Chevrolet Chevy Express G2500 (1996-2012) blk Wiring diagrams

16 17 19 DATA BUS (-)) DATA BUS (+) DATA ENABLE 19 26 2501 2500 DATA BUS (-) DATA BUS (+) 2 12 DATA BUS (+) DATA BUS (-) DATA BUS (+) DATA BUS (-) 25 18 2500 2501 DATA BUS (+) DATA BUS (-) 4.8L 4.3L, 6.0L, 5.3L 4.8L 6.0L 5.3L 6.6L 6.6L 9 8 10 DATA BUS (-) DATA BUS (+) SERIAL DATA ACC WAKE UP SERIAL DATA 11 15 19 7 6 38 37 ACC WAKE UP SERIAL DATA PNK WIRE ACC WAKE-UP SERIAL DATA AUTOMATIC TRANSMISSION (6 SPEED A/T) BLK WIRE BODY CONTROL MODULE (BCM) (BEHIND LOWER CONTROL SOLENOID VALUE ASSEMBLY COOLANT HEATER (6.6L, W/ FUEL FIRED AUXILIARY HEATER) DATA BUS - DATA BUS - DATA BUS - DATA BUS+ DATA BUS+ DATA BUS- DATA BUS- DATA COMM ENABLE DATA ENABLE DATA BUS (+) DATA BUS (-) DATA BUS (-) DATA BUS (+) DK BLU WIRE DK GRN WIRE EXCEPT 5.3L EXCEPT AUXILIARY 5.3L 5.3L HEATER IGN DATA BUS (+) DATA BUS (-) LT BLU WIRE TAN WIRE TAN/BLK WIRE TRANSMISSION CONTROL MODULE (TCM) (4 SPEED A/T) VEHICLE COMMUNICATION INTERFACE MODULE (VCM) (BELOW STEERING COLUMN) W/ ACTIVE BRAKE CONTROL W/ FUEL FIRED AUXILIARY HEATER W/ FUEL W/O FUEL FIRED FIRED AUXILIARY HEATER W/ VECHILE COMMUNICATION SYSTEM W/O ACTIVE BRAKE CONTROL W/O FUEL FIRED AUXILIARY HEATER W/O VECHILE COMMUNICATION SYSTEM

11 12 LPS DIMMER SW SIG DIMMING VOLT REF 2 15 HEAD 8 17 PARK LAMPS SIG HEADLAMPS OFF SIG AUXILIARY BLOWER MOTOR SWITCH BATTERY POS VOLT BCM 3 FUSE 26 BLK WIRE BLK/WHT WIRE BODY CONTROL MODULE (BCM) (BEHIND LOWER RIGHT SIDE OF DASH) BODY FUSE BLOCK (UNDER LEFT FRONT SEAT) BRN WIRE BRN/WHT WIRE CONNECTOR CONTROL DIMMING CTRL DK GRN WIRE DRIVER DOOR LOCK SWITCH DRIVER INFORMATION CENTER (DIC) SWITCH DRIVER WINDOW SWITCH FRONT AUXILIARY HVAC CONTROL ASSEMBLY HEADLAMP, PANEL DIMMER SWITCH HOT AT ALL TIMES HVAC CONTROL ASSEMBLY IN FRONT HEADLINER HARNESS, 21 CM INFLATABLE RESTRAINT I/P MODULE DISABLE SWITCH (W/ MANUAL SUPPRESSION) LEFT STEERING WHEEL CONTROL SWITCH LPS DIMMING CTRL LT BLU WIRE OFF AUTO PARK ORG/ WIRE ORG/WHT WIRE PASSENGER DOOR LOCK (W/ POWER SWITCH MIRRORS, POWER WINDOWS) PASSENGER WINDOW SWITCH PNK CONTROL PNK WIRE PNK PNK W/O REDUNDANT RADIO STEERING WHEEL WIRE PNK WIRE RADIO RED WIRE RED/WHT WIRE RIGHT STEERING WHEEL CONTROL SWITCH STR WHL SNSR FUSE 17 TRACTION CONTROL SWITCH (TCS) (W/ ACTIVE BRAKE CONTROL) UNDERHOOD FUSE BLOCK (ON LEFT SIDE OF ENGINE COMPT) W/ AUTOMATIC CRUISE CONTROL, REDUNDANT RADIO STEERING WHEEL CONTROL W/ AUTOMATIC ELECTRONIC CRUISE CONTROL W/ AUXILIARY HEATER W/O REAR A/C W/ ELECTRIC SIDE DOOR LOCK W/ ELECTRIC TOW/HAUL SWITCH SIDE DOOR LOCK W/ POWER OPERATED WINDOW W/ REAR W/O REAR AUXILIARY AUXILIARY CONTROLS CONTROLS W/ REDUNDANT RADIO STEERING WHEEL W/ RV UPFITTER W/O RADIO PROVISIONS W/O RV UPFITTER WHT WIRE YEL WIRE

1 18 25 COURTESY LP CTRL COURTESY LP CTRL DEFEAT SW SIG 149 (OR 690) 20 CM FROM RIGHT SUNSHADE BREAKOUT) BLK WIRE BLK/WHT WIRE BLU WIRE BODY CONTROL MODULE (BCM) (BEHIND LOWER RIGHT SIDE OF DASH) BODY FUSE BLOCK (UNDER LEFT FRONT SEAT) CARGO CARGO DOOR LATCH ASSEMBLY (IN RIGHT REAR CARGO DOOR) CARGO/PASSENGER COURTESY LP CTRL CTSY LP CTRL DK BLU WIRE DK BLU/WHT WIRE DOME DOME READING FL DOME RLY CTRL FRONT DOME/ READING LAMPS GRY WIRE GRY/BLK WIRE HEADLAMP, PANEL DIMMER SWITCH HOT AT ALL TIMES LEFT SUNSHADE LIFTGATE AJAR SW SIG MIDDLE DOME/ READING LAMPS ORG/ WIRE PASSENGER PASSENGER/CARGO W/O RV UPFITTER PNK/BLK WIRE PPL PROVISIONAL READING REAR DOME/ READING LAMPS (PASSENGER) DOME LAMP (CARGO) RED WIRE RIGHT SUNSHADE (ON UPPER RIGHT OF HEADLINER) TAN/WHT WIRE THE ENGINE BLOCK) UNDERHOOD FUSE BLOCK (ON LEFT SIDE OF ENGINE COMPT) UNDERHOOD LAMP UPFTR AUX 1 FUSE 36 (W/ CUTAWAY, AMBULANCE, RV UPFITTERS) UPFTR CTSY LAMPS FUSE 4 UPFTR CTSY LAMPS PCB RELAY (W/ AMBULANCE, RV UPFITTER) W/ COMMERCIAL TRADESMAN SALES PACKAGE, CARGO LAMP W/ CUTAWAY W/ CUTAWAY, CARGO W/O RV UPFITTER W/ LEFT, RIGHT SUNSHADE MIRROR W/ RV UPFITTER W/ RV UPFITTER, LEFT, RIGHT SUNSHADE MIRROR W/O RV UPFITTER W/O RV W/ RV UPFITTER UPFITTER WHT WIRE YEL/BLK WIRE

12 CM FROM LEFT FRONT DOME FLUORESCENT WORK LAMP CONNECTOR) BLK WIRE BLU WIRE DK BLU/WHT WIRE DOME FLUORESCENT WORK LAMPS DRIVER DOOR LATCH ASSEMBLY (AT REAR OF DRIVER DOOR) FRONT CARGO FLUORESCENT WORK LAMP FUSE 2 GRY WIRE GRY/BLK WIRE LEFT FRONT ACCESS PANEL FLUORESCENT WORK LAMP LEFT REAR ACCESS PANEL FLUORESCENT WORK LAMP LEFT REAR DOOR JAMB SWITCH (W/ LEFT REAR HINGED DOOR) (AT LEFT "B" PILLAR) ORG/ WIRE PACKAGE, CARGO LAMP) DOME FLUORESCENT WORK LAMPS RELAY PASSENGER DOOR LATCH ASSEMBLY (AT REAR OF FRONT PASSENGER DOOR) REAR CARGO FLUORESCENT WORK LAMP REAR FUSE BLOCK (ON LEFT "B" PILLAR) RED WIRE RIGHT ACCESS PANEL FLUORESCENT WORK LAMP RIGHT REAR DOOR JAMB SWITCH (CARGO/ PASSENGER) (AT RIGHT "B" PILLAR) TAN/WHT WIRE WHT WIRE YEL WIRE YEL/BLK WIRE

5.3L 5.3L EXCEPT 5.3L A/C REFRIGERANT PRESSURE SENSOR ACC SER DATA IGN VOLT BATT POS VOLT PNK WIRE ACCELERATOR PEDAL POSITION (APP) SENSOR (UNDER LEFT SIDE OF DASH) ANTI-LOCK BRAKES SYSTEM BANK 1 SENSOR 2 BANK 2 SENSOR 2 BLK LT BLU/ WIRE BLK WIRE BLK/WHT WIRE BRAKE PEDAL POSITION (BPP) SENSOR (TOP OF BRAKE PEDAL ASSEMBLY) BREAKOUT) BRK SENS SPLY BRK SW FUSE 13 BRN WIRE COMPUTER DATA LINES SYSTEM CUTAWAY DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE ECM BATT FUSE 19 ECM IGN/ GLOW PLUG MDL IGN FUSE 30 ENGINE CONTROL MODULE (ECM) (LEFT SIDE OF ENGINE COMPT) ENGINE COOLANT RADIATOR TEMPERATURE SENSORS FUEL PUMP, SENDER ASSEMBLY (ON FUEL TANK) FUEL TANK PRESSURE (FTP) SENSOR (ON FUEL TANK) GRY WIRE GRY/WHT WIRE HOT AT ALL TIMES HOT W/ RUN/ CRNK RELAY 15 ENERGIZED IAT SENS SIG LOW REF ECT SENS SIG LOW REF LOW REF PRESS SENS SIG PPL LT BLU WIRE LT BLU/ BLK WIRE LT BLU/BLK WIRE LT BLU/WHT WIRE LT GRN WIRE MAF SENS SIG LOW REF ORG/BLK WIRE ORG/WHT WIRE PNK (OR PNK) 5 6 7 WIRE PNK IGN VOLT WIRE PNK PPL 2 3 4 WIRE PNK WIRE PPL PPL FUEL LEVEL SENS PPL/WHT WIRE PRESS SENS SIG LOW REF PWR/TRN RLY CTRL RED/WHT WIRE RELAY CTRL START RLY CTRL STARTING/ CHARGING SYSTEM STOP LAMP SWITCH (BEHIND LEFT SIDE OF DASH, ABOVE BRAKE PEDAL) TAN WIRE TAN/BLK WIRE TAN/WHT WIRE TCC BRAKE SIG TOWARDS INSTRUMENT PANEL CLUSTER) TRANSMISSIONS SYSTEM UNDERHOOD FUSE BLOCK (ON LEFT SIDE OF ENGINE COMPT) VSS WHT WIRE WHT/BLK WIRE YEL WIRE YEL/BLK WIRE

4.8L/6.0L 5.3L BLK WIRE BLK/WHT WIRE BRN WIRE BRN/WHT WIRE CLUTCH RLY CTRL CNSTR VENT SOL FUSE 56 COMPT) COMPUTER DATA LINES SYSTEM DK GRN WIRE DK GRN/WHT WIRE ECM PWR/TRN FUSE 78 ENGINE CONTROL MODULE (ECM) (LEFT SIDE OF ENGINE COMPT) EVAP SOL CTRL EVAPORATIVE EMISSION (EVAP) CANISTER VENT SOLENOID (NEAR FRONT OF FUEL TANK) EVEN IGN/ INJ FUSE 79 FUEL PUMP RELAY 38 (4.8L/6.0L) GAS FUEL PUMP FUSE 24 GRY WIRE GRY/WHT WIRE HOT AT ALL TIMES IC 1 CTRL IC 2 CTRL IC 3 CTRL IC 4 CTRL IC 5 CTRL IC 6 CTRL IC 7 CTRL IC 8 CTRL IGN INSTRUMENT PANEL CLUSTER (IPC) LOGIC LOW ENGINE OIL PRESSURE IND LOW REF LT BLU WIRE LT BLU/WHT WIRE MAF/ CNSTR VENT FUSE 64 MALFUNCTION INDICATOR LAMP MIL CTRL ODD IGN/INJ FUSE 65 ORG/ WIRE ORG/BLK WIRE ORG/WHT WIRE PNK 5 6 7 (OR PNK) WIRE PNK PNK PNK PNK PNK PNK PNK PNK PNK 4 5 6 7 8 9 10 11 12 WIRE PNK PNK PPL 15 16 17 18 19 20 21 22 23 24 WIRE PNK PPL 2 3 4 WIRE PNK WIRE PPL PPL/WHT WIRE PWR/TRN RELAY 49 RED/WHT WIRE SNSR 1 (PRE)/CLS FUSE 77 SNSR 2 (POST) FUSE 62 TOS SIG TRANSMISSIONS SYSTEM AIR CONDITIONING SYSTEM UNDERHOOD FUSE BLOCK (ON LEFT SIDE OF ENGINE WHT WIRE YEL WIRE

& IGNITION COIL/MODULE 7) 1 2 3 PNK WIRE 1 2 3 PPL BLK WIRE BRN WIRE COMPUTER DATA COMPUTER DATA LINES SYSTEM DK GRN WIRE DK GRN/WHT WIRE FCSM BATT FUSE 36 FSCM IGN FUSE 6 GMLAN DATA GRY WIRE HOT AT ALL TIMES HOT W/ RUN/ CRNK RELAY 15 ENERGIZED IGN VOLT IGNITION COIL/MODULE 1 IGNITION COIL/MODULE 3 IGNITION COIL/MODULE 5 LINES SYSTEM LOW REF LT BLU WIRE LT BLU/WHT WIRE NCA WIRE ORG/ WIRE ORG/WHT WIRE PNK PNK PNK PNK PNK PNK PNK PNK PNK 4 5 6 7 8 9 10 11 12 WIRE PNK PNK PPL 15 16 17 18 19 20 21 22 23 24 WIRE PNK WIRE PPL PPL/WHT WIRE PUMP CTRL RED WIRE RED/WHT WIRE RELAY CTRL SENS SIG SERIAL DATA SPARK PLUG TAN WIRE TAN/BLK WIRE UNDERHOOD FUSE BLOCK (ON LEFT SIDE OF ENGINE COMPT)

& IGNITION COIL/MODULE 8) 1 2 3 PPL BLK WIRE BRN WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/WHT WIRE ENGINE OIL PRESSURE (EOP) SENSOR (ON TOP REAR OF ENGINE) FUEL INJECTOR 1 FUEL INJECTOR 2 FUEL INJECTOR 3 FUEL INJECTOR 4 FUEL INJECTOR 5 FUEL INJECTOR 6 FUEL INJECTOR 7 FUEL INJECTOR 8 FUEL RAIL PRESSURE (FPR) SENSOR GRY WIRE IGNITION COIL/MODULE 2) IGNITION COIL/MODULE 4 IGNITION COIL/MODULE 6 LT BLU WIRE LT BLU/BLK WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/BLK WIRE NCA WIRE ORG/BLK WIRE ORG/WHT WIRE PNK 5 6 WIRE PNK 7 8 9 10 11 12 13 14 WIRE PNK PNK PNK PNK PNK PNK PNK PNK PNK 4 5 6 7 8 9 10 11 12 WIRE PNK WIRE PNK/BLK WIRE PPL PPL/WHT WIRE RED WIRE SPARK PLUG TAN WIRE TAN/WHT WIRE YEL/BLK WIRE

BANK 1 SENSOR 1 (IN EXHAUST PIPE, IN FRONT OF CATALYTIC CONVERTER) BANK 2 SENSOR 1 (IN EXHAUST PIPE, IN FRONT OF CATALYTIC CONVERTER) BLK WIRE BRN WIRE CAMSHAFT POSITION (CMP) SENSOR (FRONT OF ENGINE) CEN FIELD SIG CKP SENS SIG LOW REF DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/WHT WIRE ENGINE CONTROL MODULE (ECM) (LEFT SIDE OF ENGINE COMPT) ENGINE COOLANT TEMPERATURE (ECT) SENSOR (AT LEFT FRONT OF ENGINE) GEN ON SIG GRY WIRE GRY/BLK WIRE GRY/WHT WIRE HEATED OXYGEN INJ 1 CTRL ECT SENS SIG LOW REF INJ 2 CTRL INJ 3 CTRL INJ 4 CTRL INJ 7 CTRL KNOCK SENSOR (KS) 1 KNOCK SENSOR (KS) 2 KS 1 SIG KS 1 SIG KS 2 SIG KS 2 SIG LOW REF LOW REF LT BLU WIRE LT BLU/BLK WIRE LT GRN WIRE LT GRN/BLK WIRE MAP SENS SIG PPL ORG/ WIRE ORG/BLK WIRE PNK 5 6 WIRE PNK 7 8 9 10 11 12 13 14 WIRE PNK WIRE PNK/BLK WIRE PPL PPL INTAKE SOL INJ 8 CTRL INJ 5 CTRL INJ 6 CTRL PPL TP SENS 2 SIG CMP SENS SIG TP SENS 1 SIG LOW REF PPL/WHT WIRE PRE SENS SIG SOL CTRL STARTING/ CHARGING SYSTEM STARTING/CHARGING SYSTEM TAC MTR CTRL 2 TAC MTR CTRL 1 TAN WIRE TAN/WHT WIRE WHT GRY/ WIRE WHT WIRE WHT/BLK WIRE YEL WIRE YEL/BLK WIRE

5.3L 5.3L EXCEPT 5.3L A/C REFRIGERANT PRESSURE SENSOR ACC SER DATA IGN VOLT BATT POS VOLT PNK WIRE ACCELERATOR PEDAL POSITION (APP) SENSOR (UNDER LEFT SIDE OF DASH) ANTI-LOCK BRAKES SYSTEM BANK 1 SENSOR 2 BANK 2 SENSOR 2 BLK LT BLU/ WIRE BLK WIRE BLK/WHT WIRE BRAKE PEDAL POSITION (BPP) SENSOR (TOP OF BRAKE PEDAL ASSEMBLY) BREAKOUT) BRK SENS SPLY BRK SW FUSE 13 BRN WIRE COMPUTER DATA LINES SYSTEM CUTAWAY DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE ECM BATT FUSE 19 ECM IGN/ GLOW PLUG MDL IGN FUSE 30 ENGINE CONTROL MODULE (ECM) (LEFT SIDE OF ENGINE COMPT) ENGINE COOLANT RADIATOR TEMPERATURE SENSORS FUEL PUMP, SENDER ASSEMBLY (ON FUEL TANK) FUEL TANK PRESSURE (FTP) SENSOR (ON FUEL TANK) GRY WIRE GRY/WHT WIRE HOT AT ALL TIMES HOT W/ RUN/ CRNK RELAY 15 ENERGIZED IAT SENS SIG LOW REF ECT SENS SIG LOW REF LOW REF PRESS SENS SIG PPL LT BLU WIRE LT BLU/ BLK WIRE LT BLU/BLK WIRE LT BLU/WHT WIRE LT GRN WIRE MAF SENS SIG LOW REF ORG/BLK WIRE ORG/WHT WIRE PNK (OR PNK) 5 6 7 WIRE PNK IGN VOLT WIRE PNK PPL 2 3 4 WIRE PNK WIRE PPL PPL FUEL LEVEL SENS PPL/WHT WIRE PRESS SENS SIG LOW REF PWR/TRN RLY CTRL RED/WHT WIRE RELAY CTRL START RLY CTRL STARTING/ CHARGING SYSTEM STOP LAMP SWITCH (BEHIND LEFT SIDE OF DASH, ABOVE BRAKE PEDAL) TAN WIRE TAN/BLK WIRE TAN/WHT WIRE TCC BRAKE SIG TOWARDS INSTRUMENT PANEL CLUSTER) TRANSMISSIONS SYSTEM UNDERHOOD FUSE BLOCK (ON LEFT SIDE OF ENGINE COMPT) VSS WHT WIRE WHT/BLK WIRE YEL WIRE YEL/BLK WIRE