Chevrolet Chevy Express G2500 (1996-2012) fuel pump relay Wiring diagrams

1-2 SHIFT SOLENOID 2-3 SHIFT SOLENOID A/T FLUID PRESSURE MANUAL VALVE POSITION SWITCH ABS RELAY, POWER BRAKE BOOSTER, ELECTRONIC BRAKE CONTROL MODULE ANTI-LOCK BRAKES SYSTEM ANTI-LOCK BRAKES SYSTEM (ELECTRONIC BRAKE CONTROL MODULE) ANTI-LOCK BRAKES SYSTEM PPL APP 3 SIG SENS GROUND A/T ISS SENS HI AUTOMATIC TRANSMISSION AUTOMATIC TRANSMISSION INPUT SHAFT SPEED SENSOR (ON LEFT SIDE OF TRANSMISSION) BLK WIRE BLK/WHT WIRE BRAKE FUSE 18 BRN WIRE BRN/WHT WIRE COMPUTER DATA LINES SYSTEM DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/WHT WIRE ECM I FUSE ECM-B FUSE ENGINE CONTROLS SYSTEM ENGINE COOLANT TEMPERATURE (ECT) SENSOR (ON TOP FRONT OF ENGINE) FUEL PUMP RELAY GAUGES FUSE 4 GLOW PLUG RELAY, TURBOCHARGER WASTEGATE SOLENOID, EPR SOLENOID GRY WIRE HOT AT ALL TIMES HOT IN HOT IN OFF, RUN OR START HOT IN RUN OR START I/P FUSE BLOCK (LOWER LEFT KICK PANEL) INSTRUMENT CLUSTER SYSTEM INSTRUMENT PANEL CLUSTER (IPC) LT BLU WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/BLK WIRE MALFUNCTION INDICATOR LAMP ORG/ WIRE PNK PNK WIRE PNK PPL WIRE PNK WIRE POWERTRAIN CONTROL MODULE (PCM) (BEHIND CENTER OF DASH) PPL PPL DATA LINK CONNECTOR (UNDER LEFT SIDE OF DASH) PPL PNK PNK WIRE PPL/WHT WIRE PRESSURE CONTROL SOLENOID VALVE RED WIRE RED/BLK WIRE REV, LO RUN WIRE SOUND SYSTEMS TAN WIRE TAN/WHT WIRE TCC PWM SOLENOID TCC/BRAKE SWITCH (ON BRAKE PEDAL SUPPORT) TRANS FLUID TEMP SENSOR TRANS FUSE 20 UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT) VEHICLE SPEED SENSOR (VSS) (ON LEFT SIDE OF TRANSMISSION) VEHICLE SPEED SENSOR BUFFER (UNDER GLOVE BOX) WHT/BLK WIRE YEL WIRE YEL/BLK WIRE

15-77 CM FROM 6-PIN CONNECTOR ON RIGHT FRAME RAIL) 4.3L 4.3L, GVW OVER 8500 LBS., FEDERAL EMISSIONS 5.0/ 5.7L 5.0L, 5.7L, 7.4L 7.4L 7.4L ONLY 7.4L OTHERS 7.4L-ENGINE HARNESS, APPROX 14 CM FROM FUEL INJECTOR BREAKOUT) 7.4L/ 4.3L SECONDARY AIR INJECTION REACTION (AIR) PUMP CLUTCH (7.4L ONLY) A/C COMPRESSOR CLUTCH A/C LOW PRESSURE CUTOUT SWITCH FUEL PUMP AND SENDER BANK 1 SENSOR 1 BANK 1 SENSOR 3 (EX 7.4L) BANK 1 SENSOR 2 BANK 2 SENSOR 1 DIODE BANK 2 SENSOR 2 (7.4L) BASE BLK WIRE BLK/WHT WIRE BLOWER MOTOR RESISTOR/ RELAY BRAKE PRESSURE DIFFERENTIAL SWITCH CRUISE CONTROL MODULE DATA LINK CONNECTOR (DLC) ELECTRONIC BRAKE CONTROL MODULE (EBCM) EXCEPT 7.4L EXCEPT 7.4L-ENGINE HARNESS, 4-16 CM FROM FUEL INJECTOR BREAKOUT) FUEL PUMP RELAY GASOLINE ENGINES HEATED OXYGEN SENSOR HEATED OXYGEN SENSOR HEATED OXYGEN SENSOR HEATED OXYGEN SENSOR UNDERHOOD FUSE/RELAY CENTER HORNS IGNITION CONTROL MODULE (ICM) INFLATABLE RESTRAINT FRONT END DISCRIMINATING SENSOR INFLATABLE RESTRAINT SENSING AND DIAGNOSTIC MODULE INSTRUMENT CLUSTER PASSLOCK MODULE LAMP GROUP LEFT FRONT DOOR JAMB SWITCH LEFT FRONT POWER DOOR LOCK SWITCH LEFT FRONT POWER SIDE WINDOW SWITCH LEFT POWER OUTSIDE REAR VIEW MIRROR MASS AIRFLOW (MAF) SENSOR NCA WIRE NON- BASE OTHERS OTHERS 7.4L OTHERS EXCEPT 7.4L PARK/ NEUTRAL POSITION SWITCH POWER OUTSIDE REAR VIEW MIRROR REMOTE CONTROL SWITCH RIGHT FRONT DOOR JAMB SWITCH RIGHT FRONT POWER DOOR LOCK SWITCH RIGHT FRONT POWER SIDE WINDOW SWITCH RIGHT POWER OUTSIDE REAR VIEW MIRROR STARTER RELAY TAN/WHT WIRE UNDERHOOD FUSE/RELAY CENTER UNDERHOOD FUSE/RELAY CENTER A/C LOW PRESSURE CUTOUT SWITCH UNDERHOOD REEL LAMP UNDERHOOD LAMP VEHICLE CONTROL MODULE (VCM)

A/C COMPRESSOR CLUTCH AMBULANCE PACKAGE AUXILIARY BLOWER MOTOR AUXILIARY BLOWER MOTOR CENTER HIGH MOUNTED STOPLAMP BLK WIRE BLK/WHT WIRE BLOWER MOTOR RESISTOR/ RELAY BRAKE PRESSURE DIFFERENTIAL SWITCH CENTER HIGH MOUNTED STOPLAMP DATA LINK CONNECTOR (DLC) DIESEL ENGINES DIODE ELECTRONIC BRAKE CONTROL MODULE (EBCM) FRONT AUXILIARY HVAC CONTROL MODULE HEATER AND A/C CONTROL LOGIC MODULE FUEL HEATER FUEL LIFT PUMP FUEL PUMP RELAY FUEL SENDER BUFFER MODULE GLOW PLUG RELAY HORNS INSTRUMENT CLUSTER LAMP GROUP LEFT REAR PARK/ STOP LAMP LEFT REAR PARK/ TURN LAMP LEFT BACKUP LAMP NCA WIRE PARK/ NEUTRAL POSITION SWITCH PASSENGER VANS ONLY PASSLOCK MODULE (BLUNT CUT) POWERTRAIN CONTROL MODULE (PCM) REAR AUXILIARY HVAC CONTROL MODULE AUXILIARY BLOWER MOTOR SWITCH RIGHT BACKUP LAMP LICENSE LAMP RIGHT POWER SEAT SWITCH RIGHT REAR DOOR JAMB SWITCH SIDE DOOR JAMB SWITCH RIGHT REAR PARK/ TURN LAMP RIGHT REAR PARK/ STOP LAMP SIDE DOOR JAMB SWITCH STARTER RELAY TAN/WHT WIRE UNDERHOOD FUSE/RELAY CENTER UNDERHOOD LAMP UNDERHOOD REEL LAMP VEHICLE SPEED SENSOR BUFFER W/ AUXILIARY HEAT ONLY W/ AUXILIARY HEAT, A/C W/ POWER PASSENGER SEAT W/O POWER PASSENGER SEAT WATER IN FUEL INDICATOR

A/C COMPRESSOR ENABLE RELAY A/C FUSE AUXILIARY POWER OUTLET BATT FUSE BLK WIRE CIG LTR FUSE 13 CIGARETTE LIGHTER CONVENIENCE CENTER CTSY FUSE 3 DATA LINK CONNECTOR (DLC) DAYTIME RUNNING LAMP (DRL) DIODE MODULE DRL FUSE 15 ECM-B FUSE FROM UNDERHOOD FUSE-RELAY CENTER (DIAGRAM 1 OF 4) FRONT DOME LAMP CENTER DOME LAMP FUEL PUMP RELAY HAZARD FUSE 5 HAZARD WARNING SWITCH HEADLAMP SWITCH HEATER AND A/C CONTROLLER MULTI- FUNCTION ALARM MODULE HORN FUSE HORN RELAY HTD MIR FUSE 2 I/P COMPARTMENT LAMP I/P FUSE BLOCK ILLUMINATED ENTRY MODULE LEFT FRONT POWER DOOR LOCK SWITCH LEFT POWER SEAT SWITCH LEFT STEPWELL LAMP REAR DOME LAMP LEFT SUN SHADE MIRROR LAMP LIGHTING FUSE NCA WIRE ORG/ WIRE OTHERS PARK LPS FUSE 9 PASSLOCK MODULE POWER ANTENNA ASSEMBLY POWER DOOR LOCK CONTROL MODULE POWER DOOR LOCK RELAY REMOTE CONTROL DOOR LOCK RECEIVER POWER OUTSIDE REAR VIEW MIRROR REMOTE CONTROL SWITCH PWR ACCY FUSE A PWR AUX FUSE 7 RADIO RADIO-B FUSE 19 RED WIRE RIGHT FRONT POWER DOOR LOCK SWITCH RIGHT REAR POWER DOOR LOCK SWITCH RIGHT STEPWELL LAMP SIDE STEPWELL LAMP RIGHT SUN SHADE MIRROR LAMP SECURITY/ STRG FUSE 21 STOP FUSE 1 TCC/STOP- LAMP SWITCH UNDERHOOD FUSE/RELAY CENTER UNDERHOOD LAMP UNDERHOOD REEL LAMP VEHICLE CONTROL MODULE (VCM) (GASOLINE) POWERTRAIN CONTROL MODULE (PCM) (DIESEL) W/ LAMP GROUP OPTION W/ POWER PASS SEAT (LEFT KICK PANEL) W/ UPFITTER PROVISIONS W/O KEYLESS ENTRY W/O UPFITTER PROVISSIONS

2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 PNK WIRE 21 22 PPL 24 25 26 PNK WIRE BLK WIRE BLK/WHT WIRE BLU WIRE BRN WIRE BRN/WHT WIRE DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE FUEL LVL INPUT FUEL PUMP RELAY FUEL PUMP, SENDER (IN FUEL TANK UNDER REAR OF VEHICLE) SIG OUT SIG IN FUEL TANK PRESSURE SENSOR (IN FUEL TANK) GAUGES FUSE 4 GRN WIRE GRY WIRE HOT AT ALL TIMES UNDERHOOD FUSE BLOCK AIR FUSE HOT IN OFF, RUN OR START HOT IN RUN OR START I/P FUSE BLOCK INPUT INSTRUMENT CLUSTER INSTRUMENT CLUSTER SYSTEM LT BLU/WHT WIRE LT GRN WIRE MALFUNCTION INDICATOR LAMP (MIL) "SERVICE ENGINE SOON" MANIFOLD ABSOLUTE PRESSURE SENSOR (TOP RIGHT SIDE OF ENGINE) MASS AIRFLOW SENSOR (PART OF AIR INTAKE DUCT, TOP FRONT OF ENGINE) ODOMETER SPEEDOMETER/ ORG/ WIRE ORG/BLK WIRE PARK/ NEUTRAL POSITION SWITCH PNK PNK WIRE PNK WIRE PPL PPL SECONDARY AIR INJECTION REACTION SOLENOID RED WIRE RED/BLK WIRE SECONDARY AIR INJECTION REACTION PUMP CLUTCH SECONDARY AIR INJECTION REACTION PUMP RELAY TAN WIRE TAN/BLK WIRE THROTTLE POSITION SENSOR (ON LEFT SIDE OF THROTTLE BODY) TRANS FUSE 20 UNDERHOOD FUSE BLOCK WHT WIRE YEL WIRE YEL/BLK WIRE

10 11 PNK WIRE 12 13 14 15 16 17 18 19 PPL 18 19 20 21 22 23 24 PNK WIRE BLK WIRE BRN/WHT WIRE CARGO/ PASSENGER CUTAWAY DK BLU WIRE DK GRN/WHT WIRE ENGINE COOLANT TEMPERATURE SENSOR (ON LEFT SIDE OF ENGINE) FUEL PUMP FUSE 12 FUEL PUMP RELAY FUEL PUMP/ SENDER ASSEMBLY (IN FUEL TANK) GRY WIRE HEATED OXYGEN SENSOR (BANK 1 SENSOR 1) (IN EXH PIPE, FRONT OF CAT CONVERTER) HEATED OXYGEN SENSOR (BANK 1 SENSOR 2) (IN EXH PIPE, REAR OF CAT CONVERTER) HEATED OXYGEN SENSOR (BANK 2 SENSOR 1) (IN EXH PIPE, FRONT OF CAT CONVERTER) HEATED OXYGEN SENSOR (BANK 2 SENSOR 2) (IN EXH PIPE, REAR OF CAT CONVERTER) HOT AT ALL TIMES KNOCK SENSOR (ON TOP LEFT REAR OF (ENGINE) LT BLU WIRE NCA WIRE ORG/ WIRE ORG/BLK WIRE PARK/NEUTRAL POSITION SWITCH (LEFT SIDE OF TRANSMISSION) PNK 1 2 3 4 5 WIRE PNK PNK 25 26 WIRE PNK PNK 6 7 WIRE PNK PNK WIRE PNK WIRE PNK/BLK WIRE PPL PPL PNK PNK WIRE PPL PPL PPL/WHT WIRE TAN WIRE TAN/WHT WIRE THROTTLE POSITION SENSOR (ON LEFT SIDE OF THROTTLE BODY) UNDER- HOOD FUSE BLOCK WHT WIRE YEL WIRE

13 14 PNK WIRE 15 16 17 18 19 20 21 22 PPL 22 23 PNK WIRE 5.3L W/ CA EMISSONS OTHER BLK WIRE BLK/WHT WIRE BRN WIRE BRN/WHT WIRE DK BLU WIRE DK BLU/WHT WIRE DK GRN/WHT WIRE ENGINE COOLANT TEMPERATURE SENSOR (AT LEFT FRONT OF ENGINE) ENGINE OIL LEVEL SWITCH (RIGHT SIDE OF OIL PAN) FUEL PUMP FUSE 12 FUEL PUMP RELAY FUEL PUMP, SENDER ASSEMBLY (ON FUEL TANK) GAS PASS/CARGO HEAVY DUTY (W/O HD TRUCK TRAILER WIRING) GRY WIRE HEATED OXYGEN SENSOR (BANK 1 SENSOR 1) (IN EXH PIPE, FRONT OF CAT CONVERTER) HEATED OXYGEN SENSOR (BANK 1 SENSOR 2) (IN EXH PIPE, BACK OF CAT CONVERTER) HEATED OXYGEN SENSOR (BANK 2 SENSOR 1) (IN EXH PIPE, FRONT OF CAT CONVERTER) HEATED OXYGEN SENSOR (BANK 2 SENSOR 2) (IN EXH PIPE, BACK OF CAT CONVERTER) HOT AT ALL TIMES KNOCK SENSOR 1 (BELOW FRONT OF INTAKE MANIFOLD) KNOCK SENSOR 2 (BELOW REAR OF INTAKE MANIFOLD) LT BLU WIRE NCA WIRE ORG/ WIRE ORG/BLK WIRE OTHER PARK/NEUTRAL POSITION SWITCH (LEFT SIDE OF TRANSMISSION) PNK 1 2 3 4 5 WIRE PNK PNK 28 29 WIRE PNK PNK 6 7 WIRE PNK PNK WIRE PNK WIRE PNK/BLK WIRE PPL PPL PNK PNK WIRE PPL PPL PPL/WHT WIRE TAN WIRE TAN/WHT WIRE UNDER- HOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT) WHT WIRE YEL WIRE

2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 PNK WIRE 21 22 PPL 24 25 26 PNK WIRE BLK WIRE BLK/WHT WIRE BLU WIRE BRN WIRE BRN/WHT WIRE DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE FUEL LVL INPUT FUEL PUMP RELAY FUEL PUMP, SENDER (IN FUEL TANK UNDER REAR OF VEHICLE) SIG OUT SIG IN FUEL TANK PRESSURE SENSOR (IN FUEL TANK) GAUGES FUSE 4 GRN WIRE GRY WIRE HOT AT ALL TIMES UNDERHOOD FUSE BLOCK AIR FUSE HOT IN OFF, RUN OR START HOT IN RUN OR START I/P FUSE BLOCK INPUT INSTRUMENT CLUSTER INSTRUMENT CLUSTER SYSTEM LT BLU/WHT WIRE LT GRN WIRE MALFUNCTION INDICATOR LAMP (MIL) "SERVICE ENGINE SOON" MANIFOLD ABSOLUTE PRESSURE SENSOR (TOP RIGHT SIDE OF ENGINE) MASS AIRFLOW SENSOR (PART OF AIR INTAKE DUCT, TOP FRONT OF ENGINE) ODOMETER SPEEDOMETER/ ORG/ WIRE ORG/BLK WIRE PARK/ NEUTRAL POSITION SWITCH PNK PNK WIRE PNK WIRE PPL PPL SECONDARY AIR INJECTION REACTION SOLENOID RED WIRE RED/BLK WIRE SECONDARY AIR INJECTION REACTION PUMP CLUTCH SECONDARY AIR INJECTION REACTION PUMP RELAY TAN WIRE TAN/BLK WIRE THROTTLE POSITION SENSOR (ON SIDE OF THROTTLE BODY) TRANS FUSE 20 UNDERHOOD FUSE BLOCK WHT WIRE YEL WIRE YEL/BLK WIRE

13 14 PNK WIRE 15 16 17 18 19 20 21 22 PPL 22 23 PNK WIRE 5.3L W/ CA EMISSONS OTHER BLK WIRE BLK/WHT WIRE BRN WIRE BRN/WHT WIRE DK BLU WIRE DK BLU/WHT WIRE DK GRN/WHT WIRE ENGINE COOLANT TEMPERATURE SENSOR (AT LEFT FRONT OF ENGINE) ENGINE OIL LEVEL SWITCH (RIGHT SIDE OF OIL PAN) FUEL PUMP FUSE 12 FUEL PUMP RELAY FUEL PUMP, SENDER ASSEMBLY (ON FUEL TANK) GAS PASS/CARGO HEAVY DUTY (W/O HD TRUCK TRAILER WIRING) GRY WIRE HEATED OXYGEN SENSOR (BANK 1 SENSOR 1) (IN EXH PIPE, FRONT OF CAT CONVERTER) HEATED OXYGEN SENSOR (BANK 1 SENSOR 2) (IN EXH PIPE, BACK OF CAT CONVERTER) HEATED OXYGEN SENSOR (BANK 2 SENSOR 1) (IN EXH PIPE, FRONT OF CAT CONVERTER) HEATED OXYGEN SENSOR (BANK 2 SENSOR 2) (IN EXH PIPE, BACK OF CAT CONVERTER) HOT AT ALL TIMES KNOCK SENSOR 1 (BELOW FRONT OF INTAKE MANIFOLD) KNOCK SENSOR 2 (BELOW REAR OF INTAKE MANIFOLD) LT BLU WIRE NCA WIRE ORG/ WIRE ORG/BLK WIRE OTHER PARK/NEUTRAL POSITION SWITCH (LEFT SIDE OF TRANSMISSION) PNK 1 2 3 4 5 WIRE PNK PNK 28 29 WIRE PNK PNK 6 7 WIRE PNK PNK WIRE PNK WIRE PNK/BLK WIRE PPL PPL PNK PNK WIRE PPL PPL PPL/WHT WIRE TAN WIRE TAN/WHT WIRE UNDER- HOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT) WHT WIRE YEL WIRE

2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 PNK WIRE 21 22 PPL 24 25 26 PNK WIRE BLK WIRE BLK/WHT WIRE BLU WIRE BRN WIRE BRN/WHT WIRE DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE FUEL LVL INPUT FUEL PUMP RELAY FUEL PUMP, SENDER (IN FUEL TANK UNDER REAR OF VEHICLE) SIG OUT SIG IN FUEL TANK PRESSURE SENSOR (IN FUEL TANK) GAUGES FUSE 4 GRN WIRE GRY WIRE HOT AT ALL TIMES UNDERHOOD FUSE BLOCK AIR FUSE HOT IN OFF, RUN OR START HOT IN RUN OR START I/P FUSE BLOCK INPUT INSTRUMENT CLUSTER INSTRUMENT CLUSTER SYSTEM LT BLU/WHT WIRE LT GRN WIRE MALFUNCTION INDICATOR LAMP (MIL) "SERVICE ENGINE SOON" MANIFOLD ABSOLUTE PRESSURE SENSOR (TOP RIGHT SIDE OF ENGINE) MASS AIRFLOW SENSOR (PART OF AIR INTAKE DUCT, TOP FRONT OF ENGINE) ODOMETER SPEEDOMETER/ ORG/ WIRE ORG/BLK WIRE PARK/ NEUTRAL POSITION SWITCH PNK PNK WIRE PNK WIRE PPL PPL SECONDARY AIR INJECTION REACTION SOLENOID RED WIRE RED/BLK WIRE SECONDARY AIR INJECTION REACTION PUMP CLUTCH SECONDARY AIR INJECTION REACTION PUMP RELAY TAN WIRE TAN/BLK WIRE THROTTLE POSITION SENSOR (ON SIDE OF THROTTLE BODY) TRANS FUSE 20 UNDERHOOD FUSE BLOCK WHT WIRE YEL WIRE YEL/BLK WIRE