Chevrolet Cab & Chassis K2500 (1989-2000) blu/wht Wiring diagrams

1-2 SHIFT SOL 1-2 SHIFT SOLENOID 2-3 SHIFT SOL 2-3 SHIFT SOLENOID A/T ISS SENS HI IN A/T ISS SENS IN A/T ISS SENS LO IN A/T ISS SENSOR OUT ACCELERATOR PEDAL POSITION MODULE (PART OF ACCELERATOR PEDAL) APP 1 SIGNAL IN APP 2 SIGNAL IN APP 3 SIGNAL IN AUTOMATIC TRANSMISSION AUTOMATIC TRANSMISSION INPUT SHAFT SPEED SENSOR (LEFT FRONT OF TRANSMISSION) BATTERY IN BLK WIRE BLK/WHT WIRE BLU/WHT WIRE BRAKE FUSE 18 BRAKE SWITCH ASSEMBLY (ON BRAKE PEDAL BRACKET) BRAKE SWITCH IN BRN WIRE BRN/WHT WIRE CLASS II DATA DK BLU WIRE DK GRN WIRE ECM-B FUSE ECT SENSOR IN ENGINE COOLANT TEMP SENSOR (NEAR THERMOSTAT HOUSING) FRONT WHEEL LOCK FUEL PUMP, OIL PRESS SWITCH/ SENDER, FUEL PUMP RELAY GAUGES FUSE 4 GROUND GRY WIRE GRY/BLK WIRE HI PPL HOT AT ALL TIMES HOT IN RUN HOT IN RUN OR START HOT IN RUN OR START UNDERHOOD FUSE/RELAY CENTER ECM 1 FUSE HOT IN RUN, BULB TEST OR START I/P FUSE BLOCK IGNITION IN INSTRUMENT CLUSTER LT BLU WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/BLK WIRE MALFUNCTION INDICATOR LAMP MIL CONTROL ORG/ WIRE PCM GROUND PCS SOL HI OUT PCS SOL LO OUT PNK PNK WIRE PNK WIRE POWER POWERTRAIN CONTROL MODULE (RIGHT SIDE OF DASH NEAR BLOWER MOTOR) PPL PPL DATA LINK CONNECTOR (UNDER LEFT SIDE OF DASH) PPL/WHT WIRE PRESS CTRL SOLENOID LO RED WIRE RED/BLK WIRE SENSOR GROUND STOP/HAZ FUSE 1 STOPLAMP SWITCH IN TAN WIRE TAN/WHT WIRE TCC PWM SOL TCC PWM SOLENOID TFT SENSOR IN TRANS FLUID TEMP SENSOR TRANS FUSE 20 TRANS RANGE "A" TRANS RANGE "B" TRANS RANGE "C" TRANS RANGE PRESSURE SWITCH ASSEMBLY TRANS RANGE SWITCHES TRANSFER CASE CIRCUIT PNK WIRE TRANSFER CASE, AXLE SWITCHES TURN/ HAZARD SWITCH, CHIME MODULE VEHICLE SPEED SENSOR VEHICLE SPEED SENSOR (VSS) ADAPTOR VEHICLE SPEED SENSOR BUFFER (RIGHT SIDE OF DASH) VSS HI IN VSS IN VSS LO IN VSS OUT WHT WIRE WHT/BLK WIRE YEL WIRE YEL/BLK WIRE

1-2 SHIFT SOL 1-2 SHIFT SOLENOID 2-3 SHIFT SOL 2-3 SHIFT SOLENOID A/T ISS SENS HI IN A/T ISS SENS IN A/T ISS SENS LO IN A/T ISS SENSOR OUT ACCELERATOR PEDAL POSITION MODULE (PART OF ACCELERATOR PEDAL) APP 1 SIGNAL IN APP 2 SIGNAL IN APP 3 SIGNAL IN AUTOMATIC TRANSMISSION AUTOMATIC TRANSMISSION INPUT SHAFT SPEED SENSOR (LEFT FRONT OF TRANSMISSION) BATTERY IN BLK WIRE BLK/WHT WIRE BLU/WHT WIRE BRAKE FUSE 18 BRAKE SWITCH ASSEMBLY (ON BRAKE PEDAL BRACKET) BRAKE SWITCH IN BRN WIRE BRN/WHT WIRE CLASS II DATA DK BLU WIRE DK GRN WIRE ECM-B FUSE ECT SENSOR IN ENGINE COOLANT TEMP SENSOR (NEAR THERMOSTAT HOUSING) FRONT WHEEL LOCK FUEL PUMP, OIL PRESS SWITCH/ SENDER, FUEL PUMP RELAY GAUGES FUSE 4 GROUND GRY WIRE GRY/BLK WIRE HI PPL HOT AT ALL TIMES HOT IN RUN HOT IN RUN OR START HOT IN RUN OR START UNDERHOOD FUSE/RELAY CENTER ECM 1 FUSE HOT IN RUN, BULB TEST OR START I/P FUSE BLOCK IGNITION IN INSTRUMENT CLUSTER LT BLU WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/BLK WIRE MALFUNCTION INDICATOR LAMP MIL CONTROL ORG/ WIRE PCM GROUND PCS SOL HI OUT PCS SOL LO OUT PNK PNK WIRE PNK WIRE POWER POWERTRAIN CONTROL MODULE (RIGHT SIDE OF DASH NEAR BLOWER MOTOR) PPL PPL DATA LINK CONNECTOR (UNDER LEFT SIDE OF DASH) PPL/WHT WIRE PRESS CTRL SOLENOID LO RED WIRE RED/BLK WIRE SENSOR GROUND STOP/HAZ FUSE 1 STOPLAMP SWITCH IN TAN WIRE TAN/WHT WIRE TCC PWM SOL TCC PWM SOLENOID TFT SENSOR IN TRANS FLUID TEMP SENSOR TRANS FUSE 20 TRANS RANGE "A" TRANS RANGE "B" TRANS RANGE "C" TRANS RANGE PRESSURE SWITCH ASSEMBLY TRANS RANGE SWITCHES TRANSFER CASE CIRCUIT PNK WIRE TRANSFER CASE, AXLE SWITCHES TURN/ HAZARD SWITCH, CHIME MODULE VEHICLE SPEED SENSOR VEHICLE SPEED SENSOR (VSS) ADAPTOR VEHICLE SPEED SENSOR BUFFER (RIGHT SIDE OF DASH) VSS HI IN VSS IN VSS LO IN VSS OUT WHT WIRE WHT/BLK WIRE YEL WIRE YEL/BLK WIRE

16 PPL 6 7 8 8 9 PNK WIRE AUTOMATIC TRANSMISSION INPUT SHAFT SPEED (A/T ISS) SENSOR BALANCE FUEL PUMP (ON INSIDE LEFT FRAME RAIL NEAR FRONT OF REAR TANK) BLK (OR WIRE BLK WIRE BLK/WHT WIRE BLU WIRE BLU/WHT WIRE BRN WIRE BRN/WHT WIRE DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE FUEL PUMP BALANCE MODULE (INSIDE LEFT SIDE OF FRAME RAIL) FUEL PUMP BALANCE RELAY (ON FUEL PUMP BALANCE MODULE) FUEL PUMP, SENDER (IN FUEL TANK) FUEL PUMP/ OIL PRESSURE SWITCH (TOP CENTER REAR OF ENGINE, BEHIND DISTRIBUTOR) FUEL TANK PRESSURE SENSOR (CALIF ONLY) (IN FUEL TANK) GAUGES FUSE 4 GRN WIRE GRY WIRE HOT IN OFF, RUN OR START HOT IN RUN OR START I/P FUSE BLOCK IGN E FUSE INPUT FUEL GAUGE INPUT OIL GAUGE INPUT TACHOMETER INSTRUMENT CLUSTER INTAKE AIR TEMPERATURE SENSOR (IN AIR INTAKE DUCT) LT BLU/WHT WIRE LT GRN WIRE M/T ONLY MAP SENSOR PRESSURE (MAP) SENSOR (TOP RIGHT OF ENGINE, NEAR FUEL INJECTORS) MASS AIR FLOW SENSOR (IN AIR INTAKE DUCT) ORG/ WIRE OUTPUT TO GAUGE PNK (TAILLAMP EXTENSION HARN, 6 CM FROM THE FUEL PUMP HARN BREAKOUT) WIRE PNK IGNITION WIRE PNK PNK PNK WIRE PNK WIRE PPL PPL PPL PPL/WHT WIRE PRIMARY TANK FUEL LVL SIG RED WIRE RED/BLK WIRE RELAY CTRL SERVICE ENGINE SOON INDICATOR SPEEDOMETER INPUT TAN WIRE TAN/BLK WIRE THROTTLE POSITION SENSOR (ON THROTTLE BODY ASSEMBLY) TRANS FUSE 20 UNDERHOOD FUSE-RELAY CENTER UPSHIFT LAMP W/ DUAL FUEL TANKS W/O DUAL FUEL TANKS W/O DUAL FUEL TANKS W/ DUAL FUEL TANKS WHT (OR WIRE WHT WIRE YEL WIRE

A/C REQUEST SIGNAL AIR CONDITIONING SYSTEM AIR INLET VLV MTR CTLR BLK WIRE BLK/WHT WIRE BLU WIRE BLU/WHT WIRE BRAKE FUSE 18 BRN WIRE BRN/WHT WIRE CLUTCH PEDAL POSITION (CPP) SWITCH (AT TOP OF CLUTCH PEDAL) CPP SW INPUT FOUR WHL DR SIG LO CRUISE CTRL SIG ENG 23 24 CRUISE CONTROL MODULE (LEFT REAR OF ENGINE COMPARTMENT, ON FIREWALL) DATA LINK CONNECTOR (UNDER LEFT SIDE OF DASH) DISTRIBUTOR DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE ELECTRONIC BRAKE CONTROL MODULE (EBCM) (ON LEFT SIDE OF ENGINE COMPARTMENT) EVO/PASSLOCK STEERING CONTROL MODULE (CENTER OF DASH) FORCE MOTOR FEED TRANS INPUT SPEED RTN TRANS INPUT SPEED SIG EST OUTPUT SIG FORCE MOTOR RETURN GROUND GROUND SENSOR GROUND FUEL LEVEL INPUT SWITCH SIGNAL FUEL PUMP PRIME CONNECTOR FUEL PUMP RELAY FUEL PUMP RLY CTRL 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 GRN WIRE GROUND GRY WIRE GRY/BLK WIRE HIGH VOLTAGE COIL WIRE HOT AT ALL TIMES UNDERHOOD FUSE- RELAY CENTER ECMB FUSE HOT IN RUN I/P FUSE BLOCK IGN BRAKE INPUT INPUT INPUT DATA SW SIG INPUT IGNITION IGNITION COIL (TOP LEFT REAR OF ENGINE) IGNITION COIL DRIVER (LEFT REAR SIDE OF ENGINE) IGNITION FEED IGN TIMING SIG. IGN COIL OUT IGNITION PRESSURE SWITCH INPUT PRESSURE SWITCH INPUT LT BLU/BLK WIRE LT BLU/WHT WIRE LT VSS SERIAL ORG/ WIRE PNK IGNITION FOUR WHL DR SIG EGR VLV GROUND WIRE PNK PNK PNK WIRE PNK WIRE PPL PPL (OR PPL A/T M/T PPL PPL PPL PPL 420 OR PPL/WHT WIRE PRESSURE SWITCH INPUT RADIO RED WIRE RED/BLK WIRE SENSOR RETURN SHIFT IND LP OUT EGR VLV FEED SPEED SENSOR SPEED STOPLAMP/ VCM SENSOR CLUTCH SIG INPUT SWITCH INPUT STOPLAMP SWITCH (TOP OF BRAKE PEDAL) SWITCH SIGNAL TAN/BLK WIRE TRANSFER CASE CONTROL MODULE (UNDER DASH ON STEERING COLUMN SUPPORT BRACKET) TRANSFER CASE SWITCH (LEFT TOP OF TRANSFER CASE) TRANSMISSIONS SYSTEM (FOUR WHEEL DRIVE INDICATOR CIRCUIT UNDERHOOD FUSE-RELAY CENTER VEHICLE CONTROL MODULE (VCM) (LEFT SIDE OF ENGINE COMPT) VSS SIG OUT VSS SIG OUT CHECK ENG LP CTRL 389 419 WHT WIRE WHT/BLK WIRE

4 WHEEL DRIVE LOW SWITCH 983 474 PPL 999 998 961 452 PPL ACCELERATOR PEDAL POSITION (APP) MODULE (TOP OF ACCELERATOR BRACKET) ANTI-LOCK BRAKES SYSTEM APP 1 SENSOR APP 2 SENSOR APP 3 SENSOR BATTERY FEED BLK WIRE BLK/WHT WIRE BLK/YEL WIRE BLU/WHT WIRE BOOST SIG ECT SIG TRANS FLUID TEMP SIG BRN WIRE BRN/WHT WIRE CKP SIG OPTICAL SENS GND OPTICAL SENS CAM SIG CLUTCH PEDAL POSITION SWITCH CONVEN- IENCE CENTER CRANK FUSE CRUISE CONTROL SYSTEM CRUISE ON/OFF SIG DATA LINK CONNECTOR (UNDER LEFT SIDE OF I/P) DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/WHT WIRE ECM-B FUSE ENGINE COOLANT TEMPERATURE (ECT) SENSOR (RIGHT SIDE OF ENGINE) ENGINE SHUT- OFF SOLENOID (TOP FRONT OF ENGINE) FUEL INJ CTRL FUEL INJ CTRL EGR SOL CTRL ENG SHUT-OFF CTRL FUEL SOL FUSE FUEL SOLENOID (TOP FRONT OF ENGINE) FUEL SOLENOID DRIVER (TOP FRONT OF ENGINE) FUSE FUSE BLOCK GLOW PLUG RLY CTRL SERIAL DATA TRANS OUTPUT SPD SIG GRY WIRE GRY/BLK WIRE HOT AT ALL TIMES HOT IN CRANK HOT IN RUN HOT IN START OR RUN LT BLU WIRE LT GRN WIRE LT GRN/BLK WIRE OPTICAL/ FUEL TEMP SENSOR (TOP FRONT OF ENGINE) ORG/ WIRE ORG/BLK WIRE PNK WIRE PNK/WHT WIRE POWERTRAIN CONTROL MODULE (PCM) (UNDER RIGHT END OF I/P) PPL PPL 15 16 PPL/WHT WIRE RED WIRE RESUME/ACCEL SIG SET/COAST SIG SPEED SENSOR (LEFT REAR SIDE OF TRANSMISSION) SYSTEM GND CLOSURE GND APP 2 SENS GND APP 1 SENS GND APP 3 SENS GND SENSOR GND SYSTEM GND FUEL INJ SIG APP SENS 2 SIG APP SENS 1 SIG EGR CTRL/BARO SIG TAN WIRE TAN/WHT WIRE TCC BRAKE SW TRANS OUTPUT VEHICLE SPEED SENSOR BUFFER (UNDER RIGHT END OF I/P) VSS VSS HI RESOLUTION SIG VSS INPUT VSS OUTPUT WHT WIRE WHT/BLK WIRE YEL WIRE YEL/BLK WIRE

A/C SIG AIR CONDITIONING SYSTEM APP 3 SENS SIG FUEL TEMP SIG IAT SIG B/H BARO SENSOR (VIN F) (UPPER LEFT SIDE OF COWL) BLK WIRE BLK/WHT WIRE BLU WIRE BLU/WHT WIRE BRN WIRE BRN/WHT WIRE DK BLU WIRE DK GRN WIRE ECM I FUSE EGR CONTROL PRESSURE/ BARO SENSOR (VIN P, S) (UPPER LEFT SIDE OF COWL) ENG-I FUSE FUEL HEATER (TOP REAR OF ENGINE) FUEL PUMP OIL PRESSURE SWITCH FUEL PUMP RELAY (RIGHT UPPER COWL) FUEL PUMP/SENDER (IN FUEL TANK) FUSE BLOCK FUSIBLE LINK FUSIBLE LINKS GAUGES FUSE GLOW PLUG CONTROL RELAY (RIGHT REAR TOP OF ENGINE) GLOW PLUG SIG GRY WIRE GRY/BLK WIRE HOT AT ALL TIMES HOT AT ALL TIMES STOP FUSE HOT IN RUN BRAKE FUSE HOT IN RUN, BULB TEST OR START HOT IN START OR RUN GLOW PLUG FUSE IGNITION FEED INSTRUMENT CLUSTER INSTRUMENT CLUSTERS SYSTEM LEFT BANK GLOW PLUGS LT BLU/BLK WIRE LT GRN WIRE MANIFOLD ABSOLUTE PRESSURE SENSOR (TURBO ONLY) (LEFT REAR ENGINE COMPT, AT COWL) ORG/ WIRE ORG/BLK WIRE PNK/BLK WIRE POWERTRAIN CONTROL MODULE (PCM) (UNDER RIGHT END OF I/P) PPL PPL 15 16 PPL/WHT WIRE RED WIRE RED/BLK WIRE RIGHT BANK GLOW PLUGS SERVICE ENGINE SOON LAMP TAN WIRE TAN/BLK WIRE TCC/ BRAKE SWITCH (ON BRAKE PEDAL SUPPORT BRACKET) VIN P ONLY WAIT LAMP "SERVICE THROTTLE" LAMP WASTEGATE SOL CTRL EGR VENT SOL CTRL "SERVICE THROTTLE" LAMP WHT WIRE WHT/BLK WIRE YEL WIRE YEL/BLK WIRE

11 12 PPL 2-3 SHIFT SOL CTRL FUEL INJ CTRL EGR SOL CTRL ENG SHUT-OFF CTRL 4 WHEEL DRIVE LOW SWITCH 983 474 PPL 999 998 961 452 PPL ACCELERATOR PEDAL POSITION (APP) MODULE (TOP OF ACCELERATOR BRACKET) ANTI-LOCK BRAKES SYSTEM APP 1 SENSOR ENGINE COOLANT TEMPERATURE (ECT) SENSOR (RIGHT SIDE OF ENGINE) APP 2 SENSOR APP 3 SENSOR B/H BATTERY FEED FWD LOW SW BLK WIRE BLK/WHT WIRE BLK/YEL WIRE BLU/WHT WIRE BRN WIRE BRN/WHT WIRE CKP SIG OPTICAL SENS GND OPTICAL SENS CAM SIG CRANK FUSE TRANS FUSE CRUISE CONTROL SYSTEM CRUISE ON/OFF SIG DATA LINK CONNECTOR (UNDER LEFT SIDE OF I/P) DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/WHT WIRE ECM-B FUSE ELECTRONIC 4-SPEED AUTOMATIC OVERDRIVE TRANSMISSION ENGINE SHUT- OFF SOLENOID (TOP FRONT OF ENGINE) FUEL INJ CTRL FUEL SOL FUSE FUEL SOLENOID (TOP FRONT OF ENGINE) FUEL SOLENOID DRIVER (TOP FRONT OF ENGINE) FUSE FUSE BLOCK GLOW PLUG RLY CTRL SERIAL DATA TRANS OUTPUT SPD SIG GRY WIRE GRY/BLK WIRE HOT AT HOT IN RUN ALL TIMES HOT IN CRANK HOT IN START OR RUN LT BLU WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/BLK WIRE OPTICAL/ FUEL TEMP SENSOR (TOP FRONT OF ENGINE) ORG/ WIRE ORG/BLK WIRE PNK WIRE POWERTRAIN CONTROL MODULE (PCM) (UNDER RIGHT END OF I/P) PPL PPL 15 16 PPL/WHT WIRE PRESS CTRL SOL (LO) RANGE MODE SELECTOR RED WIRE RED/BLK WIRE RESUME/ACCEL SIG SET/COAST SIG SPEED SENSOR (LEFT REAR SIDE OF TRANSMISSION) SYSTEM GND CLOSURE SIG APP 2 SENS GND APP 1 SENS GND APP 3 SENS GND SENSOR GND TAN WIRE TAN/BLK WIRE TAN/WHT WIRE TCC BRAKE SW TCC PWM SOL 3-2 SHIFT SOL 2-3 SHIFT SOL 1-2 SHIFT SOL TCC SOL TRANS FLUID TEMP (TFT) SENSOR TRANS OUTPUT VEHICLE SPEED SENSOR BUFFER (UNDER RIGHT END OF I/P) VIN P ONLY VSS VSS HI RESOLUTION SIG VSS INPUT VSS INPUT PRESSURE CONTROL SOL VSS OUTPUT WHT WIRE WHT/BLK WIRE YEL WIRE YEL/BLK WIRE

11 12 PPL A/C SIG AIR CONDITIONING SYSTEM APP 3 SENS SIG FUEL TEMP SIG IAT SIG B/H BARO SENSOR (VIN F) (UPPER LEFT SIDE OF COWL) BLK WIRE BLK/WHT WIRE BLU WIRE BLU/WHT WIRE BRN WIRE BRN/WHT WIRE DK BLU WIRE DK GRN WIRE ECM I FUSE EGR CONTROL PRESSURE/ BARO SENSOR (VIN P, S) (UPPER LEFT SIDE OF COWL) ENG-I FUSE FUEL HEATER (TOP REAR OF ENGINE) FUEL PUMP OIL PRESSURE SWITCH FUEL PUMP RELAY (RIGHT UPPER COWL) FUEL PUMP/SENDER (IN FUEL TANK) FUSE BLOCK FUSIBLE LINK FUSIBLE LINKS GAUGES FUSE GLOW PLUG CONTROL RELAY (RIGHT REAR TOP OF ENGINE) GLOW PLUG SIG GRY WIRE GRY/BLK WIRE HOT AT ALL TIMES HOT AT ALL TIMES STOP FUSE HOT IN RUN BRAKE FUSE HOT IN RUN, BULB TEST OR START HOT IN START OR RUN GLOW PLUG FUSE IGNITION FEED 2-3 SHIFT SOL CTRL INSTRUMENT CLUSTER INSTRUMENT CLUSTERS SYSTEM LEFT BANK GLOW PLUGS LT BLU/BLK WIRE LT GRN WIRE MANIFOLD ABSOLUTE PRESSURE SENSOR (TURBO ONLY) (LEFT REAR ENGINE COMPT, AT COWL) ORG/ WIRE ORG/BLK WIRE PNK/BLK WIRE POWERTRAIN CONTROL MODULE (PCM) (UNDER RIGHT END OF I/P) PPL PPL 15 16 RED WIRE RED/BLK WIRE RIGHT BANK GLOW PLUGS SERVICE ENGINE SOON LAMP TAN WIRE TAN/BLK WIRE TCC/ BRAKE SWITCH (ON BRAKE PEDAL SUPPORT BRACKET) VIN P ONLY WAIT LAMP "SERVICE THROTTLE" LAMP WASTEGATE SOL CTRL EGR VENT SOL CTRL "SERVICE THROTTLE" LAMP WHT WIRE WHT/BLK WIRE YEL WIRE YEL/BLK WIRE

1222 1224 1225 1226 PNK WIRE 2-3 SHIFT SOL CTRL FUEL INJ CTRL EGR SOL CTRL ENG SHUT-OFF CTRL 4 WHEEL DRIVE LOW SWITCH 983 474 PPL 999 998 961 452 PPL ACCELERATOR PEDAL POSITION (APP) MODULE (TOP OF ACCELERATOR BRACKET) ANTI-LOCK BRAKES SYSTEM APP 1 SENSOR ENGINE COOLANT TEMPERATURE (ECT) SENSOR (RIGHT SIDE OF ENGINE) APP 2 SENSOR APP 3 SENSOR B/H BATTERY FEED FWD LOW SW BLK WIRE BLK/WHT WIRE BLK/YEL WIRE BLU/WHT WIRE BRN WIRE BRN/WHT WIRE CRANK FUSE TRANS FUSE CRUISE CONTROL SYSTEM CRUISE ON/OFF SIG DATA LINK CONNECTOR (UNDER LEFT SIDE OF I/P) DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/WHT WIRE ECM-B FUSE ELECTRONIC 4-SPEED AUTOMATIC OVERDRIVE TRANSMISSION ENGINE SHUT- OFF SOLENOID (TOP FRONT OF ENGINE) FUEL INJ CTRL FUEL SOL FUSE FUEL SOLENOID (TOP FRONT OF ENGINE) FUEL SOLENOID DRIVER (TOP FRONT OF ENGINE) FUSE FUSE BLOCK GRY WIRE GRY/BLK WIRE GRY/RED WIRE HOT AT ALL TIMES HOT IN CRANK HOT IN RUN HOT IN START OR RUN LT BLU WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/BLK WIRE OPTICAL SENSOR AND FUEL TEMPER- ATURE SENSOR (TOP FRONT OF ENGINE) ORG/ WIRE ORG/BLK WIRE PNK WIRE POWERTRAIN CONTROL MODULE (PCM) (UNDER RIGHT END OF I/P) PPL PPL 15 16 PPL/WHT WIRE PRESSURE CONTROL SOL RANGE MODE SELECTOR RED WIRE RED/BLK WIRE RESUME/ACCEL SIG SET/COAST SIG SPEED SENSOR (LEFT REAR SIDE OF TRANSMISSION) SYSTEM GND CLOSURE SIG APP 2 SENS GND APP 1 SENS GND APP 3 SENS GND SENSOR GND TAN WIRE TAN/WHT WIRE TCC BRAKE SW TCC SOL 2-3 SHIFT SOL 1-2 SHIFT SOL TRANS FLUID TEMP (TFT) SENSOR TRANS INPUT SPD SIG CKP SIG OPTICAL SENS GND OPTICAL SENS CAM SIG TRANS OUTPUT TRANSMISSION INPUT SPEED SENSOR VEHICLE SPEED SENSOR BUFFER (UNDER RIGHT END OF I/P) VIN P ONLY VSS VSS HI RESOLUTION SIG VSS INPUT VSS OUTPUT WHT WIRE WHT/BLK WIRE YEL WIRE YEL/BLK WIRE

A/C SIG AIR CONDITIONING SYSTEM APP 3 SENS SIG FUEL TEMP SIG IAT SIG B/H BARO SENSOR (VIN F) (UPPER LEFT SIDE OF COWL) BLK WIRE BLK/WHT WIRE BLU WIRE BLU/WHT WIRE BRN WIRE BRN/WHT WIRE DK BLU WIRE DK GRN WIRE ECM I FUSE EGR CONTROL PRESSURE/ BARO SENSOR (VIN P, S) (UPPER LEFT SIDE OF COWL) ENG-I FUSE FUEL HEATER (TOP REAR OF ENGINE) FUEL PUMP OIL PRESSURE SWITCH FUEL PUMP RELAY (RIGHT UPPER COWL) FUEL PUMP/SENDER (IN FUEL TANK) FUSE BLOCK FUSIBLE LINK FUSIBLE LINKS GAUGES FUSE GLOW PLUG CONTROL RELAY (RIGHT REAR TOP OF ENGINE) GLOW PLUG SIG GRY WIRE GRY/BLK WIRE HOT AT ALL TIMES HOT AT ALL TIMES STOP FUSE HOT IN RUN BRAKE FUSE HOT IN RUN, BULB TEST OR START HOT IN START OR RUN GLOW PLUG FUSE IGNITION FEED INSTRUMENT CLUSTER INSTRUMENT CLUSTERS SYSTEM LEFT BANK GLOW PLUGS LT BLU/BLK WIRE LT GRN WIRE MANIFOLD ABSOLUTE PRESSURE SENSOR (TURBO ONLY) (LEFT REAR ENGINE COMPT, AT COWL) ORG/ WIRE ORG/BLK WIRE PNK/BLK WIRE POWERTRAIN CONTROL MODULE (PCM) (UNDER RIGHT END OF I/P) PPL PPL 15 16 PPL/WHT WIRE RED WIRE RED/BLK WIRE RIGHT BANK GLOW PLUGS SERVICE ENGINE SOON LAMP TAN WIRE TAN/BLK WIRE TCC/ BRAKE SWITCH (ON BRAKE PEDAL SUPPORT BRACKET) VIN P ONLY WAIT LAMP "SERVICE THROTTLE" LAMP WASTEGATE SOL CTRL EGR VENT SOL CTRL "SERVICE THROTTLE" LAMP WHT WIRE WHT/BLK WIRE YEL WIRE YEL/BLK WIRE