Chevrolet Cab & Chassis Silverado 3500 HD (2008-2011) computer data lines system Wiring diagrams

1 2 4 10 5 7 RETRACT CTRL EXTEND CTRL SENS SIG LOW REF SENS SIG 2 6 1 7 3 9 4 POSITION CTRL MTR COMM POSITION CTRL SPLY VOLT LOW REF 4 6 B+ GND 5 14 SW SIG 9 2 12 SERIAL DATA PNK WIRE AUTOMATIC DAY/NIGHT MIRROR BLK WIRE BRN WIRE COMPUTER DATA LINES SYSTEM COMPUTER DATA LINES SYSTEM ELECTROCHROMIC DDM FUSE 4 DEFOGGER SWITCH DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/WHT WIRE DOWN L/R SELECT DRIVER DOOR LOCK/ WINDOW SWITCH DRIVER MEMORY/HEATED SEAT SWITCH DRIVER OUTSIDE REARVIEW MIRROR EXIT EXTEND GRY WIRE GRY/BLK WIRE HOT AT ALL TIMES HVAC CONTROL MODULE I/P FUSE BLOCK (LEFT SIDE OF DASH, L/R SELECT SW PWR LEFT LOGIC LOGIC DRIVER DOOR LOCK/WINDOW SWITCH LT BLU WIRE MIRROR CIRCUIT ORG/ WIRE OUTSIDE REARVIEW MIRROR SWITCH PNK WIRE RED/WHT WIRE RETRACT RIGHT SERIAL DATA WHT WIRE YEL WIRE

1 2 4 10 5 7 RETRACT CTRL EXTEND CTRL SENS SIG LOW REF SENS SIG 2 6 1 3 7 POSITION CTRL MTR COMM POSITION CTRL LOW REF SPLY VOLT 4 6 B+ GND BLK WIRE BRN WIRE COMPUTER DATA LINES SYSTEM DK GRN WIRE GRY/BLK WIRE HOT AT ALL TIMES I/P FUSE BLOCK (LEFT SIDE OF DASH, LT BLU WIRE LT BLU/BLK WIRE LT GRN WIRE ORG/ WIRE ORG/BLK WIRE PASSENGER DOOR LOCK/ WINDOW SWITCH PASSENGER OUTSIDE REARVIEW MIRROR PDM FUSE 9 POWER DISTRIBUTION SYSTEM PPL RED/WHT WIRE RIGHT I/P JUNCTION BLOCK (IN RIGHT END OF DASH) SERIAL DATA WHT WIRE YEL WIRE

1 2 4 10 5 7 RETRACT CTRL EXTEND CTRL SENS SIG LOW REF SENS SIG 2 6 1 7 3 9 4 POSITION CTRL MTR COMM POSITION CTRL SPLY VOLT LOW REF 4 6 B+ GND 9 2 12 SERIAL DATA PNK WIRE AUTOMATIC DAY/NIGHT MIRROR BLK WIRE BRN WIRE COMPUTER DATA LINES SYSTEM COMPUTER DATA LINES SYSTEM ELECTROCHROMIC DDM FUSE 4 DEFOGGER SWITCH DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/WHT WIRE DOWN L/R SELECT DRIVER DOOR LOCK/ WINDOW SWITCH DRIVER DOOR LOCK/WINDOW SWITCH DRIVER MEMORY/HEATED SEAT SWITCH DRIVER OUTSIDE REARVIEW MIRROR EXIT EXTEND GRY WIRE GRY/BLK WIRE HOT AT ALL TIMES HVAC CONTROL MODULE I/P FUSE BLOCK (LEFT SIDE OF DASH, L/R SELECT SW PWR LEFT LOGIC LT BLU WIRE MIRROR CIRCUIT ORG/ WIRE OUTSIDE REARVIEW MIRROR SWITCH PNK WIRE RED/WHT WIRE RETRACT RIGHT SERIAL DATA SW SIG WHT WIRE YEL WIRE

1 2 4 10 5 7 RETRACT CTRL EXTEND CTRL SENS SIG LOW REF SENS SIG 2 6 1 3 7 POSITION CTRL MTR COMM POSITION CTRL LOW REF SPLY VOLT 4 6 B+ GND BLK WIRE BRN WIRE COMPUTER DATA LINES SYSTEM DK GRN WIRE GRY/BLK WIRE HOT AT ALL TIMES I/P FUSE BLOCK (LEFT SIDE OF DASH, LT BLU WIRE LT BLU/BLK WIRE LT GRN WIRE ORG/ WIRE ORG/BLK WIRE PASSENGER DOOR LOCK/ WINDOW SWITCH PASSENGER OUTSIDE REARVIEW MIRROR PDM FUSE 9 POWER DISTRIBUTION SYSTEM PPL RED/WHT WIRE RIGHT I/P JUNCTION BLOCK (IN RIGHT END OF DASH) SERIAL DATA WHT WIRE YEL WIRE

2500 1272 2760 COMPUTER DATA LINES SYSTEM 5 VOLT REF 3 5985 439 440 COMPUTER DATA LINES SYSTEM AIR CONDITIONING SYSTEM AIR CONDITIONING SYSTEM AIR CONDITIONING SYSTEM AIR CONDITIONING SYSTEM STARTING/CHARGING SYSTEM ANTI-LOCK BRAKES SYSTEM APP SENS 1 SIG INLET PRESS SENS SIG A/C SENS SIG LOW REF FP RLY CTRL APP SENS 2 SIG MAF SENS SIG AXLE SW SIG BLK WIRE BLK/WHT WIRE BRAKE SW SIG PARK/NEUTRAL SIG BRN WIRE BRN/WHT WIRE CHARGE IND SIG COMPUTER DATA LINES SYSTEM DK BLU WIRE DK GRN/WHT WIRE ENGINE CONTROL MODULE (ECM) (LEFT FRONT OF ENGINE COMPT, NEAR FAN SHROUD) EVAP VENT SOL CTRL EXTERIOR LIGHTS SYSTEM TRANSMISSIONS SYSTEM FUEL PMP RELAY FUEL PUMP FUSE 20 GRY WIRE GRY/BLK WIRE GRY/WHT WIRE HIGH SPD DATA BUS - HOT AT ALL TIMES IAT SENS SIG LOW REF LOW REF PWTN RLY CTRL LT BLU WIRE LT BLU/WHT WIRE MIL CTRL COMPR CLTCH RLY CTRL ORG/BLK WIRE PNK WIRE PPL RED/WHT WIRE STARTING/CHARGING SYSTEM TAN WIRE TAN/BLK WIRE TAN/WHT WIRE THROTTLE INLET ABSOLUTE PRESSURE SENSOR (ON THROTTLE BODY) TRANSMISSIONS SYSTEM TRANSMISSIONS SYSTEM UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT) VEHICLE SPD SIG WAKEUP SERIAL DATA IGNITION 1 VOLT B+ VOLT PNK WIRE WHT WIRE WHT/BLK WIRE YEL WIRE YEL/BLK WIRE YEL/WHT WIRE

AUX HVAC-IGN FUSE 48 BLK WIRE BLK/WHT WIRE BRN/WHT WIRE COMPUTER DATA LINES SYSTEM DK GRN WIRE DK GRN/WHT WIRE FRONT FUEL PUMP, SENDER ASSEMBLY (IN FRONT FUEL TANK) FUEL TANK PRESSURE (FTP) SENSOR (ON FUEL PUMP, SENDER ASSEMBLY) GND IGN GROUND DISTRIBUTION SYSTEM GRY WIRE HOT AT ALL TIMES HOT W/ RUN/CRNK RELAY ENERGIZED IGN B+ INSTRUMENT PANEL CLUSTER (IPC) IPC FUSE 46 LO BUS LOGIC LOW OIL PRESSURE IND LT BLU WIRE LT GRN WIRE LT GRN/BLK WIRE MALFUNCTION INDICATOR LAMP PNK WIRE PNK/BLK WIRE POWER DISTRIBUTION SYSTEM PPL PPL/WHT WIRE REAR FUEL PUMP, SENDER ASSEMBLY RED/WHT WIRE TAN/BLK WIRE UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT) W/ 10 SERIES W/O 10 SERIES W/O STEERING WHEEL HEATER

ACCELERATOR PEDAL POSITION (APP) SENSOR (ABOVE ACCELERATOR PEDAL) BLK WIRE BLU WIRE BRN WIRE BRN/WHT WIRE COMPUTER DATA LINES SYSTEM DK BLU WIRE DK GRN WIRE DK GRN/ WHT WIRE GRY WIRE GRY/WHT WIRE HI SPD GMLAN SER DATA - IGN VOLT IND INSTRUMENT PANEL CLUSTER (IPC) LOGIC IND CTRL LOW ENGINE OIL PRESSURE IND LT BLU WIRE LT GRN WIRE MALFUNCTION INDICATOR LAMP NITROGEN NITROGEN OXIDES SENSOR 2 (IN EXHAUST, MIDDLE OF DIESEL PARTICULATE FILTER) ORG/WHT WIRE PNK WIRE PNK/BLK WIRE PPL PPL PNK WIRE PPL/WHT WIRE RED WIRE RED/WHT WIRE REDUCTANT FLUID RESERVOIR ASSEMBLY REDUCTANT FLUID RESERVOIR ASSEMBLY REDUCTANT TANK HEATER REDUCTANT SENSOR MODULE (ABOVE REDUCTANT TANK) SENS 1 GND SENS 1 SPLY VOLT SENS 2 GND SER MIL DATA CTRL TAN WIRE TAN/BLK WIRE W/O 2 SPEED TRANSFER CASE WAIT TO WHT WIRE WHT/BLK WIRE YEL WIRE

BLK WIRE BLK/WHT WIRE BRN WIRE CHARGE AIR COOLER INLET TEMPERATURE SENSOR (INTAKE MANIFOLD) CHARGE AIR COOLER OUTLET TEMPERATURE SENSOR (TOP RIGHT FRONT OF ENGINE) COMPUTER DATA LINES SYSTEM DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE GLOW PLUGS (2, 4, 6, 8: ABOVE RESPECTIVE CYLINDERS) GRY WIRE GRY/WHT WIRE HI SPD GMLAN SER DATA - HOT AT ALL TIMES HTR CTRL IAH COMM 1 IAH COMM 2 IAH CURRENT SIG IAH DIG SIG IAH FDBK SIG IAH HEART BEAT SIG IAH SW ON/OFF SIG IAH TEMP SIG IAH VOLT FEEDBACK SIG IAH VOLT SIG IGN 1 VOLT INTAKE AIR HEATER (IAH) (LEFT FRONT OF ENGINE ) LINE HTR CTRL LT BLU WIRE LT BLU/WHT WIRE LT GRN WIRE NCA WIRE ORG/BLK WIRE ORG/WHT WIRE PLUG 1 CTRL PLUG 2 CTRL PLUG 3 CTRL PLUG 4 CTRL PLUG 5 CTRL PLUG 6 CTRL PLUG 7 CTRL PLUG 8 CTRL PNK WIRE PNK/BLK WIRE PNK/WHT WIRE POWER DISTRIBUTION SYSTEM PPL PPL/WHT WIRE PUMP HTR CTRL RED WIRE RED/BLK WIRE RED/WHT WIRE SENS 1 GND SENS 1 SPLY VOLT SENS 2 GND SENS 2 SPLY VOLT TAN WIRE TAN/BLK WIRE UNDERHOOD FUSE HOLDER (RIGHT SIDE OF FIREWALL) WAKEUP SER DATA YEL WIRE

ACCELERATOR PEDAL POSITION (APP) SENSOR (ABOVE ACCELERATOR PEDAL) BLK WIRE BLU WIRE BRN WIRE BRN/WHT WIRE COMPUTER DATA LINES SYSTEM DK BLU WIRE DK GRN WIRE DK GRN/ WHT WIRE GRY WIRE GRY/WHT WIRE HI SPD GMLAN SER DATA - IGN VOLT IND INSTRUMENT PANEL CLUSTER (IPC) LOGIC IND CTRL LOW ENGINE OIL PRESSURE IND LT BLU WIRE LT GRN WIRE MALFUNCTION INDICATOR LAMP NITROGEN NITROGEN OXIDES SENSOR 2 (IN EXHAUST, MIDDLE OF DIESEL PARTICULATE FILTER) ORG/WHT WIRE PNK WIRE PNK/BLK WIRE PPL PPL PNK WIRE PPL/WHT WIRE RED WIRE RED/WHT WIRE REDUCTANT FLUID RESERVOIR ASSEMBLY REDUCTANT FLUID RESERVOIR ASSEMBLY REDUCTANT TANK HEATER REDUCTANT SENSOR MODULE (ABOVE REDUCTANT TANK) SENS 1 GND SENS 1 SPLY VOLT SENS 2 GND SER MIL DATA CTRL TAN WIRE TAN/BLK WIRE W/O 2 SPEED TRANSFER CASE WAIT TO WHT WIRE WHT/BLK WIRE YEL WIRE

BLK WIRE BLK/WHT WIRE BRN WIRE CHARGE AIR COOLER INLET TEMPERATURE SENSOR (INTAKE MANIFOLD) CHARGE AIR COOLER OUTLET TEMPERATURE SENSOR (TOP RIGHT FRONT OF ENGINE) COMPUTER DATA LINES SYSTEM DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE GLOW PLUGS (2, 4, 6, 8: ABOVE RESPECTIVE CYLINDERS) GRY WIRE GRY/WHT WIRE HI SPD GMLAN SER DATA - HOT AT ALL TIMES HTR CTRL IAH COMM 1 IAH COMM 2 IAH CURRENT SIG IAH DIG SIG IAH FDBK SIG IAH HEART BEAT SIG IAH SW ON/OFF SIG IAH TEMP SIG IAH VOLT FEEDBACK SIG IAH VOLT SIG IGN 1 VOLT INTAKE AIR HEATER (IAH) (LEFT FRONT OF ENGINE ) LINE HTR CTRL LT BLU WIRE LT BLU/WHT WIRE LT GRN WIRE NCA WIRE ORG/BLK WIRE ORG/WHT WIRE PLUG 1 CTRL PLUG 2 CTRL PLUG 3 CTRL PLUG 4 CTRL PLUG 5 CTRL PLUG 6 CTRL PLUG 7 CTRL PLUG 8 CTRL PNK WIRE PNK/BLK WIRE PNK/WHT WIRE POWER DISTRIBUTION SYSTEM PPL PPL/WHT WIRE PUMP HTR CTRL RED WIRE RED/BLK WIRE RED/WHT WIRE SENS 1 GND SENS 1 SPLY VOLT SENS 2 GND SENS 2 SPLY VOLT TAN WIRE TAN/BLK WIRE UNDERHOOD FUSE HOLDER (RIGHT SIDE OF FIREWALL) WAKEUP SER DATA YEL WIRE