Chevrolet Cab & Chassis K2500 (1989-2000) f/sol fuse Wiring diagrams

AUDIO ALARM MODULE CONVENIENCE CENTER AUXILIARY COOLING FAN RELAY BACKUP LAMP SWITCH CONVENIENCE CENTER CRUISE CONTROL ACTIVATOR SWITCH CRUISE CONTROL MODULE DAYTIME RUNNING LAMPS MODULE (PICKUP ONLY) DAYTIME RUNNING LAMPS RELAY DK BLU WIRE ECM IGN FUSE EGR VENT SOLENOID EGR WIDTH MODULATED SOLENOID ENGINES ONLY) F/SOL FUSE FUEL HEATER FUEL INJECTION PUMP FUSE BLOCK GAUGES FUSE GLOW PLUG CONTROL MODULE IGNITION SWITCH INSTRUMENT CLUSTER PRINTED CIRCUIT LT BLU/BLK WIRE ONLY PNK WIRE PNK/BLK WIRE POWERTRAIN CONTROL MODULE PULSE WIDTH MODULATED BOOST SOLENOID REAR DEFOGGER SWITCH SOL FUSE TCC/ STOPLAMP SWITCH TURN SIGNAL FLASHER TURN-B/U FUSE WATER IN-FUEL SENSOR

1-2 SHIFT SOL 2-3 SHIFT SOL 3-2 SHIFT SOL 2-3 SHIFT SOL CTRL FUEL INJ CTRL EGR SOL CTRL ENG SHUT-OFF CTRL 4 WHEEL DRIVE LOW SWITCH 983 474 PPL 999 998 961 452 PPL ACCELERATOR PEDAL POSITION (APP) MODULE (TOP OF ACCELERATOR BRACKET) ANTI-LOCK BRAKES SYSTEM APP 1 SENSOR ENGINE COOLANT TEMPERATURE (ECT) SENSOR (RIGHT SIDE OF ENGINE) APP 2 SENSOR APP 3 SENSOR B/H BATTERY FEED FWD LOW SW BLK WIRE BLK/WHT WIRE BLK/YEL WIRE BLU/WHT WIRE BRN WIRE BRN/WHT WIRE CRUISE CONTROL SYSTEM CRUISE ON/OFF SIG DATA LINK CONNECTOR (UNDER LEFT SIDE OF I/P) DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE ELECTRONIC 4-SPEED AUTOMATIC OVERDRIVE TRANSMISSION ENGINE SHUT- OFF SOLENOID (TOP FRONT OF ENGINE) F/SOL FUSE FUEL INJ CTRL FUEL SOLENOID (TOP FRONT OF ENGINE) FUEL SOLENOID DRIVER (TOP FRONT OF ENGINE) FUSE FUSE BLOCK FUSIBLE LINK GRY WIRE GRY/BLK WIRE GRY/RED WIRE HOT AT ALL TIMES HOT IN CRANK HOT IN RUN HOT IN START OR RUN LT BLU WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/BLK WIRE MIL TCC SOL CTRL 1-2 SHIFT SOL CTRL RANGE SIGNAL A RANGE SIGNAL B RANGE SIGNAL C OPTICAL SENSOR AND FUEL TEMPER- ATURE SENSOR (TOP FRONT OF ENGINE) ORG/ WIRE ORG/BLK WIRE PNK WIRE POWERTRAIN CONTROL MODULE (PCM) (UNDER RIGHT END OF I/P) PPL PPL 15 16 PPL PNK WIRE PPL/WHT WIRE PRESSURE CONTROL SOL RANGE MODE SELECTOR RED WIRE RED/BLK WIRE RESUME/ACCEL SIG SET/COAST SIG SPEED SENSOR (LEFT REAR SIDE OF TRANSMISSION) SYSTEM GND CLOSURE SIG APP 2 SENS GND APP 1 SENS GND APP 3 SENS GND SENSOR GND TAN WIRE TAN/BLK WIRE TAN/WHT WIRE TCC BRAKE SW TCC SOL TRANS FLUID TEMP (TFT) SENSOR TRANS FUSE CRK FUSE TRANS INPUT SPD SIG CKP SIG OPTICAL SENS GND OPTICAL SENS CAM SIG TRANS OUTPUT TRANSMISSION INPUT SPEED SENSOR VEHICLE SPEED SENSOR BUFFER (UNDER RIGHT END OF I/P) VIN P ONLY VSS VSS HI RESOLUTION SIG VSS INPUT VSS OUTPUT WHT WIRE WHT/BLK WIRE YEL WIRE YEL/BLK WIRE

1-2 SHIFT SOL 1222 1224 1225 1226 1350 PNK WIRE 2-3 SHIFT SOL CTRL FUEL INJ CTRL EGR SOL CTRL ENG SHUT-OFF CTRL 2-3 SHIFT SOL TCC SOL TRANS FLUID TEMP (TFT) SENSOR 4 WHEEL DRIVE LOW SWITCH 983 474 PPL 999 998 961 452 PPL ACCELERATOR PEDAL POSITION (APP) MODULE (TOP OF ACCELERATOR BRACKET) ANTI-LOCK BRAKES SYSTEM APP 1 SENSOR ENGINE COOLANT TEMPERATURE (ECT) SENSOR (RIGHT SIDE OF ENGINE) APP 3 SENSOR APP 2 SENSOR B/H BATTERY FEED FWD LOW SW BLK WIRE BLK/WHT WIRE BLK/YEL WIRE BLU/WHT WIRE BRN WIRE BRN/WHT WIRE CRUISE CONTROL SYSTEM CRUISE ON/OFF SIG DATA LINK CONNECTOR (UNDER LEFT SIDE OF I/P) DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE ELECTRONIC 4-SPEED AUTOMATIC OVERDRIVE TRANSMISSION ENGINE SHUT- OFF SOLENOID (TOP FRONT OF ENGINE) F/SOL FUSE FUEL INJ CTRL FUEL SOLENOID (TOP FRONT OF ENGINE) FUEL SOLENOID DRIVER (TOP FRONT OF ENGINE) FUSE FUSE BLOCK FUSIBLE LINK GRY WIRE GRY/BLK WIRE GRY/RED WIRE HOT AT ALL TIMES HOT IN CRANK HOT IN RUN HOT IN START OR RUN LT BLU WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/BLK WIRE OPTICAL SENSOR AND FUEL TEMPER- ATURE SENSOR (TOP FRONT OF ENGINE) ORG/ WIRE ORG/BLK WIRE PNK WIRE POWERTRAIN CONTROL MODULE (PCM) (UNDER RIGHT END OF I/P) PPL PPL 15 16 PPL PNK WIRE PPL/WHT WIRE PRESSURE CONTROL SOL RANGE MODE SELECTOR RED WIRE RED/BLK WIRE RESUME/ACCEL SIG SET/COAST SIG SPEED SENSOR (LEFT REAR SIDE OF TRANSMISSION) SYSTEM GND CLOSURE SIG APP 2 SENS GND APP 1 SENS GND APP 3 SENS GND SENSOR GND TAN WIRE TAN/WHT WIRE TCC BRAKE SW TRANS FUSE CRK FUSE TRANS INPUT SPD SIG CKP SIG OPTICAL SENS GND OPTICAL SENS CAM SIG TRANS OUTPUT TRANSMISSION INPUT SPEED SENSOR VEHICLE SPEED SENSOR BUFFER (UNDER RIGHT END OF I/P) VIN P ONLY VSS VSS HI RESOLUTION SIG VSS INPUT VSS OUTPUT WHT WIRE WHT/BLK WIRE YEL WIRE YEL/BLK WIRE

1-2 SHIFT SOL 2-3 SHIFT SOL 3-2 SHIFT SOL 2-3 SHIFT SOL CTRL FUEL INJ CTRL EGR SOL CTRL ENG SHUT-OFF CTRL 4 WHEEL DRIVE LOW SWITCH 983 474 PPL 999 998 961 452 PPL ACCELERATOR PEDAL POSITION (APP) MODULE (TOP OF ACCELERATOR BRACKET) ANTI-LOCK BRAKES SYSTEM APP 1 SENSOR ENGINE COOLANT TEMPERATURE (ECT) SENSOR (RIGHT SIDE OF ENGINE) APP 2 SENSOR APP 3 SENSOR B/H BATTERY FEED FWD LOW SW BLK WIRE BLK/WHT WIRE BLK/YEL WIRE BLU/WHT WIRE BRN WIRE BRN/WHT WIRE CRUISE CONTROL SYSTEM CRUISE ON/OFF SIG DATA LINK CONNECTOR (UNDER LEFT SIDE OF I/P) DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE ELECTRONIC 4-SPEED AUTOMATIC OVERDRIVE TRANSMISSION ENGINE SHUT- OFF SOLENOID (TOP FRONT OF ENGINE) F/SOL FUSE FUEL INJ CTRL FUEL SOLENOID (TOP FRONT OF ENGINE) FUEL SOLENOID DRIVER (TOP FRONT OF ENGINE) FUSE FUSE BLOCK FUSIBLE LINK GRY WIRE GRY/BLK WIRE GRY/RED WIRE HOT AT ALL TIMES HOT IN CRANK HOT IN RUN HOT IN START OR RUN LT BLU WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/BLK WIRE MIL TCC SOL CTRL 1-2 SHIFT SOL CTRL RANGE SIGNAL A RANGE SIGNAL B RANGE SIGNAL C OPTICAL SENSOR AND FUEL TEMPER- ATURE SENSOR (TOP FRONT OF ENGINE) ORG/ WIRE ORG/BLK WIRE PNK WIRE POWERTRAIN CONTROL MODULE (PCM) (UNDER RIGHT END OF I/P) PPL PPL 15 16 PPL PNK WIRE PPL/WHT WIRE PRESSURE CONTROL SOL RANGE MODE SELECTOR RED WIRE RED/BLK WIRE RESUME/ACCEL SIG SET/COAST SIG SPEED SENSOR (LEFT REAR SIDE OF TRANSMISSION) SYSTEM GND CLOSURE SIG APP 2 SENS GND APP 1 SENS GND APP 3 SENS GND SENSOR GND TAN WIRE TAN/BLK WIRE TAN/WHT WIRE TCC BRAKE SW TCC SOL TRANS FLUID TEMP (TFT) SENSOR TRANS FUSE CRK FUSE TRANS INPUT SPD SIG CKP SIG OPTICAL SENS GND OPTICAL SENS CAM SIG TRANS OUTPUT TRANSMISSION INPUT SPEED SENSOR VEHICLE SPEED SENSOR BUFFER (UNDER RIGHT END OF I/P) VIN P ONLY VSS VSS HI RESOLUTION SIG VSS INPUT VSS OUTPUT WHT WIRE WHT/BLK WIRE YEL WIRE YEL/BLK WIRE

1-2 SHIFT SOL 1222 1224 1225 1226 1350 PNK WIRE 2-3 SHIFT SOL CTRL FUEL INJ CTRL EGR SOL CTRL ENG SHUT-OFF CTRL 2-3 SHIFT SOL TCC SOL TRANS FLUID TEMP (TFT) SENSOR 4 WHEEL DRIVE LOW SWITCH 983 474 PPL 999 998 961 452 PPL ACCELERATOR PEDAL POSITION (APP) MODULE (TOP OF ACCELERATOR BRACKET) ANTI-LOCK BRAKES SYSTEM APP 1 SENSOR ENGINE COOLANT TEMPERATURE (ECT) SENSOR (RIGHT SIDE OF ENGINE) APP 3 SENSOR APP 2 SENSOR B/H BATTERY FEED FWD LOW SW BLK WIRE BLK/WHT WIRE BLK/YEL WIRE BLU/WHT WIRE BRN WIRE BRN/WHT WIRE CRUISE CONTROL SYSTEM CRUISE ON/OFF SIG DATA LINK CONNECTOR (UNDER LEFT SIDE OF I/P) DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE ELECTRONIC 4-SPEED AUTOMATIC OVERDRIVE TRANSMISSION ENGINE SHUT- OFF SOLENOID (TOP FRONT OF ENGINE) F/SOL FUSE FUEL INJ CTRL FUEL SOLENOID (TOP FRONT OF ENGINE) FUEL SOLENOID DRIVER (TOP FRONT OF ENGINE) FUSE FUSE BLOCK FUSIBLE LINK GRY WIRE GRY/BLK WIRE GRY/RED WIRE HOT AT ALL TIMES HOT IN CRANK HOT IN RUN HOT IN START OR RUN LT BLU WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/BLK WIRE OPTICAL SENSOR AND FUEL TEMPER- ATURE SENSOR (TOP FRONT OF ENGINE) ORG/ WIRE ORG/BLK WIRE PNK WIRE POWERTRAIN CONTROL MODULE (PCM) (UNDER RIGHT END OF I/P) PPL PPL 15 16 PPL PNK WIRE PPL/WHT WIRE PRESSURE CONTROL SOL RANGE MODE SELECTOR RED WIRE RED/BLK WIRE RESUME/ACCEL SIG SET/COAST SIG SPEED SENSOR (LEFT REAR SIDE OF TRANSMISSION) SYSTEM GND CLOSURE SIG APP 2 SENS GND APP 1 SENS GND APP 3 SENS GND SENSOR GND TAN WIRE TAN/WHT WIRE TCC BRAKE SW TRANS FUSE CRK FUSE TRANS INPUT SPD SIG CKP SIG OPTICAL SENS GND OPTICAL SENS CAM SIG TRANS OUTPUT TRANSMISSION INPUT SPEED SENSOR VEHICLE SPEED SENSOR BUFFER (UNDER RIGHT END OF I/P) VIN P ONLY VSS VSS HI RESOLUTION SIG VSS INPUT VSS OUTPUT WHT WIRE WHT/BLK WIRE YEL WIRE YEL/BLK WIRE

1-2 SHIFT SOL 2-3 SHIFT SOL 3-2 SHIFT SOL 2-3 SHIFT SOL CTRL FUEL INJ CTRL EGR SOL CTRL ENG SHUT-OFF CTRL 4 WHEEL DRIVE LOW SWITCH 983 474 PPL 999 998 961 452 PPL ACCELERATOR PEDAL POSITION (APP) MODULE (TOP OF ACCELERATOR BRACKET) ANTI-LOCK BRAKES SYSTEM APP 1 SENSOR ENGINE COOLANT TEMPERATURE (ECT) SENSOR (RIGHT SIDE OF ENGINE) APP 2 SENSOR APP 3 SENSOR B/H BATTERY FEED FWD LOW SW BLK WIRE BLK/WHT WIRE BLK/YEL WIRE BLU/WHT WIRE BRN WIRE BRN/WHT WIRE CRUISE CONTROL SYSTEM CRUISE ON/OFF SIG DATA LINK CONNECTOR (UNDER LEFT SIDE OF I/P) DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE ELECTRONIC 4-SPEED AUTOMATIC OVERDRIVE TRANSMISSION ENGINE SHUT- OFF SOLENOID (TOP FRONT OF ENGINE) F/SOL FUSE FUEL INJ CTRL FUEL SOLENOID (TOP FRONT OF ENGINE) FUEL SOLENOID DRIVER (TOP FRONT OF ENGINE) FUSE FUSE BLOCK FUSIBLE LINK GRY WIRE GRY/BLK WIRE GRY/RED WIRE HOT AT ALL TIMES HOT IN CRANK HOT IN RUN HOT IN START OR RUN LT BLU WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/BLK WIRE MIL TCC SOL CTRL 1-2 SHIFT SOL CTRL RANGE SIGNAL A RANGE SIGNAL B RANGE SIGNAL C OPTICAL SENSOR AND FUEL TEMPER- ATURE SENSOR (TOP FRONT OF ENGINE) ORG/ WIRE ORG/BLK WIRE PNK WIRE POWERTRAIN CONTROL MODULE (PCM) (UNDER RIGHT END OF I/P) PPL PPL 15 16 PPL PNK WIRE PPL/WHT WIRE PRESSURE CONTROL SOL RANGE MODE SELECTOR RED WIRE RED/BLK WIRE RESUME/ACCEL SIG SET/COAST SIG SPEED SENSOR (LEFT REAR SIDE OF TRANSMISSION) SYSTEM GND CLOSURE SIG APP 2 SENS GND APP 1 SENS GND APP 3 SENS GND SENSOR GND TAN WIRE TAN/BLK WIRE TAN/WHT WIRE TCC BRAKE SW TCC SOL TRANS FLUID TEMP (TFT) SENSOR TRANS FUSE CRK FUSE TRANS INPUT SPD SIG CKP SIG OPTICAL SENS GND OPTICAL SENS CAM SIG TRANS OUTPUT TRANSMISSION INPUT SPEED SENSOR VEHICLE SPEED SENSOR BUFFER (UNDER RIGHT END OF I/P) VIN P ONLY VSS VSS HI RESOLUTION SIG VSS INPUT VSS OUTPUT WHT WIRE WHT/BLK WIRE YEL WIRE YEL/BLK WIRE

1-2 SHIFT SOL 1222 1224 1225 1226 1350 PNK WIRE 2-3 SHIFT SOL CTRL FUEL INJ CTRL EGR SOL CTRL ENG SHUT-OFF CTRL 2-3 SHIFT SOL TCC SOL TRANS FLUID TEMP (TFT) SENSOR 4 WHEEL DRIVE LOW SWITCH 983 474 PPL 999 998 961 452 PPL ACCELERATOR PEDAL POSITION (APP) MODULE (TOP OF ACCELERATOR BRACKET) ANTI-LOCK BRAKES SYSTEM APP 1 SENSOR ENGINE COOLANT TEMPERATURE (ECT) SENSOR (RIGHT SIDE OF ENGINE) APP 3 SENSOR APP 2 SENSOR B/H BATTERY FEED FWD LOW SW BLK WIRE BLK/WHT WIRE BLK/YEL WIRE BLU/WHT WIRE BRN WIRE BRN/WHT WIRE CRUISE CONTROL SYSTEM CRUISE ON/OFF SIG DATA LINK CONNECTOR (UNDER LEFT SIDE OF I/P) DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE ELECTRONIC 4-SPEED AUTOMATIC OVERDRIVE TRANSMISSION ENGINE SHUT- OFF SOLENOID (TOP FRONT OF ENGINE) F/SOL FUSE FUEL INJ CTRL FUEL SOLENOID (TOP FRONT OF ENGINE) FUEL SOLENOID DRIVER (TOP FRONT OF ENGINE) FUSE FUSE BLOCK FUSIBLE LINK GRY WIRE GRY/BLK WIRE GRY/RED WIRE HOT AT ALL TIMES HOT IN CRANK HOT IN RUN HOT IN START OR RUN LT BLU WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/BLK WIRE OPTICAL SENSOR AND FUEL TEMPER- ATURE SENSOR (TOP FRONT OF ENGINE) ORG/ WIRE ORG/BLK WIRE PNK WIRE POWERTRAIN CONTROL MODULE (PCM) (UNDER RIGHT END OF I/P) PPL PPL 15 16 PPL PNK WIRE PPL/WHT WIRE PRESSURE CONTROL SOL RANGE MODE SELECTOR RED WIRE RED/BLK WIRE RESUME/ACCEL SIG SET/COAST SIG SPEED SENSOR (LEFT REAR SIDE OF TRANSMISSION) SYSTEM GND CLOSURE SIG APP 2 SENS GND APP 1 SENS GND APP 3 SENS GND SENSOR GND TAN WIRE TAN/WHT WIRE TCC BRAKE SW TRANS FUSE CRK FUSE TRANS INPUT SPD SIG CKP SIG OPTICAL SENS GND OPTICAL SENS CAM SIG TRANS OUTPUT TRANSMISSION INPUT SPEED SENSOR VEHICLE SPEED SENSOR BUFFER (UNDER RIGHT END OF I/P) VIN P ONLY VSS VSS HI RESOLUTION SIG VSS INPUT VSS OUTPUT WHT WIRE WHT/BLK WIRE YEL WIRE YEL/BLK WIRE

4 WHEEL DRIVE LOW SWITCH 983 474 PPL 999 998 961 452 PPL ACCELERATOR PEDAL POSITION (APP) MODULE (TOP OF ACCELERATOR BRACKET) ANTI-LOCK BRAKES SYSTEM APP 1 SENSOR APP 3 SENSOR APP 2 SENSOR BATTERY FEED BLK WIRE BLK/WHT WIRE BLK/YEL WIRE BLU/WHT WIRE BOOST SIG ECT SIG TRANS FLUID TEMP SIG BRN WIRE BRN/WHT WIRE CKP SIG OPTICAL SENS GND OPTICAL SENS CAM SIG CLUTCH PEDAL POSITION SWITCH CONVEN- IENCE CENTER CRK FUSE CRUISE CONTROL SYSTEM CRUISE ON/OFF SIG DATA LINK CONNECTOR (UNDER LEFT SIDE OF I/P) DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE ENGINE COOLANT TEMPERATURE (ECT) SENSOR (RIGHT SIDE OF ENGINE) ENGINE SHUT- OFF SOLENOID (TOP FRONT OF ENGINE) F/SOL FUSE FUEL INJ CTRL FUEL INJ CTRL EGR SOL CTRL ENG SHUT-OFF CTRL FUEL SOLENOID (TOP FRONT OF ENGINE) FUEL SOLENOID DRIVER (TOP FRONT OF ENGINE) FUSE FUSE BLOCK FUSIBLE LINK GLOW PLUG RLY CTRL SERIAL DATA TRANS OUTPUT SPD SIG GRY WIRE GRY/BLK WIRE HOT AT ALL TIMES HOT IN CRANK HOT IN RUN HOT IN START OR RUN LT BLU WIRE LT GRN WIRE LT GRN/BLK WIRE OPTICAL SENSOR AND FUEL TEMPER- ATURE SENSOR (TOP FRONT OF ENGINE) ORG/ WIRE ORG/BLK WIRE PNK WIRE PNK/WHT WIRE POWERTRAIN CONTROL MODULE (PCM) (UNDER RIGHT END OF I/P) PPL PPL 15 16 PPL/WHT WIRE RED WIRE RESUME/ACCEL SIG SET/COAST SIG SPEED SENSOR (LEFT REAR SIDE OF TRANSMISSION) SYSTEM GND CLOSURE GND APP 2 SENS GND APP 1 SENS GND APP 3 SENS GND SENSOR GND SYSTEM GND FUEL INJ SIG APP SENS 2 SIG APP SENS 1 SIG EGR CTRL/BARO SIG TAN WIRE TAN/WHT WIRE TCC BRAKE SW TRANS OUTPUT VEHICLE SPEED SENSOR BUFFER (UNDER RIGHT END OF I/P) VSS VSS HI RESOLUTION SIG VSS INPUT VSS OUTPUT WHT WIRE WHT/BLK WIRE YEL WIRE YEL/BLK WIRE