Chevrolet Cab & Chassis Silverado 3500 (2004-2007) Manual a/c circuit

A/C COMP CL RLY CTRL A/C COMPRESSOR CLUTCH A/C COMPRESSOR CLUTCH RELAY A/C LOW PRESSURE SWITCH (RIGHT SIDE OF ACCUMULATOR) A/C ON SWITCH A/C RECIRC A/C REF PRE SENS SIG A/C REFRIGERANT PRESSURE SENSOR (IN HIGH SIDE PRESSURE LINE) BLK WIRE BLK/WHT WIRE BLOWER FUSE BLOWER MOTOR (UNDER RIGHT SIDE OF DASH) BLOWER MOTOR CONTROL SWITCH BLOWER MOTOR RELAY BLOWER MOTOR RESISTOR ASSEMBLY (ON HVAC MODULE, NEAR BLOWER MOTOR) BRN WIRE BRN/WHT WIRE CLASS 2 SER DATA CLASS 2 SERIAL DATA DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE FRT DEF GRY WIRE HOT AT ALL TIMES HOT AT ALL TIMES A/C COMP FUSE HOT IN HOT IN RUN OR START IGN E FUSE HTR A/C FUSE HVAC 1 FUSE HVAC CONTROL MODULE (BEHIND CENTER OF DASH) HVAC/ ECAS FUSE I/P RELAY BLOCK (LEFT SIDE OF DASH) INST LAMP DIM CTRL GROUND LEFT I/P FUSE BLOCK (LOWER LEFT SIDE OF DASH) LEFT TEMP CONTROL LOGIC LOW REF LT BLU WIRE LT BLU/BLK WIRE LT GRN WIRE MODE CONTROL MODE DOOR CTRL MODE DOOR CTRL IGN 3 LOW REF B(+) OFF OFF BLOW MT CTRL LO PRESS SENS SIG RT TEMP DOOR CTRL LT TEMP DOOR CTRL ORG/ WIRE POWERTRAIN CONTROL MODULE OR ENGINE CONTROL MODULE (LEFT FRONT OF ENGINE COMPT) PPL RECIR DOOR CTRL RT TEMP DOOR CTRL LT TEMP DOOR CTRL RECIRC SWITCH RED WIRE RED/BLK WIRE RIGHT I/P FUSE BLOCK (LOWER RIGHT SIDE OF DASH) RIGHT TEMP CONTROL RUN WIRE TAN WIRE UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT, NEAR BATTERY) WHT WIRE WHT/BLK WIRE YEL WIRE

80 13 45 27 14 35 43 31 58 9 (GASOLINE) (DIESEL) A/C COMP CL RLY CTRL A/C COMP FUSE A/C COMPRESSOR CLUTCH A/C COMPRESSOR CLUTCH RELAY A/C LOW PRESSURE SWITCH (RIGHT SIDE OF ACCUMULATOR) A/C ON INDIC A/C ON SWITCH A/C REF PRE SENS SIG A/C REFRIGERANT PRESSURE SENSOR (ON HIGH PRESSURE HOSE) BLK WIRE BLK/WHT WIRE BLOWER FUSE BLOWER MOTOR (UNDER RIGHT SIDE OF DASH) BLOWER MOTOR CONTROL SWITCH BLOWER MOTOR RELAY BLOWER MOTOR RESISTOR ASSEMBLY (ON HVAC MODULE, NEAR BLOWER MOTOR) BRN WIRE BRN/WHT WIRE CLASS 2 SER DATA CLASS 2 SERIAL DATA DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE GROUND GRY WIRE HOT AT ALL TIMES HOT IN HOT IN RUN OR START HTR A/C FUSE HVAC 1 FUSE HVAC CONTROL MODULE (BEHIND CENTER OF DASH) HVAC/ ECAS FUSE I/P FUSE BLOCK (LOWER LEFT SIDE OF DASH) I/P JUNCTION BLOCK (LOWER RIGHT SIDE OF DASH) I/P RELAY BLOCK (LEFT SIDE OF DASH) IGN E FUSE INST LAMP DIM CTRL GROUND LEFT TEMP CONTROL LOGIC LOW REF LT BLU WIRE LT BLU/BLK WIRE LT GRN WIRE MODE CONTROL MODE DOOR CTRL IGN 3 LOW REF B(+) MODE DOOR PO SIG OFF BLOW MT CTRL LO PRESS SENS SIG RT TEMP DOOR CTRL LT TEMP DOOR CTRL ORG/ WIRE PPL RECIR DOOR CTRL RT TMP DOOR PO SIG LT TMP DOOR PO SIG RECIRC INDIC RECIRC SWITCH RED WIRE RED/BLK WIRE RIGHT TEMP CONTROL RUN WIRE TAN WIRE UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPARTMENT) WHT WIRE WHT/BLK WIRE YEL WIRE

BLK WIRE BODY CONTROL MODULE (LOWER LEFT SIDE OF DASH, BELOW STEERING COLUMN) BRN WIRE CLASS 2 SERIAL DATA DK BLU WIRE DK GRN WIRE LEFT AIR TEMPERATURE ACTUATOR (BOTTOM OF HVAC MODULE) LOGIC LT BLU WIRE LT BLU/BLK WIRE LT GRN WIRE MODE ACTUATOR (LEFT SIDE OF HVAC MODULE) RECIRCULATION ACTUATOR (UPPER RIGHT OF HVAC MODULE) LOGIC RIGHT AIR TEMPERATURE ACTUATOR (TOP OF HVAC MODULE) RIGHT I/P FUSE BLOCK (LOWER RIGHT SIDE OF DASH) TAN WIRE WHT/BLK WIRE YEL WIRE

AIR TEMPERATURE ACTUATOR (RIGHT) (TOP OF HVAC MODULE) BLK WIRE BODY CONTROL MODULE (LOWER LEFT SIDE OF DASH, BELOW STEERING COLUMN) BRN WIRE CLASS 2 SERIAL DATA DK BLU WIRE DK GRN WIRE I/P JUNCTION BLOCK (LOWER RIGHT SIDE OF DASH) LEFT AIR TEMPERATURE ACTUATOR (BOTTOM OF HVAC MODULE) LOGIC LT BLU WIRE LT BLU/BLK WIRE LT GRN WIRE MODE ACTUATOR (LEFT SIDE OF HVAC MODULE) RECIRCULATION ACTUATOR (TOP CENTER OF HVAC MODULE) LOGIC TAN WIRE WHT/BLK WIRE YEL WIRE

BLK WIRE BLU WIRE COOL/ FAN RELAY 1 COOL/ FAN RELAY 2 COOL/ FAN RELAY 3 COOL/FAN FUSE DK BLU WIRE DK GRN WIRE ENGINE COOLANT TEMPERATURE (ECT) SENSOR (ON LEFT CYLINDER HEAD) GRN WIRE GRY WIRE HOT AT ALL TIMES LEFT COOLING FAN POWERTRAIN CONTROL MODULE (PCM) RIGHT COOLING FAN UNDERHOOD COOLING FAN FUSE BLOCK (LEFT SIDE OF ENGINE COMPT) YEL WIRE