Chevrolet Cab & Chassis Silverado 3500 (2004-2007) a/c ref pre sens sig Wiring diagrams

A/C COMP CL RLY CTRL A/C COMPRESSOR CLUTCH A/C COMPRESSOR CLUTCH RELAY A/C LOW PRESSURE SWITCH (RIGHT SIDE OF ACCUMULATOR) A/C ON A/C RECIRC A/C REF PRE SENS SIG A/C REFRIGERANT PRESSURE SENSOR (IN HIGH SIDE PRESSURE LINE) AMBIENT AIR TEMPERATURE SENSOR (IN RIGHT FRONT BUMPER FILLER ASSEMBLY AUTO BLK WIRE BLK/WHT WIRE BLOWER FUSE BLOWER MOTOR (RIGHT SIDE OF DASH) BLOWER MOTOR CONTROL PROCESSOR (BEHIND RIGHT SIDE OF DASH) BRN WIRE BRN/WHT WIRE CLASS 2 SER DATA CLASS 2 SERIAL DATA DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE FAN DN FAN UP FRT DEF GROUND GROUND TEMP SEN ASS CTRL BLOWER SPEED CTRL GRY WIRE GRY/BLK WIRE HOT AT ALL TIMES HOT AT ALL TIMES A/C COMP FUSE HOT IN HOT IN RUN OR START IGN E FUSE HVAC 1 FUSE HVAC CONTROL MODULE (BEHIND CENTER OF DASH) HVAC/ ECAS FUSE I/P RELAY BLOCK (LEFT SIDE OF DASH) INSIDE AIR TEMPERATURE SENSOR ASSEMBLY (IN HEADLINER ABOVE DRIVER) INST LAMP DIM CTRL GROUND LEFT I/P FUSE BLOCK (LOWER LEFT SIDE OF DASH) LEFT TEMP CONTROL LO PRESS SENS SIG RT TEMP DOOR CTRL LT TEMP DOOR CTRL LOGIC LOW REF LOWER LEFT AIR TEMPERATURE SENSOR (LEFT END OF HVAC MODULE) LOWER RIGHT AIR TEMPERATURE SENSOR (BOTTOM OF HVAC MODULE) LT BLU WIRE LT BLU/BLK WIRE LT GRN WIRE LT GRN/BLK WIRE MODE MODE DOOR CTRL MODE DOOR CTRL IGN 3 LOW REF B(+) OFF ORG/ WIRE POWERTRAIN CONTROL MODULE OR ENGINE CONTROL MODULE (LEFT FRONT OF ENGINE COMPT) PPL PPL/WHT WIRE RECIR RECIR DOOR CTRL RT TEMP DOOR CTRL LT TEMP DOOR CTRL RED WIRE RED/BLK WIRE RIGHT I/P FUSE BLOCK (LOWER RIGHT SIDE OF DASH) RIGHT TEMP CONTROL RUN WIRE SPEED CTRL B(+) GROUND TAN WIRE UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT, NEAR BATTERY) UPPER LEFT AIR TEMPERATURE SENSOR (BELOW DASH TRIM PANEL) UPPER RIGHT AIR TEMPERATURE SENSOR (BELOW DASH TRIM PANEL) WHT WIRE WHT/BLK WIRE YEL WIRE

80 13 45 27 14 35 43 31 58 9 (GASOLINE) (DIESEL) A/C COMP CL RLY CTRL A/C COMP FUSE A/C COMPRESSOR CLUTCH A/C COMPRESSOR CLUTCH RELAY A/C IND A/C LOW PRESSURE SWITCH (RIGHT SIDE OF ACCUMULATOR) A/C ON A/C RECIRC A/C REF PRE SENS SIG A/C REFRIGERANT PRESSURE SENSOR (ON HIGH PRESSURE HOSE) AIR TEMPERATURE SENSOR (LOWER LEFT) (LOWER LEFT FLOOR DUCT ASSEMBLY) AIR TEMPERATURE SENSOR (LOWER RIGHT) (BOTTOM OF HVAC MODULE) AIR TEMPERATURE SENSOR (UPPER LEFT) (BELOW DASH TRIM PANEL) AIR TEMPERATURE SENSOR (UPPER RIGHT) (BELOW DASH TRIM PANEL) AMBIENT AIR TEMPERATURE SENSOR (IN RIGHT FRONT BUMPER FILLER ASSEMBLY AUTO BLK WIRE BLK/WHT WIRE BLOWER MOTOR (RIGHT SIDE OF DASH) BLOWER MOTOR CONTROL PROCESSOR (BEHIND RIGHT SIDE OF DASH) BLWR FUSE BRN WIRE BRN/WHT WIRE CLASS 2 SER DATA CLASS 2 SERIAL DATA DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE FAN DN FAN UP FRT DEF GROUND GROUND TEMP SEN ASSY CTRL BLOWER SPEED CTRL GRY WIRE GRY/BLK WIRE HOT AT ALL TIMES HOT IN HOT IN RUN OR START HVAC 1 FUSE HVAC CONTROL MODULE (BEHIND CENTER OF DASH) HVAC/ ECAS FUSE I/P FUSE BLOCK (LOWER LEFT SIDE OF DASH) I/P JUNCTION BLOCK (LOWER RIGHT SIDE OF DASH) I/P RELAY BLOCK (NEAR LEFT KICK PANEL) IGN E FUSE INSIDE AIR TEMPERATURE SENSOR ASSEMBLY (IN HEADLINER ABOVE DRIVER) INST LAMP DIM CTRL GROUND LEFT TEMP CONTROL LO PRESS SENS SIG RT TEMP DOOR CTRL LT TEMP DOOR CTRL LOGIC LOW REF LT BLU WIRE LT BLU/BLK WIRE LT GRN WIRE LT GRN/BLK WIRE MODE MODE DOOR CTRL IGN 3 LOW REF B(+) MODE DOOR PO SIG OFF ORG/ WIRE PPL PPL/WHT WIRE RECIR RECIR DOOR CTRL RT TMP DOOR PO SIG LT TMP DOOR PO SIG RED WIRE RED/BLK WIRE RIGHT I/P FUSE BLOCK (LOWER RIGHT SIDE OF DASH) RIGHT TEMP CONTROL RUN WIRE SPEED CTRL B(+) GROUND TAN WIRE UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT) WHT WIRE WHT/BLK WIRE YEL WIRE

80 13 45 21 14 33 43 41 58 15 (GASOLINE) (DIESEL) A/C COMP CL RLY CTRL A/C COMPRESSOR CLUTCH A/C COMPRESSOR CLUTCH RELAY A/C LOW PRESSURE SWITCH (RIGHT SIDE OF ACCUMULATOR) A/C ON A/C RECIRC A/C REF PRE SENS SIG A/C REFRIGERANT PRESSURE SENSOR (IN HIGH SIDE PRESSURE LINE) AMBIENT AIR TEMPERATURE SENSOR (IN RIGHT FRONT BUMPER FILLER ASSEMBLY AUTO BLK WIRE BLK/WHT WIRE BLOWER MOTOR (RIGHT SIDE OF DASH) BLOWER MOTOR CONTROL PROCESSOR (BEHIND RIGHT SIDE OF DASH) BLWR FUSE BRN WIRE BRN/WHT WIRE CLASS 2 SER DATA CLASS 2 SERIAL DATA DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE FAN DN FAN UP FRT DEF GROUND GROUND TEMP SEN ASS CTRL BLOWER SPEED CTRL GRY WIRE GRY/BLK WIRE HOT AT ALL TIMES HOT AT ALL TIMES A/C COMP FUSE HOT IN HOT IN RUN OR START IGN E FUSE HVAC 1 FUSE HVAC CONTROL MODULE (BEHIND CENTER OF DASH) HVAC/ ECAS FUSE I/P FUSE BLOCK (LOWER LEFT SIDE OF DASH) I/P JUNCTION BLOCK (LOWER RIGHT SIDE OF DASH) I/P RELAY BLOCK (LEFT SIDE OF DASH) INSIDE AIR TEMPERATURE SENSOR ASSEMBLY (IN HEADLINER ABOVE DRIVER) INST LAMP DIM CTRL GROUND LEFT TEMP CONTROL LO PRESS SENS SIG RT TEMP DOOR CTRL LT TEMP DOOR CTRL LOGIC LOW REF LOWER LEFT AIR TEMPERATURE SENSOR (LEFT END OF HVAC MODULE) LOWER RIGHT AIR TEMPERATURE SENSOR (BOTTOM OF HVAC MODULE) LT BLU WIRE LT BLU/BLK WIRE LT GRN WIRE LT GRN/BLK WIRE MODE MODE DOOR CTRL MODE DOOR CTRL IGN 3 LOW REF B(+) OFF ORG/ WIRE POWERTRAIN CONTROL MODULE OR ENGINE CONTROL MODULE (LEFT FRONT OF ENGINE COMPT) PPL PPL/WHT WIRE RECIR RECIR DOOR CTRL RT TEMP DOOR CTRL LT TEMP DOOR CTRL RED WIRE RED/BLK WIRE RIGHT I/P FUSE BLOCK (LOWER RIGHT SIDE OF DASH) RIGHT TEMP CONTROL RUN WIRE SPEED CTRL B(+) GROUND TAN WIRE UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT, NEAR BATTERY) UPPER LEFT AIR TEMPERATURE SENSOR (BELOW DASH TRIM PANEL) UPPER RIGHT AIR TEMPERATURE SENSOR (BELOW DASH TRIM PANEL) WHT WIRE WHT/BLK WIRE YEL WIRE

80 13 45 27 14 35 43 31 58 9 (GASOLINE) (DIESEL) A/C COMP CL RLY CTRL A/C COMP FUSE A/C COMPRESSOR CLUTCH A/C COMPRESSOR CLUTCH RELAY A/C LOW PRESSURE SWITCH (RIGHT SIDE OF ACCUMULATOR) A/C ON SWITCH A/C REF PRE SENS SIG A/C REFRIGERANT PRESSURE SENSOR (ON HIGH PRESSURE HOSE) BLK WIRE CLASS 2 SER DATA LO PRESS SENS SIG CLASS 2 SERIAL DATA DK BLU WIRE DK GRN WIRE GRY WIRE HOT AT ALL TIMES HOT IN RUN OR START HVAC CONTROL MODULE (BEHIND CENTER OF DASH) IGN E FUSE LOGIC LOW REF RED WIRE UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPARTMENT) WHT WIRE

A/C COMP CL RLY CTRL A/C COMPRESSOR CLUTCH A/C COMPRESSOR CLUTCH RELAY A/C LOW PRESSURE SWITCH (RIGHT SIDE OF ACCUMULATOR) A/C ON SWITCH A/C RECIRC A/C REF PRE SENS SIG A/C REFRIGERANT PRESSURE SENSOR (IN HIGH SIDE PRESSURE LINE) BLK WIRE BLK/WHT WIRE BLOWER FUSE BLOWER MOTOR (UNDER RIGHT SIDE OF DASH) BLOWER MOTOR CONTROL SWITCH BLOWER MOTOR RELAY BLOWER MOTOR RESISTOR ASSEMBLY (ON HVAC MODULE, NEAR BLOWER MOTOR) BRN WIRE BRN/WHT WIRE CLASS 2 SER DATA CLASS 2 SERIAL DATA DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE FRT DEF GRY WIRE HOT AT ALL TIMES HOT AT ALL TIMES A/C COMP FUSE HOT IN HOT IN RUN OR START IGN E FUSE HTR A/C FUSE HVAC 1 FUSE HVAC CONTROL MODULE (BEHIND CENTER OF DASH) HVAC/ ECAS FUSE I/P RELAY BLOCK (LEFT SIDE OF DASH) INST LAMP DIM CTRL GROUND LEFT I/P FUSE BLOCK (LOWER LEFT SIDE OF DASH) LEFT TEMP CONTROL LOGIC LOW REF LT BLU WIRE LT BLU/BLK WIRE LT GRN WIRE MODE CONTROL MODE DOOR CTRL MODE DOOR CTRL IGN 3 LOW REF B(+) OFF OFF BLOW MT CTRL LO PRESS SENS SIG RT TEMP DOOR CTRL LT TEMP DOOR CTRL ORG/ WIRE POWERTRAIN CONTROL MODULE OR ENGINE CONTROL MODULE (LEFT FRONT OF ENGINE COMPT) PPL RECIR DOOR CTRL RT TEMP DOOR CTRL LT TEMP DOOR CTRL RECIRC SWITCH RED WIRE RED/BLK WIRE RIGHT I/P FUSE BLOCK (LOWER RIGHT SIDE OF DASH) RIGHT TEMP CONTROL RUN WIRE TAN WIRE UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT, NEAR BATTERY) WHT WIRE WHT/BLK WIRE YEL WIRE

80 13 45 27 14 35 43 31 58 9 (GASOLINE) (DIESEL) A/C COMP CL RLY CTRL A/C COMP FUSE A/C COMPRESSOR CLUTCH A/C COMPRESSOR CLUTCH RELAY A/C LOW PRESSURE SWITCH (RIGHT SIDE OF ACCUMULATOR) A/C ON INDIC A/C ON SWITCH A/C REF PRE SENS SIG A/C REFRIGERANT PRESSURE SENSOR (ON HIGH PRESSURE HOSE) BLK WIRE BLK/WHT WIRE BLOWER FUSE BLOWER MOTOR (UNDER RIGHT SIDE OF DASH) BLOWER MOTOR CONTROL SWITCH BLOWER MOTOR RELAY BLOWER MOTOR RESISTOR ASSEMBLY (ON HVAC MODULE, NEAR BLOWER MOTOR) BRN WIRE BRN/WHT WIRE CLASS 2 SER DATA CLASS 2 SERIAL DATA DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE GROUND GRY WIRE HOT AT ALL TIMES HOT IN HOT IN RUN OR START HTR A/C FUSE HVAC 1 FUSE HVAC CONTROL MODULE (BEHIND CENTER OF DASH) HVAC/ ECAS FUSE I/P FUSE BLOCK (LOWER LEFT SIDE OF DASH) I/P JUNCTION BLOCK (LOWER RIGHT SIDE OF DASH) I/P RELAY BLOCK (LEFT SIDE OF DASH) IGN E FUSE INST LAMP DIM CTRL GROUND LEFT TEMP CONTROL LOGIC LOW REF LT BLU WIRE LT BLU/BLK WIRE LT GRN WIRE MODE CONTROL MODE DOOR CTRL IGN 3 LOW REF B(+) MODE DOOR PO SIG OFF BLOW MT CTRL LO PRESS SENS SIG RT TEMP DOOR CTRL LT TEMP DOOR CTRL ORG/ WIRE PPL RECIR DOOR CTRL RT TMP DOOR PO SIG LT TMP DOOR PO SIG RECIRC INDIC RECIRC SWITCH RED WIRE RED/BLK WIRE RIGHT TEMP CONTROL RUN WIRE TAN WIRE UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPARTMENT) WHT WIRE WHT/BLK WIRE YEL WIRE

80 13 45 21 14 33 43 41 58 15 (GASOLINE) (DIESEL) A/C COMP CL RLY CTRL A/C COMPRESSOR CLUTCH A/C COMPRESSOR CLUTCH RELAY A/C LOW PRESSURE SWITCH (RIGHT SIDE OF ACCUMULATOR) A/C ON SWITCH A/C RECIRC A/C REF PRE SENS SIG A/C REFRIGERANT PRESSURE SENSOR (IN HIGH SIDE PRESSURE LINE) BLK WIRE BLK/WHT WIRE BLOWER FUSE BLOWER MOTOR (UNDER RIGHT SIDE OF DASH) BLOWER MOTOR CONTROL SWITCH BLOWER MOTOR RELAY BLOWER MOTOR RESISTOR ASSEMBLY (ON HVAC MODULE, NEAR BLOWER MOTOR) BRN WIRE BRN/WHT WIRE CLASS 2 SER DATA CLASS 2 SERIAL DATA DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE FRT DEF GRY WIRE HOT AT ALL TIMES HOT AT ALL TIMES A/C COMP FUSE HOT IN HOT IN RUN OR START IGN E FUSE HTR A/C FUSE HVAC 1 FUSE HVAC CONTROL MODULE (BEHIND CENTER OF DASH) HVAC/ ECAS FUSE I/P FUSE BLOCK (LOWER LEFT SIDE OF DASH) I/P JUNCTION BLOCK (LOWER RIGHT SIDE OF DASH) I/P RELAY BLOCK (LEFT SIDE OF DASH) INST LAMP DIM CTRL GROUND LEFT TEMP CONTROL LOGIC LOW REF LT BLU WIRE LT BLU/BLK WIRE LT GRN WIRE MODE CONTROL MODE DOOR CTRL MODE DOOR CTRL IGN 3 LOW REF B(+) OFF OFF BLOW MT CTRL LO PRESS SENS SIG RT TEMP DOOR CTRL LT TEMP DOOR CTRL ORG/ WIRE POWERTRAIN CONTROL MODULE OR ENGINE CONTROL MODULE (LEFT FRONT OF ENGINE COMPT) PPL RECIR DOOR CTRL RT TEMP DOOR CTRL LT TEMP DOOR CTRL RECIRC SWITCH RED WIRE RED/BLK WIRE RIGHT TEMP CONTROL RUN WIRE TAN WIRE UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT, NEAR BATTERY) WHT WIRE WHT/BLK WIRE YEL WIRE