Chevrolet Cab & Chassis K2500 (1989-2000) underhood fuse/relay center Wiring diagrams

1-2 SHIFT SOL 2-3 SHIFT SOL 3-2 SHIFT SOL TRANS FLUID TEMP (TFT) SENSOR 450 450 551 413 451 417 (4.3L ONLY) BLK WIRE BLK/WHT WIRE BLK/YEL WIRE BRAKE FUSE 18 BRN WIRE BRN/WHT WIRE DATA LINK CONNECTOR (BELOW LEFT SIDE OF DASH) DK BLU WIRE ECM I FUSE ECM-B FUSE ENGINE COOLANT TEMPERATURE (ECT) SENSOR (TOP FRONT OF ENGINE) GAGES FUSE 4 GRY WIRE HOT AT ALL TIMES HOT IN HOT IN RUN OR START HOT IN RUN, BULB TEST OR START I/P FUSE BLOCK INSTRUMENT CLUSTER LT BLU/WHT WIRE LT GRN WIRE LT GRN/BLK WIRE ORG/ WIRE PNK WIRE POWERTRAIN CONTROL MODULE (PCM) (UNDER RIGHT END OF DASH) PPL PPL PNK WIRE PPL/WHT WIRE RANGE MODE SELECTOR PRESSURE CONTROL SOLENOID RED WIRE RED/BLK WIRE RUN WIRE SERVICE ENGINE SOON SPEED SENSOR (LEFT REAR SIDE OF TRANSMISSION) TAN WIRE TAN/BLK WIRE TAN/WHT WIRE TCC SOL TCC/STOPLAMP SWITCH (ON BRAKE PEDAL BRACKET) THROTTLE POSITION SENSOR (RIGHT SIDE OF TBI) TRANS FUSE 20 TRANSMISSION UNDERHOOD FUSE/RELAY CENTER VEHICLE SPEED SENSOR BUFFER (UNDER RIGHT END OF DASH) WHT WIRE WHT/BLK WIRE YEL WIRE YEL/BLK WIRE

1-2 SHIFT SOL 2-3 SHIFT SOL 3-2 SHIFT SOL TRANS FLUID TEMP (TFT) SENSOR 450 450 551 413 451 417 (4.3L ONLY) BLK WIRE BLK/WHT WIRE BLK/YEL WIRE BRAKE FUSE 18 BRN WIRE BRN/WHT WIRE DATA LINK CONNECTOR (BELOW LEFT SIDE OF DASH) DK BLU WIRE ECM I FUSE ECM-B FUSE ENGINE COOLANT TEMPERATURE (ECT) SENSOR (TOP FRONT OF ENGINE) GAGES FUSE 4 GRY WIRE HOT AT ALL TIMES HOT IN HOT IN RUN OR START HOT IN RUN, BULB TEST OR START I/P FUSE BLOCK INSTRUMENT CLUSTER LT BLU/WHT WIRE LT GRN WIRE LT GRN/BLK WIRE ORG/ WIRE PNK WIRE POWERTRAIN CONTROL MODULE (PCM) (UNDER RIGHT END OF DASH) PPL PPL PNK WIRE PPL/WHT WIRE RANGE MODE SELECTOR PRESSURE CONTROL SOLENOID RED WIRE RED/BLK WIRE RUN WIRE SERVICE ENGINE SOON SPEED SENSOR (LEFT REAR SIDE OF TRANSMISSION) TAN WIRE TAN/BLK WIRE TAN/WHT WIRE TCC SOL TCC/STOPLAMP SWITCH (ON BRAKE PEDAL BRACKET) THROTTLE POSITION SENSOR (RIGHT SIDE OF TBI) TRANS FUSE 20 TRANSMISSION UNDERHOOD FUSE/RELAY CENTER VEHICLE SPEED SENSOR BUFFER (UNDER RIGHT END OF DASH) WHT WIRE WHT/BLK WIRE YEL WIRE YEL/BLK WIRE

1-2 SHIFT SOL 2-3 SHIFT SOL 3-2 SHIFT SOL TRANS FLUID TEMP (TFT) SENSOR BLK WIRE BLK/WHT WIRE BLK/YEL WIRE BRAKE FUSE 18 BRN WIRE BRN/WHT WIRE DATA LINK CONNECTOR (BELOW LEFT SIDE OF DASH) DK BLU WIRE DK BLU/WHT WIRE ECM I FUSE ECM-B FUSE ENGINE COOLANT TEMPERATURE (ECT) SENSOR (TOP FRONT OF ENGINE) GAGES FUSE 4 GRY WIRE HOT AT ALL TIMES HOT IN RUN HOT IN RUN OR START HOT IN RUN, BULB TEST OR START I/P FUSE BLOCK INSTRUMENT CLUSTER LT BLU/WHT WIRE LT GRN WIRE LT GRN/BLK WIRE ORG/ WIRE PNK WIRE POWERTRAIN CONTROL MODULE (PCM) (UNDER RIGHT END OF DASH) PPL PPL PNK WIRE PPL/WHT WIRE PRESSURE CONTROL SOLENOID RANGE MODE SELECTOR RED WIRE RED/BLK WIRE SERVICE ENGINE SOON SPEED SENSOR (LEFT REAR SIDE OF TRANSMISSION) TAN WIRE TCC/STOPLAMP SWITCH (ON BRAKE PEDAL BRACKET) THROTTLE POSITION SENSOR (RIGHT SIDE OF TBI) TRANS FUSE 20 TRANSMISSION TRANSMISSION INPUT SHAFT SPEED SENSOR (FRONT OF TRANSMISSION) UNDERHOOD FUSE/RELAY CENTER VEHICLE SPEED SENSOR BUFFER (UNDER RIGHT END OF DASH) WHT/BLK WIRE YEL WIRE YEL/BLK WIRE

1-2 SHIFT SOL 2-3 SHIFT SOL 3-2 SHIFT SOL TRANS FLUID TEMP (TFT) SENSOR 450 450 551 413 451 417 (4.3L ONLY) BLK WIRE BLK/WHT WIRE BLK/YEL WIRE BRAKE FUSE 18 BRN WIRE BRN/WHT WIRE DATA LINK CONNECTOR (BELOW LEFT SIDE OF DASH) DK BLU WIRE ECM I FUSE ECM-B FUSE ENGINE COOLANT TEMPERATURE (ECT) SENSOR (TOP FRONT OF ENGINE) GAGES FUSE 4 GRY WIRE HOT AT ALL TIMES HOT IN HOT IN RUN OR START HOT IN RUN, BULB TEST OR START I/P FUSE BLOCK INSTRUMENT CLUSTER LT BLU/WHT WIRE LT GRN WIRE LT GRN/BLK WIRE ORG/ WIRE PNK WIRE POWERTRAIN CONTROL MODULE (PCM) (UNDER RIGHT END OF DASH) PPL PPL PNK WIRE PPL/WHT WIRE RANGE MODE SELECTOR PRESSURE CONTROL SOLENOID RED WIRE RED/BLK WIRE RUN WIRE SERVICE ENGINE SOON SPEED SENSOR (LEFT REAR SIDE OF TRANSMISSION) TAN WIRE TAN/BLK WIRE TAN/WHT WIRE TCC SOL TCC/STOPLAMP SWITCH (ON BRAKE PEDAL BRACKET) THROTTLE POSITION SENSOR (RIGHT SIDE OF TBI) TRANS FUSE 20 TRANSMISSION UNDERHOOD FUSE/RELAY CENTER VEHICLE SPEED SENSOR BUFFER (UNDER RIGHT END OF DASH) WHT WIRE WHT/BLK WIRE YEL WIRE YEL/BLK WIRE

1-2 SHIFT SOL 2-3 SHIFT SOL 3-2 SHIFT SOL TRANS FLUID TEMP (TFT) SENSOR BLK WIRE BLK/WHT WIRE BLK/YEL WIRE BRAKE FUSE 18 BRN WIRE BRN/WHT WIRE DATA LINK CONNECTOR (BELOW LEFT SIDE OF DASH) DK BLU WIRE DK BLU/WHT WIRE ECM I FUSE ECM-B FUSE ENGINE COOLANT TEMPERATURE (ECT) SENSOR (TOP FRONT OF ENGINE) GAGES FUSE 4 GRY WIRE HOT AT ALL TIMES HOT IN RUN HOT IN RUN OR START HOT IN RUN, BULB TEST OR START I/P FUSE BLOCK INSTRUMENT CLUSTER LT BLU/WHT WIRE LT GRN WIRE LT GRN/BLK WIRE ORG/ WIRE PNK WIRE POWERTRAIN CONTROL MODULE (PCM) (UNDER RIGHT END OF DASH) PPL PPL PNK WIRE PPL/WHT WIRE PRESSURE CONTROL SOLENOID RANGE MODE SELECTOR RED WIRE RED/BLK WIRE SERVICE ENGINE SOON SPEED SENSOR (LEFT REAR SIDE OF TRANSMISSION) TAN WIRE TCC/STOPLAMP SWITCH (ON BRAKE PEDAL BRACKET) THROTTLE POSITION SENSOR (RIGHT SIDE OF TBI) TRANS FUSE 20 TRANSMISSION TRANSMISSION INPUT SHAFT SPEED SENSOR (FRONT OF TRANSMISSION) UNDERHOOD FUSE/RELAY CENTER VEHICLE SPEED SENSOR BUFFER (UNDER RIGHT END OF DASH) WHT/BLK WIRE YEL WIRE YEL/BLK WIRE

1-2 SHIFT SOL 2-3 SHIFT SOL 3-2 SHIFT SOL TRANS FLUID TEMP (TFT) SENSOR 999 998 961 452 389 995 PPL ACCELERATOR PEDAL POSITION (APP) MODULE (TOP OF ACCEL- ERATOR BRACKET) APP #3 APP #3 SENSOR SIG APP 1 APP 2 BLK WIRE BLK/WHT WIRE BLK/YEL WIRE BRN WIRE BRN/WHT WIRE DATA LINK CONNECTOR (BELOW LEFT SIDE OF DASH) DK BLU WIRE DK GRN WIRE ECM I FUSE ECM-B FUSE ENGINE COOLANT TEMPERATURE (ECT) SENSOR (LEFT LOWER FRONT OF ENGINE BLOCK) GAUGES FUSE GRY WIRE HOT AT ALL TIMES HOT IN RUN OR START HOT IN RUN, BULB TEST OR START I/P FUSE BLOCK INSTRUMENT CLUSTER LT BLU WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/BLK WIRE ORG/ WIRE PNK IGNITION FEED 3-2 CONTROL SOL DIAGNOSTIC REQUEST WIRE PNK WIRE POWERTRAIN CONTROL MODULE (UNDER RIGHT SIDE OF DASH) PPL PPL TCC/BRAKE SW PPL/WHT WIRE PRESSURE CONTROL SOLENOID RANGE MODE SELECTOR RED WIRE RED/BLK WIRE SERVICE ENGINE SOON SPEED SENSOR (LEFT REAR SIDE OF TRANSMISSION) STOP/HAZ FUSE 1 TAN WIRE TAN/BLK WIRE TCC PWM SOL TCC SOL TCC/STOP LAMP SWITCH (ON BRAKE PEDAL SUPPORT BRACKET) TRANS FUSE 20 TRANSFER CASE SWITCH TRANSMISSION UNDERHOOD FUSE/RELAY CENTER VEHICLE SPEED SENSOR BUFFER (UNDER RIGHT END OF DASH) WHT WIRE WHT/BLK WIRE YEL WIRE YEL/BLK WIRE

1-2 SHIFT SOL 2-3 SHIFT SOL 3-2 SHIFT SOL TRANS FLUID TEMP (TFT) SENSOR BLK WIRE BLK/WHT WIRE BLK/YEL WIRE BRAKE FUSE 18 BRN WIRE BRN/WHT WIRE DATA LINK CONNECTOR (BELOW LEFT SIDE OF DASH) DK BLU WIRE DK BLU/WHT WIRE ECM I FUSE ECM-B FUSE ENGINE COOLANT TEMPERATURE (ECT) SENSOR (TOP FRONT OF ENGINE) GAGES FUSE 4 GRY WIRE HOT AT ALL TIMES HOT IN RUN HOT IN RUN OR START HOT IN RUN, BULB TEST OR START I/P FUSE BLOCK INSTRUMENT CLUSTER LT BLU/WHT WIRE LT GRN WIRE LT GRN/BLK WIRE ORG/ WIRE PNK WIRE POWERTRAIN CONTROL MODULE (PCM) (UNDER RIGHT END OF DASH) PPL PPL PNK WIRE PPL/WHT WIRE PRESSURE CONTROL SOLENOID RANGE MODE SELECTOR RED WIRE RED/BLK WIRE SERVICE ENGINE SOON SPEED SENSOR (LEFT REAR SIDE OF TRANSMISSION) TAN WIRE TCC/STOPLAMP SWITCH (ON BRAKE PEDAL BRACKET) THROTTLE POSITION SENSOR (RIGHT SIDE OF TBI) TRANS FUSE 20 TRANSMISSION TRANSMISSION INPUT SHAFT SPEED SENSOR (FRONT OF TRANSMISSION) UNDERHOOD FUSE/RELAY CENTER VEHICLE SPEED SENSOR BUFFER (UNDER RIGHT END OF DASH) WHT/BLK WIRE YEL WIRE YEL/BLK WIRE

BLK WIRE CARGO DOOR JAMB SWITCH COURTESY CTSY FUSE 3 FRONT DOME LAMP FUSE BLOCK- I/P HEADLAMP, PANEL DIMMER SWITCH DOME LAMP DEFEAT HORN MINI FUSE HOT AT ALL TIMES I/P COMPT BOX LAMP LEFT FRONT DOOR JAMB SWITCH LEFT I/P COURTESY LAMP LEFT REAR DOOR JAMB SWITCH ORG/ WIRE PPL REAR DOME LAMP RIGHT FRONT DOOR JAMB SWITCH RIGHT I/P COURTESY LAMP RIGHT REAR DOOR JAMB SWITCH SUBURBAN ONLY TAHOE, YUKON, SUBURBAN ONLY UNDERHOOD FUSE/RELAY CENTER UNDERHOOD LAMP UNDERHOOD REEL LAMP WHT WIRE

27 28 29 30 31 PPL 5 VOLT REF ACCELERATOR PEDAL POSITION (APP) MODULE (PART OF ACCELERATOR PEDAL) BLK WIRE BLU WIRE BRAKE FUSE 18 BRN WIRE BRN/WHT WIRE CLUTCH PEDAL POSITION (CPP) SWITCH (M/T ONLY) (TOP OF CLUTCH PEDAL BRACKET) CMP SIG DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/WHT WIRE DK PNK WIRE ECM 1 FUSE ELECTRONIC BRAKE CONTROL MODULE (ON LEFT SIDE OF ENGINE COMPT) ENGINE SHUTOFF SOLENOID (TOP OF FUEL INJECTION PUMP) GRN WIRE GRY WIRE HIGH RES SIG HOT AT ALL TIMES HOT IN HOT IN RUN OR START I/P FUSE BLOCK INJECTION TIMING STEPPER MOTOR (TOP RIGHT FRONT OF ENGINE) LT BLU WIRE LT GRN WIRE LT PPL NCA WIRE OPTICAL FUEL TEMPERATURE SENSOR (ON TOP OF FUEL INJECTION PUMP) ORG/ WIRE ORG/BLK WIRE PNK PNK 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 WIRE PNK PNK 8 9 WIRE PNK PNK PPL WIRE PNK PNK WIRE PNK WIRE PNK/BLK WIRE POWER DISTRIBUTION SYSTEM PPL PPL (OR BRN/WHT) WIRE RED WIRE RED/BLK WIRE RUN WIRE SENS GRD STOP- LAMP SWITCH (ON TOP OF BRAKE PEDAL) STOP/HAZ FUSE 1 TAN WIRE TAN/BLK WIRE TRANS FUSE 20 UNDERHOOD FUSE/RELAY CENTER WHT WIRE WHT/BLK WIRE YEL WIRE YEL/BLK WIRE

"SERV ENG SOON" IND ENGINE SHUTOFF SOL OUT "SERV THROTTLE SOON" IND A/C ENABLE PCM GND PCM GND A/C SYSTEM BLK WIRE BLK/WHT WIRE BLU WIRE BRN WIRE BRN/WHT WIRE DK BLU WIRE DK BLU/WHT WIRE DK GRN/WHT WIRE ENG-I FUSE FUEL SOL MODULE (5 VREF) FUSIBLE LINK FUSIBLE LINK FUSIBLE LINK GLOW GLOW PLUG 3 PLUG 1 GLOW PLUG 2 GLOW PLUG 4 GLOW PLUG 5 GLOW PLUG 6 GLOW PLUG 7 GLOW PLUG 8 GLOW PLUG OUTPUT GLOW PLUG RELAY (TOP LEFT REAR OF ENGINE) GRD GRY WIRE HOT AT ALL TIMES FUSIBLE LINK HOT IN RUN OR START LT GRN WIRE NCA WIRE ORG/ WIRE PNK IGN WIRE PNK PNK 439 439 IGNITION IGNITION WIRE PNK PNK PNK WIRE PNK WIRE POWERTRAIN CONTROL MODULE (PCM) (BEHIND RIGHT SIDE OF DASH, NEAR BLOWER MOTOR) PPL RED WIRE RELAY CTRL TAN WIRE TAN/WHT WIRE UNDERHOOD FUSE/RELAY CENTER WASTEGATE SOL ENGINE SHUTOFF SOL OUT WASTEGATE SOLENOID (TOP LEFT REAR OF ENGINE) WHT/BLK WIRE YEL WIRE YEL/BLK WIRE