Chevrolet Cab & Chassis Silverado 3500 (2004-2007) power distribution system Wiring diagrams

8.1L ANTI-LOCK BRAKE SYSTEM AUXILIARY BATTERY RELAY (RIGHT REAR OF ENG COMPT) BATTERY BATTERY CABLE JUNCTION BLOCK (NEAR LEFT SIDE OF ENG) BATTERY NOT CHARGING BLK WIRE BLK/WHT WIRE BRN WIRE CHARGE INDICATOR CONTROL CLASS 2 SERIAL DATA COMPUTER DATA LINES SYSTEM DK BLU WIRE DK GRN WIRE DRIVER INFO CENTER EXCEPT 8.1L FUSE BLOCK MOBILE RADIO (UPFITTER OPTION) FUSIBLE LINK 1 (8 GA- FUSIBLE LINK 4 (14 GA- GRAY) FUSIBLE LINK 5 (10 GA- FUSIBLE LINK 6 (10 GA- GENERATOR B+ GENERATOR FIELD DUTY CYCLE SIGNAL GROUND GRY WIRE HOT IN RUN, START I/P RELAY BLOCK (NEAR LEFT KICK PANEL) IGN 1 VOLT IGN E FUSE INSTRUMENT PANEL CLUSTER LEFT BATTERY LOGIC MEGA FUSE PNK WIRE POWER DISTRIBUTION SYSTEM POWERTRAIN CONTROL MODULE (PCM) (ON LEFT FRONT OF ENGINE COMPARTMENT) RED WIRE RIGHT BATTERY RIGHT BATTERY (W/AUX BATTERY) SEO IGN FUSE SERIAL DATA CLASS 2 STARTER UNDERHOOD FUSE BLOCK (AT LEFT SIDE OF ENG COMPT) VOLTS W/ SEO W/AUX BATTERY W/DUAL BATTERIES W/O SEO WRECKER OPTION

A/T BLK WIRE CLUTCH CLUTCH START SWITCH SIGN CRANK FUSE CRANK SIGN DK GRN WIRE GRN WIRE IGN A FUSE IGN B FUSE IGN E FUSE IGNITION SWITCH LEFT BATTERY LOCK OFF M/T NCA WIRE PARK/NEUTRAL POSITION SWITCH (A/T) (ON LEFT SIDE OF TRANSMISSION) PNK PNK WIRE PNK WIRE POWER DISTRIBUTION POWER DISTRIBUTION SYSTEM PPL RED WIRE RED/WHT WIRE RUN WIRE STARTER MOTOR STARTER RELAY STARTER SOLENOID SWITCH (M/T) (ON TOP OF CLUTCH PEDAL BRACKET) SYSTEM UNDERHOOD FUSE BLOCK (AT LEFT SIDE OF ENG COMPT) UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENG COMPT) UNDERHOOD JUNCTION BLOCK (AT LEFT SIDE OF ENG COMPT) YEL WIRE YEL/BLK WIRE

3 2 1 PPL BLK WIRE BLK/WHT WIRE BODY CONTROL MODULE (ON LOWER LEFT SIDE OF DASH, BELOW STEERING COLUMN) BRN WIRE BRN/WHT WIRE CIG LTR FUSE DATA LINK CONNECTOR (DLC) (UNDER LEFT SIDE OF DASH, BELOW STEERING COLUMN) DIGITAL RADIO RECEIVER DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/WHT WIRE DRIVER DOOR MODULE (DDM) (IN LEFT FRONT DOOR) ELECTRONIC BRAKE CONTROL MODULE (EBCM) (ON LEFT SIDE OF INNER FRAME) EXCEPT 6.6L VIN 2 6.6L VIN 2 FRONT PASSENGER DOOR MODULE (FPDM) (IN RIGHT FRONT DOOR) GROUND DISTRIBUTION SYSTEM GRY WIRE HOT AT ALL TIMES HVAC CONTROL MODULE (BEHIND CENTER OF DASH) I/P RELAY BLOCK INFLATABLE RESTRAINT SENSING/DIAGNOSTIC MODULE (UNDER LEFT FRONT SEAT) INSTRUMENT PANEL CLUSTER (IPC) LEFT I/P FUSE BLOCK (UNDER LEFT SIDE OF DASH) LT BLU WIRE LT GRN WIRE LT GRN/BLK WIRE MEMORY SEAT MODULE (UNDERSIDE OF DRIVER SEAT) NEAR KICK PANEL) ORG/ WIRE PNK WIRE POWER DISTRIBUTION SYSTEM RADIO (AT CENTER OF DASH) REAR SEAT AUDIO (RSA) CONTROLLER (UNDER REAR OF CENTER CONSOLE) REAR SEAT ENTERTAINMENT (RSE) ASSEMBLY (AT CENTER OF HEADLINER) REMOTE PLAYBACK DEVICE-CD PLAYER (CENTER OF DASH, BELOW RADIO) RIGHT I/P FUSE BLOCK (UNDER RIGHT SIDE OF DASH) TAN WIRE TRANSFER CASE SHIFT CONTROL MODULE (BEHIND HEADLAMP SWITCH) TRANSMISSION CONTROL MODULE (AT LEFT FRONT OF ENG COMPT) UNDERHOOD FUSE BLOCK (AT LEFT SIDE OF ENGINE COMPT, NEAR BATTERY) VEHICLE COMMUNICATION INTERFACE MODULE (VCIM) (BEHIND PASSENGER AIR BAG MODULE) WHT WIRE YEL WIRE

3 2 1 PPL AUDIO AMPLIFIER (UNDER REAR OF CENTER CONSOLE) BLK WIRE BLK/WHT WIRE BODY CONTROL MODULE (ON LOWER LEFT SIDE OF DASH, BELOW STEERING COLUMN) BRN WIRE BRN/WHT WIRE CIG LTR FUSE DATA LINK CONNECTOR (DLC) (UNDER LEFT SIDE OF DASH, BELOW STEERING COLUMN) DIGITAL RADIO RECEIVER DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/WHT WIRE DRIVER DOOR MODULE (DDM) (IN LEFT FRONT DOOR) ELECTRONIC BRAKE CONTROL MODULE (EBCM) (ON LEFT SIDE OF INNER FRAME) EXCEPT 6.6L VIN 2 6.6L VIN 2 FRONT PASSENGER DOOR MODULE (FPDM) (IN RIGHT FRONT DOOR) GROUND DISTRIBUTION SYSTEM GRY WIRE HOT AT ALL TIMES HVAC CONTROL MODULE (BEHIND CENTER OF DASH) I/P RELAY BLOCK INFLATABLE RESTRAINT SENSING/DIAGNOSTIC MODULE (UNDER LEFT FRONT SEAT) INSTRUMENT PANEL CLUSTER (IPC) LEFT I/P FUSE BLOCK (UNDER LEFT SIDE OF DASH) LT BLU WIRE LT GRN WIRE LT GRN/BLK WIRE MEMORY SEAT MODULE (UNDERSIDE OF DRIVER SEAT) NEAR KICK PANEL) ORG/ WIRE PNK WIRE POWER DISTRIBUTION SYSTEM RADIO (AT CENTER OF DASH) REAR SEAT AUDIO (RSA) CONTROLLER (UNDER REAR OF CENTER CONSOLE) REAR SEAT ENTERTAINMENT (RSE) ASSEMBLY (AT CENTER OF HEADLINER) RIGHT I/P FUSE BLOCK (UNDER RIGHT SIDE OF DASH) TAN WIRE TRANSFER CASE SHIFT CONTROL MODULE (BEHIND HEADLAMP SWITCH) TRANSMISSION CONTROL MODULE (AT LEFT FRONT OF ENG COMPT) UNDERHOOD FUSE BLOCK (AT LEFT SIDE OF ENGINE COMPT, NEAR BATTERY) VEHICLE COMMUNICATION INTERFACE MODULE (VCIM) (BEHIND PASSENGER AIR BAG MODULE) WHT WIRE YEL WIRE

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 HALL A SIG HALL B SIG SENS GND POS 2 SIG 5 VOLT REF B+ VOLT B+ VOLT SERIAL DATA BASE BASE CASE GND GND B+ VOLT BLK WIRE BLK/WHT WIRE BODY CONTROL MODULE (ON LOWER LEFT SIDE OF DASH, BELOW STEERING COLUMN) BRN WIRE CASE GROUND COMPUTER DATA LINES SYSTEM CRUISE FUSE DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE FUSE GRY WIRE HALL A SIG HALL B SIG SENS GND HALL C SIG HALL C SIG RLY VOLT SENS GND POS 1 SIG 5 VOLT REF HOT AT ALL TIMES HOT IN HOT IN RUN LEFT I/P FUSE BLOCK IGN 3 FUSE I/P RELAY BLOCK (LOWER LEFT SIDE OF DASH) INSTRUMENT CLUSTER SYSTEM LOW REF LT BLU WIRE LT GRN WIRE MEGA FUSE MODE IND CTRL LAT ACCEL SIG ORG/ WIRE PHASE A CTRL PHASE B CTRL PHASE C CTRL PNK PNK WIRE PNK WIRE POS A SIG POS B SIG POWER DISTRIBUTION SYSTEM PPL PULSE SIG REAR WHEEL POSITION SENSOR (LEFT REAR OF VEHICLE) REAR WHEEL STEERING CONTROL MODULE (NEAR SPARE TIRE BRACKET) REAR WHEEL STEERING MODE SELECT SWITCH RED WIRE RLY GND RUN WIRE SENS SIG STEERING GEAR MOTOR ASSEMBLY (NEAR SPARE TIRE BRACKET) STEERING WHEEL SPEED/ POSITION SENSOR (ON STEERING COLUMN) TAN WIRE UNDERHOOD FUSE BLOCK UNDERHOOD FUSE HOLDER VSS IGN 3 VOLT YAW SENS SIG MODE SW SIG WHT WIRE YEL WIRE

AUX HTR PUMP FUSE AUX HTR PUMP RELAY AUXILIARY WATER PUMP (RIGHT SIDE OF ENGINE COMPT) BLK WIRE BLOWER FUSE BLOWER MOTOR (UNDER RIGHT SIDE OF DASH) BLOWER MOTOR CONTROL SWITCH BLOWER MOTOR RELAY BLOWER MOTOR RESISTOR ASSEMBLY (ON HVAC MODULE, NEAR BLOWER MOTOR) BRN WIRE COMPUTER DATA LINES SYSTEM HOT AT ALL TIMES HOT IN HVAC CONTROL MODULE (BEHIND CENTER OF DASH) HYBRID CONTROL MODULE (HCM) (LEFT SIDE OF ENGINE COMPT) HYBRID ONLY I/P FUSE BLOCK (LOWER LEFT I/P JUNCTION FUSE BLOCK (LOWER RIGHT SIDE OF DASH) IGN B FUSE LT BLU WIRE ORG/ WIRE PNK PNK POWER DISTRIBUTION SYSTEM WIRE PNK WIRE POWER DISTRIBUTION SYSTEM PPL PWR MAINT FUSE PWR MAINT RELAY RED WIRE RUN WIRE SECONDARY UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT) (HYBRID) SIDE OF DASH) HTR A/C FUSE STUD 1 FUSE TAN WIRE UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT) WHT WIRE YEL WIRE

2115 2713 1932 2353 1050 EXTERIOR LIGHTS SYSTEM ABS IND. AIR BAG IND BATTERY GROUND BLK WIRE BLK/WHT WIRE BODY CONTROL MODULE (BCM) (ON LOWER LEFT SIDE OF DASH, BELOW STEERING COLUMN) BRAKE IND BRN/WHT WIRE CHARGE CLASS 2 DATA COMPUTER DATA LINES SYSTEM COOLANT TEMP GAUGE CRUISE IND DIC MODE SW DIC TOGGLE SW DIC SW SIG DIC FUEL SIG DIESEL DK BLU WIRE DK GRN/WHT WIRE DRIVER INFORMATION CENTER (DIC) FOG LAMP IND FUEL GAUGE FUSE GRY WIRE HIGH BEAM IND HOT AT ALL TIMES HOT IN RUN OR START I/P DIM I/P RELAY BLOCK IGN E FUSE IGNITION IGNITION CLASS 2 DATA ILLUMINATION IND (MIL) MALFUNCTION INFO NOT AVAIL INSTRUMENT PANEL CLUSTER IPC SERIAL DATA IPC/DIC FUSE LAMP LEFT TURN LEFT TURN IND LOW FUEL IND LT BLU WIRE MESSAGE DISPLAY VARIABLE DIMMING MIL CNTRL WAIT TO START LO WASH FLUID VSS ENG SPEED SIG OIL GAUGE ORG/ WIRE ORN/ OVERDRIVE DEFEAT IND PNK PNK WIRE PNK WIRE POWER DISTRIBUTION SYSTEM RED WIRE RIGHT TURN BRAKE SEL SW PRK SIG RIGHT TURN IND SEAT BELT IND SECURITY IND SEO IGN FUSE SPEEDOMETER TACHOMETER TIRE PRESSURE IND TOW/HAUL IND TRACTION CONTROL IND TRANSMISSION TEMP GAUGE TRIP ODOMETER HOUR METER UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT) UPSHIFT IND VOLTS GAUGE WAIT TO START IND WASHER FLUID LEVEL SENSOR (IN WASHER FLUID RESERVOIR) WHT WIRE YEL WIRE

3-2 SS CTRL REF LOW A/C SYSTEM ANTI-LOCK BRAKES SYS 470 451 1671 1667 451 1669 1664 ANTI-LOCK BRAKES SYS 771 420 776 48 1744 846 1101 625 451 B+ CLS 2 DATA BLK WIRE BLK/ WHT WIRE BLK/WHT WIRE BRN WIRE BRN/WHT WIRE CFAN LO RLY INJ 7 CTRL INJ 4 CTRL COOLING FANS SYSTEM DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE ELECTRONIC SUSPENSION SYSTEM FUEL INJECTORS FUSE FUSE FUSE GRN WIRE GRY WIRE HOT AT ALL TIMES HOT IN ACCY, RUN, START HOT IN RUN, START I/P FUSE BLOCK (LOWER LEFT SIDE OF DASH) IGN 0 FUSE KS SIGNAL KS SIGNAL CKP SIG REQ TORQ SIG SERIAL DATA SERIAL DATA LT BLU WIRE LT BLU/BLK WIRE LT GRN WIRE LT GRN/BLK WIRE OIL LEV SW SIG ORG/ WIRE ORG/BLK WIRE PCMB FUSE PNK 1 2 3 4 5 WIRE PNK PNK 25 26 WIRE PNK PNK 6 7 WIRE PNK PNK WIRE PNK WIRE PNK/BLK WIRE PNK/WHT WIRE POWER DISTRIBUTION SYSTEM POWERTRAIN CONTROL MODULE (LEFT FRONT OF ENGINE COMPT) PPL PPL PPL PPL/WHT WIRE PRND B SIG CMP SIG ECT SIG IGN INJ 5 CTRL INJ 8 CTRL RANGE B RANGE C IGN B+ REF LOW RED WIRE RED/BLK WIRE REF LOW REF LOW (A/T) REF LOW REF LOW GND STARTING/ CHARGING SYSTEM TAN WIRE TAN/WHT WIRE UNDER- HOOD FUSE BLOCK (LEFT SIDE OF ENG COMPT) WHT WIRE YEL WIRE YEL/BLK WIRE

A/T ACCELERATOR PEDAL POSITION SENSOR BLK WIRE BLK/WHT WIRE BRN WIRE BUS - COMPUTER DATA LINES SYSTEM DK BLU WIRE DK BLU/WHT WIRE FUSIBLE LINK 3 GLOW PLUG 1 GLOW PLUG 2 GLOW PLUG 3 GLOW PLUG 4 GLOW PLUG 5 GLOW PLUG 6 GLOW PLUG 7 GLOW PLUG 8 GLOW PLUG CONTROL MODULE (GPM) GLOW PLUG FUSE GLOW PLUGS GRD GRY WIRE GRY/BLK WIRE HOT AT ALL TIMES IAH COMM 1 IAH COMM 2 IAH CURRENT SIG IAH SIG IAH TEMP SIG IAH VOLT SIG IGN 0 IGN 1 INTAKE AIR HEATER (IAH) MODULE LT BLU WIRE LT BLU/BLK WIRE LT GRN WIRE LT GRN/BLK WIRE M/T NCA WIRE ORG/ WIRE ORG/BLK WIRE PNK WIRE PNK/BLK WIRE POWER DISTRIBUTION SYSTEM PPL PPL 28 29 PPL/WHT WIRE RED WIRE RED/BLK WIRE RED/BLU WIRE RED/GRN WIRE RED/LT GRN WIRE RED/WHT WIRE TAN WIRE TAN/BLK WIRE WHT WIRE WHT/BLK WIRE WHT/BLU WIRE WHT/GRN WIRE WHT/LT GRN WIRE WHT/YEL WIRE YEL WIRE YEL/BLK WIRE

A/C SYSTEM ANTI-LOCK BRAKES SYS B+ CLS 2 DATA BLK WIRE BLK/ WHT WIRE BLK/WHT WIRE BRN WIRE BRN/WHT WIRE CMP SIG ECT SIG IGN INJ 5 CTRL INJ 8 CTRL PTO ENGAGE CRANKSHAFT POSITION (CKP) SENSOR (BEHIND LEFT VALVE COVER) DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE FUSE FUSE FUSE GRN WIRE GRY WIRE HOT AT ALL TIMES HOT IN ACCY, RUN, START HOT IN RUN, START I/P FUSE BLOCK (LOWER LEFT SIDE OF DASH) IGN 0 FUSE INJ 7 CTRL INJ 4 CTRL INJECTORS KS SIGNAL CKP SIG REQ TORQ SIG SERIAL DATA SERIAL DATA KS SIGNAL PTO STATUS LEV SW SIG LT BLU WIRE LT BLU/BLK WIRE LT GRN WIRE LT GRN/BLK WIRE M/T OIL LEV SW SIG PTO ENG KILL ORG/ WIRE ORG/BLK WIRE PCMB FUSE PNK IGN B+ REF LOW PTO ENABLE SW REF LOW GND WIRE PNK PNK 2 3 WIRE PNK PNK 27 28 WIRE PNK PNK 4 5 6 7 8 9 10 11 12 13 WIRE PNK WIRE PNK/BLK WIRE POWER DISTRIBUTION SYSTEM POWERTRAIN CONTROL MODULE (PCM) (LEFT FRONT OF ENGINE COMPT) PPL PPL BRK SW SIG P/N SIG CPP SW SIG INJ 1 CTRL INJ 6 CTRL PPL PPL PPL PPL 31 32 33 34 35 36 37 PPL/WHT WIRE RED/BLK WIRE REF LOW REF LOW GND RLY CTRL GND STARTING/ CHARGING SYSTEM TAN WIRE TAN/WHT WIRE UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENG COMPT) WHT WIRE YEL WIRE YEL/BLK WIRE