Chevrolet Chevy Express G2500 (1996-2012) gry Wiring diagrams

27 28 2501 2500 44 43 COMPUTER DATA LINES SYSTEM DATA BUS (-) DATA BUS (+) 4.3L 4.3L/5.3L 4.8L/6.0L BATTERY BATTERY CURRENT SENSOR (4.3L/5.3L) BLK WIRE BODY CONTROL MODULE (BCM) (BEHIND LOWER RIGHT SIDE OF DASH) BRN WIRE CHARGE IND COMPUTER DATA LINES SYSTEM CURRENT SENSOR SIG DK GRN WIRE DRIVER INFORMATION CENTER (DIC) DISPLAY ENGINE CONTROL MODULE (ECM) (LEFT SIDE OF ENGINE COMPT) EXCEPT 4.3L FUSIBLE LINK 3 GENERATOR GENERATOR FIELD DUTY CYCLE SIG GENERATOR TURN ON SIG GMLAN SERIAL DATA GRY WIRE HOT W/ RUN/CRANK RELAY 15 ENERGIZED IPC FUSE 10 IGN VOLT INSTRUMENT PANEL CLUSTER (IPC) LOGIC LOW REF LOW SPEED GMLAN SERIAL DATA PNK WIRE ORG/ WIRE PNK WIRE POWER DISTRIBUTION SYSTEM RED WIRE SENS SIG STARTING CIRCUIT TAN WIRE TAN/BLK WIRE UNDERHOOD FUSE BLOCK (ON LEFT SIDE OF ENGINE COMPT) WHT WIRE

3 21 DIMMING CTRL TRACTION SW 6 16 TCC BRAKE SIG PRK BRK SW ABS IND. BLK WIRE BLK/WHT WIRE BODY CONTROL MODULE (BCM) (BEHIND LOWER RIGHT SIDE OF DASH) BRAKE BOOSTER FLUID FLOW ALARM SWITCH (IN POWER STEERING PUMP OUTLET HOSE) BRAKE FLUID LEVEL SWITCH (AT LEFT REAR OF ENGINE COMPT) BRAKE IND BRAKE PRESSURE DIFFERENTIAL SWITCH (ON BRAKE VALVE, NEAR FRONT OF EBCM) BRAKE WARNING INDICATOR CTRL BREAKOUT TOWARDS INSTRUMENT PANEL CLUSTER) BRK FLUID LEVEL SENSOR SIG BRN WIRE BRN/WHT WIRE COMPUTER DATA LINES SYSTEM DK BLU WIRE DK GRN WIRE GRY WIRE HEAVY DUTY IGN VOLT IGN VOLT STEERING SENS A STEERING SENS C INSTRUMENT PANEL CLUSTER (IPC) LIGHT DUTY LO SPD GMLAN LOGIC LOGIC STEERING WHEEL SPEED/ POSITION SENSOR (AT BASE OF STEERING COLUMN) LOW STABILITY IND LT BLU WIRE LT BLU/BLK WIRE LT BLU/WHT WIRE LT GRN WIRE ORG/BLK WIRE PARK BRAKE SWITCH (UNDER LEFT PNK 7 3 5 6 2 4 1 8 WIRE PNK WIRE PPL RIGHT REAR WHEEL SPEED SENSOR (WSS) (AT RIGHT REAR WHEEL HUB) SERIAL DATA SIDE OF DASH) STEERING SENS B TAN WIRE TAN/WHT WIRE TRACTION CONTROL SWITCH VDC IND WHT WIRE YEL WIRE

1589 2759 PPL 2759 1589 (OR 6049) 31 16 LOW REF SENS SIG PPL 4.3L 4.8L/5.3L/6.0L 6.6L 44 43 DATA BUS(-) DATA BUS(+) 50 41 36 35 SENS SIG 7 8 PPL 9 10 PPL BLK WIRE BLK/WHT WIRE BRN WIRE CARGO DOOR LATCH ASSEMBLY (W/ CARGO/PASSENGER) (IN RIGHT REAR CARGO DOOR) COMPUTER DATA LINES SYSTEM DK BLU WIRE DK BLU/WHT WIRE DK BLU/YEL WIRE DK GRN WIRE DK GRN/WHT WIRE DRIVER DOOR LATCH ASSEMBLY DRIVER INFORMATION CENTER (DIC) SWITCH ENGINE CONTROL MODULE (ECM) (LEFT SIDE OF ENGINE COMPT) GRY WIRE GRY/BLK WIRE ILLUMI- NATION LEFT REAR SIDE DOOR JAMB SWITCH (W/ LEFT REAR HINGED DOOR) LOW REF PASSENGER DOOR LATCH ASSEMBLY (AT REAR OF FRONT PASSENGER DOOR) PERSON- ALIZATION VEHICLE INFO PNK WIRE PNK/BLK WIRE PPL PPL 2 3 PPL PNK WIRE RIGHT REAR DOOR JAMB SWITCH (W/ CARGO/PASSENGER) SENS SIG SENS SIG LOW REF SET/ RESET SWITCH SIG TAN WIRE TAN/BLK WIRE TAN/WHT WIRE TRIP/ FUEL W/ BRAKE WARNING INDICATOR SYSTEM WATER IN-FUEL SENSOR WHT WIRE YEL WIRE YEL/BLK WIRE

4.3L 4.8L/5.3L/6.0L 6.6L 4.3L, 4.8L, 6.0L 5.3L (VIN G) 6.0L (VIN B) 7 8 PPL 9 10 PPL ALTERNATIVE FUEL TANK PRESSURE SENSOR BLK WIRE BRAKE BOOSTER FLUID FLOW ALARM SWITCH (IN POWER STEERING PUMP OUTLET HOSE) BRAKE BOOSTER FLUID PRESSURE ALARM SWITCH (IN POWER STEERING PUMP INLET HOSE) BRAKE FLUID LEVEL SWITCH (AT LEFT REAR OF ENGINE COMPT) BRAKE PRESSURE DIFFERENTIAL SWITCH (ON BRAKE VALVE, NEAR FRONT OF EBCM) BRN WIRE CNG CONTROL MODULE (6.0L(VIN B)) (FORWARD OF LEFT REAR SPRING ON FRAME) CNG FUEL VEHICLE ENGINE CONTROLS SYSTEM ENGINE OIL LEVEL SWITCH (ON LEFT SIDE OF OIL PAN) ENGINE OIL PRESSURE (EOP) SENSOR (EXCEPT 6.6L: ON TOP REAR OF ENGINE) FUEL LEVEL SENSOR (ON LEFT FRAME FUEL PUMP, SENDER ASSEMBLY (ON FUEL TANK) GRN WIRE GRY WIRE HEAVY DUTY LIGHT DUTY LOW REF LPG CONTROL MODULE (6.0L(VIN B)) (ON TANK CONTROL BOX) LPG FUEL VEHICLE W/ 3 TANK LPG FUEL VEHICLE W/ 4 TANK LT BLU/BLK WIRE PPL PPL 2 3 PPL FUEL PUMP RELAY SIG PPL SENSING PRESSING PRIMARY FUEL LEVEL SENSOR PRIMARY SIG FUEL SENDER RAIL) RED WIRE SECONDARY FUEL LEVEL SENSOR SECONDARY SIG FUEL SENDER TAN WIRE TAN/WHT WIRE W/ BRAKE WARNING INDICATOR SYSTEM WHT WIRE

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 LH AUDIO SIG (+) RH AUDIO SIG (+) 1 2 3 4 5 6 7 8 9 10 11 12 13 14 B+ LF MID OUT (+) RF MID OUT (+) 1959 1955 LR MID OUT (-) RR MID OUT (-) 2 1 8 LO REF 658 1782 VOICE SIG DRAIN WIRE HI SPD GMLAN ANTENNA IN BATT POSITIVE VOLT BLK/WHT WIRE BODY CONTROL MODULE (BCM) (BEHIND LOWER RIGHT SIDE OF DASH) BODY FUSE BLOCK (UNDER LEFT FRONT SEAT) BREAKOUT) BRN/WHT WIRE CELLULAR, DIGITAL RADIO ANTENNA CELLULAR/ NAVIGATION ANTENNA COAX COMPUTER DATA LINES SYSTEM CRUISE CONTROL SYSTEM CUTAWAY UPFITTER DIGITAL RADIO RECEIVER (LEFT SIDE OF DASH) DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE DRAIN WIRE GRY WIRE HOT AT ALL TIMES INFLATABLE RESTRAINT STEERING WHEEL MODULE COIL (AT TOP OF STEERING COLUMN) INFO LED DIMMING CTRL GND LF MID OUT (-) RF MID OUT (-) LEFT CARGO DOOR SPEAKER (IF EQUIPPED) LEFT FRONT SPEAKER LEFT REAR SPEAKER LH AUDIO SIG + RH AUDIO SIG + LO GMLAN SERIAL DATA LO REF LO SERIAL DATA LR MID OUT (+) RR MID OUT (+) LT BLU WIRE LT BLU/BLK WIRE LT GRN WIRE MUTE NCA WIRE ORG/ WIRE PASSENGER/ CARGO PNK WIRE RADIO RADIO ANTENNA RDO/ CHIME FUSE 20 RED/WHT WIRE RIGHT CARGO DOOR SPEAKER (IF EQUIPPED) RIGHT FRONT SPEAKER RIGHT REAR SPEAKER RIGHT STEERING WHEEL CONTROL SWITCH SEEK DOWN SEEK UP SOURCE STEERING WHEEL CTRL TAN WIRE TAN/BLK WIRE TAN/WHT WIRE USB CABLE USB CHARGE USB RECEPTACLE VEHICLE COMMUNICATION INTERFACE MODULE (VICM) (BELOW STEERING COLUMN) VOICE SIG VOL DOWN VOL UP W/ VEHICLE COMMUNICATION SYSTEM W/O VEHICLE COMMUNICATION SYSTEM WHT WIRE YEL WIRE

5.3L 5.3L EXCEPT 5.3L A/C REFRIGERANT PRESSURE SENSOR ACC SER DATA IGN VOLT BATT POS VOLT PNK WIRE ACCELERATOR PEDAL POSITION (APP) SENSOR (UNDER LEFT SIDE OF DASH) ANTI-LOCK BRAKES SYSTEM BANK 1 SENSOR 2 BANK 2 SENSOR 2 BLK LT BLU/ WIRE BLK WIRE BLK/WHT WIRE BRAKE PEDAL POSITION (BPP) SENSOR (TOP OF BRAKE PEDAL ASSEMBLY) BREAKOUT) BRK SENS SPLY BRK SW FUSE 13 BRN WIRE COMPUTER DATA LINES SYSTEM CUTAWAY DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE ECM BATT FUSE 19 ECM IGN/ GLOW PLUG MDL IGN FUSE 30 ENGINE CONTROL MODULE (ECM) (LEFT SIDE OF ENGINE COMPT) ENGINE COOLANT RADIATOR TEMPERATURE SENSORS FUEL PUMP, SENDER ASSEMBLY (ON FUEL TANK) FUEL TANK PRESSURE (FTP) SENSOR (ON FUEL TANK) GRY WIRE GRY/WHT WIRE HOT AT ALL TIMES HOT W/ RUN/ CRNK RELAY 15 ENERGIZED IAT SENS SIG LOW REF ECT SENS SIG LOW REF LOW REF PRESS SENS SIG PPL LT BLU WIRE LT BLU/ BLK WIRE LT BLU/BLK WIRE LT BLU/WHT WIRE LT GRN WIRE MAF SENS SIG LOW REF ORG/BLK WIRE ORG/WHT WIRE PNK (OR PNK) 5 6 7 WIRE PNK IGN VOLT WIRE PNK PPL 2 3 4 WIRE PNK WIRE PPL PPL FUEL LEVEL SENS PPL/WHT WIRE PRESS SENS SIG LOW REF PWR/TRN RLY CTRL RED/WHT WIRE RELAY CTRL START RLY CTRL STARTING/ CHARGING SYSTEM STOP LAMP SWITCH (BEHIND LEFT SIDE OF DASH, ABOVE BRAKE PEDAL) TAN WIRE TAN/BLK WIRE TAN/WHT WIRE TCC BRAKE SIG TOWARDS INSTRUMENT PANEL CLUSTER) TRANSMISSIONS SYSTEM UNDERHOOD FUSE BLOCK (ON LEFT SIDE OF ENGINE COMPT) VSS WHT WIRE WHT/BLK WIRE YEL WIRE YEL/BLK WIRE

4.8L/6.0L 5.3L BLK WIRE BLK/WHT WIRE BRN WIRE BRN/WHT WIRE CLUTCH RLY CTRL CNSTR VENT SOL FUSE 56 COMPT) COMPUTER DATA LINES SYSTEM DK GRN WIRE DK GRN/WHT WIRE ECM PWR/TRN FUSE 78 ENGINE CONTROL MODULE (ECM) (LEFT SIDE OF ENGINE COMPT) EVAP SOL CTRL EVAPORATIVE EMISSION (EVAP) CANISTER VENT SOLENOID (NEAR FRONT OF FUEL TANK) EVEN IGN/ INJ FUSE 79 FUEL PUMP RELAY 38 (4.8L/6.0L) GAS FUEL PUMP FUSE 24 GRY WIRE GRY/WHT WIRE HOT AT ALL TIMES IC 1 CTRL IC 2 CTRL IC 3 CTRL IC 4 CTRL IC 5 CTRL IC 6 CTRL IC 7 CTRL IC 8 CTRL IGN INSTRUMENT PANEL CLUSTER (IPC) LOGIC LOW ENGINE OIL PRESSURE IND LOW REF LT BLU WIRE LT BLU/WHT WIRE MAF/ CNSTR VENT FUSE 64 MALFUNCTION INDICATOR LAMP MIL CTRL ODD IGN/INJ FUSE 65 ORG/ WIRE ORG/BLK WIRE ORG/WHT WIRE PNK 5 6 7 (OR PNK) WIRE PNK PNK PNK PNK PNK PNK PNK PNK PNK 4 5 6 7 8 9 10 11 12 WIRE PNK PNK PPL 15 16 17 18 19 20 21 22 23 24 WIRE PNK PPL 2 3 4 WIRE PNK WIRE PPL PPL/WHT WIRE PWR/TRN RELAY 49 RED/WHT WIRE SNSR 1 (PRE)/CLS FUSE 77 SNSR 2 (POST) FUSE 62 TOS SIG TRANSMISSIONS SYSTEM AIR CONDITIONING SYSTEM UNDERHOOD FUSE BLOCK (ON LEFT SIDE OF ENGINE WHT WIRE YEL WIRE

& IGNITION COIL/MODULE 7) 1 2 3 PNK WIRE 1 2 3 PPL BLK WIRE BRN WIRE COMPUTER DATA COMPUTER DATA LINES SYSTEM DK GRN WIRE DK GRN/WHT WIRE FCSM BATT FUSE 36 FSCM IGN FUSE 6 GMLAN DATA GRY WIRE HOT AT ALL TIMES HOT W/ RUN/ CRNK RELAY 15 ENERGIZED IGN VOLT IGNITION COIL/MODULE 1 IGNITION COIL/MODULE 3 IGNITION COIL/MODULE 5 LINES SYSTEM LOW REF LT BLU WIRE LT BLU/WHT WIRE NCA WIRE ORG/ WIRE ORG/WHT WIRE PNK PNK PNK PNK PNK PNK PNK PNK PNK 4 5 6 7 8 9 10 11 12 WIRE PNK PNK PPL 15 16 17 18 19 20 21 22 23 24 WIRE PNK WIRE PPL PPL/WHT WIRE PUMP CTRL RED WIRE RED/WHT WIRE RELAY CTRL SENS SIG SERIAL DATA SPARK PLUG TAN WIRE TAN/BLK WIRE UNDERHOOD FUSE BLOCK (ON LEFT SIDE OF ENGINE COMPT)

& IGNITION COIL/MODULE 8) 1 2 3 PPL BLK WIRE BRN WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/WHT WIRE ENGINE OIL PRESSURE (EOP) SENSOR (ON TOP REAR OF ENGINE) FUEL INJECTOR 1 FUEL INJECTOR 2 FUEL INJECTOR 3 FUEL INJECTOR 4 FUEL INJECTOR 5 FUEL INJECTOR 6 FUEL INJECTOR 7 FUEL INJECTOR 8 FUEL RAIL PRESSURE (FPR) SENSOR GRY WIRE IGNITION COIL/MODULE 2) IGNITION COIL/MODULE 4 IGNITION COIL/MODULE 6 LT BLU WIRE LT BLU/BLK WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/BLK WIRE NCA WIRE ORG/BLK WIRE ORG/WHT WIRE PNK 5 6 WIRE PNK 7 8 9 10 11 12 13 14 WIRE PNK PNK PNK PNK PNK PNK PNK PNK PNK 4 5 6 7 8 9 10 11 12 WIRE PNK WIRE PNK/BLK WIRE PPL PPL/WHT WIRE RED WIRE SPARK PLUG TAN WIRE TAN/WHT WIRE YEL/BLK WIRE

BANK 1 SENSOR 1 (IN EXHAUST PIPE, IN FRONT OF CATALYTIC CONVERTER) BANK 2 SENSOR 1 (IN EXHAUST PIPE, IN FRONT OF CATALYTIC CONVERTER) BLK WIRE BRN WIRE CAMSHAFT POSITION (CMP) SENSOR (FRONT OF ENGINE) CEN FIELD SIG CKP SENS SIG LOW REF DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/WHT WIRE ENGINE CONTROL MODULE (ECM) (LEFT SIDE OF ENGINE COMPT) ENGINE COOLANT TEMPERATURE (ECT) SENSOR (AT LEFT FRONT OF ENGINE) GEN ON SIG GRY WIRE GRY/BLK WIRE GRY/WHT WIRE HEATED OXYGEN INJ 1 CTRL ECT SENS SIG LOW REF INJ 2 CTRL INJ 3 CTRL INJ 4 CTRL INJ 7 CTRL KNOCK SENSOR (KS) 1 KNOCK SENSOR (KS) 2 KS 1 SIG KS 1 SIG KS 2 SIG KS 2 SIG LOW REF LOW REF LT BLU WIRE LT BLU/BLK WIRE LT GRN WIRE LT GRN/BLK WIRE MAP SENS SIG PPL ORG/ WIRE ORG/BLK WIRE PNK 5 6 WIRE PNK 7 8 9 10 11 12 13 14 WIRE PNK WIRE PNK/BLK WIRE PPL PPL INTAKE SOL INJ 8 CTRL INJ 5 CTRL INJ 6 CTRL PPL TP SENS 2 SIG CMP SENS SIG TP SENS 1 SIG LOW REF PPL/WHT WIRE PRE SENS SIG SOL CTRL STARTING/ CHARGING SYSTEM STARTING/CHARGING SYSTEM TAC MTR CTRL 2 TAC MTR CTRL 1 TAN WIRE TAN/WHT WIRE WHT GRY/ WIRE WHT WIRE WHT/BLK WIRE YEL WIRE YEL/BLK WIRE