Chevrolet Cab & Chassis Silverado 3500 HD (2008-2011) power distribution system Wiring diagrams

AUTOMATIC TRANSMISSION AUTOMATIC TRANSMISSION FLUID TEMPERATURE (TFT) SENSOR AUTOMATIC TRANSMISSION FLUID TEMPERATURE (TFT) SENSOR SIGNAL AUX HVAC- IGN FUSE 45 BATT + GND BRAKE PEDAL SIG BLK/WHT WIRE COMPUTER DATA LINES SYSTEM CONTROL SOLENOID VALVE ASSEMBLY DK BLU WIRE DRIVER INFORMATION CENTER (DIC) DISPLAY ENGINE CONTROL MODULE (ECM) (LEFT FRONT OF ENGINE COMPT, NEAR FAN SHROUD) FUSE 19 GROUND DISTRIBUTION SYSTEM HOT AT ALL TIMES HOT W/ RUN/CRNK RELAY ENERGIZED IGN INSTRUMENT CLUSTER PANEL (IPC) LEFT I/P JUNCTION BLOCK LOGIC LOW REFERENCE LT BLU/WHT WIRE LT GRN/BLK WIRE MISC-IGN FUSE 43 ORG/BLK WIRE PC SOLENOID 1 CONTROL PC SOLENOID 2 CONTROL PC SOLENOID 3 CONTROL PC SOLENOID 4 CONTROL PC SOLENOID 5 CONTROL PNK IGN WIRE PNK PNK ANTI-LOCK BRAKES SYSTEM WIRE PNK PNK PNK PNK WIRE PNK WIRE POWER DISTRIBUTION SYSTEM PPL/WHT WIRE PRESSURE CONTROL (PC) SOLENOID VALVE 1 PRESSURE CONTROL (PC) SOLENOID VALVE 2 PRESSURE CONTROL (PC) SOLENOID VALVE 3 PRESSURE CONTROL (PC) SOLENOID VALVE 4 PRESSURE CONTROL (PC) SOLENOID VALVE 5 RED/WHT WIRE REPLICATED TOS SIGNAL SHIFT SOLENOID (SS) 1 CONTROL SHIFT SOLENOID (SS) 2 CONTROL SHIFT SOLENOID (SS) VALVE 1 SHIFT SOLENOID (SS) VALVE 2 STOP LAMP SWITCH (TOP OF BRAKE PEDAL ASSEMBLY) TAN WIRE TAN/BLK WIRE TAN/WHT WIRE TCM- BATT FUSE 14 TO AUTOMATIC TRANSMISSION INTERNAL MODE SWITCH (IMS) (DIAGRAM 2 OF 2) TORQUE CONVERTER CLUTCH (TCC) PRESSURE CONTROL (PC) SOLENOID VALVE TORQUE CONVERTER CLUTCH PRESSURE CONTROL SOLENOID CONTROL TOW/ HAUL IND TRANSMISSION CONTROL MODULE (TCM) UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT) VEHICLE SPEED SENSOR (VSS) (ON TRANSFER CASE TAILSHAFT HOUSING) VSS SIG W/0 2 SPEED TRANSFER CASE

2 MODE HYBRID 6 SPEED A/T 4.3L EXCEPT 4.3L 6.6L ALLISON TRANSMISSION 6 SPEED A/T AUTOMATIC TRANSMISSION AUTOMATIC TRANSMISSION FLUID PRESSURE (TFP) MANUAL VALVE POSITION SWITCH AUTOMATIC TRANSMISSION INTERNAL MODE SWITCH (IMS) BLK WIRE BODY CONTROL MODULE (BCM) (LOWER LEFT SIDE OF DASH) COMPUTER DATA LINES SYSTEM CONTROL SOLENOID VALVE ASSEMBLY DATA BUS - ENGINE CONTROL MODULE (ECM) (LEFT FRONT OF ENGINE COMPT) HEAD IGN IGNITION SWITCH LOCK MEGA FUSE ORG/ WIRE ORG/BLK WIRE PARK/ NEUTRAL POSITION (PNP) SWITCH (ON LEFT REAR SIDE OF TRANSMISSION) PARK/NEUTRAL SIGNAL PNK/BLK WIRE POWER DISTRIBUTION SYSTEM POWER SUPPLY PPL RED WIRE RED/BLK WIRE RIGHT BATTERY RUN WIRE STARTER MOTOR STRT RLY CTRL STRTR FUSE 62 (EXCEPT 6.6L) FUSE 57 (6.6L) TAN WIRE TAN/BLK WIRE TRANSMISSION CONTROL MODULE (TCM) TRANSMISSION CONTROL MODULE (TCM) (LEFT FRONT OF ENGINE COMPT, NEAR FAN SHROUD) UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT) STRTR RELAY WHT WIRE YEL WIRE YEL/BLK WIRE

12 VOLT REF 12-VOLT REF ANGLE SENSOR PHASE B CAN BUS LOW SERIAL DATA 12-VOLT REF LF WHEEL SPD SENS SIG 16 17 2500 2501 COMPUTER DATA BUS + DATA BUS - DATA LINES SYSTEM 2501 2501 COMPUTER DATA LINES SYSTEM 3 5 SENS PHASE A SENS PHASE C 5-VOLT REF VEHICLE SPEED SIGNAL CAN BUS HIGH SERIAL DATA ABS INDICATOR ABS-1 FUSE 61 (GAS) FUSE 56 (DIESEL) BLK WIRE BLK/ WHT WIRE BLK/WHT WIRE BODY CONTROL MODULE (BCM) (LOWER LEFT SIDE OF DASH) BRAKE FLUID LEVEL SWITCH (ON BRAKE MASTER CYLINDER RESERVOIR) BRAKE PRESSURE MODULATOR VALVE BRAKE WARNING INDICATOR BRN WIRE COMPUTER DATA LINES SYSTEM DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE ELECTRONIC BRAKE CONTROL MODULE (EBCM) (ON LEFT SIDE OF FRAME ASSEMBLY) EXCEPT LUXURY GAS GROUND GRY WIRE GRY/BLK WIRE GRY/WHT WIRE HI SERIAL DATA HOT AT ALL TIMES I/P MULTI-FUNCTION SWITCH INSTRUMENT PANEL CLUSTER (IPC) IPC FUSE LEFT I/P JUNCTION BLOCK (LOWER LEFT SIDE OF DASH) LEFT REAR WHEEL SPEED SENSOR (WSS) (ON LEFT REAR BRAKE BACKING PLATE) LO SERIAL DATA LOGIC LOW REF 12-VOLT REF LT BLU WIRE LT BLU/BLK WIRE LT GRN WIRE LT GRN/BLK WIRE LUXURY NCA WIRE ORG/BLK WIRE ORG/WHT WIRE PARK BRAKE SW SIG PARK BRAKE SWITCH (ON PARK BRAKE PEDAL ASSEMBLY) POWER DISTRIBUTION SYSTEM PPL PPL BRAKE SW SIG RED/BLK WIRE RED/WHT WIRE RIGHT REAR WHEEL SPEED SENSOR (WSS) (ON RIGHT REAR BRAKE BACKING PLATE) SENS PHASE B SERIAL DATA SERIAL DATA BATTERY POSITIVE VOLTAGE SERIAL DATA BUS (+) SERIAL DATA BUS (+) BATTERY POSITIVE VOLTAGE SERIAL DATA BUS- SERIAL DATA BUS- GROUND SIG TAN WIRE TAN/BLK WIRE TAN/WHT WIRE TRACTION CONTROL SWITCH SIGNAL TRACTION CTRL SW SIG VEHICLE SPD SIG RADIO YAW RATE, LATERAL ACCELERATION SENSOR (UNDER CENTER CONSOLE TRIM PANEL) YEL WIRE YEL/BLK WIRE

12 VOLT REF 12-VOLT REF RF WHEEL SPD SENS SIG GROUND ABS INDICATOR ABS-1 FUSE 61 (GAS) FUSE 56 (DIESEL) BLK WIRE BLK/WHT WIRE BODY CONTROL MODULE (BCM) (LOWER LEFT SIDE OF DASH) BRAKE FLUID LEVEL SWITCH (ON BRAKE MASTER CYLINDER RESERVOIR) BRAKE PRESSURE MODULATOR VALVE BRAKE WARNING INDICATOR COMPUTER DATA LINES SYSTEM DATA BUS - DIESEL GAS DK GRN WIRE DK GRN/WHT WIRE ELECTRONIC BRAKE CONTROL MODULE (EBCM) (ON LEFT SIDE OF FRAME ASSEMBLY) ENGINE CONTROL MODULE (ECM) (LEFT FRONT OF ENGINE COMPT) EXCEPT LUXURY GAS GRY WIRE GRY/WHT WIRE HEAVY DUTY ABS FUSE 59 (GAS) FUSE 55 (DIESEL) HOT AT ALL TIMES HOT AT ALL TIMES UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT) INSTRUMENT PANEL CLUSTER (IPC) IPC FUSE LEFT FRONT WHEEL SPEED SENSOR (WSS) (ON LEFT FRONT STEERING KNUCKLE) LEFT I/P JUNCTION BLOCK (LOWER LEFT SIDE OF DASH) LOGIC LT BLU WIRE LT BLU/BLK WIRE LUXURY NCA WIRE NEAR FAN SHROUD) ORG/ WIRE ORG/WHT WIRE PARK BRAKE SW SIG PARK BRAKE SWITCH (ON PARK BRAKE PEDAL ASSEMBLY) POWER DISTRIBUTION SYSTEM PPL PPL BRAKE SW SIG RED WIRE RED/BLK WIRE RED/WHT WIRE RIGHT FRONT WHEEL SPEED SENSOR (WSS) (ON RIGHT FRONT STEERING KNUCKLE) SERIAL DATA SIG TAN WIRE TAN/BLK WIRE VEHICLE SPD SIG VEHICLE SPD SIG RADIO YEL WIRE YEL/BLK WIRE

12-VOLT REF 12-VOLT REF LR SIG WHEEL SPD SENS 12-VOLT REF LF WHEEL SPD SENS SIG 16 17 2500 2501 COMPUTER DATA LINES SYSTEM DATA BUS + DATA BUS - 2 4 3 1 SERIAL DATA 12-VOLT SERIAL DATA LOW REF 2150 2501 2501 COMPUTER DATA LINES SYSTEM 2500 2500 COMPUTER DATA LINES SYSTEM 3 4 5 6 SENS PHASE A SENS PHASE B SENS PHASE C 35 36 37 38 SERIAL DATA 6032 (OR 817) ABS INDICATOR ABS-1 FUSE 61 ABS-2 FUSE 9 BLK WIRE BLK/WHT WIRE BODY CONTROL MODULE (BCM) (LOWER LEFT SIDE OF DASH) BRAKE BOOSTER VACUUM SENSOR (LEFT REAR OF ENGINE COMPT) BRAKE FLUID LEVEL SWITCH (ON BRAKE MASTER CYLINDER RESERVOIR) BRAKE PRESSURE MODULATOR VALVE BRAKE WARNING INDICATOR BRN WIRE CAN BUS HIGH SERIAL DATA GROUND COMPUTER DATA LINES SYSTEM DATA SERIAL DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE ELECTRONIC BRAKE CONTROL MODULE (EBCM) (ON LEFT SIDE OF FRAME ASSEMBLY) EXCEPT 4.3L EXCEPT LUXURY GAS GRY WIRE GRY/BLK WIRE GRY/WHT WIRE HOT AT ALL TIMES HOT AT ALL TIMES UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT) I/P MULTI-FUNCTION SWITCH (W/ ACTIVE BRAKE CONTROL) INSTRUMENT PANEL CLUSTER (IPC) IPC FUSE LEFT FRONT WHEEL SPEED SENSOR (WSS) (ON LEFT FRONT STEERING KNUCKLE) LEFT I/P JUNCTION BLOCK (LOWER LEFT SIDE OF DASH) LEFT REAR WHEEL SPEED SENSOR (WSS) (ON LEFT REAR BRAKE BACKING PLATE) LF WHEEL SPD SENS SIG LOGIC LOW REF LT BLU WIRE LT BLU/BLK WIRE LT GRN WIRE LT GRN/BLK WIRE LUXURY NCA WIRE ORG/ WIRE ORG/BLK WIRE ORG/WHT WIRE PARK BRAKE SWITCH (ON PARK BRAKE PEDAL ASSEMBLY) PARK BRK SW POWER DISTRIBUTION SYSTEM PPL RADIO RED WIRE RED/BLK WIRE RED/WHT WIRE RF SIG WHEEL SPD SENS RIGHT FRONT WHEEL SPEED SENSOR (WSS) (ON RIGHT FRONT STEERING KNUCKLE) SENSOR PHASE A 5-VOLT REF BOOSTER VACUUM SENS SIG SIG STEERING ANGLE SENS SIG STOP LAMP SWITCH (TOP OF BRAKE PEDAL ASSEMBLY) TAN WIRE TAN/BLK WIRE TAN/WHT WIRE TRACTION CONTROL SWITCH SIGNAL TRACTION CTRL SW SIG 12 13 812 7062 12-VOLT REF PPL BRAKE SW SIG VEH SPD SIGNAL VEHICLE SPD SIG VEHICLE SPD SIG LOW REF GROUND SERIAL DATA BUS- SERIAL DATA BUS- W/ ACTIVE BRAKE CONTROL W/O ACTIVE BRAKE CONTROL WHT WIRE YAW RATE, LATERAL ACCELERATION SENSOR (W/ ACTIVE BRAKE CONTROL) YEL WIRE YEL/BLK WIRE

12 VOLT REFERENCE BAT POS VOLT BLK WIRE BLK/WHT WIRE BODY CONTROL MODULE (BCM) (LOWER LEFT SIDE OF DASH) COMPUTER DATA LINES SYSTEM DK GRN WIRE GROUND HOT AT ALL TIMES I/P FUSE BLOCK (LEFT SIDE OF DASH, LT GRN WIRE OUTSIDE IGN MOISTURE VOLT SENSOR SIGNAL OUTSIDE MOISTURE SENSOR SIGNAL OUTSIDE MOISTURE SIG 1 OUTSIDE MOISTURE SIG 2 POWER DISTRIBUTION SYSTEM RED/WHT WIRE RIGHT I/P JUNCTION BLOCK (IN RIGHT END OF DASH) RT STOP TRN FUSE 8 SERIAL DAT TAN WIRE WHT WIRE WINDSHIELD OUTSIDE MOISTURE SENSOR (NEAR INSIDE REARVIEW MIRROR MOUNT)

2-HI IND 4-HI IND 4-LO IND 5 VOLT INCRMT ENCODER SIG 7475 7476 1693 1566 1565 PPL ACCY WAKEUP SRL DATA ASSEMBLY AUX HVAC-IGN FUSE 48 FUSE 45 AXLE ACTR CTRL AXLE SW SIG GMLAN BUS - GMLAN BUS + IGN VOLT BLK WIRE BLK/WHT WIRE BODY CONTROL MODULE (BCM) (LOWER LEFT SIDE OF DASH) BRN WIRE COMPUTER DATA LINES SYSTEM DIRTN SIG DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE FRONT AXLE ACTUATOR FUSE 19 FUSE 13 GAS GAS DIESEL GMLAN BUS - GMLAN BUS + INCRMT ENCODER SIG GRY WIRE GRY/BLK WIRE HOT AT ALL TIMES HOT W/ RUN/CRNK RELAY ENERGIZED HOT W/ RUN/CRNK RELAY ENERGIZED UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT) IGN IGN LOGIC INSTRUMENT PANEL CLUSTER (IPC) LEFT I/P JUNCTION BLOCK (LOWER LEFT SIDE OF DASH) LO REF SW SIG 4 HI IND CTRL 4 LO IND CTRL LOGIC LOW REF LT BLU WIRE LT GRN/BLK WIRE LT GRN/DK BLU WIRE MISC IGN FUSE 43 FUSE 40 MTR CTRL B MTR CTRL A BATT + GND NEUTRAL IND NEUTRAL IND 2 HI IND CTRL ORG/ WIRE PNK WIRE POWER DISTRIBUTION SYSTEM PPL PPL/WHT WIRE PULSE SIG RED/BLK WIRE SHIFT MOTOR TAN WIRE TAN/BLK WIRE TAN/WHT WIRE TRANSFER CASE ENCODER MOTOR (ON TRANSFER CASE) TRANSFER CASE SHIFT CONTROL MODULE (LOWER LEFT SIDE OF DASH) TRANSFER CASE SHIFT CONTROL SWITCH (ON TOP LEFT OF TRANSFER CASE) TREC FUSE 67 FUSE 62 WHT WIRE WHT/GRN WIRE YEL WIRE

1 2 3 4 9 10 BATTERY (+) BATTERY (+) BATTERY (+) BATTERY (+) GROUND BATTERY (+) 14 15 RIGHT REAR DOOR AJAR SW LEFT REAR DOOR AJAR SW 5 4 13 9 LOW REF LF OPEN SIG LF AJAR SIG LO SPD DATA 9 5 13 LO SPD DATA LOW REF RF AJAR SIG BCM FUSE BLK WIRE BLK/WHT WIRE BODY CONTROL MODULE (BCM) (LOWER LEFT SIDE OF DASH) COMPUTER DATA LINES SYSTEM CREW CAB CTSY FUSE DIM FUSE DK GRN WIRE DOOR) PNK WIRE DRIVER DOOR LATCH ASSEMBLY (IN REAR OF DRIVER FRONT DRIVER DOOR LOCK/ WINDOW SWITCH FRONT DOOR) GRY/BLK WIRE HEAD HEAD OFF AUTO PARK HEADLAMP, PANEL DIMMER SWITCH HOT AT ALL TIMES I/P FUSE BLOCK (LEFT SIDE IS LPS FUSE LEFT REAR DOOR LATCH ASSEMBLY (REAR OF LEFT REAR DOOR) LT BLU WIRE LT BLU/BLK WIRE LT GRN WIRE LT GRN/BLK WIRE LT STOP TRN FUSE OF DASH) OFF AUTO PARK PARK BRAKE SW SIGNAL PASSENGER DOOR LATCH ASSEMBLY (IN REAR OF PASSENGER PASSENGER DOOR LOCK/ WINDOW SWITCH PNK IGN III WIRE POWER DISTRIBUTION SYSTEM RED/WHT WIRE RIGHT I/P JUNCTION BLOCK (IN RIGHT END OF DASH) RIGHT REAR DOOR LATCH ASSEMBLY (REAR OF RIGHT REAR DOOR) RT STOP TRN FUSE STOP LAMPS FUSE TAN WIRE TAN/BLK WIRE TAN/WHT WIRE WHT WIRE YEL WIRE

1 2 3 4 5 6 7 8 9 10 11 12 13 14 B+ 1 8 13 B+ LOW REF LO SPD DATA BLK WIRE BLK/WHT WIRE BLU WIRE BRAKE IND CHIME MODULE (CENTER OF DASH, BEHIND RADIO) DK GRN WIRE DLIS FUSE 35 FUSE 32 DRIVER SEAT BELT BUCKLE DRIVER SEAT BELT SW SIG DRIVER SEAT BELT SWITCH GAS DIESEL HOT AT ALL TIMES IGNITION SWITCH INFLATABLE RESTRAINT SENSING, DIAGNOSTIC MODULE (SDM) (UNDER DRIVER'S SEAT) INSTRUMENT PANEL CLUSTER (IPC) IPC FUSE 46 FUSE 43 KEY-IN IGNITION SWITCH LEFT I/P JUNCTION BLOCK (LOWER LEFT SIDE OF DASH) LO SPD GMLAN SERIAL DATA LOGIC LOW REF LOW TIRE PRESSURE IND LT BLU WIRE NCA WIRE PARK BRAKE SWITCH (ON PARK BRAKE PEDAL ASSEMBLY) PNK LOW REF WIRE PNK PNK SUPPLEMENTAL RESTRAINTS SYSTEM WIRE PNK WIRE POWER DISTRIBUTION SYSTEM PPL RADIO RDO FUSE 42 FUSE 39 RED/WHT WIRE SEAT BELT IND SERIAL DATA SOUND SYSTEMS SPLICE PACK TAN WIRE TAN/WHT WIRE UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT) W/ LUXURY EDITION W/ RADIO PROVISIONS W/O RADIO PROVISIONS WHT WIRE

1 2 3 4 5 6 7 8 9 10 11 12 13 14 B+ 1 8 13 B+ LOW REF LO SPD DATA BLK WIRE BLK/WHT WIRE BLU WIRE BRAKE IND CHIME MODULE (CENTER OF DASH, BEHIND RADIO) DK GRN WIRE DLIS FUSE 35 FUSE 32 DRIVER SEAT BELT BUCKLE DRIVER SEAT BELT SW SIG DRIVER SEAT BELT SWITCH GAS DIESEL HOT AT ALL TIMES IGNITION SWITCH INFLATABLE RESTRAINT SENSING, DIAGNOSTIC MODULE (SDM) (UNDER DRIVER'S SEAT) INSTRUMENT PANEL CLUSTER (IPC) IPC FUSE 46 FUSE 43 KEY-IN IGNITION SWITCH LEFT I/P JUNCTION BLOCK (LOWER LEFT LO SPD GMLAN SERIAL DATA LOGIC LOW REF LOW TIRE PRESSURE IND LT BLU WIRE NCA WIRE PARK BRAKE SWITCH (ON PARK BRAKE PEDAL ASSEMBLY) PNK LOW REF WIRE PNK PNK SUPPLEMENTAL RESTRAINTS SYSTEM WIRE PNK WIRE POWER DISTRIBUTION SYSTEM PPL RADIO RDO FUSE 42 FUSE 39 RED WIRE RED/WHT WIRE SEAT BELT IND SERIAL DATA SIDE OF DASH) SOUND SYSTEMS TAN WIRE TAN/WHT WIRE UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT) W/ LUXURY EDITION W/ RADIO PROVISIONS W/O RADIO PROVISIONS WHT WIRE