEL IND LOW OIL LOW STABILITY IND LT BLU WIRE LT GRN WIRE MALFUNCTION MIL CTRL NETWORK 3 ODOMETER PARK BRAKE SWITCH (UNDER LEFT SIDE OF DASH) PASS SEAT BELT PASSENGER SEAT BELT IND PNK WIRE PNK/BLK WIRE PPL PPL PNK WIRE PRESSURE IND PRND 321 RED/WHT WIRE RF DOOR AJAR SW RIGHT TURN IND SEAT BELT IND SECURITY IND SEO FUSE 27 SPEEDOMETER SUPPLEMENTAL RESTRAINTS SYSTEM SW SIG SWITCH SIG TAN/WHT WIRE TIRE PRESSURE IND TOW/HAUL IND TRACTION CONTROL IND UNDERHOOD FUSE BLOCK (ON LEFT SIDE OF VOLTS GAUGE W/ BRAKE WARNING INDICATOR SYSTEM W/ ODOMETER SECURITY WIRING PROVISION (SEO) W/O ODOMETER SECURITY WIRING PROVISION (SEO) WAIT TO START IND WHT WIRE YEL WIRE YEL/BLK WIRE

4.8L/6.0L 5.3L BLK WIRE BLK/WHT WIRE BRN WIRE BRN/WHT WIRE CLUTCH RLY CTRL CNSTR VENT SOL FUSE 56 COMPT) COMPUTER DATA LINES SYSTEM DK GRN WIRE DK GRN/WHT WIRE ECM PWR/TRN FUSE 78 ENGINE CONTROL MODULE (ECM) (LEFT SIDE OF ENGINE COMPT) EVAP SOL CTRL EVAPORATIVE EMISSION (EVAP) CANISTER VENT SOLENOID (NEAR FRONT OF FUEL TANK) EVEN IGN/ INJ FUSE 79 FUEL PUMP RELAY 38 (4.8L/6.0L) GAS FUEL PUMP FUSE 24 GRY WIRE GRY/WHT WIRE HOT AT ALL TIMES IC 1 CTRL IC 2 CTRL IC 3 CTRL IC 4 CTRL IC 5 CTRL IC 6 CTRL IC 7 CTRL IC 8 CTRL IGN INSTRUMENT PANEL CLUSTER (IPC) LOGIC LOW ENGINE OIL PRESSURE IND LOW REF LT BLU WIRE LT BLU/WHT WIRE MAF/ CNSTR VENT FUSE 64 MALFUNCTION INDICATOR LAMP MIL CTRL ODD IGN/INJ FUSE 65 ORG/ WIRE ORG/BLK WIRE ORG/WHT WIRE PNK 5 6 7 (OR PNK) WIRE PNK PNK PNK PNK PNK PNK PNK PNK PNK 4 5 6 7 8 9 10 11 12 WIRE PNK PNK PPL 15 16 17 18 19 20 21 22 23 24 WIRE PNK PPL 2 3 4 WIRE PNK WIRE PPL PPL/WHT WIRE PWR/TRN RELAY 49 RED/WHT WIRE SNSR 1 (PRE)/CLS FUSE 77 SNSR 2 (POST) FUSE 62 TOS SIG TRANSMISSIONS SYSTEM AIR CONDITIONING SYSTEM UNDERHOOD FUSE BLOCK (ON LEFT SIDE OF ENGINE WHT WIRE YEL WIRE

4.8L/6.0L 5.3L BLK WIRE BLK/WHT WIRE BRN WIRE BRN/WHT WIRE CLUTCH RLY CTRL CNSTR VENT SOL FUSE 17 COMPT) COMPUTER DATA LINES SYSTEM DK GRN WIRE DK GRN/WHT WIRE ECM PWR/TRN FUSE 50 ENGINE CONTROL MODULE (ECM) (LEFT SIDE OF ENGINE COMPT) EVAP SOL CTRL EVAPORATIVE EMISSION (EVAP) CANISTER VENT SOLENOID (NEAR FRONT OF FUEL TANK) EVEN IGN/ INJ FUSE 52 FUEL PUMP RELAY 72 (4.8L/6.0L) FUEL/PUMP FUSE 2 GRY WIRE GRY/WHT WIRE HOT AT ALL TIMES IC 1 CTRL IC 2 CTRL IC 3 CTRL IC 4 CTRL IC 5 CTRL IC 6 CTRL IC 7 CTRL IC 8 CTRL IGN INSTRUMENT PANEL CLUSTER (IPC) LOGIC LOW ENGINE OIL PRESSURE IND LOW REF LT BLU WIRE LT BLU/WHT WIRE MAF/ CNSTR VENT FUSE 49 MALFUNCTION INDICATOR LAMP MIL CTRL ODD IGN/INJ FUSE 55 ORG/ WIRE ORG/BLK WIRE ORG/WHT WIRE PNK 5 6 7 (OR PNK) WIRE PNK PNK PNK PNK PNK PNK PNK PNK PNK 4 5 6 7 8 9 10 11 12 WIRE PNK PNK PPL PPL 15 16 17 18 19 20 21 22 23 24 WIRE PNK PPL 2 3 4 WIRE PNK WIRE PPL PPL/WHT WIRE PWR/TRN RELAY 76 RED WIRE RED/WHT WIRE SNSR 1 FUSE 46 SNSR 2 FUSE 56 TOS SIG TRANSMISSIONS SYSTEM AIR CONDITIONING SYSTEM UNDERHOOD FUSE BLOCK (ON LEFT SIDE OF ENGINE WHT WIRE YEL WIRE

5 VOLT REF BLK WIRE BLK/WHT WIRE BRN WIRE BRN/WHT WIRE COMPUTER DATA LINES SYSTEM DK (DASH HARN, NEAR POWER SEAT BREAKOUT) DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE ECT SENSOR EVAP PURGE FTP SENSOR FTT SENSOR FUEL GAGE FUEL IND FUEL LVL INPUT FUEL LVL OUT FUEL RLY CTRL FUEL TANK PRESSURE SENSOR FUEL TANK TEMPERATURE SENSOR GAUGES FUSE 4 GRN WIRE GRY WIRE HOT IN RUN OR START I/P FUSE BLOCK IAT SENSOR IN ALTERNATIVE FUELS HARNESS INPUT INSTRUMENT CLUSTER LOCK-OFF RLY LT BLU/WHT WIRE LT GRN WIRE MAF SENSOR MALFUNCTION INDICATOR LAMP (MIL) "SERVICE ENGINE SOON" MANIFOLD ABSOLUTE PRESSURE SENSOR (TOP RIGHT SIDE OF ENGINE) MAP SENSOR MIL CTRL MIL INPUT NCA WIRE NGO ENABLE ORG/ WIRE ORG/BLK WIRE PNK 12 13 14 15 16 17 18 19 20 WIRE PNK 15 16 17 18 19 20 21 22 23 24 WIRE PNK 35 36 WIRE PNK PNK 4 5 6 7 WIRE PNK WIRE PPL PPL PNK PNK WIRE PPL/WHT WIRE RED WIRE RED/BLK WIRE SENSOR GRND SERIAL DATA SPEEDOMETER/ ODOMETER TACH TAN WIRE TAN/BLK WIRE TAN/WHT WIRE TP SENSOR VEHICLE SPEED WHT WIRE YEL WIRE YEL/BLK WIRE

4.8L/6.0L 5.3L BLK WIRE BLK/WHT WIRE BRN WIRE BRN/WHT WIRE CLUTCH RLY CTRL CNSTR VENT SOL FUSE 56 COMPT) COMPUTER DATA LINES SYSTEM DK GRN WIRE DK GRN/WHT WIRE ECM PWR/TRN FUSE 78 ENGINE CONTROL MODULE (ECM) (LEFT SIDE OF ENGINE COMPT) EVAP SOL CTRL EVAPORATIVE EMISSION (EVAP) CANISTER VENT SOLENOID (NEAR FRONT OF FUEL TANK) EVEN IGN/ INJ FUSE 79 FUEL PUMP RELAY 38 (4.8L/6.0L) GAS FUEL PUMP FUSE 24 GRY WIRE GRY/WHT WIRE HOT AT ALL TIMES IC 1 CTRL IC 2 CTRL IC 3 CTRL IC 4 CTRL IC 5 CTRL IC 6 CTRL IC 7 CTRL IC 8 CTRL IGN INSTRUMENT PANEL CLUSTER (IPC) LOGIC LOW ENGINE OIL PRESSURE IND LOW REF LT BLU WIRE LT BLU/WHT WIRE MAF/ CNSTR VENT FUSE 64 MALFUNCTION INDICATOR LAMP MIL CTRL ODD IGN/INJ FUSE 65 ORG/ WIRE ORG/BLK WIRE ORG/WHT WIRE PNK 5 6 7 (OR PNK) WIRE PNK PNK PNK PNK PNK PNK PNK PNK PNK 4 5 6 7 8 9 10 11 12 WIRE PNK PNK PPL 15 16 17 18 19 20 21 22 23 24 WIRE PNK PPL 2 3 4 WIRE PNK WIRE PPL PPL/WHT WIRE PWR/TRN RELAY 49 RED/WHT WIRE SNSR 1 (PRE)/CLS FUSE 77 SNSR 2 (POST) FUSE 62 TOS SIG TRANSMISSIONS SYSTEM AIR CONDITIONING SYSTEM UNDERHOOD FUSE BLOCK (ON LEFT SIDE OF ENGINE WHT WIRE YEL WIRE

4.8L/6.0L 5.3L BLK WIRE BLK/WHT WIRE BRN WIRE BRN/WHT WIRE CLUTCH RLY CTRL CNSTR VENT SOL FUSE 56 COMPT) COMPUTER DATA LINES SYSTEM DK GRN WIRE DK GRN/WHT WIRE ECM PWR/TRN FUSE 78 ENGINE CONTROL MODULE (ECM) (LEFT SIDE OF ENGINE COMPT) EVAP SOL CTRL EVAPORATIVE EMISSION (EVAP) CANISTER VENT SOLENOID (NEAR FRONT OF FUEL TANK) EVEN IGN/ INJ FUSE 79 FUEL PUMP RELAY 38 (4.8L/6.0L) GAS FUEL PUMP FUSE 24 GRY WIRE GRY/WHT WIRE HOT AT ALL TIMES IC 1 CTRL IC 2 CTRL IC 3 CTRL IC 4 CTRL IC 5 CTRL IC 6 CTRL IC 7 CTRL IC 8 CTRL IGN INSTRUMENT PANEL CLUSTER (IPC) LOGIC LOW ENGINE OIL PRESSURE IND LOW REF LT BLU WIRE LT BLU/WHT WIRE MAF/ CNSTR VENT FUSE 64 MALFUNCTION INDICATOR LAMP MIL CTRL ODD IGN/INJ FUSE 65 ORG/ WIRE ORG/BLK WIRE ORG/WHT WIRE PNK 5 6 7 (OR PNK) WIRE PNK PNK PNK PNK PNK PNK PNK PNK PNK 4 5 6 7 8 9 10 11 12 WIRE PNK PNK PPL 15 16 17 18 19 20 21 22 23 24 WIRE PNK PPL 2 3 4 WIRE PNK WIRE PPL PPL/WHT WIRE PWR/TRN RELAY 49 RED/WHT WIRE SNSR 1 (PRE)/CLS FUSE 77 SNSR 2 (POST) FUSE 62 TOS SIG TRANSMISSIONS SYSTEM AIR CONDITIONING SYSTEM UNDERHOOD FUSE BLOCK (ON LEFT SIDE OF ENGINE WHT WIRE YEL WIRE

4.8L/6.0L 5.3L BLK WIRE BLK/WHT WIRE BRN WIRE BRN/WHT WIRE CLUTCH RLY CTRL CNSTR VENT SOL FUSE 17 COMPT) COMPUTER DATA LINES SYSTEM DK GRN WIRE DK GRN/WHT WIRE ECM PWR/TRN FUSE 50 ENGINE CONTROL MODULE (ECM) (LEFT SIDE OF ENGINE COMPT) EVAP SOL CTRL EVAPORATIVE EMISSION (EVAP) CANISTER VENT SOLENOID (NEAR FRONT OF FUEL TANK) EVEN IGN/ INJ FUSE 52 FUEL PUMP RELAY 72 (4.8L/6.0L) FUEL/PUMP FUSE 2 GRY WIRE GRY/WHT WIRE HOT AT ALL TIMES IC 1 CTRL IC 2 CTRL IC 3 CTRL IC 4 CTRL IC 5 CTRL IC 6 CTRL IC 7 CTRL IC 8 CTRL IGN INSTRUMENT PANEL CLUSTER (IPC) LOGIC LOW ENGINE OIL PRESSURE IND LOW REF LT BLU WIRE LT BLU/WHT WIRE MAF/ CNSTR VENT FUSE 49 MALFUNCTION INDICATOR LAMP MIL CTRL ODD IGN/INJ FUSE 55 ORG/ WIRE ORG/BLK WIRE ORG/WHT WIRE PNK 5 6 7 (OR PNK) WIRE PNK PNK PNK PNK PNK PNK PNK PNK PNK 4 5 6 7 8 9 10 11 12 WIRE PNK PNK PPL PPL 15 16 17 18 19 20 21 22 23 24 WIRE PNK PPL 2 3 4 WIRE PNK WIRE PPL PPL/WHT WIRE PWR/TRN RELAY 76 RED WIRE RED/WHT WIRE SNSR 1 FUSE 46 SNSR 2 FUSE 56 TOS SIG TRANSMISSIONS SYSTEM AIR CONDITIONING SYSTEM UNDERHOOD FUSE BLOCK (ON LEFT SIDE OF ENGINE WHT WIRE YEL WIRE