Chevrolet Cab & Chassis C3500 (1989-2000) tan/blk Wiring diagrams

1-2 SHIFT SOL 2-3 SHIFT SOL 3-2 SHIFT SOL TRANS FLUID TEMP (TFT) SENSOR 450 450 551 413 451 417 (4.3L ONLY) BLK WIRE BLK/WHT WIRE BLK/YEL WIRE BRAKE FUSE 18 BRN WIRE BRN/WHT WIRE DATA LINK CONNECTOR (BELOW LEFT SIDE OF DASH) DK BLU WIRE ECM I FUSE ECM-B FUSE ENGINE COOLANT TEMPERATURE (ECT) SENSOR (TOP FRONT OF ENGINE) GAGES FUSE 4 GRY WIRE HOT AT ALL TIMES HOT IN HOT IN RUN OR START HOT IN RUN, BULB TEST OR START I/P FUSE BLOCK INSTRUMENT CLUSTER LT BLU/WHT WIRE LT GRN WIRE LT GRN/BLK WIRE ORG/ WIRE PNK WIRE POWERTRAIN CONTROL MODULE (PCM) (UNDER RIGHT END OF DASH) PPL PPL PNK WIRE PPL/WHT WIRE RANGE MODE SELECTOR PRESSURE CONTROL SOLENOID RED WIRE RED/BLK WIRE RUN WIRE SERVICE ENGINE SOON SPEED SENSOR (LEFT REAR SIDE OF TRANSMISSION) TAN WIRE TAN/BLK WIRE TAN/WHT WIRE TCC SOL TCC/STOPLAMP SWITCH (ON BRAKE PEDAL BRACKET) THROTTLE POSITION SENSOR (RIGHT SIDE OF TBI) TRANS FUSE 20 TRANSMISSION UNDERHOOD FUSE/RELAY CENTER VEHICLE SPEED SENSOR BUFFER (UNDER RIGHT END OF DASH) WHT WIRE WHT/BLK WIRE YEL WIRE YEL/BLK WIRE

1-2 SHIFT SOL 2-3 SHIFT SOL 3-2 SHIFT SOL TRANS FLUID TEMP (TFT) SENSOR 450 450 551 413 451 417 (4.3L ONLY) BLK WIRE BLK/WHT WIRE BLK/YEL WIRE BRAKE FUSE 18 BRN WIRE BRN/WHT WIRE DATA LINK CONNECTOR (BELOW LEFT SIDE OF DASH) DK BLU WIRE ECM I FUSE ECM-B FUSE ENGINE COOLANT TEMPERATURE (ECT) SENSOR (TOP FRONT OF ENGINE) GAGES FUSE 4 GRY WIRE HOT AT ALL TIMES HOT IN HOT IN RUN OR START HOT IN RUN, BULB TEST OR START I/P FUSE BLOCK INSTRUMENT CLUSTER LT BLU/WHT WIRE LT GRN WIRE LT GRN/BLK WIRE ORG/ WIRE PNK WIRE POWERTRAIN CONTROL MODULE (PCM) (UNDER RIGHT END OF DASH) PPL PPL PNK WIRE PPL/WHT WIRE RANGE MODE SELECTOR PRESSURE CONTROL SOLENOID RED WIRE RED/BLK WIRE RUN WIRE SERVICE ENGINE SOON SPEED SENSOR (LEFT REAR SIDE OF TRANSMISSION) TAN WIRE TAN/BLK WIRE TAN/WHT WIRE TCC SOL TCC/STOPLAMP SWITCH (ON BRAKE PEDAL BRACKET) THROTTLE POSITION SENSOR (RIGHT SIDE OF TBI) TRANS FUSE 20 TRANSMISSION UNDERHOOD FUSE/RELAY CENTER VEHICLE SPEED SENSOR BUFFER (UNDER RIGHT END OF DASH) WHT WIRE WHT/BLK WIRE YEL WIRE YEL/BLK WIRE

1-2 SHIFT SOL 2-3 SHIFT SOL 3-2 SHIFT SOL TRANS FLUID TEMP (TFT) SENSOR 450 450 551 413 451 417 (4.3L ONLY) BLK WIRE BLK/WHT WIRE BLK/YEL WIRE BRAKE FUSE 18 BRN WIRE BRN/WHT WIRE DATA LINK CONNECTOR (BELOW LEFT SIDE OF DASH) DK BLU WIRE ECM I FUSE ECM-B FUSE ENGINE COOLANT TEMPERATURE (ECT) SENSOR (TOP FRONT OF ENGINE) GAGES FUSE 4 GRY WIRE HOT AT ALL TIMES HOT IN HOT IN RUN OR START HOT IN RUN, BULB TEST OR START I/P FUSE BLOCK INSTRUMENT CLUSTER LT BLU/WHT WIRE LT GRN WIRE LT GRN/BLK WIRE ORG/ WIRE PNK WIRE POWERTRAIN CONTROL MODULE (PCM) (UNDER RIGHT END OF DASH) PPL PPL PNK WIRE PPL/WHT WIRE RANGE MODE SELECTOR PRESSURE CONTROL SOLENOID RED WIRE RED/BLK WIRE RUN WIRE SERVICE ENGINE SOON SPEED SENSOR (LEFT REAR SIDE OF TRANSMISSION) TAN WIRE TAN/BLK WIRE TAN/WHT WIRE TCC SOL TCC/STOPLAMP SWITCH (ON BRAKE PEDAL BRACKET) THROTTLE POSITION SENSOR (RIGHT SIDE OF TBI) TRANS FUSE 20 TRANSMISSION UNDERHOOD FUSE/RELAY CENTER VEHICLE SPEED SENSOR BUFFER (UNDER RIGHT END OF DASH) WHT WIRE WHT/BLK WIRE YEL WIRE YEL/BLK WIRE

1-2 SHIFT SOL TCC SOL 2-3 SHIFT SOL 3-2 SHIFT SOL 999 998 961 452 1586 995 PPL ACCELERATOR PEDAL POSITION (APP) MODULE (TOP OF ACCE- LERATOR BRACKET) APP #3 APP #3 SENSOR SIG APP 1 BLK WIRE BLK/WHT WIRE BLK/YEL WIRE BRN WIRE BRN/WHT WIRE DATA LINK CONNECTOR (BELOW LEFT SIDE OF I/P) DK BLU WIRE DK GRN WIRE ECM IGN FUSE ELECTRONIC 4-SPEED AUTOMATIC OVERDRIVE TRANSMISSION ENGINE COOLANT TEMPERATURE (ECT) SENSOR (RIGHT SIDE OF ENGINE) FUSIBLE LINK GRY WIRE HOT AT ALL TIMES HOT IN RUN, BULB TEST OR START HOT IN START OR RUN FUSE BLOCK TRANS FUSE IGNITION FEED 3-2 CONTROL SOL DIAGNOSTIC REQUEST LT BLU WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/BLK WIRE ORG/ WIRE ORG/BLK WIRE PNK WIRE PNK/BLK WIRE POWERTRAIN CONTROL MODULE PPL PPL APP #2 PPL TCC/BRAKE SW PPL/WHT WIRE PRESSURE CONTROL SOLENOID RANGE MODE SELECTOR RED WIRE RED/BLK WIRE SPEED SENSOR (LEFT REAR SIDE OF TRANSMISSION) TAN WIRE TAN/BLK WIRE TCC/ BRAKE SWITCH (ON BRAKE PEDAL SUPPORT BRACKET) TRANS FLUID TEMP (TFT) SENSOR TRANSFER CASE SWITCH VEHICLE SPEED SENSOR BUFFER (UNDER RIGHT END OF I/P) WHT WIRE WHT/BLK WIRE YEL WIRE YEL/BLK WIRE

A/T ACCY AIR BAG ANTI-LOCK BRAKES ANTI-LOCK BRAKES SYSTEM BLK WIRE BLK/WHT WIRE BRAKE PRESSURE WARNING SWITCH (ON REAR OF BRAKE PRESSURE MODULATOR VALVE BODY) BRAKE/ BRN WIRE BRN/WHT WIRE BULB TEST CHECK GAUGES CHECK GAUGES LAMP DRIVER CONVENIENCE CENTER (BEHIND LEFT SIDE OF I/P) DAYTIME RUNNING LAMPS DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE ELECTRONIC PRNDL DISPLAY MODULE ENG-I MINI FUSE ENGINE CONTROLS SYSTEM ENGINE CONTROLS SYSTEM SOUND SYSTEMS ENGINE CONTROLS SYSTEM ENGINE COOLANT TEMPERATURE SENDER (FRONT OF LEFT CYLINDER HEAD) FUEL GAUGE FUEL PUMP, SENDER (IN FUEL TANK) GAUGES FUSE 4 GEN WAIT TO GRY WIRE HEADLIGHTS SYSTEM HEADLIGHTS SYSTEM (DRL) HI BEAM HOT IN RUN OR START I/P FUSE BLOCK (BEHIND LEFT SIDE OF I/P) IGNITION SWITCH ILLUM INSTRUMENT CLUSTER LEFT TURN LOCK OFF W/ DRL ONLY LOW COOLANT LOW COOLANT LEVEL SENDER (IN COOLANT RESERVOIR) LOW ENGINE COOLANT LEVEL INDICATOR MODULE (UNDER CENTER OF I/P) LT BLU WIRE LT GRN WIRE LT GRN/BLK WIRE M/T PNK WIRE NCA WIRE OIL PRESS OIL PRESSURE SWITCH/SENDER (LEFT REAR TOP OF ENGINE) PARK BRAKE WARNING SWITCH (LEFT END OF I/P) PNK WIRE PPL PPL/WHT WIRE RIGHT TURN RUN WIRE SAFETY BELT SERVICE ENGINE SOON SERVICE THROTTLE SOON UP- SHIFT SPEED- OMETER STARTING/CHARGING SYSTEM SUPPLEMENTAL RESTRAINTS SYSTEM TACH VOLT- METER TAN WIRE TAN/ WHT WIRE TAN/BLK WIRE TAN/WHT WIRE TEMP GAUGE TRANS FUSE 20 TRANSMISSSION RANGE SELECTOR TRUNK, TAILGATE, FUEL DOORS SYSTEM TRUNK/TAIL- GATE/FUEL DOORS SYSTEM UNDERHOOD FUSE/RELAY CENTER (LEFT REAR OF ENGINE COMPT) VEHICLE SPEED SENSOR (LEFT REAR OF TRANSMISSION) VEHICLE SPEED SENSOR BUFFER (BEHIND RIGHT END OF I/P) W/O DRL ONLY WARNING SYSTEMS WATER IN FUEL WATER-IN FUEL SENSOR (TOP REAR OF ENGINE) WHT TAN/ WIRE WHT WIRE WHT/BLK WIRE YEL WIRE YEL/BLK WIRE

A/T ACCY AIR BAG DAYTIME RUNNING LAMPS ANTI-LOCK BRAKES ANTI-LOCK BRAKES SYSTEM BLK WIRE BLK/ WHT WIRE BLK/WHT WIRE BRAKE PRESSURE WARNING SWITCH (ON REAR OF BRAKE PRESSURE MODULATOR VALVE BODY) BRAKE/ BRN WIRE BRN/WHT WIRE BULB TEST CHECK GAUGES CHECK GAUGES LAMP DRIVER CONVENIENCE CENTER (BEHIND LEFT SIDE OF I/P) DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE ELECTRONIC PRNDL DISPLAY MODULE ENGINE CONTROLS SYSTEM ENGINE CONTROLS SYSTEM SOUND SYSTEMS ENGINE CONTROLS SYSTEM ENGINE COOLANT TEMPERATURE SENDER (FRONT OF LEFT CYLINDER HEAD) FUEL GAUGE FUEL PUMP OIL PRESSURE SWITCH/SENDER (TOP REAR OF ENGINE) FUEL PUMP, SENDER (IN FUEL TANK) GAUGES FUSE 4 GEN GRY WIRE HEADLIGHTS SYSTEM HEADLIGHTS SYSTEM (DRL) HI BEAM HOT IN RUN OR START I/P FUSE BLOCK (BEHIND LEFT SIDE OF I/P) IGNITION SWITCH ILLUM INSTRUMENT CLUSTER LEFT TURN LOCK OFF LT BLU WIRE LT GRN WIRE LT GRN/BLK WIRE M/T PNK WIRE NCA WIRE OIL PRESS PARK BRAKE WARNING SWITCH (LEFT END OF I/P) PNK WIRE PPL PPL/WHT WIRE RIGHT TURN RUN WIRE SAFETY BELT SERVICE ENGINE SOON SPEED- OMETER STARTING/CHARGING SYSTEM SYSTEM SUPPLEMENTAL RESTRAINTS TACH VOLT- METER TAN WIRE TAN/ WHT WIRE TAN/BLK WIRE TAN/WHT WIRE TEMP GAUGE TRANS FUSE 20 TRANSMISSION RANGE SELECTOR (LEFT SIDE OF TRANSMISSION) TRUNK, TAILGATE, FUEL DOORS SYSTEM TRUNK/TAIL- GATE/FUEL DOORS SYSTEM UP SHIFT VEHICLE SPEED SENSOR (LEFT REAR OF TRANSMISSION) VEHICLE SPEED SENSOR BUFFER (BEHIND RIGHT END OF I/P) W/ DRL ONLY W/O DRL ONLY WARNING SYSTEMS WHT TAN/ WIRE WHT WIRE YEL WIRE

A/C SIG AIR CONDITIONING SYSTEM APP 3 SENS SIG FUEL TEMP SIG IAT SIG B/H BARO SENSOR (VIN F) (UPPER LEFT SIDE OF COWL) BLK WIRE BLK/WHT WIRE BLU WIRE BLU/WHT WIRE BRN WIRE BRN/WHT WIRE DK BLU WIRE DK GRN WIRE ECM I FUSE EGR CONTROL PRESSURE/ BARO SENSOR (VIN P, S) (UPPER LEFT SIDE OF COWL) ENG-I FUSE FUEL HEATER (TOP REAR OF ENGINE) FUEL PUMP OIL PRESSURE SWITCH FUEL PUMP RELAY (RIGHT UPPER COWL) FUEL PUMP/SENDER (IN FUEL TANK) FUSE BLOCK FUSIBLE LINK FUSIBLE LINKS GAUGES FUSE GLOW PLUG CONTROL RELAY (RIGHT REAR TOP OF ENGINE) GLOW PLUG SIG GRY WIRE GRY/BLK WIRE HOT AT ALL TIMES HOT AT ALL TIMES STOP FUSE HOT IN RUN BRAKE FUSE HOT IN RUN, BULB TEST OR START HOT IN START OR RUN GLOW PLUG FUSE IGNITION FEED INSTRUMENT CLUSTER INSTRUMENT CLUSTERS SYSTEM LEFT BANK GLOW PLUGS LT BLU/BLK WIRE LT GRN WIRE MANIFOLD ABSOLUTE PRESSURE SENSOR (TURBO ONLY) (LEFT REAR ENGINE COMPT, AT COWL) ORG/ WIRE ORG/BLK WIRE PNK/BLK WIRE POWERTRAIN CONTROL MODULE (PCM) (UNDER RIGHT END OF I/P) PPL PPL 15 16 PPL/WHT WIRE RED WIRE RED/BLK WIRE RIGHT BANK GLOW PLUGS SERVICE ENGINE SOON LAMP TAN WIRE TAN/BLK WIRE TCC/ BRAKE SWITCH (ON BRAKE PEDAL SUPPORT BRACKET) VIN P ONLY WAIT LAMP "SERVICE THROTTLE" LAMP WASTEGATE SOL CTRL EGR VENT SOL CTRL "SERVICE THROTTLE" LAMP WHT WIRE WHT/BLK WIRE YEL WIRE YEL/BLK WIRE

A/C SIG AIR CONDITIONING SYSTEM APP 3 SENS SIG FUEL TEMP SIG IAT SIG B/H BARO SENSOR (VIN F) (UPPER LEFT SIDE OF COWL) BLK WIRE BLK/WHT WIRE BLU WIRE BLU/WHT WIRE BRN WIRE BRN/WHT WIRE DK BLU WIRE DK GRN WIRE ECM I FUSE EGR CONTROL PRESSURE/ BARO SENSOR (VIN P, S) (UPPER LEFT SIDE OF COWL) ENG-I FUSE FUEL HEATER (TOP REAR OF ENGINE) FUEL PUMP OIL PRESSURE SWITCH FUEL PUMP RELAY (RIGHT UPPER COWL) FUEL PUMP/SENDER (IN FUEL TANK) FUSE BLOCK FUSIBLE LINK FUSIBLE LINKS GAUGES FUSE GLOW PLUG CONTROL RELAY (RIGHT REAR TOP OF ENGINE) GLOW PLUG SIG GRY WIRE GRY/BLK WIRE HOT AT ALL TIMES HOT AT ALL TIMES STOP FUSE HOT IN RUN BRAKE FUSE HOT IN RUN, BULB TEST OR START HOT IN START OR RUN GLOW PLUG FUSE IGNITION FEED INSTRUMENT CLUSTER INSTRUMENT CLUSTERS SYSTEM LEFT BANK GLOW PLUGS LT BLU/BLK WIRE LT GRN WIRE MANIFOLD ABSOLUTE PRESSURE SENSOR (TURBO ONLY) (LEFT REAR ENGINE COMPT, AT COWL) ORG/ WIRE ORG/BLK WIRE PNK/BLK WIRE POWERTRAIN CONTROL MODULE (PCM) (UNDER RIGHT END OF I/P) PPL PPL 15 16 PPL/WHT WIRE RED WIRE RED/BLK WIRE RIGHT BANK GLOW PLUGS SERVICE ENGINE SOON LAMP TAN WIRE TAN/BLK WIRE TCC/ BRAKE SWITCH (ON BRAKE PEDAL SUPPORT BRACKET) VIN P ONLY WAIT LAMP "SERVICE THROTTLE" LAMP WASTEGATE SOL CTRL EGR VENT SOL CTRL "SERVICE THROTTLE" LAMP WHT WIRE WHT/BLK WIRE YEL WIRE YEL/BLK WIRE

11 12 PPL 2-3 SHIFT SOL CTRL FUEL INJ CTRL EGR SOL CTRL ENG SHUT-OFF CTRL 4 WHEEL DRIVE LOW SWITCH 983 474 PPL 999 998 961 452 PPL ACCELERATOR PEDAL POSITION (APP) MODULE (TOP OF ACCELERATOR BRACKET) ANTI-LOCK BRAKES SYSTEM APP 1 SENSOR ENGINE COOLANT TEMPERATURE (ECT) SENSOR (RIGHT SIDE OF ENGINE) APP 2 SENSOR APP 3 SENSOR B/H BATTERY FEED FWD LOW SW BLK WIRE BLK/WHT WIRE BLK/YEL WIRE BLU/WHT WIRE BRN WIRE BRN/WHT WIRE CKP SIG OPTICAL SENS GND OPTICAL SENS CAM SIG CRANK FUSE TRANS FUSE CRUISE CONTROL SYSTEM CRUISE ON/OFF SIG DATA LINK CONNECTOR (UNDER LEFT SIDE OF I/P) DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/WHT WIRE ECM-B FUSE ELECTRONIC 4-SPEED AUTOMATIC OVERDRIVE TRANSMISSION ENGINE SHUT- OFF SOLENOID (TOP FRONT OF ENGINE) FUEL INJ CTRL FUEL SOL FUSE FUEL SOLENOID (TOP FRONT OF ENGINE) FUEL SOLENOID DRIVER (TOP FRONT OF ENGINE) FUSE FUSE BLOCK GLOW PLUG RLY CTRL SERIAL DATA TRANS OUTPUT SPD SIG GRY WIRE GRY/BLK WIRE HOT AT HOT IN RUN ALL TIMES HOT IN CRANK HOT IN START OR RUN LT BLU WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/BLK WIRE OPTICAL/ FUEL TEMP SENSOR (TOP FRONT OF ENGINE) ORG/ WIRE ORG/BLK WIRE PNK WIRE POWERTRAIN CONTROL MODULE (PCM) (UNDER RIGHT END OF I/P) PPL PPL 15 16 PPL/WHT WIRE PRESS CTRL SOL (LO) RANGE MODE SELECTOR RED WIRE RED/BLK WIRE RESUME/ACCEL SIG SET/COAST SIG SPEED SENSOR (LEFT REAR SIDE OF TRANSMISSION) SYSTEM GND CLOSURE SIG APP 2 SENS GND APP 1 SENS GND APP 3 SENS GND SENSOR GND TAN WIRE TAN/BLK WIRE TAN/WHT WIRE TCC BRAKE SW TCC PWM SOL 3-2 SHIFT SOL 2-3 SHIFT SOL 1-2 SHIFT SOL TCC SOL TRANS FLUID TEMP (TFT) SENSOR TRANS OUTPUT VEHICLE SPEED SENSOR BUFFER (UNDER RIGHT END OF I/P) VIN P ONLY VSS VSS HI RESOLUTION SIG VSS INPUT VSS INPUT PRESSURE CONTROL SOL VSS OUTPUT WHT WIRE WHT/BLK WIRE YEL WIRE YEL/BLK WIRE

11 12 PPL A/C SIG AIR CONDITIONING SYSTEM APP 3 SENS SIG FUEL TEMP SIG IAT SIG B/H BARO SENSOR (VIN F) (UPPER LEFT SIDE OF COWL) BLK WIRE BLK/WHT WIRE BLU WIRE BLU/WHT WIRE BRN WIRE BRN/WHT WIRE DK BLU WIRE DK GRN WIRE ECM I FUSE EGR CONTROL PRESSURE/ BARO SENSOR (VIN P, S) (UPPER LEFT SIDE OF COWL) ENG-I FUSE FUEL HEATER (TOP REAR OF ENGINE) FUEL PUMP OIL PRESSURE SWITCH FUEL PUMP RELAY (RIGHT UPPER COWL) FUEL PUMP/SENDER (IN FUEL TANK) FUSE BLOCK FUSIBLE LINK FUSIBLE LINKS GAUGES FUSE GLOW PLUG CONTROL RELAY (RIGHT REAR TOP OF ENGINE) GLOW PLUG SIG GRY WIRE GRY/BLK WIRE HOT AT ALL TIMES HOT AT ALL TIMES STOP FUSE HOT IN RUN BRAKE FUSE HOT IN RUN, BULB TEST OR START HOT IN START OR RUN GLOW PLUG FUSE IGNITION FEED 2-3 SHIFT SOL CTRL INSTRUMENT CLUSTER INSTRUMENT CLUSTERS SYSTEM LEFT BANK GLOW PLUGS LT BLU/BLK WIRE LT GRN WIRE MANIFOLD ABSOLUTE PRESSURE SENSOR (TURBO ONLY) (LEFT REAR ENGINE COMPT, AT COWL) ORG/ WIRE ORG/BLK WIRE PNK/BLK WIRE POWERTRAIN CONTROL MODULE (PCM) (UNDER RIGHT END OF I/P) PPL PPL 15 16 RED WIRE RED/BLK WIRE RIGHT BANK GLOW PLUGS SERVICE ENGINE SOON LAMP TAN WIRE TAN/BLK WIRE TCC/ BRAKE SWITCH (ON BRAKE PEDAL SUPPORT BRACKET) VIN P ONLY WAIT LAMP "SERVICE THROTTLE" LAMP WASTEGATE SOL CTRL EGR VENT SOL CTRL "SERVICE THROTTLE" LAMP WHT WIRE WHT/BLK WIRE YEL WIRE YEL/BLK WIRE