Chevrolet Chevy Express G2500 (1996-2012) dk blu Wiring diagrams

4.8L 6.0L 5.3L AIR BAG FUSE 34 AUTOMATIC TRANSMISSION BLK WIRE BODY CONTROL MODULE (BCM) BREAKOUT FOR REAR FUSE BLOCK) BRK SW FUSE 32 BRN WIRE CONNECTOR DK BLU WIRE DOME FLUORESCENT WORK LAMPS FUSE 2 ECM IGN FUSE 48 ELECTRONIC BRAKE CONTROL MODULE (EBCM) ENGINE CONTROL MODULE (ECM) ENGINE CONTROL MODULE (EDM) EXCEPT 4.3L 4.3L FLUORESCENT WORK LAMP RELAY FROM MEGA FUSE 77 (DIAGRAM 2 OF 4) FSCM IGN FUSE 11 FUEL PUMP FLOW CONTROL MODULE FUEL PUMP FLOW CONTROL MODULE (5.3L) HARNESS, 15 CM FROM REAR FUSE BLOCK) HARNESS, 7 CM FROM HARNESS, 8 CM FROM REAR FUSE BLOCK) IGNITION SWITCH INFLATABLE RESTRAINT SENSING, DIAGNOSTIC MODULE (SDM) INSTRUMENT PANEL CLUSTER (IPC) IP CLSTR FUSE 30 KEY-IN SWITCH LEFT FRONT ACCESS PANEL RELAY 5 LEFT REAR ACCESS PANEL RELAY 1 LT BLU WIRE OFF ORG/ WIRE PANEL ACTUATOR FUSE 3 PNK WIRE REAR FUSE BLOCK (ON LEFT "B" PILLAR) RED WIRE RED/ WHT WIRE RED/BLK WIRE RIGHT ACCESS PANEL RELAY 6 RUN WIRE RUN/CRNK RELAY 69 STEERING WHEEL SPEED/ POSITION SENSOR STOP LAMP SWITCH STR/WHL SNSR FUSE 36 (W/ ACTIVE CONTROL BRAKE) TCM IGN FUSE 47 THEFT DETERRENT MODULE (TDM) TO BODY FUSE BLOCK (DIAGRAM 4 OF 4) TRANS FUSE 51 TRANSMISSION CONTROL MODULE (TCM) UNDERHOOD FUSE BLOCK (ON LEFT SIDE OF ENGINE COMPT) W/ CARGO W/ POWER BRAKE W/ ACTIVE BRAKE CONTROL W/O RV UPFITTER, MANUAL W/ MANUAL SUPPRESSION SUPPRESSION WHT RED/ WIRE WHT WIRE YEL WIRE

68 47 28 4 SENS SIG LOW REF CLUTCH CTRL SPEED SIG BLK WIRE BRN/WHT WIRE DK BLU WIRE ENGINE CONTROL MODULE (ECM) (LEFT SIDE OF ENGINE COMPT) ENGINE COOLANT TEMPERATURE (ECT) SENSOR (TOP OF ENGINE, NEAR THERMOSTAT HOUSING) ENGINE COOLING FAN (BEHIND RADIATOR) FAN CLTCH (D) FUSE 58 FAN CLTCH (D) RELAY 75 GRY WIRE HOT W/ PWR/TRN RELAY ENERGIZED LOW REF TAN WIRE UNDERHOOD FUSE BLOCK (ON LEFT SIDE OF ENGINE COMPT) WHT WIRE WHT/BLK WIRE YEL WIRE

1 18 25 COURTESY LP CTRL COURTESY LP CTRL DEFEAT SW SIG 149 (OR 690) 16 17 DATA BUS+ DATA BUS- 20 CM FROM RIGHT SUNSHADE BREAKOUT) 2500 2501 COMPUTER DATA LINES SYSTEM BLK WIRE BLK/WHT WIRE BODY CONTROL MODULE (BCM) (BEHIND LOWER RIGHT SIDE OF DASH) BODY FUSE BLOCK (UNDER LEFT FRONT SEAT) CARGO CARGO DOOR LATCH ASSEMBLY (IN RIGHT REAR CARGO DOOR) CARGO/PASSENGER COURTESY LP CTRL CTSY LP CTRL DK BLU WIRE DK BLU/WHT WIRE DOME DOME READING FL DOME RLY CTRL FRONT DOME/ READING LAMPS GRY WIRE GRY/BLK WIRE HEADLAMP, PANEL DIMMER SWITCH HOT AT ALL TIMES LEFT SUNSHADE LIFTGATE AJAR SW SIG LOWER RIGHT "B" MIDDLE DOME/ READING LAMPS ORG/ WIRE PASSENGER PASSENGER/CARGO W/O RV UPFITTER PNK/BLK WIRE PPL PROVISIONAL READING REAR DOME/ READING LAMPS (PASSENGER) DOME LAMP (CARGO) RED WIRE RIGHT SUNSHADE (ON UPPER RIGHT OF HEADLINER) SPLICE BLOCK TAN WIRE TAN/BLK WIRE TAN/WHT WIRE THE ENGINE BLOCK) (4.3L: RIGHT REAR OF ENGINE) UNDERHOOD FUSE BLOCK (ON LEFT SIDE OF ENGINE COMPT) UNDERHOOD LAMP UPFTR AUX 1 UPFTR CTSY UPFTR CTSY LAMP W/ COMMERCIAL TRADESMAN SALES PACKAGE, CARGO LAMP W/ CUTAWAY W/ CUTAWAY, CARGO W/O RV UPFITTER W/ LEFT, RIGHT SUNSHADE MIRROR W/ RV UPFITTER W/ RV UPFITTER, LEFT, RIGHT SUNSHADE MIRROR W/O RV UPFITTER W/O RV W/ RV UPFITTER UPFITTER WHT WIRE YEL/BLK WIRE

19 16 15 ALARM ENABLE SIG HAZARD SW SIG HAZARD SW SIG 2 1 3 5 B+ B+ B+ RF TURN SIG LP CTRL 2 1 RR TURN SIG LP CTRL LR TURN SIG LP CTRL 5 6 4 STOP LAMPS CTRL BRAKE SIG LF TURN SIG LP CTRL AUX PRK LAMP FUSE 3 BCM 6 FUSE 72 BLK WIRE BLK/WHT WIRE BLU WIRE BODY CONTROL MODULE (BCM) (BEHIND LOWER RIGHT SIDE OF DASH) BODY FUSE BLOCK BRN WIRE CARGO/ PASSENGER CENTER HIGH MOUNTED STOP LAMP (CHMSL) CHMSL CTRL CUTAWAY DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DRIVER OUTSIDE REARVIEW FRT PRK LAMP FUSE 4 FUSE 26 FUSE 7 GROUND DISTRIBUTION SYSTEM HAZARD SWITCH HOT AT ALL TIMES UNDER- HOOD FUSE BLOCK (ON LEFT SIDE OF ENGINE COMPT) LEFT LEFT TAIL/STOP, TURN SIGNAL LAMP LICENSE LAMP LT BLU WIRE LT BLU/WHT WIRE LT REAR PARK LAMP FUSE 8 MEGA FUSE MIRROR (IN DRIVER DOOR) MIRROR (IN RIGHT FRONT PASSENGER DOOR) NCA WIRE PARK LAMP CTRL PARK LAMPS SIG PASSENGER OUTSIDE REARVIEW PRK LAMP RELAY PROVISIONAL RED WIRE RED/WHT WIRE RIGHT RIGHT TAIL/STOP, TURN SIGNAL LAMP RT REAR PRK LAMP FUSE 7 SPLICE SUPPLEMENTAL RESTRAINTS SYSTEM TAN WIRE TRAILER TOW CIRCUIT TRLR PRK LAMP FUSE 5 TURN SIGNAL/ MULTI-FUNCTION SWITCH UPFTR PARK LAMP FUSE 6 W/ AMBULANCE, RECREATIONAL VEHICLE SALES PACKAGE W/ FOLDING MIRRORS RADIO BREAKOUT) W/O REAR WINDOW DEFOGGER WHT WIRE YEL WIRE

4 SPEED A/T 6 SPEED A/T AUTOMATIC TRANSMISSION AUX STOP LAMP FUSE 68 BLK WIRE BLK/WHT WIRE BREAKOUT TOWARDS INSTRUMENT PANEL CLUSTER) BREAKOUT) BRK SW FUSE 13 BRN WIRE COMPUTER DATA LINES SYSTEM CONTROL SOLENOID VALVE ASSEMBLY CUTAWAY DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE ENGINE CONTROL MODULE (ECM) (LEFT SIDE OF ENGINE COMPT) EXCEPT 4.3L 4.3L HEAD PARK AUTO HEADLAMP, PANEL DIMMER HOT AT ALL TIMES HOT W/ RUN/CRANK RELAY 15 ENERGIZED IGN INSTRUMENT PANEL CLUSTER (IPC) IPC FUSE 10 LEFT FRONT MARKER LAMP LEFT PARK/ TURN SIGNAL LAMP LEFT TURN IND LOGIC LT BLU WIRE LT BLU/WHT WIRE OFF PNK WIRE PROVISIONAL RIGHT RIGHT PARK/ FRONT TURN MARKER SIGNAL LAMP LAMP RIGHT TURN IND SER DATA STOP LAMP SWITCH (BEHIND LEFT SIDE OF DASH, ABOVE BRAKE PEDAL) STOP LAMPS PCB RELAY SWITCH TRANSMISSION CONTROL MODULE (TCM) UNDERHOOD FUSE BLOCK UNDERHOOD FUSE BLOCK (ON LEFT SIDE OF ENGINE COMPT) WHT WIRE YEL WIRE

10 8 9 LO SPD GMLAN HI SPD GMLAN+ BACKUP LAMPS CIRCUIT BLK WIRE BODY CONTROL MODULE (BCM) (BEHIND LOWER RIGHT SIDE OF DASH) BODY FUSE BLOCK (UNDER LEFT FRONT SEAT) BRN WIRE COMPUTER DATA LINES SYSTEM DK BLU WIRE DK GRN WIRE EXCEPT 5.3L W/ BACKUP ALARM HI SPD GMLAN HOT AT ALL TIMES HOT W/ PRK LAMP LT GRN WIRE LT STOP/ TRN TRLR FUSE 21 LT TRAILER TURN SIGNAL LAMP ORG/ WIRE RED WIRE RED/BLK WIRE RT STOP/ TRN TRLR FUSE 3 RT TRAILER TURN SIGNAL LAMP TAN WIRE TAN/BLK WIRE TRAILER CONNECTOR TRAILER PROVISION (BLUNT CUT) TRLR LT STOP/TRN PCB RELAY TRLR PRK LAMP FUSE 13 TRLR RT STOP/TRN PCB RELAY TRLR WRG FUSE 11 TRLR WRG FUSE 42 UNDERHOOD FUSE BLOCK (ON LEFT SIDE OF ENGINE COMPT) WHT WIRE WHT(OR BLK) WIRE YEL WIRE

A/C REFRIGERANT PRESSURE SENSOR ACC SER DATA IGN VOLT BATT POS VOLT PNK WIRE ACCELERATOR PEDAL POSITION (APP) SENSOR (UNDER LEFT SIDE OF DASH) ANTI-LOCK BRAKES SYSTEM BANK 1 SENSOR 2 BANK 2 SENSOR 2 BLK WIRE BLK/WHT WIRE BREAKOUT) BRK SW FUSE 32 BRN WIRE COMPUTER DATA LINES SYSTEM DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE ECM BATT FUSE 54 ECM IGN FUSE 48 ENGINE CONTROL MODULE (ECM) (LEFT SIDE OF ENGINE COMPT) FUEL PUMP, SENDER ASSEMBLY (ON FUEL TANK) GMLAN DATA- GMLAN DATA+ APP SENS 1 SIG LOW REF LOW REF APP SENS 2 SIG GRY WIRE GRY/WHT WIRE HOT AT ALL TIMES HOT W/ RUN/ CRNK RELAY 69 ENERGIZED IAT SENS SIG LOW REF LT BLU WIRE LT BLU/WHT WIRE MAF SENS SIG NCA WIRE ORG/BLK WIRE ORG/WHT WIRE PNK (OR PNK) 5 6 7 WIRE PNK IGN VOLT WIRE PNK PPL 2 3 4 WIRE PNK WIRE PPL PPL FUEL LEVEL SENS PPL LOW REF PRESS SENS SIG PPL/WHT WIRE PRESS SENS SIG LOW REF PWR/TRN RLY CTRL RED/WHT WIRE RELAY CTRL START RLY CTRL STARTING/CHARGING SYSTEM STOP LAMP SWITCH (BEHIND LEFT SIDE OF DASH, ABOVE BRAKE PEDAL) TAN WIRE TAN/BLK WIRE TAN/WHT WIRE TCC BRAKE SIG TRANSMISSIONS SYSTEM UNDERHOOD FUSE BLOCK (ON LEFT SIDE OF ENGINE COMPT) VSS WHT/BLK WIRE YEL WIRE YEL/BLK WIRE

1745 1746 844 877 2705 INJ 2 CTRL INJ 3 CTRL INJ 4 CTRL INJ 7 CTRL 2199 469 LOW REF LOW REF 23 1174 STARTING/CHARGING SYSTEM CEN FIELD SIG OIL SW SIG LOW REF LOW REF 486 6265 485 6266 PPL TP SENS 2 SIG CMP SENS SIG TP SENS 1 SIG LOW REF 6271 6272 CKP SENS SIG LOW REF BANK 1 SENSOR 1 (IN EXHAUST PIPE, IN FRONT OF CATALYTIC CONVERTER) BANK 2 SENSOR 1 (IN EXHAUST PIPE, IN FRONT OF CATALYTIC CONVERTER) BLK WIRE BLK/WHT WIRE BRN WIRE DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/WHT WIRE ENGINE CONTROL MODULE (ECM) (LEFT SIDE OF ENGINE COMPT) ENGINE COOLANT TEMPERATURE (ECT) SENSOR (AT LEFT FRONT OF ENGINE) ENGINE OIL LEVEL (EOL) SWITCH (ON RIGHT SIDE OF OIL PAN) GEN ON SIG GRY WIRE GRY/BLK WIRE GRY/WHT WIRE HEATED OXYGEN INJ 1 CTRL ECT SENS SIG LOW REF KS 1 SIG KS 1 SIG KS 2 SIG KS 2 SIG LT BLU WIRE LT BLU/BLK WIRE LT GRN WIRE LT GRN/BLK WIRE MAP SENS SIG PPL ORG/ WIRE ORG/BLK WIRE PNK 5 6 WIRE PNK 7 8 9 10 11 12 13 14 WIRE PNK WIRE PNK/BLK WIRE PPL PPL INTAKE SOL INJ 8 CTRL INJ 5 CTRL INJ 6 CTRL PPL/WHT WIRE PRE SENS SIG SOL CTRL STARTING/ CHARGING SYSTEM TAC MTR CTRL 2 TAC MTR CTRL 1 TAN WIRE TAN/WHT WIRE WHT GRY/ WIRE WHT WIRE WHT/BLK WIRE YEL WIRE YEL/BLK WIRE

A/C REFRIGERANT PRESSURE SENSOR ACC SER DATA IGN VOLT BATT POS VOLT PNK WIRE ACCELERATOR PEDAL POSITION (APP) SENSOR (UNDER LEFT SIDE OF DASH) ANTI-LOCK BRAKES SYSTEM BANK 1 SENSOR 2 BANK 2 SENSOR 2 BLK WIRE BLK/WHT WIRE BREAKOUT) BRK SW FUSE 32 BRN WIRE COMPUTER DATA LINES SYSTEM DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE ECM BATT FUSE 54 ECM IGN FUSE 48 ENGINE CONTROL MODULE (ECM) (LEFT SIDE OF ENGINE COMPT) FUEL PUMP, SENDER ASSEMBLY (ON FUEL TANK) GMLAN DATA- GMLAN DATA+ APP SENS 1 SIG LOW REF LOW REF APP SENS 2 SIG GRY WIRE GRY/WHT WIRE HOT AT ALL TIMES HOT W/ RUN/ CRNK RELAY 69 ENERGIZED IAT SENS SIG LOW REF LT BLU WIRE LT BLU/WHT WIRE MAF SENS SIG NCA WIRE ORG/BLK WIRE ORG/WHT WIRE PNK (OR PNK) 5 6 7 WIRE PNK IGN VOLT WIRE PNK PPL 2 3 4 WIRE PNK WIRE PPL PPL FUEL LEVEL SENS PPL LOW REF PRESS SENS SIG PPL/WHT WIRE PRESS SENS SIG LOW REF PWR/TRN RLY CTRL RED/WHT WIRE RELAY CTRL START RLY CTRL STARTING/CHARGING SYSTEM STOP LAMP SWITCH (BEHIND LEFT SIDE OF DASH, ABOVE BRAKE PEDAL) TAN WIRE TAN/BLK WIRE TAN/WHT WIRE TCC BRAKE SIG TRANSMISSIONS SYSTEM UNDERHOOD FUSE BLOCK (ON LEFT SIDE OF ENGINE COMPT) VSS WHT/BLK WIRE YEL WIRE YEL/BLK WIRE

1745 1746 844 877 2705 INJ 2 CTRL INJ 3 CTRL INJ 4 CTRL INJ 7 CTRL 2199 469 LOW REF LOW REF 23 1174 STARTING/CHARGING SYSTEM CEN FIELD SIG OIL SW SIG LOW REF LOW REF 486 6265 485 6266 PPL TP SENS 2 SIG CMP SENS SIG TP SENS 1 SIG LOW REF 6271 6272 CKP SENS SIG LOW REF BANK 1 SENSOR 1 (IN EXHAUST PIPE, IN FRONT OF CATALYTIC CONVERTER) BANK 2 SENSOR 1 (IN EXHAUST PIPE, IN FRONT OF CATALYTIC CONVERTER) BLK WIRE BLK/WHT WIRE BRN WIRE DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/WHT WIRE ENGINE CONTROL MODULE (ECM) (LEFT SIDE OF ENGINE COMPT) ENGINE COOLANT TEMPERATURE (ECT) SENSOR (AT LEFT FRONT OF ENGINE) ENGINE OIL LEVEL (EOL) SWITCH (ON RIGHT SIDE OF OIL PAN) GEN ON SIG GRY WIRE GRY/BLK WIRE GRY/WHT WIRE HEATED OXYGEN INJ 1 CTRL ECT SENS SIG LOW REF KS 1 SIG KS 1 SIG KS 2 SIG KS 2 SIG LT BLU WIRE LT BLU/BLK WIRE LT GRN WIRE LT GRN/BLK WIRE MAP SENS SIG PPL ORG/ WIRE ORG/BLK WIRE PNK 5 6 WIRE PNK 7 8 9 10 11 12 13 14 WIRE PNK WIRE PNK/BLK WIRE PPL PPL INTAKE SOL INJ 8 CTRL INJ 5 CTRL INJ 6 CTRL PPL/WHT WIRE PRE SENS SIG SOL CTRL STARTING/ CHARGING SYSTEM TAC MTR CTRL 2 TAC MTR CTRL 1 TAN WIRE TAN/WHT WIRE WHT GRY/ WIRE WHT WIRE WHT/BLK WIRE YEL WIRE YEL/BLK WIRE