Chevrolet Chevy Express G1500 (1996-2012) computer data lines system Wiring diagrams

ABS FUSE ABS IND. BATTERY SIGNAL GROUND BLK WIRE BLK/WHT WIRE BRAKE FUSE 18 BRAKE IND BRAKE PRESSURE DIFFERENTIAL SWITCH (ON LEFT FRAME RAIL, NEAR CENTER OF VEHICLE) BRN WIRE COMPUTER DATA LINES SYSTEM DATA LINK CONNECTOR (DLC) (UNDER LEFT SIDE OF DASH) DK GRN WIRE GAUGES FUSE 4 HOT AT ALL TIMES HOT IN RUN HOT IN RUN OR START I/P FUSE BLOCK (ON LEFT LOWER KICK PANEL) IGNITION ABS IND GROUND BRAKE SW INPUT INSTRUMENT CLUSTER LEFT FRONT WHEEL SPEED SENSOR LT BLU WIRE LT GRN WIRE LT GRN/BLK WIRE PNK WIRE POWERTRAIN CONTROL MODULE (PCM) (IN ENGINE COMPT, ON LEFT INNER FENDER) PPL PPL PPL 1807 680 PPL/WHT WIRE RED WIRE RIGHT FRONT WHEEL SPEED SENSOR SENSOR HIGH SENSOR HIGH SENSOR LOW SENSOR LOW 873 833 TAN WIRE TAN/WHT WIRE TCC/BRAKE SWITCH (BEHIND DASH, ON BRAKE PEDAL SUPPORT) UNDERHOOD FUSE BLOCK UNDERHOOD FUSE BLOCK (ON LEFT SIDE OF ENGINE COMPT) VEHICLE SPEED SENSOR (VSS) (ON SIDE OF TRANSMISSION) VEHICLE SPEED SENSOR (VSS) MODULE (BELOW DASH, NEAR STEERING COLUMN) VSS VSS SIG VSS SIG DIAGNOSTIC SIG SERIAL DATA BRAKE IND INPUT EBCM GROUND W/ 6.5L W/O 6.5L WARNING SYSTEMS YEL WIRE YEL/BLK WIRE

37 38 GMLAN HI-SPD (-) GMLAN HI-SPD (+) 38 37 GMLAN HI-SPD (+) GMLAN HI-SPD (-) 39 23 46 29 RANGE SW - P RANGE SW - C RANGE SW - B RANGE SW - A 72 32 RANGE SW - B RANGE SW - A BACKUP LAMP (LEFT) BACKUP LAMP- RIGHT BKUP LAMP SUPPLY BLK WIRE BLK/WHT WIRE BODY CONTROL MODULE (BEHIND LOWER RIGHT SIDE OF DASH) CLASS 2 DATA COMPUTER DATA LINES SYSTEM CUTAWAY DIESEL DK GRN WIRE ENGINE CONTROL MODULE (LEFT FRONT SIDE OF ENGINE COMPARTMENT) GAS GROUND GRY WIRE HOT AT ALL TIMES LT GRN WIRE MIRRORS SYSTEM PARK/NEUTRAL POSITION SWITCH (ON LEFT SIDE OF TRANSMISSION) PASSENGER/ CARGO POWERTRAIN CONTROL MODULE (IN ENGINE COMPT, ON LEFT INNER FENDER) RANGE SW - C RANGE SW P RED WIRE RED/WHT WIRE TAIL/STOP, TURN SIGNAL LAMP (LEFT) TAIL/STOP, TURN SIGNAL LAMP (RIGHT) TAN WIRE TAN/BLK WIRE TAN/WHT WIRE TBC 2 FUSE 18 TRANSMISSION CONTROL MODULE (LEFT FRONT CORNER OF ENGINE COMPARTMENT) UNDERHOOD FUSE BLOCK (ON LEFT SIDE OF ENGINE COMPARTMENT) WHT WIRE YEL WIRE

AUTOMATIC TRANSMISSION AUTOMATIC TRANSMISSION ASSEMBLY (6 SPEED A/T) AUTOMATIC TRANSMISSION INTERNAL MODE SWITCH (IMS) AUX/TRLR BCK/UP FUSE 26 BACKUP ALARM (REAR OF VEHICLE ON FRAME) BCK/UP LAMP PCB RELAY BLK WIRE BLK/WHT WIRE BODY CONTROL MODULE (BCM) (BEHIND LOWER RIGHT SIDE OF DASH) BODY FUSE BLOCK (UNDER LEFT BUS-DATA COMPUTER DATA LINES SYSTEM CONTROL SOLENOID VALVE ASSEMBLY DATA BUS - DK BLU WIRE FRONT SEAT) GMLAN HI SPD GRN WIRE GRY WIRE HI SPD GMLAN DATA BUS - HI SPD GMLAN SERIAL DATA BUS + HOT AT ALL TIMES LEFT BACKUP LAMP (CARGO/ PASSENGER) LEFT TAIL/ STOP/ TURN SIGNAL LAMP LT GRN WIRE NCA WIRE PARK/NEUTRAL POSITION (PNP) SWITCH PROVISIONAL RED WIRE RELAY CTRL RIGHT BACKUP LAMP (CARGO/ PASSENGER) RIGHT TAIL/ STOP/ TURN SIGNAL LAMP SIG A SIG B SIG C TAIL LAMP BCK/UP FUSE 27 TAN WIRE TAN/BLK WIRE TAN/WHT WIRE TRAILER CONNECTOR (IF EQUIPPED) TRANS RNG SW SIG A TRANS RNG SW SIG B TRANS- MISSION CONTROL MODULE (TCM) TRANSMISSION CONTROL MODULE (TCM) (4 SPEED A/T) UNDERHOOD FUSE BLOCK W/ ELECTRICAL BACKUP CUTAWAY ALARM YEL WIRE

27 28 2501 2500 44 43 COMPUTER DATA LINES SYSTEM DATA BUS (-) DATA BUS (+) 4.3L 4.3L/5.3L 4.8L/6.0L BATTERY BATTERY CURRENT SENSOR (4.3L/5.3L) BLK WIRE BODY CONTROL MODULE (BCM) (BEHIND LOWER RIGHT SIDE OF DASH) BRN WIRE CHARGE IND COMPUTER DATA LINES SYSTEM CURRENT SENSOR SIG DK GRN WIRE DRIVER INFORMATION CENTER (DIC) ENGINE CONTROL MODULE (ECM) (LEFT SIDE OF ENGINE COMPT) EXCEPT 4.3L FUSIBLE LINK 3 GENERATOR GENERATOR FIELD DUTY CYCLE SIG GENERATOR TURN ON SIG GMLAN SERIAL DATA GRY WIRE HOT W/ RUN/CRANK RELAY ENERGIZED IGN VOLT INSTRUMENT PANEL CLUSTER (IPC) IP CLSTR FUSE 10 LOGIC LOW REF LOW SPEED GMLAN SERIAL DATA PNK WIRE ORG/ WIRE PNK WIRE POWER DISTRIBUTION SYSTEM RED WIRE SENS SIG STARTING CIRCUIT TAN WIRE TAN/BLK WIRE UNDERHOOD FUSE BLOCK (ON LEFT SIDE OF ENGINE COMPT) WHT WIRE

6.6L 4.3L 4.8L, 5.3L, 6.0L 8 9 2500 2501 GMLAN (+) GMLAN (-) A/C CMPRSR FUSE 18 A/C COMPRSR RELAY 40 A/C LOW PRESSURE SWITCH (ON SIDE OF ACCUMULATOR) A/C REFRIGERANT PRESSURE SENSOR A/C REQUEST SIG BLK WIRE BODY CONTROL MODULE (BCM) (BEHIND LOWER RIGHT SIDE OF DASH) BODY FUSE BLOCK (UNDER LEFT FRONT SEAT) BRN WIRE COMPUTER DATA LINES SYSTEM DEF MAX A/C MIX-BLEND A/C FLOOR BI-LEV VENT LOGIC DEFOGGER, POWER MIRRORS DK GRN WIRE DK GRN/WHT WIRE ENGINE CONTROL MODULE (ECM) (LEFT SIDE OF ENGINE COMPT) GMLAN - GMLAN + GRY WIRE HOT AT ALL TIMES HOT W/ RUN/ HVAC 2 FUSE 13 HVAC CONTROL ASSEMBLY LT GRN WIRE OFF ORG/BLK WIRE TAN WIRE TAN/BLK WIRE UNDERHOOD FUSE BLOCK (ON LEFT SIDE OF ENGINE COMPT) W/ ELECTRIC REAR WINDOW

14 13 15 5 BRAKE LOW REF BRAKE SENS SIG 15 5 38 45 61 11 54 26 42 FUEL TEM SIG BRAKE APPLY SEN SIG LOW REF 43 44 28 27 SER DATA BUS(+) SER DATA BUS(-) 6.6L 53 57 40 59 32 16 3 65 35 63 5 6 ACCELERATOR PEDAL POSITION (APP) SENSOR (UNDER LEFT SIDE OF DASH) APP SEN 1 SIG LOW REF APP SEN 2 SIG LOW REF PPL AUTOMATIC TRANSMISSION (6 SPEED A/T) AUTOMATIC TRANSMISSION OUTPUT SHAFT SPEED (OSS) SENSOR AUTOMATIC TRANSMISSION OUTPUT SHAFT SPEED (OSS) SENSOR ASSEMBLY BATT + BCM 2 FUSE 58 BLK WIRE BLK/WHT WIRE BODY CONTROL MODULE (BCM) (BEHIND LOWER RIGHT SIDE OF DASH) BRAKE PEDAL POSITION (BPP) SENSOR (TOP OF BRAKE PEDAL ASSEMBLY) BRN WIRE BRN/WHT WIRE COMPUTER DATA LINES SYSTEM CONTROL SOLENOID VALVE ASSEMBLY CRUISE CONTROL IND DIMMING SIG CRUISE CONTROL SWITCH SIGNAL CRUISE IND CRUISE SWITCH DATA BUS - DATA BUS + VSS LOW SIG VSS HIGH SIG DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE ECM BATT FUSE 19 ENGINE CONTROL MODULE (ECM) GMLAN GROUND GRY WIRE HI SPD GMLAN SER DATA BUS- HOT AT ALL TIMES HOT W/ RUN/CRANK RELAY 15 ENERGIZED IGN INFLATABLE RESTRAINT STEERING WHEEL MODULE COIL (AT TOP OF STEERING COLUMN) INSTRUMENT PANEL CLUSTER (IPC) IPC FUSE 10 LEFT STEERING WHEEL CONTROL SWITCH LOGIC LT BLU WIRE LT GRN/BLK WIRE PNK WIRE PPL PPL/WHT WIRE RED WIRE RED/WHT WIRE RES+ SET- TAN WIRE TAN/BLK WIRE THROTTLE BODY (EXCEPT 6.6L) TP SENS 1 SIG LOW REF TP SENS 2 SIG TAC MOTOR CTRL 2 TAC MOTOR CTRL 1 TRANS- MISSIONS SYSTEM TRANSMISSION CONTROL MODULE (4 SPEED A/T) TRANSMISSION CONTROL MODULE (TCM) UNDERHOOD FUSE BLOCK (ON LEFT SIDE OF ENGINE COMPT) WHT WIRE WHT/BLK WIRE YEL WIRE

ABS IND. AIR BAG IND BLK WIRE BLK/WHT WIRE BODY CONTROL MODULE (BCM) (BEHIND LOWER RIGHT SIDE OF DASH) BODY FUSE BLOCK (UNDER LEFT BODY FUSE BLOCK (UNDER LEFT FRONT SEAT) BRAKE IND BRN WIRE BRN/WHT WIRE CHARGE IND CMPS FUSE 19 COMPUTER DATA LINES SYSTEM CRUISE IND DIESEL DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/WHT WIRE DRIVER INFORMATION CENTER (DIC) ENGINE COMPT) ENGINE CONTROLS SYSTEM SUPPLEMENTAL RESTRAINTS SYSTEM ENGINE COOLANT TEMPERATURE GAUGE FRONT SEAT) FUEL GAUGE GMLAN SERIAL GRY/BLK WIRE HIGH BEAM IND HOT AT ALL TIMES HOT W/ RUN RELAY HOT W/ RUN/CRANK RELAY 15 ENERGIZED IGN VOLT IND CTRL IND LAMP (MIL) INSTRUMENT PANEL CLUSTER (IPC) IP CLSTR FUSE 10 IP CLSTR FUSE 23 LEFT TURN IND LIFTGATE AJAR SW SIG LF DOOR AJAR SW RR DOOR OPEN SW LR DOOR OPEN SW LOGIC LOW ENGINE OIL LOW ENGINE OIL PRESSURE GAUGE LOW TIRE PRESSURE IND LT BLU WIRE LT GRN WIRE MALFUNCTION MIL CTRL NETWORK 3 ODOMETER PARK BRAKE SWITCH (UNDER LEFT SIDE OF DASH) PASS SEAT BELT PNK WIRE PNK/BLK WIRE PPL PPL PNK WIRE PRESSURE IND RED/WHT WIRE RF DOOR AJAR SW RIGHT TURN IND SEAT BELT IND SECURITY IND SEO FUSE 27 SPEEDOMETER SUPPLEMENTAL RESTRAINTS SYSTEM SW SIG SWITCH SIG TAN/WHT WIRE TOW/HAUL IND TRACTION CONTROL IND UNDERHOOD FUSE BLOCK (ON LEFT SIDE OF VOLTS GAUGE W/ ODOMETER SECURITY WIRING PROVISION (SEO) W/O ODOMETER SECURITY WIRING PROVISION (SEO) WAIT TO START IND WHT WIRE YEL WIRE YEL/BLK WIRE

1589 2759 PPL 31 16 LOW REF SENS SIG PPL 4.3L 4.8L/5.3L/6.0L 6.6L 50 41 36 35 SENS SIG BLK WIRE BLK/WHT WIRE BRAKE BOOSTER FLUID FLOW ALARM SWITCH (W/ BRAKE WARNING INDICATOR) BRAKE BOOSTER FLUID PRESSURE ALARM SWITCH (IN POWER STEERING PUMP INLET HOSE) BRAKE FLUID LEVEL SWITCH (AT LEFT REAR OF ENGINE COMPT) BRAKE PRESSURE BRN WIRE CARGO DOOR LATCH ASSEMBLY (W/ CARGO/PASSENGER) (IN RIGHT REAR CARGO DOOR) COMPUTER DATA LINES SYSTEM DIFFERENTIAL SWITCH (ON BRAKE VALVE, NEAR FRONT OF EBCM) DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/WHT WIRE DRIVER DOOR LATCH ASSEMBLY (AT REAR OF DRIVER DOOR) DRIVER INFORMATION CENTER (DIC) SWITCH ENGINE CONTROL MODULE (ECM) (LEFT SIDE OF ENGINE COMPT) ENGINE CONTROLS SYSTEM ENGINE OIL LEVEL SWITCH (ON LEFT SIDE OF OIL PAN) ENGINE OIL PRESSURE (EOP) SENSOR (EXCEPT 6.6L: ON TOP REAR OF ENGINE) EXCEPT 5.3L 5.3L FUEL LEVEL SENSOR (ON LEFT FRAME FUEL PUMP, SENDER ASSEMBLY (ON FUEL TANK) GRY WIRE GRY/BLK WIRE ILLUMI- NATION IND CTRL LEFT REAR SIDE DOOR JAMB SWITCH (W/ HINGED) (AT LEFT "B" PILLAR) LIGHT DUTY LOW REF LT BLU/BLK WIRE PASSENGER DOOR LATCH ASSEMBLY (AT REAR OF FRONT PASSENGER DOOR) PERSON- ALIZATION PNK WIRE PNK/BLK WIRE PPL PPL HEAVY DUTY PPL PNK WIRE RAIL) RIGHT REAR SIDE DOOR JAMB SWITCH (W/ CARGO/PASSENGER) (AT RIGHT "B" PILLAR) SENS SIG LOW REF SET/ RESET SWITCH SIG DATA LINK RESISTOR 44 43 TAN WIRE TAN/BLK WIRE TAN/WHT WIRE TRIP/ FUEL VEHICLE INFO W/ BRAKE WARNING INDICATOR SYSTEM WATER IN-FUEL SENSOR WHT WIRE YEL WIRE YEL/BLK WIRE

10 11 12 PPL 3-2 SHIFT SOL LOW REF BATTERY PPL PPL BLK WIRE BLK/WHT WIRE BLU WIRE BRN WIRE BRN/WHT WIRE CAMSHAFT POSITION SENSOR (PART OF DISTRIBUTOR, REAR TOP OF ENGINE) CKP SENS COMPUTER DATA LINES SYSTEM DK BLU WIRE DK BLU/WHT WIRE ECM-B FUSE ENG 1 FUSE ENGINE COOLANT TEMPERATURE SENSOR (ON TOP FRONT OF ENGINE) GROUND EGR GND GRY WIRE HOT AT ALL TIMES HOT IN RUN OR START INJ 1 INJ 6 INJ 4 INJ 7 INJ. #2 INJ. #3 KNOCK SENSOR (ON RIGHT SIDE OF ENGINE) KS #1 LOW REF LOW REF LOW REF LOW REF LOW REF EGR VALVE LT BLU/BLK WIRE LT GRN WIRE LT GRN/BLK WIRE NCA WIRE ORG/ WIRE ORG/BLK WIRE PNK PNK WIRE PNK WIRE PNK/BLK WIRE POWERTRAIN CONTROL MODULE (ON LEFT INNER FENDER) PPL PPL PNK WIRE PPL PPL PPL/WHT WIRE RED WIRE RED/BLK WIRE SOLID STATE TAN WIRE TAN/WHT WIRE TRANS PRES B TRANS PRES C IGN 1 BATTERY LOW REF TRANS SW A TCC BK SW TRANS SW P PPL TRANS SW B CMP SENSOR ECT SENSOR OFF/RUN/CRK INJ 5 INJ 8 UNDERHOOD FUSE BLOCK W/ W/ WHT WIRE YEL WIRE YEL/BLK WIRE

10 11 12 PPL 3-2 SHIFT SOL LOW REF BATTERY PPL PPL BLK WIRE BLK/WHT WIRE BLU WIRE BRN WIRE BRN/WHT WIRE CAMSHAFT POSITION SENSOR (PART OF DISTRIBUTOR, REAR TOP OF ENGINE) CKP SENS COMPUTER DATA LINES SYSTEM DK BLU WIRE DK BLU/WHT WIRE ECM-B FUSE ENG 1 FUSE ENGINE COOLANT TEMPERATURE SENSOR (ON TOP FRONT OF ENGINE) GROUND EGR GND GRY WIRE HOT AT ALL TIMES HOT IN RUN OR START INJ 1 INJ 6 INJ 4 INJ 7 INJ. #2 INJ. #3 KNOCK SENSOR (ON RIGHT SIDE OF ENGINE) KS #1 LOW REF LOW REF LOW REF LOW REF LOW REF EGR VALVE LT BLU/BLK WIRE LT GRN WIRE LT GRN/BLK WIRE NCA WIRE ORG/ WIRE ORG/BLK WIRE PNK PNK WIRE PNK WIRE PNK/BLK WIRE POWERTRAIN CONTROL MODULE (ON LEFT INNER FENDER) PPL PPL PNK WIRE PPL PPL PPL/WHT WIRE RED WIRE RED/BLK WIRE SOLID STATE TAN WIRE TAN/WHT WIRE TRANS PRES B TRANS PRES C IGN 1 BATTERY LOW REF TRANS SW A TCC BK SW TRANS SW P PPL TRANS SW B CMP SENSOR ECT SENSOR OFF/RUN/CRK INJ 5 INJ 8 UNDERHOOD FUSE BLOCK W/ W/ WHT WIRE YEL WIRE YEL/BLK WIRE