Chevrolet Cab & Chassis K2500 (1989-2000) instrument cluster Wiring diagrams

2-HI IND 2-HI SW 4 LO INDIC CTRL 4 LO SW 4 LOW SELECT SW IN 2 HI SELECT SW IN 4 HI SELECT SW IN BATTERY IN 4-HI IND 4-HI SW 4-LO IND ANTI-LOCK BRAKES SYSTEM BLK WIRE BLK/WHT WIRE BRN WIRE BRN/WHT WIRE CHANNEL A CHANNEL B CHANNEL C CHANNEL P DATA LINK CONNECTOR (PARTIAL) (UNDER LEFT SIDE OF DASH) DIESEL DK BLU/WHT WIRE DK GRN/WHT WIRE ENGINE CONTROLS, CRUISE CONTROL, SOUND SYSTEMS FRONT AXLE ACTUATOR FRONT AXLE SWITCH FUSE 24 GASOLINE GAUGES FUSE 4 GROUND GROUND GROUND BATTERY IN BATTERY IN PNP SW-P/N IN GRY WIRE GRY/BLK WIRE HEADLAMP, PANEL DIMMER SWITCH HOT AT ALL TIMES HOT IN RUN HOT IN RUN OR START I/P FUSE BLOCK (UNDER LEFT SIDE OF DASH) IGNITION IN ENCODER GROUND GROUND 2 HI INDIC CTRL 4 HI INDIC CTRL ILLUMINATION LAMP INSTRUMENT CLUSTER LOW SIG LT GRN WIRE LT GRN/BLK WIRE ORG/ WIRE PARK/NEUTRAL POSITION SWITCH (ON LEFT SIDE, CENTER OF TRANSMISSION) PNK WIRE POWERTRAIN CONTROL MODULE (DIESEL) (BEHIND RIGHT SIDE OF DASH) PPL/WHT WIRE RED WIRE RED/WHT WIRE SIG AXLE SPARE POWER SOURCE AUXILIARY BATTERY RELAY TAN/BLK WIRE TCASE FUSE 2 TCC/STOP LAMP SWITCH (TOP OF BRAKE PEDAL) TRANSFER CASE CONTROL MODULE (STEERING COLUMN BRACKET) TRANSFER CASE ENCODER (RIGHT SIDE CENTER OF TRANSFER CASE) TRANSFER CASE ENCODER MOTOR (RIGHT SIDE OF TRANSFER CASE) TRANSFER CASE SELECT SWITCH TRANSFER CASE SWITCH (TOP LEFT OF TRANSFER CASE) VEHICLE CONTROL MODULE (GASOLINE) (LEFT SIDE OF ENGINE COMPT) VSS OUT YEL WIRE YEL/BLK WIRE

2-HI IND 2-HI SW 4 LO INDIC CTRL 4 LO SW 4 LOW SELECT SW IN 2 HI SELECT SW IN 4 HI SELECT SW IN BATTERY IN 4-HI IND 4-HI SW 4-LO IND ANTI-LOCK BRAKES SYSTEM BLK WIRE BLK/WHT WIRE BRN WIRE BRN/WHT WIRE CHANNEL A CHANNEL B CHANNEL C CHANNEL P DATA LINK CONNECTOR (PARTIAL) (UNDER LEFT SIDE OF DASH) DIESEL DK BLU/WHT WIRE DK GRN/WHT WIRE ENGINE CONTROLS, CRUISE CONTROL, SOUND SYSTEMS FRONT AXLE ACTUATOR FRONT AXLE SWITCH FUSE 24 GASOLINE GAUGES FUSE 4 GROUND GROUND GROUND BATTERY IN BATTERY IN PNP SW-P/N IN GRY WIRE GRY/BLK WIRE HEADLAMP, PANEL DIMMER SWITCH HOT AT ALL TIMES HOT IN RUN HOT IN RUN OR START I/P FUSE BLOCK (UNDER LEFT SIDE OF DASH) IGNITION IN ENCODER GROUND GROUND 2 HI INDIC CTRL 4 HI INDIC CTRL ILLUMINATION LAMP INSTRUMENT CLUSTER LOW SIG LT GRN WIRE LT GRN/BLK WIRE ORG/ WIRE PARK/NEUTRAL POSITION SWITCH (ON LEFT SIDE, CENTER OF TRANSMISSION) PNK WIRE POWERTRAIN CONTROL MODULE (DIESEL) (BEHIND RIGHT SIDE OF DASH) PPL/WHT WIRE RED WIRE RED/WHT WIRE SIG AXLE SPARE POWER SOURCE AUXILIARY BATTERY RELAY TAN/BLK WIRE TCASE FUSE 2 TCC/STOP LAMP SWITCH (TOP OF BRAKE PEDAL) TRANSFER CASE CONTROL MODULE (STEERING COLUMN BRACKET) TRANSFER CASE ENCODER (RIGHT SIDE CENTER OF TRANSFER CASE) TRANSFER CASE ENCODER MOTOR (RIGHT SIDE OF TRANSFER CASE) TRANSFER CASE SELECT SWITCH TRANSFER CASE SWITCH (TOP LEFT OF TRANSFER CASE) VEHICLE CONTROL MODULE (GASOLINE) (LEFT SIDE OF ENGINE COMPT) VSS OUT YEL WIRE YEL/BLK WIRE

2-HI IND 2-HI SW 4 LO INDIC CTRL 4 LO SW 4 LOW SELECT SW IN 2 HI SELECT SW IN 4 HI SELECT SW IN BATTERY IN 4-HI IND 4-HI SW 4-LO IND ANTI-LOCK BRAKES SYSTEM BLK WIRE BLK/WHT WIRE BRN WIRE BRN/WHT WIRE CHANNEL A CHANNEL B CHANNEL C CHANNEL P DATA LINK CONNECTOR (PARTIAL) (UNDER LEFT SIDE OF DASH) DIESEL DK BLU/WHT WIRE DK GRN/WHT WIRE ENGINE CONTROLS, CRUISE CONTROL, SOUND SYSTEMS FRONT AXLE ACTUATOR FRONT AXLE SWITCH FUSE 24 GASOLINE GAUGES FUSE 4 GROUND GROUND GROUND BATTERY IN BATTERY IN PNP SW-P/N IN GRY WIRE GRY/BLK WIRE HEADLAMP, PANEL DIMMER SWITCH HOT AT ALL TIMES HOT IN RUN HOT IN RUN OR START I/P FUSE BLOCK (UNDER LEFT SIDE OF DASH) IGNITION IN ENCODER GROUND GROUND 2 HI INDIC CTRL 4 HI INDIC CTRL ILLUMINATION LAMP INSTRUMENT CLUSTER LOW SIG LT GRN WIRE LT GRN/BLK WIRE ORG/ WIRE PARK/NEUTRAL POSITION SWITCH (ON LEFT SIDE, CENTER OF TRANSMISSION) PNK WIRE POWERTRAIN CONTROL MODULE (DIESEL) (BEHIND RIGHT SIDE OF DASH) PPL/WHT WIRE RED WIRE RED/WHT WIRE SIG AXLE SPARE POWER SOURCE AUXILIARY BATTERY RELAY TAN/BLK WIRE TCASE FUSE 2 TCC/STOP LAMP SWITCH (TOP OF BRAKE PEDAL) TRANSFER CASE CONTROL MODULE (STEERING COLUMN BRACKET) TRANSFER CASE ENCODER (RIGHT SIDE CENTER OF TRANSFER CASE) TRANSFER CASE ENCODER MOTOR (RIGHT SIDE OF TRANSFER CASE) TRANSFER CASE SELECT SWITCH TRANSFER CASE SWITCH (TOP LEFT OF TRANSFER CASE) VEHICLE CONTROL MODULE (GASOLINE) (LEFT SIDE OF ENGINE COMPT) VSS OUT YEL WIRE YEL/BLK WIRE

1-2 SHIFT SOLENOID 2-3 SHIFT SOLENOID 29 30 VSS LO (GROUND) VSS HI (SIGNAL) ANTI-LOCK BRAKES SYSTEM AUTOMATIC TRANSMISSION BLK WIRE BLK/WHT WIRE BLU/WHT WIRE BRAKE FUSE 18 BRN WIRE BRN/WHT WIRE CRUISE CONTROL DK BLU WIRE ECM 1 FUSE ECM-B FUSE ELECTRONIC BRAKE CONTROL MODULE ENGINE CONTROLS ENGINE COOLANT TEMPERATURE SENSOR (TOP RIGHT FRONT OF ENGINE) FLUID TEMP SENSOR FRONT WHEEL LOCK FUEL INJECTORS, IGNITION CONTROL MOUDULE, IGNITION COIL FUEL PUMP, OIL PRESS SWITCH/ SENDER, FUEL PUMP RELAY GRY WIRE GRY/BLK WIRE HI LO HOT AT ALL TIMES HOT IN HOT IN OFF, RUN OR START HOT IN RUN OR START HOT IN RUN OR START I/P FUSE BLOCK (UNDER LEFT SIDE OF DSAH) GAUGES FUSE 4 I/P FUSE BLOCK (UNDER LEFT SIDE OF DASH) INLINE GENDER ADAPTOR INSTRUMENT CLUSTER LT BLU WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/BLK WIRE MALFUNCTION INDICATOR LAMP ORG/ WIRE PNK PNK WIRE PNK WIRE PPL PPL DATA LINK CONNECTOR (UNDER LEFT SIDE OF DASH) PPL/WHT WIRE PRESS CTRL SOLENOID RED WIRE RED/BLK WIRE REV, LO RUN WIRE TAN WIRE TCC PWM SOLENOID TCC/ABS/ CRUISE SWITCH THROTTLE POSITION SENSOR (MOUNTED TO SIDE OF THROTTLE BODY) TRANS FUSE 20 TRANS RANGE PRESSURE SWITCH ASSEMBLY TRANSFER CASE CIRCUIT TRANSFER CASE, AXLE SWITCHES UNDERHOOD FUSE/RELAY CENTER (LEFT REAR OF ENGINE COMPT) VEHICLE CONTROL MODULE (LEFT SIDE OF ENGINE COMPT) VEHICLE SPEED SENSOR (LEFT SIDE OF YEL WIRE YEL/BLK WIRE

1-2 SHIFT SOLENOID 2-3 SHIFT SOLENOID A/T ISS SENSOR VSS IN SENSOR GROUND SENSOR GROUND APP 1 SIGNAL IN ACCELERATOR PEDAL POSITION MODULE (PART OF ACCELERATOR PEDAL) APP 3 SIGNAL IN SENSOR GROUND A/T ISS SENS LO AUTOMATIC TRANSMISSION BLK WIRE BLK/WHT WIRE BLU/WHT WIRE BRAKE FUSE 18 BRN WIRE BRN/WHT WIRE DK BLU WIRE DK GRN WIRE ECM-B FUSE ELECTRONIC BRAKE CONTROL MODULE PPL ENGINE CONTROLS SYSTEM ENGINE SHUTOFF SOLENOID, FUEL SOLENOID EXTERIOR LIGHTS FUEL PUMP, OIL PRESS SWITCH/ SENDER, FUEL PUMP RELAY GAUGES FUSE 4 GRY WIRE GRY/BLK WIRE HI LO HOT AT ALL TIMES HOT IN HOT IN RUN OR START I/P FUSE BLOCK (UNDER LEFT SIDE OF DASH) INLINE GENDER ADAPTOR INSTRUMENT CLUSTER LT BLU WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/BLK WIRE MALFUNCTION INDICATOR LAMP ORG/ WIRE PNK PPL WIRE PNK WIRE POWERTRAIN CONTROL MODULE (RIGHT SIDE OF DASH NEAR BLOWER MOTOR) PPL PPL DATA LINK CONNECTOR (UNDER LEFT SIDE OF DASH) PPL PNK PNK WIRE PPL PRESS CTRL SOLENOID PPL/WHT WIRE RED WIRE RED/BLK WIRE RUN WIRE STOP/HAZ FUSE 1 TAN WIRE TAN/WHT WIRE TCC PWM SOLENOID TRANS FLUID TEMP SENSOR TRANS FUSE 20 TRANS RANGE PNK PNK REV, LO WIRE TRANS RANGE PRESSURE SWITCH ASSEMBLY TRANSFER CASE CIRCUIT TRANSFER CASE CIRCUIT PNK WIRE TURN/ HAZARD SWITCH, CHIME MODULE VEHICLE SPEED SENSOR (LEFT SIDE OF VEHICLE SPEED SENSOR BUFFER (RIGHT SIDE OF DASH) WHT WIRE WHT/BLK WIRE YEL WIRE YEL/BLK WIRE

1-2 SHIFT SOLENOID 2-3 SHIFT SOLENOID 29 30 VSS LO (GROUND) VSS HI (SIGNAL) ANTI-LOCK BRAKES SYSTEM AUTOMATIC TRANSMISSION BLK WIRE BLK/WHT WIRE BLU/WHT WIRE BRAKE FUSE 18 BRN WIRE BRN/WHT WIRE CRUISE CONTROL DK BLU WIRE ECM 1 FUSE ECM-B FUSE ELECTRONIC BRAKE CONTROL MODULE ENGINE CONTROLS ENGINE COOLANT TEMPERATURE SENSOR (TOP RIGHT FRONT OF ENGINE) FLUID TEMP SENSOR FRONT WHEEL LOCK FUEL INJECTORS, IGNITION CONTROL MOUDULE, IGNITION COIL FUEL PUMP, OIL PRESS SWITCH/ SENDER, FUEL PUMP RELAY GRY WIRE GRY/BLK WIRE HI LO HOT AT ALL TIMES HOT IN HOT IN OFF, RUN OR START HOT IN RUN OR START HOT IN RUN OR START I/P FUSE BLOCK (UNDER LEFT SIDE OF DSAH) GAUGES FUSE 4 I/P FUSE BLOCK (UNDER LEFT SIDE OF DASH) INLINE GENDER ADAPTOR INSTRUMENT CLUSTER LT BLU WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/BLK WIRE MALFUNCTION INDICATOR LAMP ORG/ WIRE PNK PNK WIRE PNK WIRE PPL PPL DATA LINK CONNECTOR (UNDER LEFT SIDE OF DASH) PPL/WHT WIRE PRESS CTRL SOLENOID RED WIRE RED/BLK WIRE REV, LO RUN WIRE TAN WIRE TCC PWM SOLENOID TCC/ABS/ CRUISE SWITCH THROTTLE POSITION SENSOR (MOUNTED TO SIDE OF THROTTLE BODY) TRANS FUSE 20 TRANS RANGE PRESSURE SWITCH ASSEMBLY TRANSFER CASE CIRCUIT TRANSFER CASE, AXLE SWITCHES UNDERHOOD FUSE/RELAY CENTER (LEFT REAR OF ENGINE COMPT) VEHICLE CONTROL MODULE (LEFT SIDE OF ENGINE COMPT) VEHICLE SPEED SENSOR (LEFT SIDE OF YEL WIRE YEL/BLK WIRE

BLK WIRE BLK/WHT WIRE BRN WIRE DATA LINK CONNECTOR (DLC) (LEFT SIDE OF DASH) DK GRN WIRE ELECTRONIC POWER STEERING SYSTEM ENGINE CONTROLS SYSTEM EVO SOL FEED EVO SOL OUT EVO/PASSLOCK MODULE (NEAR DASH AUXILIARY STORAGE COMPARTMENT) GAUGES FUSE 4 GRY WIRE HOT AT ALL TIMES HOT IN RUN OR START I/P FUSE BLOCK INSTRUMENT CLUSTER LT BLU WIRE NCA WIRE ORG/ WIRE ORG/BLK WIRE PASSLOCK SENSOR (IN STEERING COLUMN, NEAR LOCK CYLINDER) PNK PPL WIRE PNK WIRE PPL RED WIRE RED/WHT WIRE RESISTOR 10 OHMS SEC/STRG FUSE 21 SECURITY INDICATOR SENSOR PASSLOCK GRD SIGNAL STEERING HANDWHEEL SPEED SENSOR (SENSOR GROUND) WHT WIRE YEL WIRE

BLK/WHT WIRE BRN WIRE CAPACITOR DK GRN/WHT WIRE ELECTRONIC POWER STEERING SYSTEM SECURITY INDICATOR ENGINE CONTROLS SYSTEM EVO SOL FD EVO SOL OUT EVO/PASSLOCK MODULE (UNDER CENTER OF DASH) FILTER (MOLDED IN STEERING COLUMN HARNESS) GAUGES FUSE 4 GRY WIRE HOT AT ALL TIMES HOT IN RUN OR START I/P FUSE BLOCK INSTRUMENT CLUSTER LT BLU WIRE NCA WIRE ORG/ WIRE ORG/BLK WIRE PASSLOCK SENSOR (INTERNAL TO STEERING COLUMN) PASSLOCK SENSOR REF SIGNAL GRD PNK PPL WIRE PNK WIRE PPL DATA LINK CONNECTOR (UNDER LEFT SIDE OF DASH) RED WIRE RED/WHT WIRE RESISTOR 10 OHMS SECURITY FUSE 21 STEERING HANDWHEEL SPEED SENSOR (SENSOR GROUND) WHT WIRE YEL WIRE

BLK/WHT WIRE BRN WIRE CAPACITOR DK GRN/WHT WIRE ELECTRONIC POWER STEERING SYSTEM ENGINE CONTROLS SYSTEM EVO SOL FD EVO SOL OUT EVO/PASSLOCK MODULE (UNDER CENTER OF DASH) GAUGES FUSE 4 GRY WIRE HOT AT ALL TIMES HOT IN RUN OR START I/P FUSE BLOCK INSTRUMENT CLUSTER LT BLU WIRE NCA WIRE ORG/ WIRE ORG/BLK WIRE PASSLOCK SENSOR (INTERNAL TO STEERING COLUMN) PASSLOCK SIGNAL PNK PPL WIRE PNK WIRE PPL DATA LINK CONNECTOR (UNDER LEFT SIDE OF DASH) RED WIRE RED/WHT WIRE RESISTOR 10 OHMS SECURITY FUSE 21 SECURITY INDICATOR SENSOR GRD STEERING HANDWHEEL SPEED SENSOR (SENSOR GROUND) WHT WIRE YEL WIRE

AUDIO ALARM MODULE AUDIO AMPLIFIER AUTOMATIC AUTOMATIC TRANSFER CASE AUTOMATIC TRANSFER CASE CONTROL MODULE BASE AUX/PWR FUSE 7 BASE CARGO DOOR UPPER LEVLE BATTERY FUSE 7 BLK WIRE CIG LTR FUSE 13 CIGAR LIGHTER COLUMN HARNESS BREAKOUT) CONVENIENCE CENTER DATA LINK CONNECTOR DOOR REAR LIFTGATE LOCK DOOR RELEASE CONTROL LOCK RELAY MODULE SWITCH ELECTRIC FROM UNDERHOOD FUSE-RELAY CENTER (DIAGRAM 1 OF 6) I/P CLUSTER BREAKOUT) I/P FUSE BLOCK INSTRUMENT CLUSTER LEFT FRONT DOOR LOCK SWITCH LIFTGATE RELEASE SWITCH NON- BASE ORG/ WIRE OTHERS PICKUP POLICE PACKAGE UPPER LEVEL POWER OUTLET BREAKOUT) PWR-ACCY CIRCUIT BREAKER (REGULAR CAB/EXTENDED CAB) RADIO RADIO BATT FUSE 19 REAR AUXILIARY POWER CONNECTOR REAR CONSOLE AUXILIARY POWER CONNECTOR RED WIRE REMOTE CONTROL DOOR LOCK RECEIVER REMOTE RIGHT FRONT CONTROL DOOR LOCK DOOR LOCK SWITCH RECEIVER RIGHT FRONT LEFT FRONT POWER POWER LUMBAR LUMBAR SEAT SWITCH SEAT SWITCH RIGHT LUMBAR POWER SEAT RIGHT LUMBAR POWER SEAT SWITCH RIGHT POWER SEAT ADJUSTER SWITCH SEAT LUMBAR SWITCH BREAKOUT) STEERING COLUMN HARNESS BREAKOUT) STOP LAMP SWITCH STOP/HAZ FUSE 1 SUBURBAN/ UTILITY SWITCH T CASE FUSE 2 TO SEATS FUSE (DIAGRAM 3 OF 6) TRANSFER CASE CONTROL MODULE TURN/ HAZARD SWITCH UNDERHOOD FUSE-RELAY CENTER UPPER LEVEL VEHICLE INTERFACE UNIT W/ RKE W/BENCH SEAT W/O RKE