Chevrolet Cab & Chassis K2500 (1989-2000) bulb test Wiring diagrams

A/T ACCY AIR BAG ANTI-LOCK BRAKES ANTI-LOCK BRAKES SYSTEM BLK WIRE BLK/WHT WIRE BRAKE PRESSURE WARNING SWITCH (ON REAR OF BRAKE PRESSURE MODULATOR VALVE BODY) BRAKE/ BRN WIRE BRN/WHT WIRE BULB TEST CHECK GAUGES CHECK GAUGES LAMP DRIVER CONVENIENCE CENTER (BEHIND LEFT SIDE OF I/P) DAYTIME RUNNING LAMPS DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE ELECTRONIC PRNDL DISPLAY MODULE ENG-I MINI FUSE ENGINE CONTROLS SYSTEM ENGINE CONTROLS SYSTEM SOUND SYSTEMS ENGINE CONTROLS SYSTEM ENGINE COOLANT TEMPERATURE SENDER (FRONT OF LEFT CYLINDER HEAD) FUEL GAUGE FUEL PUMP, SENDER (IN FUEL TANK) GAUGES FUSE 4 GEN WAIT TO GRY WIRE HEADLIGHTS SYSTEM HEADLIGHTS SYSTEM (DRL) HI BEAM HOT IN RUN OR START I/P FUSE BLOCK (BEHIND LEFT SIDE OF I/P) IGNITION SWITCH ILLUM INSTRUMENT CLUSTER LEFT TURN LOCK OFF W/ DRL ONLY LOW COOLANT LOW COOLANT LEVEL SENDER (IN COOLANT RESERVOIR) LOW ENGINE COOLANT LEVEL INDICATOR MODULE (UNDER CENTER OF I/P) LT BLU WIRE LT GRN WIRE LT GRN/BLK WIRE M/T PNK WIRE NCA WIRE OIL PRESS OIL PRESSURE SWITCH/SENDER (LEFT REAR TOP OF ENGINE) PARK BRAKE WARNING SWITCH (LEFT END OF I/P) PNK WIRE PPL PPL/WHT WIRE RIGHT TURN RUN WIRE SAFETY BELT SERVICE ENGINE SOON SERVICE THROTTLE SOON UP- SHIFT SPEED- OMETER STARTING/CHARGING SYSTEM SUPPLEMENTAL RESTRAINTS SYSTEM TACH VOLT- METER TAN WIRE TAN/ WHT WIRE TAN/BLK WIRE TAN/WHT WIRE TEMP GAUGE TRANS FUSE 20 TRANSMISSSION RANGE SELECTOR TRUNK, TAILGATE, FUEL DOORS SYSTEM TRUNK/TAIL- GATE/FUEL DOORS SYSTEM UNDERHOOD FUSE/RELAY CENTER (LEFT REAR OF ENGINE COMPT) VEHICLE SPEED SENSOR (LEFT REAR OF TRANSMISSION) VEHICLE SPEED SENSOR BUFFER (BEHIND RIGHT END OF I/P) W/O DRL ONLY WARNING SYSTEMS WATER IN FUEL WATER-IN FUEL SENSOR (TOP REAR OF ENGINE) WHT TAN/ WIRE WHT WIRE WHT/BLK WIRE YEL WIRE YEL/BLK WIRE

A/T ACCY AIR BAG DAYTIME RUNNING LAMPS ANTI-LOCK BRAKES ANTI-LOCK BRAKES SYSTEM BLK WIRE BLK/ WHT WIRE BLK/WHT WIRE BRAKE PRESSURE WARNING SWITCH (ON REAR OF BRAKE PRESSURE MODULATOR VALVE BODY) BRAKE/ BRN WIRE BRN/WHT WIRE BULB TEST CHECK GAUGES CHECK GAUGES LAMP DRIVER CONVENIENCE CENTER (BEHIND LEFT SIDE OF I/P) DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE ELECTRONIC PRNDL DISPLAY MODULE ENGINE CONTROLS SYSTEM ENGINE CONTROLS SYSTEM SOUND SYSTEMS ENGINE CONTROLS SYSTEM ENGINE COOLANT TEMPERATURE SENDER (FRONT OF LEFT CYLINDER HEAD) FUEL GAUGE FUEL PUMP OIL PRESSURE SWITCH/SENDER (TOP REAR OF ENGINE) FUEL PUMP, SENDER (IN FUEL TANK) GAUGES FUSE 4 GEN GRY WIRE HEADLIGHTS SYSTEM HEADLIGHTS SYSTEM (DRL) HI BEAM HOT IN RUN OR START I/P FUSE BLOCK (BEHIND LEFT SIDE OF I/P) IGNITION SWITCH ILLUM INSTRUMENT CLUSTER LEFT TURN LOCK OFF LT BLU WIRE LT GRN WIRE LT GRN/BLK WIRE M/T PNK WIRE NCA WIRE OIL PRESS PARK BRAKE WARNING SWITCH (LEFT END OF I/P) PNK WIRE PPL PPL/WHT WIRE RIGHT TURN RUN WIRE SAFETY BELT SERVICE ENGINE SOON SPEED- OMETER STARTING/CHARGING SYSTEM SYSTEM SUPPLEMENTAL RESTRAINTS TACH VOLT- METER TAN WIRE TAN/ WHT WIRE TAN/BLK WIRE TAN/WHT WIRE TEMP GAUGE TRANS FUSE 20 TRANSMISSION RANGE SELECTOR (LEFT SIDE OF TRANSMISSION) TRUNK, TAILGATE, FUEL DOORS SYSTEM TRUNK/TAIL- GATE/FUEL DOORS SYSTEM UP SHIFT VEHICLE SPEED SENSOR (LEFT REAR OF TRANSMISSION) VEHICLE SPEED SENSOR BUFFER (BEHIND RIGHT END OF I/P) W/ DRL ONLY W/O DRL ONLY WARNING SYSTEMS WHT TAN/ WIRE WHT WIRE YEL WIRE

4.3L ONLY 423 3 121 PNK WIRE ACCY BLK WIRE BRAKE FUSE 18 BRN WIRE BRN/WHT WIRE BULB TEST DISTRIBUTOR (CENTER REAR OF ENGINE) DK BLU WIRE DK GRN/WHT WIRE ENGINE COOLANT TEMPERATURE SENSOR (FRONT OF ENGINE) GAUGES FUSE 4 GRY WIRE HOT AT ALL TIMES HOT IN RUN HOT IN RUN, BULB TEST OR START I/P FUSE BLOCK (BEHIND LEFT SIDE OF I/P) IGNITION COIL (CENTER REAR OF ENGINE) IGNITION SWITCH INSTRUMENT CLUSTER KNOCK SENSOR (4.3L ONLY) (REAR OF ENGINE) KNOCK SENSOR (RIGHT SIDE OF ENGINE, BELOW EXHAUST MANIFOLD) LINEAR EGR VALVE (4.3L W/ 4L60E, CALIF EMISS. ONLY) (RIGHT SIDE TOP OF ENGINE) LOCK OFF LT BLU/WHT WIRE LT GRN WIRE MANIFOLD ABSOLUTE PRESSURE SENSOR (RIGHT REAR TOP OF ENGINE) NCA WIRE ORG/ WIRE PNK WIRE PPL PPL 1 2 3 4 PPL 23 24 PPL/WHT WIRE RED WIRE RED/BLK WIRE RUN WIRE SERVICE ENGINE SOON INDICATOR TACHOMETER TEST LEAD TAN WIRE TAN/BLK WIRE TCC/BRAKE SWITCH (TOP OF BRAKE PEDAL BRACKET) THROTTLE POSITION SENSOR (RIGHT SIDE OF THROTTLE BODY) WHT WIRE WHT/BLK WIRE YEL WIRE YEL/BLK WIRE

4.3L ONLY 423 3 121 PNK WIRE ACCY BLK WIRE BRN WIRE BRN/WHT WIRE BULB TEST DISTRIBUTOR (CENTER REAR OF ENGINE) DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE ENGINE COOLANT TEMPERATURE SENSOR (FRONT OF ENGINE) GAUGES FUSE 4 GRY WIRE HOT AT ALL TIMES HOT IN RUN, BULB TEST OR START I/P FUSE BLOCK (BEHIND LEFT SIDE OF I/P) IGNITION COIL (CENTER REAR OF ENGINE) IGNITION SWITCH INSTRUMENT CLUSTER KNOCK SENSOR (4.3L ONLY) (REAR OF ENGINE) KNOCK SENSOR (RIGHT SIDE OF ENGINE, BELOW EXHAUST MANIFOLD) LINEAR EGR VALVE (7.4L ONLY) (RIGHT SIDE TOP OF ENGINE) LOCK OFF LT GRN WIRE MANIFOLD ABSOLUTE PRESSURE SENSOR (RIGHT REAR TOP OF ENGINE) NCA WIRE ORG/ WIRE PNK WIRE PPL PPL 1 2 3 4 PPL/WHT WIRE RED/BLK WIRE RUN WIRE SERVICE ENGINE SOON INDICATOR TACHOMETER TEST LEAD TAN WIRE TAN/BLK WIRE THROTTLE POSITION SENSOR (RIGHT SIDE OF THROTTLE BODY) UPSHIFT LAMP WHT WIRE WHT/BLK WIRE YEL WIRE

4.3L ONLY 423 3 121 PNK WIRE ACCY BLK WIRE BRAKE FUSE 18 BRN WIRE BRN/WHT WIRE BULB TEST DISTRIBUTOR (CENTER REAR OF ENGINE) DK BLU WIRE DK GRN/WHT WIRE ENGINE COOLANT TEMPERATURE SENSOR (FRONT OF ENGINE) GAUGES FUSE 4 GRY WIRE HOT AT ALL TIMES HOT IN RUN HOT IN RUN, BULB TEST OR START I/P FUSE BLOCK (BEHIND LEFT SIDE OF I/P) IGNITION COIL (CENTER REAR OF ENGINE) IGNITION SWITCH INSTRUMENT CLUSTER KNOCK SENSOR (4.3L ONLY) (REAR OF ENGINE) KNOCK SENSOR (RIGHT SIDE OF ENGINE, BELOW EXHAUST MANIFOLD) LINEAR EGR VALVE (4.3L W/ 4L60E, CALIF EMISS. ONLY) (RIGHT SIDE TOP OF ENGINE) LOCK OFF LT BLU/WHT WIRE LT GRN WIRE MANIFOLD ABSOLUTE PRESSURE SENSOR (RIGHT REAR TOP OF ENGINE) NCA WIRE ORG/ WIRE PNK WIRE PPL PPL 1 2 3 4 PPL 23 24 PPL/WHT WIRE RED WIRE RED/BLK WIRE RUN WIRE SERVICE ENGINE SOON INDICATOR TACHOMETER TEST LEAD TAN WIRE TAN/BLK WIRE TCC/BRAKE SWITCH (TOP OF BRAKE PEDAL BRACKET) THROTTLE POSITION SENSOR (RIGHT SIDE OF THROTTLE BODY) WHT WIRE WHT/BLK WIRE YEL WIRE YEL/BLK WIRE

423 3 121 PNK WIRE ACCY BLK WIRE BLK/WHT WIRE BRN WIRE BULB TEST DISTRIBUTOR (CENTER REAR OF ENGINE) DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE EGR ELEC- TRONIC VACUUM REGULATOR SOLENOID (5.7L H/D ONLY) (RIGHT TOP OF ENGINE) ENGINE COOLANT TEMPERATURE SENSOR (FRONT OF LEFT CYLINDER HEAD) FUEL PUMP AND SENDER FUEL PUMP CYCLE MODULE (5.7L H/D ONLY) FUEL PUMP PRIME CONNECTOR FUEL PUMP RELAY (UNDERHOOD FUSE/RELAY CENTER) GRY WIRE HOT AT ALL TIMES IGNITION COIL (CENTER REAR OF ENGINE) IGNITION SWITCH INSTRUMENT CLUSTER KNOCK SENSOR (RIGHT SIDE OF ENGINE, BELOW EXHAUST MANIFOLD) KNOCK SENSOR MODULE (ABOVE RIGHT SIDE ROCKER COVER) LOCK OFF LT GRN WIRE LT GRN/BLK WIRE MANIFOLD ABSOLUTE PRESSURE SENSOR (RIGHT REAR TOP OF ENGINE) NCA WIRE OIL PRESS IN ORG/ WIRE PNK 21 22 WIRE PNK WIRE PPL/WHT WIRE RED WIRE RED/BLK WIRE RUN WIRE TACH IN TACHOMETER TEST LEAD TAN WIRE TAN/BLK WIRE THROTTLE POSITION SENSOR (RIGHT SIDE OF THROTTLE BODY) VEHICLE SPEED SENSOR (LEFT REAR SIDE OF TRANSMISSION) VEHICLE SPEED SENSOR BUFFER (UNDER RIGHT END OF I/P) VSS IN WHT WIRE YEL WIRE YEL/BLK WIRE

4.3L ONLY 423 3 121 PNK WIRE ACCY BLK WIRE BRAKE FUSE 18 BRN WIRE BRN/WHT WIRE BULB TEST DISTRIBUTOR (CENTER REAR OF ENGINE) DK BLU WIRE DK GRN/WHT WIRE ENGINE COOLANT TEMPERATURE SENSOR (FRONT OF ENGINE) GAUGES FUSE 4 GRY WIRE HOT AT ALL TIMES HOT IN RUN HOT IN RUN, BULB TEST OR START I/P FUSE BLOCK (BEHIND LEFT SIDE OF I/P) IGNITION COIL (CENTER REAR OF ENGINE) IGNITION SWITCH INSTRUMENT CLUSTER KNOCK SENSOR (4.3L ONLY) (REAR OF ENGINE) KNOCK SENSOR (RIGHT SIDE OF ENGINE, BELOW EXHAUST MANIFOLD) LINEAR EGR VALVE (4.3L W/ 4L60E, CALIF EMISS. ONLY) (RIGHT SIDE TOP OF ENGINE) LOCK OFF LT BLU/WHT WIRE LT GRN WIRE MANIFOLD ABSOLUTE PRESSURE SENSOR (RIGHT REAR TOP OF ENGINE) NCA WIRE ORG/ WIRE PNK WIRE PPL PPL 1 2 3 4 PPL 23 24 PPL/WHT WIRE RED WIRE RED/BLK WIRE RUN WIRE SERVICE ENGINE SOON INDICATOR TACHOMETER TEST LEAD TAN WIRE TAN/BLK WIRE TCC/BRAKE SWITCH (TOP OF BRAKE PEDAL BRACKET) THROTTLE POSITION SENSOR (RIGHT SIDE OF THROTTLE BODY) WHT WIRE WHT/BLK WIRE YEL WIRE YEL/BLK WIRE

423 3 121 PNK WIRE ACCY BLK WIRE BLK/WHT WIRE BRN WIRE BULB TEST DISTRIBUTOR (CENTER REAR OF ENGINE) DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE EGR ELEC- TRONIC VACUUM REGULATOR SOLENOID (5.7L H/D ONLY) (RIGHT TOP OF ENGINE) ENGINE COOLANT TEMPERATURE SENSOR (FRONT OF LEFT CYLINDER HEAD) FUEL PUMP AND SENDER FUEL PUMP CYCLE MODULE (5.7L H/D ONLY) FUEL PUMP PRIME CONNECTOR FUEL PUMP RELAY (UNDERHOOD FUSE/RELAY CENTER) GRY WIRE HOT AT ALL TIMES IGNITION COIL (CENTER REAR OF ENGINE) IGNITION SWITCH INSTRUMENT CLUSTER KNOCK SENSOR (RIGHT SIDE OF ENGINE, BELOW EXHAUST MANIFOLD) KNOCK SENSOR MODULE (ABOVE RIGHT SIDE ROCKER COVER) LOCK OFF LT GRN WIRE LT GRN/BLK WIRE MANIFOLD ABSOLUTE PRESSURE SENSOR (RIGHT REAR TOP OF ENGINE) NCA WIRE OIL PRESS IN ORG/ WIRE PNK 21 22 WIRE PNK WIRE PPL/WHT WIRE RED WIRE RED/BLK WIRE RUN WIRE TACH IN TACHOMETER TEST LEAD TAN WIRE TAN/BLK WIRE THROTTLE POSITION SENSOR (RIGHT SIDE OF THROTTLE BODY) VEHICLE SPEED SENSOR (LEFT REAR SIDE OF TRANSMISSION) VEHICLE SPEED SENSOR BUFFER (UNDER RIGHT END OF I/P) VSS IN WHT WIRE YEL WIRE YEL/BLK WIRE

423 3 121 PNK WIRE ACCY BLK WIRE BRN WIRE BRN/WHT WIRE BULB TEST DISTRIBUTOR (CENTER REAR OF ENGINE) DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE ENGINE COOLANT TEMPERATURE SENSOR (RIGHT TOP FRONT OF ENGINE) GAUGES FUSE 4 GRY WIRE HOT AT ALL TIMES HOT IN RUN OR START I/P FUSE BLOCK (BEHIND LEFT SIDE OF I/P) IGNITION COIL (CENTER REAR OF ENGINE) IGNITION SWITCH INSTRUMENT CLUSTER KNOCK SENSOR (REAR OF LEFT CYLINDER HEAD) LOCK OFF LT BLU/WHT WIRE LT GRN WIRE MANIFOLD ABSOLUTE PRESSURE SENSOR (REAR TOP CENTER OF ENGINE) NCA WIRE ORG/ WIRE PNK PNK PNK 25 26 27 WIRE PNK WIRE PNK/BLK WIRE PPL PPL 1 2 3 4 PPL 22 23 PPL/WHT WIRE RED WIRE RED/BLK WIRE RUN WIRE SERVICE ENGINE SOON INDICATOR TACHOMETER TEST LEAD TAN WIRE TAN/BLK WIRE TCC/BRAKE SWITCH (TOP OF BRAKE PEDAL BRACKET) THROTTLE POSITION SENSOR (RIGHT SIDE OF THROTTLE BODY) WHT WIRE WHT/BLK WIRE YEL WIRE YEL/BLK WIRE

4.3L ONLY 423 3 121 PNK WIRE ACCY BLK WIRE BRN WIRE BRN/WHT WIRE BULB TEST DISTRIBUTOR (CENTER REAR OF ENGINE) DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE ENGINE COOLANT TEMPERATURE SENSOR (FRONT OF ENGINE) GAUGES FUSE 4 GRY WIRE HOT AT ALL TIMES HOT IN RUN, BULB TEST OR START I/P FUSE BLOCK (BEHIND LEFT SIDE OF I/P) IGNITION COIL (CENTER REAR OF ENGINE) IGNITION SWITCH INSTRUMENT CLUSTER KNOCK SENSOR (4.3L ONLY) (REAR OF ENGINE) KNOCK SENSOR (RIGHT SIDE OF ENGINE, BELOW EXHAUST MANIFOLD) LINEAR EGR VALVE (7.4L ONLY) (RIGHT SIDE TOP OF ENGINE) LOCK OFF LT GRN WIRE MANIFOLD ABSOLUTE PRESSURE SENSOR (RIGHT REAR TOP OF ENGINE) NCA WIRE ORG/ WIRE PNK WIRE PPL PPL 1 2 3 4 PPL/WHT WIRE RED/BLK WIRE RUN WIRE SERVICE ENGINE SOON INDICATOR TACHOMETER TEST LEAD TAN WIRE TAN/BLK WIRE THROTTLE POSITION SENSOR (RIGHT SIDE OF THROTTLE BODY) UPSHIFT LAMP WHT WIRE WHT/BLK WIRE YEL WIRE