Chevrolet Cab & Chassis K2500 (1989-2000) single fuel tank dual fuel tanks Wiring diagrams

419 456 389 5 15 4 MIL IND UPSHIFT IND SPEEDO ACCY BULB TEST LOCK OFF ANTI- LOCK BRAKES IND ANTI-LOCK BRAKES SYSTEM BAT IND BLK WIRE BLK/WHT WIRE BRAKE IND BRAKE PRESSURE WARNING SWITCH (ON REAR OF EBCM CASTING) BRN WIRE BRN/WHT WIRE CHECK GAUGES IND CHECK GAUGES LAMP DRIVER DAYTIME RUNNING LAMPS IND AIR BAG IND DAYTIME RUNNING LAMPS MODULE (BEHIND LEFT SIDE OF DASH, TAPED TO DASH HARNESS) DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE ENGINE CONTROLS SYSTEM (FUEL PUMP BALANCE RELAY) ENGINE COOLANT TEMPERATURE SENDER (LEFT CYLINDER HEAD) FUEL GAUGE FUEL PUMP BALANCE MODULE (INSIDE LEFT SIDE FRAME RAIL) FUEL PUMP, SENDER (IN FRONT FUEL TANK) FUEL PUMP, SENDER (IN FUEL TANK) GRN WIRE GRY WIRE HEADLIGHTS SYSTEM HI-BEAM IND HOT IN RUN OR START HOT IN RUN, BULB TEST OR START I/P FUSE BLOCK (LEFT END OF DASH) GAUGES FUSE 4 IGN IGN E MINI FUSE IGN SW BRAKE IND BRAKE PSI PK BRAKE 33 33 IGNITION COIL (RIGHT REAR OF ENGINE) IGNITION SWITCH ILLUM ILLUMINATION INSTRUMENT CLUSTER LED DIMMING LEFT TURN IND LT BLU WIRE LT GRN WIRE LT GRN/BLK WIRE M/T A/T PNK WIRE OIL GAUGE PARITY PRNDL PNK WIRE PPL PPL 9 29 30 FUEL VSS VSS PPL/WHT WIRE PRNDL PRNDL A PRNDL B PRNDL C RIGHT TURN IND RUN WIRE SAFETY BELT IND SECONDARY FUEL GAGE SENDER (IN REAR FUEL TANK) SENS RTRN FUEL IN SERVICE ENGINE SOON IND SINGLE FUEL TANK DUAL FUEL TANKS STARTING/CHARGING SYSTEM SUPPLEMENTAL RESTRAINTS SYSTEM TACH TAN WIRE TAN/BLK WIRE TAN/WHT WIRE TEMP GAUGE TRANS FUSE 20 TRANSMISSION RANGE SELECTOR (LEFT SIDE OF TRANSMISSION) TWISTED PAIR UNDERHOOD FUSE-RELAY CENTER UPSHIFT IND (M/T ONLY) VEHICLE CONTROL MODULE (LEFT SIDE OF ENGINE COMPT) VEHICLE SPEED SENSOR (LEFT REAR OF TRANSMISSION OR TRANSFER CASE) VEHICLE SPEED SENSOR (VSS) ADAPTER VOLTMETER SPEEDOMETER WARNING SYSTEMS WHT TAN/ WIRE WHT WIRE YEL WIRE

39 (OR 1020) 7.4L VIN J ONLY 900 419 507 389 12 5 15 4 FUEL RET MIL IND UPSHIFT IND SPEEDO ACCY ANTI- LOCK BRAKES IND ANTI-LOCK BRAKES SYSTEM ANTI-THEFT SYSTEM BAT IND HI BEAM IND BLK WIRE BLK/WHT WIRE BRAKE IND BRAKE PRESSURE WARNING SWITCH (ON UNDERSIDE OF ELECTRONIC BRAKE CONTROL MODULE) BRN WIRE BRN/WHT WIRE CHECK GAUGES IND CHECK GAUGES LAMP DRIVER CONVENIENCE CENTER DAYTIME RUNNING LAMPS IND AIR BAG IND DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE ELECTRONIC BRAKE CONTROL MODULE (EBCM) (ON LEFT SIDE OF ENGINE COMPT) ENGINE CONTROLS SYSTEM (FUEL PUMP BALANCE RELAY) FUEL GAUGE FUEL PUMP BALANCE MODULE (INSIDE LEFT SIDE OF FRAME RAIL) FUEL PUMP, SENDER (IN FUEL TANK) GRN WIRE GRY WIRE HEADLIGHTS SYSTEM HOT IN RUN OR START I/P FUSE BLOCK GAUGES FUSE 4 HOT IN RUN, BULB TEST OR START IGN IGN E MINI FUSE IGN SW BRAKE IND BRAKE PSI PK BRAKE 33 33 IGNITION COIL (TOP LEFT REAR OF ENGINE) IGNITION SWITCH ILLUMINATION INSTRUMENT CLUSTER LED DIMMING LEFT TURN IND LOCK OFF LT BLU WIRE LT GRN WIRE LT GRN/BLK WIRE M/T A/T PNK WIRE MALFUNC- TION INDICATOR LAMP NCA WIRE PARITY PRNDL PARK BRAKE SWITCH (ON PARK BRAKE PEDAL BRACKET) PNK WIRE PPL PPL 9 29 30 FUEL VSS VSS PPL/WHT WIRE PRNDL PRNDL A PRNDL B PRNDL C RIGHT TURN IND RUN WIRE SAFETY BELT IND SECONDARY FUEL GAUGE SENDER (IN REAR FUEL TANK) SECURITY IND SENS RTRN FUEL IN SERVICE ENGINE SOON SINGLE FUEL TANK DUAL FUEL TANKS SPEEDOMETER STARTING/CHARGING SYSTEM SUPPLEMENTAL RESTRAINTS SYSTEM TACH TAN WIRE TAN/WHT WIRE TEMP GAUGE OIL GAUGE TRANS FUSE 20 TRANSMISSION RANGE SWITCH TWISTED PAIR UNDERHOOD FUSE BLOCK UPSHIFT IND (M/T ONLY) VEHICLE CONTROL MODULE (VCM) (LEFT SIDE OF ENGINE COMPT) VEHICLE SPEED SENSOR (LEFT SIDE OF TRANSMISSION, LEFT SIDE OF TRAN- VEHICLE SPEED SENSOR (VSS) ADAPTER VOLTMETER WARNING SYSTEMS WHT WIRE YEL WIRE

ACCY ANTI-LOCK BRAKES SYSTEM BLK WIRE BLK/WHT WIRE BRAKE IND IN BRAKE PRESSURE WARNING SWITCH (ON REAR OF EBCM CASTING) BRN WIRE BULB TEST DK BLU/WHT WIRE DK GRN WIRE DK GRN/WHT WIRE ELECTRONIC BRAKE CONTROL MODULE (LEFT SIDE OF ENGINE COMPT) ENG-1 MINI FUSE ENGINE CONTROLS SYSTEM (FUEL PUMP BALANCE RELAY) ENGINE CONTROLS SYSTEM TRANSMISSION SYSTEM ENGINE CONTROLS SYSTEM FUEL GAGE SENDER (IN FRONT FUEL TANK) FUEL PUMP BALANCE MODULE (INSIDE LEFT SIDE OF FRAME RAIL) FUEL PUMP/ SENDER GAUGES FUSE 4 GRN WIRE HOT IN RUN, BULB TEST OR START I/P FUSE BLOCK (LEFT END OF DASH) IGN E MINI FUSE IGN SW BRAKE IND BRAKE PSI PK BRAKE 33 33 IGNITION SWITCH LOCK OFF LT BLU WIRE LT GRN WIRE LT GRN/BLK WIRE M/T A/T PARK BRAKE WARNING SWITCH (ON PARKING BRAKE PEDAL BRACKET) PNK PNK WIRE PNK PPL WIRE PNK WIRE PPL PPL/WHT WIRE RADIO RUN WIRE SECONDARY FUEL GAGE SENDER (IN REAR FUEL TANK) SINGLE FUEL TANK DUAL FUEL TANKS TAN/WHT WIRE TRANS FUSE 20 TWISTED PAIR UNDERHOOD FUSE-RELAY CENTER (LEFT REAR OF ENGINE COMPT) UNDERHOOD FUSE-RELAY CENTER (LEFT REAR OF ENGINE COMPT) DIODE 1 VEHICLE SPEED SENSOR (LEFT REAR OF TRANSMISSION OR TRANSFER CASE) VEHICLE SPEED SENSOR (VSS) ADAPTER VEHICLE SPEED SENSOR BUFFER (BEHIND RIGHT SIDE OF DASH) WHT TAN/ WIRE WHT WIRE YEL/BLK WIRE

39 (OR 1020) 7.4L VIN J ONLY 900 419 507 389 12 5 15 4 FUEL RET MIL IND UPSHIFT IND SPEEDO ACCY ANTI- LOCK BRAKES IND ANTI-LOCK BRAKES SYSTEM ANTI-THEFT SYSTEM BAT IND HI BEAM IND BLK WIRE BLK/WHT WIRE BRAKE IND BRAKE PRESSURE WARNING SWITCH (ON UNDERSIDE OF ELECTRONIC BRAKE CONTROL MODULE) BRN WIRE BRN/WHT WIRE CHECK GAUGES IND CHECK GAUGES LAMP DRIVER CONVENIENCE CENTER DAYTIME RUNNING LAMPS IND AIR BAG IND DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE ELECTRONIC BRAKE CONTROL MODULE (EBCM) (ON LEFT SIDE OF ENGINE COMPT) ENGINE CONTROLS SYSTEM (FUEL PUMP BALANCE RELAY) FUEL GAUGE FUEL PUMP BALANCE MODULE (INSIDE LEFT SIDE OF FRAME RAIL) FUEL PUMP, SENDER (IN FUEL TANK) GRN WIRE GRY WIRE HEADLIGHTS SYSTEM HOT IN RUN OR START I/P FUSE BLOCK GAUGES FUSE 4 HOT IN RUN, BULB TEST OR START IGN IGN E MINI FUSE IGN SW BRAKE IND BRAKE PSI PK BRAKE 33 33 IGNITION COIL (TOP LEFT REAR OF ENGINE) IGNITION SWITCH ILLUMINATION INSTRUMENT CLUSTER LED DIMMING LEFT TURN IND LOCK OFF LT BLU WIRE LT GRN WIRE LT GRN/BLK WIRE M/T A/T PNK WIRE MALFUNC- TION INDICATOR LAMP NCA WIRE PARITY PRNDL PARK BRAKE SWITCH (ON PARK BRAKE PEDAL BRACKET) PNK WIRE PPL PPL 9 29 30 FUEL VSS VSS PPL/WHT WIRE PRNDL PRNDL A PRNDL B PRNDL C RIGHT TURN IND RUN WIRE SAFETY BELT IND SECONDARY FUEL GAUGE SENDER (IN REAR FUEL TANK) SECURITY IND SENS RTRN FUEL IN SERVICE ENGINE SOON SINGLE FUEL TANK DUAL FUEL TANKS SPEEDOMETER STARTING/CHARGING SYSTEM SUPPLEMENTAL RESTRAINTS SYSTEM TACH TAN WIRE TAN/WHT WIRE TEMP GAUGE OIL GAUGE TRANS FUSE 20 TRANSMISSION RANGE SWITCH TWISTED PAIR UNDERHOOD FUSE BLOCK UPSHIFT IND (M/T ONLY) VEHICLE CONTROL MODULE (VCM) (LEFT SIDE OF ENGINE COMPT) VEHICLE SPEED SENSOR (LEFT SIDE OF TRANSMISSION, LEFT SIDE OF TRAN- VEHICLE SPEED SENSOR (VSS) ADAPTER VOLTMETER WARNING SYSTEMS WHT WIRE YEL WIRE