Chevrolet Chevy Express G1500 (1996-2012) ign volt Wiring diagrams

27 28 2501 2500 44 43 COMPUTER DATA LINES SYSTEM DATA BUS (-) DATA BUS (+) 4.3L 4.3L/5.3L 4.8L/6.0L BATTERY BATTERY CURRENT SENSOR (4.3L/5.3L) BLK WIRE BODY CONTROL MODULE (BCM) (BEHIND LOWER RIGHT SIDE OF DASH) BRN WIRE CHARGE IND COMPUTER DATA LINES SYSTEM CURRENT SENSOR SIG DK GRN WIRE DRIVER INFORMATION CENTER (DIC) DISPLAY ENGINE CONTROL MODULE (ECM) (LEFT SIDE OF ENGINE COMPT) EXCEPT 4.3L FUSIBLE LINK 3 GENERATOR GENERATOR FIELD DUTY CYCLE SIG GENERATOR TURN ON SIG GMLAN SERIAL DATA GRY WIRE HOT W/ RUN/CRANK RELAY 15 ENERGIZED IPC FUSE 10 IGN VOLT INSTRUMENT PANEL CLUSTER (IPC) LOGIC LOW REF LOW SPEED GMLAN SERIAL DATA PNK WIRE ORG/ WIRE PNK WIRE POWER DISTRIBUTION SYSTEM RED WIRE SENS SIG STARTING CIRCUIT TAN WIRE TAN/BLK WIRE UNDERHOOD FUSE BLOCK (ON LEFT SIDE OF ENGINE COMPT) WHT WIRE

27 28 2501 2500 44 43 COMPUTER DATA LINES SYSTEM DATA BUS (-) DATA BUS (+) 4.3L 4.3L/5.3L 4.8L/6.0L BATTERY BATTERY CURRENT SENSOR (4.3L/5.3L) BLK WIRE BODY CONTROL MODULE (BCM) (BEHIND LOWER RIGHT SIDE OF DASH) BRN WIRE CHARGE IND COMPUTER DATA LINES SYSTEM CURRENT SENSOR SIG DK GRN WIRE DRIVER INFORMATION CENTER (DIC) DISPLAY ENGINE CONTROL MODULE (ECM) (LEFT SIDE OF ENGINE COMPT) EXCEPT 4.3L FUSIBLE LINK 3 GENERATOR GENERATOR FIELD DUTY CYCLE SIG GENERATOR TURN ON SIG GMLAN SERIAL DATA GRY WIRE HOT W/ RUN/CRANK RELAY 15 ENERGIZED IPC FUSE 10 IGN VOLT INSTRUMENT PANEL CLUSTER (IPC) LOGIC LOW REF LOW SPEED GMLAN SERIAL DATA PNK WIRE ORG/ WIRE PNK WIRE POWER DISTRIBUTION SYSTEM RED WIRE SENS SIG STARTING CIRCUIT TAN WIRE TAN/BLK WIRE UNDERHOOD FUSE BLOCK (ON LEFT SIDE OF ENGINE COMPT) WHT WIRE

2 6 3 1 CAN BUS HI LO REF CAN BUS LO 3 21 DIMMING CTRL TRACTION SW 5.3L, 4.8L, 6.0L 4.3L 6 16 TCC BRAKE SIG PRK BRK SW ABS IND. ABS MDL FUSE 2 ABS MTR FUSE 1 BLK WIRE BLK/PPL WIRE BLK/WHT WIRE BODY CONTROL MODULE (BCM) (BEHIND LOWER RIGHT SIDE OF DASH) BRAKE IND BREAKOUT TOWARDS INSTRUMENT PANEL CLUSTER) BRK SW FUSE 13 BRN WIRE BRN/WHT WIRE COMPUTER DATA LINES SYSTEM DK BLU WIRE DK GRN WIRE ENGINE CONTROL MODULE (ECM) (LEFT SIDE OF ENGINE COMPT) FUSE 29 GRY WIRE GRY/BLK WIRE HI SPD GMLAN DATA + HI SPD GMLAN DATA + B+ HI SPD GMLAN DATA- HI SPD GMLAN DATA- GND HOT AT ALL TIMES HOT W/ RUN/CRNK RELAY 15 ENERGIZED IGN VOLT IGN VOLT STEERING SENS A STEERING SENS C INSTRUMENT PANEL CLUSTER (IPC) IP CLSTR FUSE 10 LEFT FRONT WHEEL SPEED SENSOR (WSS) (ON INSIDE OF LEFT FRONT WHEEL) LEFT REAR WHEEL SPEED SENSOR (WSS) (AT LEFT REAR WHEEL HUB) LF WHEEL SPD SENS LOW REF LOW REF LO SPD GMLAN LOGIC LOGIC STEERING WHEEL SPEED/ POSITION SENSOR (AT BASE OF STEERING COLUMN) LOW REF RF WHEEL SPD SENS LOW STABILITY IND LT BLU WIRE LT BLU/WHT WIRE LT GRN WIRE ORG/ WIRE ORG/BLK WIRE PARK BRAKE SWITCH (UNDER LEFT PNK 7 3 5 6 2 4 1 8 WIRE PNK WIRE RED WIRE RED/BLK WIRE RED/WHT WIRE RIGHT FRONT WHEEL SPEED SENSOR (WSS) (ON INSIDE OF RIGHT FRONT WHEEL) RIGHT REAR WHEEL SPEED SENSOR (WSS) (AT RIGHT REAR WHEEL HUB) SERIAL DATA SERIAL DATA ENABLE B+ SIDE OF DASH) STEERING ANGLE SENS CAN BUS LO DATA STEERING SENS B STOP LAMP SWITCH (BEHIND LEFT SIDE OF DASH, ABOVE BRAKE PEDAL) STR/WHL SNSR (G) TAN WIRE TAN/BLK WIRE TRACTION CONTROL SWITCH UNDERHOOD FUSE BLOCK (ON LEFT SIDE OF ENGINE COMPT) VDC IND VEHICLE SPD SIG CAN BUS HI DATA VEHICLE SPEED SIGNAL WHT WIRE WHT/BLK WIRE YAW, LATERAL ACCELERATION SENSOR (UNDER FRONT PASSENGER SEAT) YEL WIRE YEL/BLK WIRE

3 21 DIMMING CTRL TRACTION SW 6 16 TCC BRAKE SIG PRK BRK SW ABS IND. BLK WIRE BLK/WHT WIRE BODY CONTROL MODULE (BCM) (BEHIND LOWER RIGHT SIDE OF DASH) BRAKE BOOSTER FLUID FLOW ALARM SWITCH (IN POWER STEERING PUMP OUTLET HOSE) BRAKE FLUID LEVEL SWITCH (AT LEFT REAR OF ENGINE COMPT) BRAKE IND BRAKE PRESSURE DIFFERENTIAL SWITCH (ON BRAKE VALVE, NEAR FRONT OF EBCM) BRAKE WARNING INDICATOR CTRL BREAKOUT TOWARDS INSTRUMENT PANEL CLUSTER) BRK FLUID LEVEL SENSOR SIG BRN WIRE BRN/WHT WIRE COMPUTER DATA LINES SYSTEM DK BLU WIRE DK GRN WIRE GRY WIRE HEAVY DUTY IGN VOLT IGN VOLT STEERING SENS A STEERING SENS C INSTRUMENT PANEL CLUSTER (IPC) LIGHT DUTY LO SPD GMLAN LOGIC LOGIC STEERING WHEEL SPEED/ POSITION SENSOR (AT BASE OF STEERING COLUMN) LOW STABILITY IND LT BLU WIRE LT BLU/BLK WIRE LT BLU/WHT WIRE LT GRN WIRE ORG/BLK WIRE PARK BRAKE SWITCH (UNDER LEFT PNK 7 3 5 6 2 4 1 8 WIRE PNK WIRE PPL RIGHT REAR WHEEL SPEED SENSOR (WSS) (AT RIGHT REAR WHEEL HUB) SERIAL DATA SIDE OF DASH) STEERING SENS B TAN WIRE TAN/WHT WIRE TRACTION CONTROL SWITCH VDC IND WHT WIRE YEL WIRE

1 2 PNK IGN VOLT WIRE 149 (OR 690) AMBIENT LIGHT SENS SIG HDLP ON SIG ANTI-LOCK BRAKES SYSTEM EXTERIOR LIGHTS SYSTEM ANTI-THEFT SYSTEM INSTRUMENT CLUSTER SYSTEM BCM 7 FUSE 8 BODY CONTROL MODULE (BCM) (BEHIND LOWER RIGHT SIDE OF DASH) BRN WIRE BRN/WHT WIRE CHMSL CTRL CONTROL SYSTEMS COURTESY LAMP CTRL CRUISE CONTROL SYSTEM CRUISE CONTROL, SOUND SYSTEMS CRUISE CTRL SW SIG CURRENT SENS SIG LO REF IGN VOLT DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DOOR LOCKS, ANTI-THEFT SYSTEMS DOOR LOCKS, ANTI-THEFT SYSTEMS AIR CONDITIONING SYSTEM DRV DOOR LOCK SW UNLOCK SIG DRV DOOR LOCK SW LOCK SIG DRV DR LOCK RLY UNLOCK CTRL DRV DR LOCK RLY UNLOCK CTRL PASS DOOR LOCK SW LOCK CTRL GRY WIRE GRY/BLK WIRE HDLP LOW BEAM RLY CTRL PARK LAMP CTRL HDLP OFF SIG COURTESY LAMPS CTRL HEADLIGHTS SYSTEM HEADLIGHTS SYSTEM EXTERIOR LIGHTS SYSTEM HEADLIGHTS SYSTEM EXTERIOR LIGHTS SYSTEM TRANSMISSIONS SYSTEM HEADLIGHTS SYSTEM INTERIOR LIGHTS SYSTEM HORN RLY CTRL HORNS SYSTEM HOT AT ALL TIMES IGN VOLT IGNITION SWITCH KEY-IN SWITCH LF DOOR OPEN SW SIG A/C REQUEST SIGNAL LF TURN SIG LAMP CTRL STOP LAMPS CTRL TCC BRAKE SIG LIFTGATE AJAR SW SIG LOW REF WIPER LOW SW SIG LT BLU WIRE LT BLU/WHT WIRE LT GRN WIRE OFF ORG/ WIRE ORG/BLK WIRE PARK LAMPS SIG PASS DOOR LOCK SW LOCK CTRL PNK 12 VOLT REF WIRE PNK IGN VOLT L TURN HAZ SW SIG R TURN HAZ SW SIG WIRE PNK WIRE PNK/BLK WIRE PNK/WHT WIRE POWER DISTRIBUTION SYSTEM PPL PPL DEFEAT SW SIG PPL HOOD CLD SW SIG PARK BRAKE SW SIG REAR ACCESS OPEN SW SIG RED/WHT WIRE RF DOOR AJAR SW SIG PASS DR LOCK SW UNLOCK CTRL LF DOOR AJAR SW SIG RR DOOR OPEN SW SIG LR DOOR OPEN SW SIG RF DOOR OPEN SW SIG RUN WIRE STARTING/ CHARGING SYSTEM TAN WIRE TAN/BLK WIRE TAN/WHT WIRE TRACTION CTRL SW SIG BACKUP LAMP RLY CTRL UNDERHOOD FUSE BLOCK (ON LEFT SIDE OF ENGINE COMPT) WHT WIRE WIPER SW SIG 2 FRONT WIND WIPER SW HI SIG WIPER/WASHER SYSTEM WIPER/WASHER SYSTEM SOUND, CRUISE YEL WIRE YEL/BLK WIRE

27 28 2501 2500 44 43 COMPUTER DATA LINES SYSTEM DATA BUS (-) DATA BUS (+) 4.3L 4.3L/5.3L 4.8L/6.0L BATTERY BATTERY CURRENT SENSOR (4.3L/5.3L) BLK WIRE BODY CONTROL MODULE (BCM) (BEHIND LOWER RIGHT SIDE OF DASH) BRN WIRE CHARGE IND COMPUTER DATA LINES SYSTEM CURRENT SENSOR SIG DK GRN WIRE DRIVER INFORMATION CENTER (DIC) ENGINE CONTROL MODULE (ECM) (LEFT SIDE OF ENGINE COMPT) EXCEPT 4.3L FUSIBLE LINK 3 GENERATOR GENERATOR FIELD DUTY CYCLE SIG GENERATOR TURN ON SIG GMLAN SERIAL DATA GRY WIRE HOT W/ RUN/CRANK RELAY ENERGIZED IGN VOLT INSTRUMENT PANEL CLUSTER (IPC) IP CLSTR FUSE 10 LOGIC LOW REF LOW SPEED GMLAN SERIAL DATA PNK WIRE ORG/ WIRE PNK WIRE POWER DISTRIBUTION SYSTEM RED WIRE SENS SIG STARTING CIRCUIT TAN WIRE TAN/BLK WIRE UNDERHOOD FUSE BLOCK (ON LEFT SIDE OF ENGINE COMPT) WHT WIRE

ABS IND. AIR BAG IND BLK WIRE BLK/WHT WIRE BODY CONTROL MODULE (BCM) (BEHIND LOWER RIGHT SIDE OF DASH) BODY FUSE BLOCK (UNDER LEFT BODY FUSE BLOCK (UNDER LEFT FRONT SEAT) BRAKE IND BRN WIRE BRN/WHT WIRE CHARGE IND CMPS FUSE 19 COMPUTER DATA LINES SYSTEM CRUISE IND DIESEL DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/WHT WIRE DRIVER INFORMATION CENTER (DIC) ENGINE COMPT) ENGINE CONTROLS SYSTEM SUPPLEMENTAL RESTRAINTS SYSTEM ENGINE COOLANT TEMPERATURE GAUGE FRONT SEAT) FUEL GAUGE GMLAN SERIAL GRY/BLK WIRE HIGH BEAM IND HOT AT ALL TIMES HOT W/ RUN RELAY HOT W/ RUN/CRANK RELAY 15 ENERGIZED IGN VOLT IND CTRL IND LAMP (MIL) INSTRUMENT PANEL CLUSTER (IPC) IP CLSTR FUSE 10 IP CLSTR FUSE 23 LEFT TURN IND LIFTGATE AJAR SW SIG LF DOOR AJAR SW RR DOOR OPEN SW LR DOOR OPEN SW LOGIC LOW ENGINE OIL LOW ENGINE OIL PRESSURE GAUGE LOW TIRE PRESSURE IND LT BLU WIRE LT GRN WIRE MALFUNCTION MIL CTRL NETWORK 3 ODOMETER PARK BRAKE SWITCH (UNDER LEFT SIDE OF DASH) PASS SEAT BELT PNK WIRE PNK/BLK WIRE PPL PPL PNK WIRE PRESSURE IND RED/WHT WIRE RF DOOR AJAR SW RIGHT TURN IND SEAT BELT IND SECURITY IND SEO FUSE 27 SPEEDOMETER SUPPLEMENTAL RESTRAINTS SYSTEM SW SIG SWITCH SIG TAN/WHT WIRE TOW/HAUL IND TRACTION CONTROL IND UNDERHOOD FUSE BLOCK (ON LEFT SIDE OF VOLTS GAUGE W/ ODOMETER SECURITY WIRING PROVISION (SEO) W/O ODOMETER SECURITY WIRING PROVISION (SEO) WAIT TO START IND WHT WIRE YEL WIRE YEL/BLK WIRE

BLK WIRE BLK/WHT WIRE BRK APLY SENS SIG BRK SW FUSE 13 CNSTR VENT SOL FUSE 56 DK GRN/WHT WIRE ECM PWR/TRN FUSE 78 ENGINE CONTROL MODULE (ECM) (LEFT SIDE OF ENGINE COMPT) ENGINE OIL PRESSURE (EOP) SENSOR (ON TOP REAR OF ENGINE) EVAP SOL CTRL FUEL PUMP RELAY 38 GAS FUEL PUMP FUSE 24 GRY WIRE HOT AT ALL TIMES HOT W/ RUN/ CRNK RELAY 15 ENERGIZED IAT SENS SIG IGN VOLT INJ FUSE 75 LT BLU WIRE LT BLU/WHT WIRE LT GRN WIRE MAF/ CNSTR VENT FUSE 64 MANIFOLD ABSOLUTE PRESSURE (MAP) SENSOR ODD IGN/INJ FUSE 65 OF ENGINE COMPT) ORG/BLK WIRE PARK/NEUTRAL SIG PNK PNK 3 4 WIRE PNK PNK WIRE PNK WIRE PWR/TRN RELAY 49 RED/WHT WIRE SNSR 1 (PRE)/CLS FUSE 77 SNSR 2 (POST) FUSE 62 STOP LAMP SWITCH (BEHIND LEFT SIDE OF DASH, ABOVE BRAKE PEDAL) TAN WIRE TAN/WHT WIRE TCC BRAKE SIG TOWARDS INSTRUMENT PANEL CLUSTER) TRANSMISSIONS SYSTEM UNDERHOOD FUSE BLOCK (ON LEFT SIDE WHT WIRE YEL WIRE

AT IGNITION COIL) BANK 1 SENSOR 1 (IN EXHAUST PIPE, IN FRONT OF CATALYTIC CONVERTER) BANK 2 SENSOR 1 (IN EXHAUST PIPE, IN FRONT OF CATALYTIC CONVERTER) BLK WIRE BLK/WHT WIRE BRN WIRE BRN/WHT WIRE CAMSHAFT POSITION (CMP) SENSOR (PART OF DISTRIBUTOR, TOP REAR OF ENGINE) CKP SENS SIG CMP SENS SIG CRANKSHAFT POSITION (CKP) SENSOR (ON LOWER FRONT OF ENGINE, NEAR CRANKSHAFT) DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/WHT WIRE ENGINE CONTROL MODULE (ECM) (LEFT SIDE OF ENGINE COMPT) ENGINE COOLANT TEMPERATURE (ECT) SENSOR (ON LEFT SIDE OF ENGINE) EVAP SOL CTRL GEN ON SIG TAC MTR 2 GEN FIELD SIG GRY WIRE GRY/BLK WIRE GRY/WHT WIRE HEATED OXYGEN IGN VOLT IGNITION CONTROL MODULE (ICM) (ON TOP RIGHT SIDE OF ENGINE) KNOCK SENSOR (KS) 1 KNOCK SENSOR (KS) 2 KS 2 SIG KS 2 SIG LOW REF LOW REF KS 1 SIG KS 1 SIG LT BLU WIRE LT BLU/BLK WIRE LT GRN WIRE LT GRN/BLK WIRE MAP SENS SIG LOW REF LOW REF NCA WIRE ORG/ WIRE ORG/BLK WIRE ORG/WHT WIRE PNK 2 3 WIRE PNK WIRE PNK/BLK WIRE PPL PPL IC 1 CTRL IC 3 CTRL IC 2 CTRL PPL/WHT WIRE RED WIRE SENS SIG STARTING/CHARGING SYSTEM TAC MTR 1 TAN WIRE TAN/WHT WIRE TP SENS 1 ECT SENS SIG TP SENS 2 WHT/BLK WIRE YEL WIRE YEL/BLK WIRE

& IGNITION COIL/MODULE 7) 1 2 3 PNK WIRE 1 2 3 PPL BLK WIRE BRN WIRE COMPUTER DATA COMPUTER DATA LINES SYSTEM DK GRN WIRE DK GRN/WHT WIRE FCSM BATT FUSE 36 FSCM IGN FUSE 6 GMLAN DATA GRY WIRE HOT AT ALL TIMES HOT W/ RUN/ CRNK RELAY 15 ENERGIZED IGN VOLT IGNITION COIL/MODULE 1 IGNITION COIL/MODULE 3 IGNITION COIL/MODULE 5 LINES SYSTEM LOW REF LT BLU WIRE LT BLU/WHT WIRE NCA WIRE ORG/ WIRE ORG/WHT WIRE PNK PNK PNK PNK PNK PNK PNK PNK PNK 4 5 6 7 8 9 10 11 12 WIRE PNK PNK PPL 15 16 17 18 19 20 21 22 23 24 WIRE PNK WIRE PPL PPL/WHT WIRE PUMP CTRL RED WIRE RED/WHT WIRE RELAY CTRL SENS SIG SERIAL DATA SPARK PLUG TAN WIRE TAN/BLK WIRE UNDERHOOD FUSE BLOCK (ON LEFT SIDE OF ENGINE COMPT)