Chevrolet Chevy Express G1500 (1996-2012) hot at all times Wiring diagrams

2 6 3 1 CAN BUS HI LO REF CAN BUS LO 32 33 34 35 36 37 38 VEHICLE SPD SIG CAN BUS HI DATA 5.3L, 4.8L, 6.0L 4.3L ABS MDL FUSE 2 ABS MTR FUSE 1 BLK WIRE BLK/PPL WIRE BRK SW FUSE 13 BRN WIRE BRN/WHT WIRE COMPUTER DATA LINES SYSTEM DIESEL DIESEL GASOLINE DK BLU WIRE DK GRN WIRE ENGINE CONTROL MODULE (ECM) (LEFT SIDE OF ENGINE COMPT) FUSE 29 GASOLINE GRY WIRE GRY/BLK WIRE HI SPD GMLAN DATA + HI SPD GMLAN DATA + B+ HI SPD GMLAN DATA- HI SPD GMLAN DATA- GND HOT AT ALL TIMES HOT W/ RUN/CRNK RELAY 15 ENERGIZED IPC FUSE 10 LEFT FRONT WHEEL SPEED SENSOR (WSS) (ON INSIDE OF LEFT FRONT WHEEL) LEFT REAR WHEEL SPEED SENSOR (WSS) (AT LEFT REAR WHEEL HUB) LF WHEEL SPD SENS LOW REF LOW REF LOW REF RF WHEEL SPD SENS LT BLU WIRE LT BLU/WHT WIRE LT GRN WIRE ORG/ WIRE ORG/BLK WIRE PNK WIRE RED WIRE RED/BLK WIRE RED/WHT WIRE RIGHT FRONT WHEEL SPEED SENSOR (WSS) (ON INSIDE OF RIGHT FRONT WHEEL) SERIAL DATA ENABLE B+ STEERING ANGLE SENS CAN BUS LO DATA STOP LAMP SWITCH (BEHIND LEFT SIDE OF DASH, ABOVE BRAKE PEDAL) STR/WHL/ SNSR TAN WIRE TAN/BLK WIRE UNDERHOOD FUSE BLOCK (ON LEFT SIDE OF ENGINE COMPT) VEHICLE SPEED SIGNAL WHT WIRE WHT/BLK WIRE YAW, LATERAL ACCELERATION SENSOR (UNDER FRONT PASSENGER SEAT) YEL WIRE YEL/BLK WIRE

2 3 11 13 DATA BUS (-) DATA BUS (+) 2 3 DATA BUS (+) DATA BUS (-) 2 3 SERIAL DATA SERIAL DATA 5 4 6 7 157 147 167 177 DATA BUS (+) DATA BUS (-) DATA BUS (-) DATA BUS (+) 6 5 DATA BUS (-) DATA BUS (+) 6.6L 4.8L, 5.3L, 6.0L 4.3L ACC WAKE UP SERIAL DATA DATA BUS (+) DATA BUS (-) BLK/WHT WIRE CHIME MODULE (BEHIND LEFT CENTER OF DASH) CUTAWAY DATA LINK CONNECTOR (DLC) (UNDER LEFT SIDE OF DASH) DATA LINK RESISTOR DIGITAL RADIO RECEIVER (S-BAND DIGITAL AUDIO SYSTEM) (LEFT SIDE OF DASH) DK BLU WIRE DK GRN WIRE ENGINE CONTROL MODULE (ECM) (LEFT SIDE OF ENGINE COMPT) HOT AT ALL TIMES INFLATABLE RESTRAINT SENSING, DIAGNOSTIC MODULE (SDM) (UNDER LEFT FRONT SEAT) INSTRUMENT PANEL CLUSTER (IPC) LIGHT DUTY W/O RECREATIONAL VEHICLE, UPFITTER SALES PACKAGE LT GRN WIRE LTR/DLC FUSE 73 NITROGEN OXIDES SENSOR 1 (TOP LEFT REAR SIDE OF ENGINE) NITROGEN OXIDES SENSOR 2 (MIDDLE OF DIESEL PARTICULATE FILTER) RADIO RED WIRE RED/WHT WIRE REDUCTANT SENSOR MODULE (ABOVE REDUCTANT TANK) REMOTE CONTROL DOOR LOCK RECEIVER (RCDLR) (IF EQUIPPED) (BEHIND CENTER OF DASH) SERIAL DATA SPLICE PACK TAN WIRE TAN/BLK WIRE UNDERHOOD FUSE BLOCK (ON LEFT SIDE OF ENGINE COMPT) W/O RADIO WHT WIRE

11 12 LPS DIMMER SW SIG DIMMING VOLT REF 2 15 HEAD 8 17 PARK LAMPS SIG HEADLAMPS OFF SIG AUXILIARY BLOWER MOTOR SWITCH BATTERY POS VOLT BCM 3 FUSE 26 BLK WIRE BLK/WHT WIRE BODY CONTROL MODULE (BCM) (BEHIND LOWER RIGHT SIDE OF DASH) BODY FUSE BLOCK (UNDER LEFT FRONT SEAT) BRN WIRE BRN/WHT WIRE CONNECTOR CONTROL DIMMING CTRL DK GRN WIRE DRIVER DOOR LOCK SWITCH DRIVER INFORMATION CENTER (DIC) SWITCH DRIVER WINDOW SWITCH FRONT AUXILIARY HVAC CONTROL ASSEMBLY HEADLAMP, PANEL DIMMER SWITCH HOT AT ALL TIMES HVAC CONTROL ASSEMBLY IN FRONT HEADLINER HARNESS, 21 CM INFLATABLE RESTRAINT I/P MODULE DISABLE SWITCH (W/ MANUAL SUPPRESSION) LEFT STEERING WHEEL CONTROL SWITCH LPS DIMMING CTRL LT BLU WIRE OFF AUTO PARK ORG/ WIRE ORG/WHT WIRE PASSENGER DOOR LOCK (W/ POWER SWITCH MIRRORS, POWER WINDOWS) PASSENGER WINDOW SWITCH PNK CONTROL PNK WIRE PNK PNK W/O REDUNDANT RADIO STEERING WHEEL WIRE PNK WIRE RADIO RED WIRE RED/WHT WIRE RIGHT STEERING WHEEL CONTROL SWITCH STR WHL SNSR FUSE 17 TRACTION CONTROL SWITCH (TCS) (W/ ACTIVE BRAKE CONTROL) UNDERHOOD FUSE BLOCK (ON LEFT SIDE OF ENGINE COMPT) W/ AUTOMATIC CRUISE CONTROL, REDUNDANT RADIO STEERING WHEEL CONTROL W/ AUTOMATIC ELECTRONIC CRUISE CONTROL W/ AUXILIARY HEATER W/O REAR A/C W/ ELECTRIC SIDE DOOR LOCK W/ ELECTRIC TOW/HAUL SWITCH SIDE DOOR LOCK W/ POWER OPERATED WINDOW W/ REAR W/O REAR AUXILIARY AUXILIARY CONTROLS CONTROLS W/ REDUNDANT RADIO STEERING WHEEL W/ RV UPFITTER W/O RADIO PROVISIONS W/O RV UPFITTER WHT WIRE YEL WIRE

1 18 25 COURTESY LP CTRL COURTESY LP CTRL DEFEAT SW SIG 149 (OR 690) 16 17 DATA BUS+ DATA BUS- 20 CM FROM RIGHT SUNSHADE BREAKOUT) 2500 2501 COMPUTER DATA LINES SYSTEM BLK WIRE BLK/WHT WIRE BODY CONTROL MODULE (BCM) (BEHIND LOWER RIGHT SIDE OF DASH) BODY FUSE BLOCK (UNDER LEFT FRONT SEAT) CARGO CARGO DOOR LATCH ASSEMBLY (IN RIGHT REAR CARGO DOOR) CARGO/PASSENGER COURTESY LP CTRL CTSY LP CTRL DK BLU WIRE DK BLU/WHT WIRE DOME DOME READING FL DOME RLY CTRL FRONT DOME/ READING LAMPS GRY WIRE GRY/BLK WIRE HEADLAMP, PANEL DIMMER SWITCH HOT AT ALL TIMES LEFT SUNSHADE LIFTGATE AJAR SW SIG LOWER RIGHT "B" MIDDLE DOME/ READING LAMPS ORG/ WIRE PASSENGER PASSENGER/CARGO W/O RV UPFITTER PNK/BLK WIRE PPL PROVISIONAL READING REAR DOME/ READING LAMPS (PASSENGER) DOME LAMP (CARGO) RED WIRE RIGHT SUNSHADE (ON UPPER RIGHT OF HEADLINER) SPLICE BLOCK TAN WIRE TAN/BLK WIRE TAN/WHT WIRE THE ENGINE BLOCK) (4.3L: RIGHT REAR OF ENGINE) UNDERHOOD FUSE BLOCK (ON LEFT SIDE OF ENGINE COMPT) UNDERHOOD LAMP UPFTR AUX 1 UPFTR CTSY UPFTR CTSY LAMP W/ COMMERCIAL TRADESMAN SALES PACKAGE, CARGO LAMP W/ CUTAWAY W/ CUTAWAY, CARGO W/O RV UPFITTER W/ LEFT, RIGHT SUNSHADE MIRROR W/ RV UPFITTER W/ RV UPFITTER, LEFT, RIGHT SUNSHADE MIRROR W/O RV UPFITTER W/O RV W/ RV UPFITTER UPFITTER WHT WIRE YEL/BLK WIRE

ABS IND. AIR BAG IND BLK WIRE BLK/WHT WIRE BODY CONTROL MODULE (BCM) (BEHIND LOWER RIGHT SIDE OF DASH) BODY FUSE BLOCK (UNDER LEFT BODY FUSE BLOCK (UNDER LEFT FRONT SEAT) BRAKE IND BRN WIRE BRN/WHT WIRE CHARGE IND CMPS FUSE 19 COMPUTER DATA LINES SYSTEM CRUISE IND DIESEL DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/WHT WIRE DRIVER INFORMATION CENTER (DIC) DISPLAY ENGINE COMPT) ENGINE CONTROLS SYSTEM SUPPLEMENTAL RESTRAINTS SYSTEM ENGINE COOLANT TEMPERATURE GAUGE FRONT SEAT) FUEL GAUGE GMLAN SERIAL GRY/BLK WIRE HIGH BEAM IND HOT AT ALL TIMES HOT W/ RUN RELAY HOT W/ RUN/CRNK RELAY 15 ENERGIZED I/P CLUSTER FUSE 23 IGN VOLT IND CTRL IND LAMP (MIL) INSTRUMENT PANEL CLUSTER (IPC) IPC FUSE 10 LEFT TURN IND LIFTGATE AJAR SW SIG LF DOOR AJAR SW RR DOOR OPEN SW LR DOOR OPEN SW LOGIC LOW ENGINE OIL PRESSURE GAUGE LOW FUEL IND LOW OIL LOW STABILITY IND LT BLU WIRE LT GRN WIRE MALFUNCTION MIL CTRL NETWORK 3 ODOMETER PARK BRAKE SWITCH (UNDER LEFT SIDE OF DASH) PASS SEAT BELT PASSENGER SEAT BELT IND PNK WIRE PNK/BLK WIRE PPL PPL PNK WIRE PRESSURE IND PRND 321 RED/WHT WIRE RF DOOR AJAR SW RIGHT TURN IND SEAT BELT IND SECURITY IND SEO FUSE 27 SPEEDOMETER SUPPLEMENTAL RESTRAINTS SYSTEM SW SIG SWITCH SIG TAN/WHT WIRE TIRE PRESSURE IND TOW/HAUL IND TRACTION CONTROL IND UNDERHOOD FUSE BLOCK (ON LEFT SIDE OF VOLTS GAUGE W/ BRAKE WARNING INDICATOR SYSTEM W/ ODOMETER SECURITY WIRING PROVISION (SEO) W/O ODOMETER SECURITY WIRING PROVISION (SEO) WAIT TO START IND WHT WIRE YEL WIRE YEL/BLK WIRE

1 18 25 COURTESY LP CTRL COURTESY LP CTRL DEFEAT SW SIG 149 (OR 690) 20 CM FROM RIGHT SUNSHADE BREAKOUT) BLK WIRE BLK/WHT WIRE BLU WIRE BODY CONTROL MODULE (BCM) (BEHIND LOWER RIGHT SIDE OF DASH) BODY FUSE BLOCK (UNDER LEFT FRONT SEAT) CARGO CARGO DOOR LATCH ASSEMBLY (IN RIGHT REAR CARGO DOOR) CARGO/PASSENGER COURTESY LP CTRL CTSY LP CTRL DK BLU WIRE DK BLU/WHT WIRE DOME DOME READING FL DOME RLY CTRL FRONT DOME/ READING LAMPS GRY WIRE GRY/BLK WIRE HEADLAMP, PANEL DIMMER SWITCH HOT AT ALL TIMES LEFT SUNSHADE LIFTGATE AJAR SW SIG MIDDLE DOME/ READING LAMPS ORG/ WIRE PASSENGER PASSENGER/CARGO W/O RV UPFITTER PNK/BLK WIRE PPL PROVISIONAL READING REAR DOME/ READING LAMPS (PASSENGER) DOME LAMP (CARGO) RED WIRE RIGHT SUNSHADE (ON UPPER RIGHT OF HEADLINER) TAN/WHT WIRE THE ENGINE BLOCK) UNDERHOOD FUSE BLOCK (ON LEFT SIDE OF ENGINE COMPT) UNDERHOOD LAMP UPFTR AUX 1 FUSE 36 (W/ CUTAWAY, AMBULANCE, RV UPFITTERS) UPFTR CTSY LAMPS FUSE 4 UPFTR CTSY LAMPS PCB RELAY (W/ AMBULANCE, RV UPFITTER) W/ COMMERCIAL TRADESMAN SALES PACKAGE, CARGO LAMP W/ CUTAWAY W/ CUTAWAY, CARGO W/O RV UPFITTER W/ LEFT, RIGHT SUNSHADE MIRROR W/ RV UPFITTER W/ RV UPFITTER, LEFT, RIGHT SUNSHADE MIRROR W/O RV UPFITTER W/O RV W/ RV UPFITTER UPFITTER WHT WIRE YEL/BLK WIRE

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 LH AUDIO SIG (+) RH AUDIO SIG (+) 1 2 3 4 5 6 7 8 9 10 11 12 13 14 B+ LF MID OUT (+) RF MID OUT (+) 1959 1955 LR MID OUT (-) RR MID OUT (-) 2 1 8 LO REF 658 1782 VOICE SIG DRAIN WIRE HI SPD GMLAN ANTENNA IN BATT POSITIVE VOLT BLK/WHT WIRE BODY CONTROL MODULE (BCM) (BEHIND LOWER RIGHT SIDE OF DASH) BODY FUSE BLOCK (UNDER LEFT FRONT SEAT) BREAKOUT) BRN/WHT WIRE CELLULAR, DIGITAL RADIO ANTENNA CELLULAR/ NAVIGATION ANTENNA COAX COMPUTER DATA LINES SYSTEM CRUISE CONTROL SYSTEM CUTAWAY UPFITTER DIGITAL RADIO RECEIVER (LEFT SIDE OF DASH) DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE DRAIN WIRE GRY WIRE HOT AT ALL TIMES INFLATABLE RESTRAINT STEERING WHEEL MODULE COIL (AT TOP OF STEERING COLUMN) INFO LED DIMMING CTRL GND LF MID OUT (-) RF MID OUT (-) LEFT CARGO DOOR SPEAKER (IF EQUIPPED) LEFT FRONT SPEAKER LEFT REAR SPEAKER LH AUDIO SIG + RH AUDIO SIG + LO GMLAN SERIAL DATA LO REF LO SERIAL DATA LR MID OUT (+) RR MID OUT (+) LT BLU WIRE LT BLU/BLK WIRE LT GRN WIRE MUTE NCA WIRE ORG/ WIRE PASSENGER/ CARGO PNK WIRE RADIO RADIO ANTENNA RDO/ CHIME FUSE 20 RED/WHT WIRE RIGHT CARGO DOOR SPEAKER (IF EQUIPPED) RIGHT FRONT SPEAKER RIGHT REAR SPEAKER RIGHT STEERING WHEEL CONTROL SWITCH SEEK DOWN SEEK UP SOURCE STEERING WHEEL CTRL TAN WIRE TAN/BLK WIRE TAN/WHT WIRE USB CABLE USB CHARGE USB RECEPTACLE VEHICLE COMMUNICATION INTERFACE MODULE (VICM) (BELOW STEERING COLUMN) VOICE SIG VOL DOWN VOL UP W/ VEHICLE COMMUNICATION SYSTEM W/O VEHICLE COMMUNICATION SYSTEM WHT WIRE YEL WIRE

1 2 3 4 BATTERY B+ SERIAL DATA BLK WIRE BLK/WHT WIRE BODY CONTROL MODULE (BCM) (BEHIND LOWER RIGHT SIDE OF DASH) CARGO DR UNLCK FUSE 33 CARGO DR UNLCK PCB RELAY CHIME MODULE (BEHIND LEFT CENTER OF DASH) COMPUTER DATA LINES SYSTEM DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DRV DR UNLCK FUSE 36 DRVR DR UNLCK PCB RELAY FRT DR LCK FUSE 31 FRT PASS DR UNLCK FUSE 34 FRT REAR PASS DR UNLCK PCB FTR REAR DR LCK PCB GROUND GRY WIRE GRY/BLK WIRE HOT AT ALL TIMES HOT AT ALL TIMES BODY FUSE BLOCK (UNDER LEFT FRONT SEAT) LEFT REAR SIDE DOOR JAM SWITCH (W/ HINGED DOOR) (AT LEFT "B" PILLAR) LIFTGATE AJAR SW SIG LO SPD GMLAN SERIAL DATA LO SPD SERIAL DATA LT BLU WIRE LT GRN WIRE ORG/BLK WIRE PNK/BLK WIRE RADIO REAR DR LCK FUSE 32 REAR OPEN SW REAR PASS DR UNLCK FUSE 35 RED/WHT WIRE REMOTE CONTROL DOOR LOCK RECEIVER (RCDLR) (BEHIND CENTER OF DASH) RFA/TPM FUSE 21 RIGHT REAR SIDE DOOR JAM SWITCH (W/ CARGO PASSENGER) (AT RIGHT "B" PILLAR) TAN WIRE TAN/BLK WIRE TAN/WHT WIRE W/ COMMERCIAL TRADESMAN W/ HINGED DOOR W/O COMMERCIAL TRADESMAN YEL WIRE YEL/BLK WIRE

ACC WAKEUP DATA AUTOMATIC TRANSMISSION (A/T) OUTPUT SHAFT SPEED (OSS) SENSOR BLK/WHT WIRE BRK SW FUSE 13 BRN WIRE COMPUTER DATA LINES SYSTEM DK BLU WIRE DK BLU/WHT WIRE GRY WIRE HI SPD GMLAN DATA (+) 2-3 SHIFT SOL HI SPD GMLAN DATA (-) VSS LOW SIG PC SOL LOW HOT AT ALL TIMES HOT W/ RUN/CRNK RELAY 15 ENERGIZED LOW REF TR SW B SIG LT BLU/WHT WIRE LT GRN WIRE LT GRN/BLK WIRE ORG/BLK WIRE PNK WIRE PPL/WHT WIRE RED/WHT WIRE REPLICATED TOS SIG HI SPD GMLAN DATA (-) HI SPD GMLAN DATA (+) STOP LAMP SWITCH (BEHIND LEFT SIDE OF DASH, ABOVE BRAKE PEDAL) TAN WIRE TAN/BLK WIRE TAN/WHT WIRE TCC SOL VALVE CTRL TCM BATT FUSE 32 TCM IGN FUSE 31 TFT SENS SIG TR SW A SIG LOW REF IGN VOLT BATT POS VOLT TR SW C SIG TRANS FUSE 17 TRANSMISSION CONTROL MODULE (TCM) UNDERHOOD FUSE BLOCK (ON LEFT SIDE OF ENGINE COMPT) WHT WIRE YEL WIRE YEL/BLK WIRE