Chevrolet Cab & Chassis Silverado 3500 HD (2008-2011) hvac control module Wiring diagrams

2 OF 6) AIR BAG BATT FUSE 45 ALC/COMP FUSE 58 AMP FUSE 41 AUTOMATIC A/C AUX PWR 2 FUSE AUX PWR FUSE BLK WIRE BODY CONTROL MODULE (BCM) CENTER CONSOLE ACCESSORY POWER OUTLET CENTER CONSOLE COMPARTMENT ACCESSORY POWER OUTLET CHIME POWER MODULE TAKE OFF (PTO) RELAY COMFORT, DECOR LEVEL 3 CONVENIENCE PACKAGE CREW CAB W/ INDIVIDUAL FRONT SEAT REAR SEAT ENT FUSE LOCK/UNLOCK PCB RELAY ESC/ALC EXH FUSE 2 EXP/PTO FUSE 47 FROM AUXILIARY BATTERY RUN RELAY (DIAGRAM 1 OF 6) FROM FSCM FUSE 21 (DIAGRAM 2 OF 6) GARAGE DOOR OPENER (GDO) HVAC CONTROL MODULE I/P 2 ACCESSORY POWER OUTLET I/P FUSE BLOCK (LEFT SIDE OF DASH) TO LT DR CIRCUIT BREAKER (DIAGRAM INFLATABLE RESTRAINT VEHICLE ROLLOVER SENSOR INFO FUSE LBEC 1 FUSE 64 LEFT I/P J/B (LOWER LEFT SIDE OF DASH) LGM FUSE 71 LUXURY EDITION MERCHANDISED PACKAGE MANUAL A/C NCA WIRE OF HVAC MODULE) ORG/ WIRE PDM FUSE (W/ COMFORT, DECOR LEVEL 3 CONVENIENCE PACKAGE, LUXURY) POWER LOCKS W/O INDIVIDUAL FRONT SEAT, POWER MIRROR POWER TAKE OFF (BLUNT CUT) PREMIUM AUDIO BRANDED W/ AMPLIFIER SPEAKER SYSTEM RADIO RDO FUSE 42 REAR SEAT AUDIO (RSA) CONTROL (IF EQUIPPED) RED WIRE RED/BLK WIRE RED/WHT WIRE RIGHT I/P J/B (IN RIGHT END OF DASH) RIGHT I/P J/B (IN RIGHT END OF DASH) CENTER SEAT ACCESSORY POWER OUTLET STOP IS LPS FUSE LT STOP TRN FUSE LAMPS FUSE TO BODY CONTROL MODULE (DIAGRAM 4 OF 6) TO DLIS FUSE 35 (DIAGRAM 4 OF 6) TO LEFT I/P BLOCK (DIAGRAM 2 OF 6) PASSENGER DOOR LOCK/ WINDOW SWITCH UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT) UNLOCK PCB LOCK PCB RELAY RELAY VEHICLE COMMUNICATION INTERFACE MODULE (VCIM) VIDEO DISPLAY PERFORMANCE ENHANCED AUDIO W/ CUSTOM CONSOLE FRONT COMPT FLOOR W/ HEAD CURTAIN AIR BAG W/ INDIVIDUAL FRONT SEAT, POWER MIRROR W/ LUXURY W/ REAR SEAT ENTERTAIN- MENT PACKAGE W/ UNIVERSAL GARAGE DOOR OPENER W/ W/O LUXURY LUXURY W/ WRECKER, EMERGENCY VEHICLE ROOF LAMP, ROOF BEACON RELAY W/O LUXURY W/O LUXURY W/ LUXURY W/O RADIO W/O W/ LUXURY LUXURY WHT WIRE WINDSHIELD WASHER SOLVENT HEATER (IF EQUIPPED)

2 OF 5) AIR BAG BATT FUSE 42 ALC/COMP FUSE 54 AMP FUSE 38 AUDIO AMPLIFIER (PREMIUM AUDIO BRANDED W/ AMPLIFIER SPEAKER SYSTEM) AUTOMATIC A/C AUX PWR 2 FUSE 2 AUX PWR FUSE 16 BLK WIRE BODY CONTROL MODULE (BCM) CENTER CONSOLE ACCESSORY POWER OUTLET CENTER CONSOLE COMPARTMENT ACCESSORY POWER OUTLET CENTER SEAT ACCESSORY POWER OUTLET CHIME POWER TAKE OFF MODULE (PTO) RELAY CREW CAB W/ INDIVIDUAL FRONT SEAT CREW CAB/ EXTENDED CAB W/ PERFORMANCE EXHANCED AUDIO, FRONT COMPARTMENT CONSOLE DIGITAL RADIO RECEIVER (IF EQUIPPED) ESC/ALC EXH FUSE 1 FROM HEAVY ABS-2 FUSE 8 (DIAGRAM 2 OF 5) FROM LEFT I/P J/B (DIAGRAM 2 OF 5) FROM LT DR CIRCUIT BREAKER (DIAGRAM GARAGE DOOR OPENER (GDO) HVAC CONTROL MODULE I/P 2 ACCESSORY POWER OUTLET INFO FUSE 22 LBEC 2 FUSE 67 LEFT I/P J/B (LOWER LEFT SIDE OF DASH) LGM FUSE 66 LOCK PCB UNLOCK PCB RELAY RELAY LOCK/UNLOCK PCB RELAY MANUAL A/C NCA WIRE ORG/ WIRE PASSENGER DOOR LOCK/ WINDOW SWITCH PDM FUSE 9 (W/ COMFORT, DECOR LEVEL 3 CONVENIENCE PACKAGE) PERFORMANCE ENHANCED AUDIO POWER LOCKS W/O INDIVIDUAL FRONT SEAT, POWER MIRROR POWER TAKE OFF (BLUNT CUT) PREMIUM AUDIO BRANDED W/ AMPLIFIER SPEAKER SYSTEM PTO FUSE 44 RADIO RDO FUSE 39 REAR SEAT AUDIO (RSA) CONTROL (IF EQUIPPED) RED WIRE RED/ WHT WIRE RED/BLK WIRE RED/WHT WIRE RIGHT I/P J/B (IN RIGHT END OF DASH) RSE FUSE 19 STOP IS LPS FUSE 17 LT STOP TRN FUSE 6 LAMPS FUSE TO BODY CONTROL MODULE (DIAGRAM 4 OF 5) TO DLIS FUSE 32 (DIAGRAM 4 OF 5) UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT) VEHICLE COMMUNICATION INTERFACE MODULE (VCIM) VIDEO DISPLAY W/ CUSTOM FRONT COMPARTMENT FLOOR CONSOLE W/ FULL FEATURE CENTER CONSOLE W/ INDIVIDUAL FRONT SEAT, POWER MIRROR W/ LUXURY W/ ONSTAR W/ REAR SEAT ENTERTAIN- MENT PACKAGE W/O LUXURY W/O LUXURY, RADIO W/O RADIO W/O W/ LUXURY LUXURY WHT RED/ WIRE WHT WIRE WINDSHIELD WASHER SOLVENT HEATER (IF EQUIPPED)

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 AIR TMP 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 B(+) A/C ON AIR TEMP RF SUNLD AMB AIR TMP GMLAN L AMBIENT AIR TEMPERATURE SENSOR (ON LEFT SIDE OF RADIATOR SUPPORT) AMBIENT LIGHT/SUNLOAD SENSOR ASSEMBLY (TOP CENTER OF DASH) AUTO BATT POS VOLT BLK WIRE BLK/WHT WIRE BREAKOUT) BRN WIRE COLNT LVL GROUND LOW REF COMPUTER DATA LINES SYSTEM DK BLU WIRE DK GRN WIRE DRIVER INFORMATION CENTER (DIC) DISPLAY ENGINE COOLANT LEVEL SWITCH (6.6L) (ON BOTTOM OF SURGE TANK) EVAPORATOR TEMPERATURE SENSOR (ON HVAC ASSEMBLY) FAN DN FAN UP FRESH AIR FRNT DFG FRT DEF A/C IND FSH AIR GROUND GROUND DISTRIBUTION SYSTEM GROUND IGN 3 REAR DEFOG GRY WIRE GRY/BLK WIRE HVAC CONTROL MODULE INSTRUMENT PANEL CLUSTER (IPC) LEFT I/P JUNCTION BLOCK (LOWER LEFT SIDE OF DASH) LEFT SUNLOAD SENSOR LEFT TEMP CONTROL LF SUNLD L AIR TMP R AIR TMP LOGIC LOW REF LT BLU WIRE LT BLU/BLK WIRE LT GRN WIRE LT GRN/BLK WIRE MODE DN MODE UP MTR SPD CTRL OFF ORG/ WIRE POWER DISTRIBUTION SYSTEM DEFOGGER SYSTEM PPL R AIR TMP AIR TMP R AIR TMP TEMP SENS MODE CTRL L AIR TMP RECIR CTRL R AIR TMP REAR DFG RECIR RECIRC RED/BLK WIRE RED/WHT WIRE RER DEF RIGHT I/P JUNCTION BLOCK (IN RIGHT END OF DASH) RIGHT SUNLOAD SENSOR RIGHT TEMP CONTROL SERIAL DATA TAN WIRE UPPER LEFT AIR TEMPERATURE SENSOR (UNDER UPPER LEFT SIDE OF DASH) UPPER RIGHT AIR TEMPERATURE SENSOR (UNDER UPPER RIGHT SIDE OF DASH) WHT WIRE WHT/BLK WIRE YEL WIRE YEL/BLK WIRE

1 5 B(+) GMLAN L 2501 2500 COMPUTER DATA LINES SYSTEM 3340 5060 COMPUTER DATA LINES SYSTEM 4.3L 6.6L EXCEPT 4.3L, 6.6L 4.3L A/C CMPRSR FUSE 17 (EXCEPT 6.6L) FUSE 16 (6.6L) A/C CMPRSR RELAY A/C IND A/C ON A/C REFRIGERANT PRESSURE SENSOR (NEAR COMPRESSOR, ON A/C HIGH PRESSURE HOSE) BLK WIRE DK GRN WIRE DK GRN/WHT WIRE ENGINE CONTROL MODULE (ECM) (LEFT FRONT OF ENGINE COMPT, NEAR FAN SHROUD) GROUND GRY WIRE HOT AT ALL TIMES HVAC BATT FUSE 39 (EXCEPT 6.6L) FUSE 36 (6.6L) HVAC CONTROL MODULE LOGIC MANUAL A/C AUTOMATIC A/C ORG/BLK WIRE RED/WHT WIRE TAN WIRE TAN/BLK WIRE UNDER- HOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT)

2 OR MORE OF W/ ONSTAR, AUDIO AMPLIFIER (IF EQUIPPED) (UNDER REAR OF CENTER CONSOLE) BLK WIRE BLK/WHT WIRE BODY CONTROL MODULE (BCM) (LOWER LEFT SIDE OF DASH) CHIME MODULE (CENTER OF DASH, BEHIND RADIO) DATA LINK CONNECTOR (DLC) (LOWER LEFT SIDE OF DASH) DIGITAL RADIO RECEIVER (BEHIND RIGHT END OF DASH) DIGITAL RADIO RECEIVER (IF EQUIPPED) (BEHIND RIGHT END OF DASH) DIGITAL RADIO, REAR SEAT, DK GRN WIRE DRIVER DOOR LOCK/WINDOW SWITCH DRIVER'S SEAT EARPHONE JACKS RADIO CONTROL GROUND DISTRIBUTION SYSTEM HEATED SEAT CONTROL MODULE (W/ SPO HEATED SEATS) HOT AT ALL TIMES HVAC CONTROL MODULE I/P FUSE BLOCK (LEFT SIDE OF DASH, INFLATABLE RESTRAINT SENSING, DIAGNOSTIC MODULE (SDM) (UNDER INSTRUMENT PANEL CLUSTER (IPC) LEFT I/P JUNCTION BLOCK (LOWER LEFT SIDE OF DASH) LOW SPD GMLAN SER DATA LOW SPEED GMLAN SERIAL DATA LOW SPEED SERIAL DATA LTR FUSE 53 (EXCEPT 6.6L) FUSE 50 (6.6L) MEMORY SEAT MODULE (W/ INDIVIDUAL FRONT SEAT) (UNDER FRONT OF NOT USED NOT USED PASSENGER DOOR LOCK/WINDOW SWITCH POWER DISTRIBUTION SYSTEM RADIO REAR OBJECT SENSOR CONTROL MODULE (AT REAR CARGO AREA, BEHIND TRIM PANEL) REAR SEAT AUDIO (RSA) CONTROL REAR SEAT AUDIO (RSA) CONTROL (IF EQUIPPED) RED/WHT WIRE REMOTE CONTROL DOOR LOCK RECEIVER (RCDLR) (TOP REAR OF PASSENGER COMPT) RIGHT I/P JUNCTION BLOCK (IN RIGHT END OF DASH) TAN WIRE TAN/BLK WIRE THEFT DETERRENT CONTROL MODULE (TDM) (ON RIGHT SIDE OF STEERING COLUMN) UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT) VEHICLE COMMUNICATION INTERFACE MODULE (VCIM) (BEHIND CENTER OF DASH) W/ DIGITAL RADIO W/ DIGITAL RADIO, REAR SEAT, ONSTAR, EARPHONE JACKS RADIO CONTROL W/ FRONT SEAT, REMOTE CONTROL W/ INDIVIDUAL FRONT SEAT W/ LUXURY EDITION W/ ONSTAR W/ RADIO PROVISIONS W/ REAR SEAT, EARPHONE JACKS RADIO CONTROL W/ REMOTE KEYLESS ENTRY W/O INDIVIDUAL FRONT SEAT W/O LUXURY EDITION W/O RADIO PROVISIONS WHT WIRE

6.6L EXCEPT 6.6L, 4.3L 4.3L AUTOMATIC A/C MANUAL A/C BLK WIRE BLK/WHT WIRE COLNT LVL COMPUTER DATA LINES SYSTEM COOLING FAN DIODE 1 COOLING FAN DIODE 2 DK BLU/WHT WIRE DK GRN WIRE ENGINE CONTROL MODULE (ECM) (LEFT FRONT OF ENGINE COMPT, NEAR FAN SHROUD) ENGINE COOLANT LEVEL SWITCH (6.6L) (ON BOTTOM OF SURGE TANK) EXCEPT 6.6L, 6.0L (VIN K) FAN CNTRL RELAY FAN HI RELAY FAN LO RELAY FAN-1 FUSE 57 FAN-2 FUSE 60 GMLAN L GRY WIRE HOT AT ALL TIMES HVAC CONTROL MODULE LEFT COOLING FAN (LEFT FRONT OF ENGINE COMPT) LOGIC LT BLU WIRE LT GRN WIRE ORG/BLK WIRE PWR/ TRN RELAY RIGHT COOLING FAN (RIGHT FRONT OF ENGINE COMPT) TAN WIRE TAN/BLK WIRE UNDER- HOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT) YEL WIRE

ACCESSORY DC POWER CONTROL MODULE AUTOMATIC A/C MANUAL A/C 15 10 BARE BLK WIRE BLOWER MOTOR CONTROL MODULE BREAKOUT) CENTER CONSOLE ACCESSORY POWER OUTLET CENTER CONSOLE COMPARTMENT ACCESSORY POWER OUTLET CENTER HIGH MOUNTED STOP LAMP (CHMSL) DATA LINK CONNECTOR (DLC) DRIVER INFORMATION CENTER (DIC) SWITCH ELECTRONIC ELECTRONIC ADJUSTABLE PEDALS PCB RELAY ELECTRONIC COMPASS MODULE EXTENDED CAB/CREW CAB FROM HORN SWITCH HVAC CONTROL MODULE INSIDE REARVIEW MIRROR (ISRVM) LEFT I/P JUNCTION BLOCK (LOWER LEFT SIDE OF DASH) LEFT STEERING WHEEL CONTROL SWITCH MIDDLE LEFT FRONT ROOF FRONT CLEARANCE OUTER LAMP ROOF CLEARANCE LAMP NCA WIRE PARK ENABLE PCB RELAY PASSENGER OUTSIDE REAR VIEW MIRROR PASSENGER WINDOW SWITCH PASSENGER DOOR LOCK/ WINDOW SWITCH REAR DOME READING LAMPS RIGHT FRONT OUTER ROOF CLEARANCE LAMP RIGHT I/P JUNCTION BLOCK (IN RIGHT END OF DASH) RIGHT STEERING WHEEL CONTROL SWITCH RIGHT SUNSHADE (IF EQUIPPED) SUNROOF MODULE SUNROOF SWITCH TO SPLICE TRANSFER CASE SHIFT CONTROL SWITCH W/ ACCESSORY STEERING CONTROL W/ ACCESSORY STEERING CONTROL, W/ ODOMETER SECURITY WIRING PROVISIONS W/ BODY BUILDER EMERGENCY LAMP W/ COMFORT, DECOR LEVEL 3 W/ LUXURY EDITION W/ MANUAL FOLDING MIRROR, HEATED MIRROR W/ MANUAL FOLDING MIRROR, HEATED MIRROR (IN RIGHT FRONT DOOR HARNESS) W/ ROOF MARKER LAMP W/ ROOF MOUNTED LAMP PROVISIONS W/ STEERING WHEEL HEATER, ACCESSORY STEERING CONTROL, AUTOMATIC CRUISE CONTROL W/ STEERING WHEEL HEATER, AUTOMATIC CRUISE CONTROL W/ SUNROOF ROOF LAMP PROVISION W/ SUNROOF ROOF LAMP PROVISION W/O ROOF MARKER LAMP W/ SUNROOF SLIDING W/ WRECKER EMERGENCY LAMP W/O STEERING WHEEL HEATER W/O STEERING WHEEL HEATER, ACCESSORY STEERING CONTROL, AUTOMATIC CRUISE CONTROL WHT WIRE

AMBIENT LIGHT SENSOR AMBIENT LIGHT/ SUNLOAD SENSOR AUTOMATIC A/C AUTOMATIC A/C MANUAL A/C 8 3 AUTOMATIC TRANSMISSION SHIFT LEVER BLK WIRE BLK/WHT WIRE BODY CONTROL MODULE (BCM) BRAKE FLUID LEVEL SWITCH DATA LINK CONNECTOR DOOR LOCK CONTROL DRIVER DOOR LATCH DRIVER DOOR LOCK SWITCH DRIVER DOOR LOCK/ WINDOW SWITCH DRIVER WINDOW SWITCH EXCEPT HYBRID FRONT DOOR LOCK DIODE FRONT DOOR UNLOCK DIODE HEADLAMP, PANEL I/P DIMMER MULTI-FUNCTION SWITCH SWITCH HVAC CONTROL MODULE HYBRID, W/O NON BUCKET FRONT INDIVIDUAL SEAT I/P FUSE BLOCK (LEFT SIDE OF DASH, INSTRUMENT PANEL CLUSTER (IPC) LEFT I/P JUNCTION BLOCK (LOWER LEFT SIDE OF DASH) MANUAL A/C NCA WIRE PASSENGER DOOR LATCH PASSENGER DOOR LOCK SWITCH PASSENGER SEAT ADJUSTER SWITCH PASSENGER SEAT LUMBAR SWITCH POWER WINDOW REAR DOOR LOCK DIODE REAR DOOR UNLOCK DIODE RIGHT I/P JUNCTION BLOCK (IN RIGHT END OF DASH) THEFT DETERRENT MODULE TURN SIGNAL/ MULTI-FUNCTION SWITCH W/ NON BUCKET FRONT INDIVIDUAL SEAT W/ POWER W/O W/O NON BUCKET, FRONT INDIVIDUAL SEAT, W/ COMFORT, DECOR LEVEL 3 W/O POWER DOOR LOCK CONTROL WHT WIRE WINDSHIELD WIPER MOTOR

1 2 4 10 5 7 RETRACT CTRL EXTEND CTRL SENS SIG LOW REF SENS SIG 2 6 1 7 3 9 4 POSITION CTRL MTR COMM POSITION CTRL SPLY VOLT LOW REF 4 6 B+ GND 9 2 12 SERIAL DATA PNK WIRE BLK WIRE BRN WIRE COMPUTER DATA LINES SYSTEM COMPUTER DATA LINES SYSTEM ELECTROCHROMIC DDM FUSE 4 DEFOGGER SWITCH DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/WHT WIRE DOWN L/R SELECT DRIVER DOOR LOCK/ WINDOW SWITCH DRIVER OUTSIDE REARVIEW MIRROR ELECTRO- CHROMIC EXTEND GRY WIRE HOT AT ALL TIMES HVAC CONTROL MODULE I/P FUSE BLOCK (LEFT SIDE OF DASH, L/R SELECT SW PWR LEFT LOGIC LT BLU WIRE MIRROR CIRCUIT OUTSIDE REARVIEW MIRROR SWITCH PNK WIRE RED/WHT WIRE RETRACT RIGHT WHT WIRE YEL WIRE

6.6L EXCEPT 6.6L, 4.3L 4.3L BLK WIRE EXCEPT 6.6L 6.6L HOT AT ALL TIMES HVAC CONTROL MODULE LOGIC MANUAL A/C AUTOMATIC A/C POWER DISTRIBUTION SYSTEM PPL REAR DEFOG FUSE 50 FUSE 47 REAR DEFOG RELAY REAR DEFOGGER IND REAR DEFOGGER SWITCH REAR WINDOW DEFOGGER GRID RED WIRE RED/BLK WIRE UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT) WHT WIRE