Chevrolet Cab & Chassis C3500 (1989-2000) lt grn Wiring diagrams

1 2 3 4 5 6 7 8 9 10 ILLUMINATION GROUND A/C DISABLE AUX FAN CTRL IGNITION A/C COMPRESSOR CLUTCH A/C COMPRESSOR CLUTCH RELAY (IN UNDERHOOD FUSE/RELAY CENTER) A/C COMPRESSOR CYCLING SWITCH (IN LOW PRESSURE LINE, ON ACCUMULATOR) A/C CTRL A/C HIGH PRESSURE CUTOUT SWITCH (ON A/C COMPRESSOR) A/C LOW PRESSURE CUTOUT SWITCH (ON A/C COMPRESSOR) A/C REQ AUX FAN FUSE AUXILIARY COOLING FAN MOTOR AUXILIARY COOLING FAN RELAY (EXC 4.3L) (IN UNDERHOOD FUSE/RELAY CENTER) BATTERY IGNITION GROUND DEFOGGER ELEMENT BLK WIRE BLK/WHT WIRE BLOWER FUSE 3 BLOWER MOTOR (UNDER RIGHT SIDE OF DASH) BLOWER RESISTOR (ON BLOWER MOTOR HOUSING) BLOWER SWITCH BRN WIRE DIODE DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE FRONT MODE DOOR MOTOR (ON FRONT A/C-HEATER HOUSING) FUSE BLOCK GRY WIRE GRY/BLK WIRE HIGH BLOWER RELAY (ON TOP OF FRONT A/C-HEATER HOUSING) HOT AT ALL TIMES HOT AT ALL TIMES UNDERHOOD FUSE-RELAY CENTER HOT IN RUN HOT IN RUN OR START HTR A/C FUSE 12 HVAC CONTROL MODULE IGN E FUSE A/C COMP FUSE LT BLU WIRE LT GRN WIRE OFF LO ORG/ WIRE PNK WIRE PPL REAR DEFOGGER SYSTEM RED WIRE SW SIG SW SIG RELAY CTRL TAN WIRE UNDERHOOD FUSE-RELAY CENTER VALVE CTRL AIR TEMP DR SENSOR MODE SIGNAL A/C SWITCH VEHICLE CONTROL MODULE (LEFT SIDE OF ENGINE COMPT) WATER VALVE (SUBURBAN, UTILITY, CREW CAB ONLY) (RIGHT CENTER OF INTAKE AREA) WHT WIRE YEL WIRE

A/C COMP FUSE A/C COMPRESSOR CLUTCH A/C COMPRESSOR CLUTCH RELAY (IN UNDERHOOD FUSE BLOCK) A/C COMPRESSOR CYCLING SWITCH A/C CONTROL A/C DISABLE A/C HIGH PRESSURE CUTOUT SWITCH (ON A/C COMPRESSOR) A/C LOW PRESSURE CUTOUT SWITCH A/C REQ A/C SWITCH BLK WIRE BLK/ WHT WIRE BLOWER SWITCH BRN WIRE DIODE DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE FUSE BLOCK HOT IN RUN HTR A/C FUSE 12 HOT IN RUN OR START HVAC CONTROL MODULE LO OFF IGNITION LT GRN WIRE ORG/ WIRE PNK WIRE SW SIG UNDERHOOD FUSE BLOCK IGN E FUSE VEHICLE CONTROL MODULE (LEFT SIDE OF ENGINE COMPT) WHT WIRE

1-2 SHIFT SOL 1-2 SHIFT SOLENOID 2-3 SHIFT SOL 2-3 SHIFT SOLENOID A/T ISS HI IN A/T ISS LO IN AUTOMATIC TRANSMISSION BATTERY IN BLK WIRE BLK/WHT WIRE BLU/WHT WIRE BRAKE FUSE 18 BRAKE SWITCH ASSEMBLY (ON BRAKE PEDAL BRACKET) BRAKE SWITCH INPUT BRN WIRE BRN/WHT WIRE DATA CLASS II DK BLU WIRE ECM 1 FUSE ECM-B FUSE ECT SENS INPUT ELECTRONIC BRAKE CONTROL MODULE ENG 1 FUSE FRONT WHEEL LOCK FUEL INJECTORS, IGNITION CONTROL MOUDULE, IGNITION COIL FUEL PUMP, OIL PRESS SWITCH/ SENDER, FUEL PUMP RELAY GAUGES FUSE 4 GRY WIRE GRY/BLK WIRE HEADLAMP, PANEL DIMMER SWITCH PNK WIRE HOT AT ALL TIMES HOT IN RUN HOT IN RUN OR START HOT IN RUN, BULB TEST OR START I/P FUSE BLOCK IGNITION IN INSTRUMENT CLUSTER LEFT REAR SIDE LT BLU WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/BLK WIRE MAF SENSOR, HEATED OXYGEN SENSORS MALFUNCTION INDICATOR LAMP MIL CONTROL ORG/ WIRE PCM GROUND PCS SOL HI OUT PCS SOL LO OUT PNK WIRE PPL PPL DATA LINK CONNECTOR (UNDER LEFT SIDE OF DASH) PPL/WHT WIRE PRESS CTRL HI SOLENOID LO RANGE SIGNAL "A" RANGE SIGNAL "B" RANGE SIGNAL "C" RED WIRE RED/BLK WIRE SENSOR GROUND SENSOR RETURN TAN WIRE TCC PWM SOL TCC PWM SOLENOID THROTTLE POSITION SENSOR (MOUNTED TO SIDE OF THROTTLE BODY) TP SENS INPUT TRANS FLUID TEMP SENSOR TRANS FUSE 20 TRANS RANGE PRESSURE SWITCH ASSEMBLY TRANS RANGE SWITCHES TRANS TEMP SIG IN TRANSFER CASE, AXLE SWITCHES UNDERHOOD FUSE/RELAY CENTER VEHICLE CONTROL MODULE (VCM) (LEFT SIDE OF ENGINE COMPT) VEHICLE SPEED SENSOR VEHICLE SPEED SENSOR ADAPTOR VSS HI VSS LO YEL WIRE YEL/BLK WIRE

1 2 3 4 5 6 7 8 9 10 ILLUMINATION GROUND A/C DISABLE AUX FAN CTRL IGNITION A/C COMP FUSE A/C COMPRESSOR CLUTCH A/C COMPRESSOR CLUTCH RELAY (IN UNDERHOOD FUSE/RELAY CENTER) A/C COMPRESSOR CYCLING SWITCH (IN LOW PRESSURE LINE, ON ACCUMULATOR) A/C CTRL A/C ENABLE A/C HIGH PRESSURE CUTOUT SWITCH (ON A/C COMPRESSOR) A/C LOW PRESSURE CUTOUT SWITCH (ON A/C COMPRESSOR) AIR TEMP DR SENSOR MODE SIGNAL A/C SWITCH BATTERY IGNITION GROUND DEFOGGER ELEMENT BLK WIRE BLOWER FUSE 3 BLOWER MOTOR BLOWER RESISTOR (UNDER RIGHT SIDE OF DASH, ON HEATER HOUSING) BLOWER SWITCH BRN WIRE DIODE DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE FRONT MODE DOOR MOTOR (UNDER DASH ON HEATER- A/C CASE) FUSE BLOCK GRY WIRE HEATER AND A/C CONTROL MODULE HIGH BLOWER RELAY (UNDER DASH ON TOP OF HEATER-A/C CASE) HOT AT ALL TIMES UNDERHOOD FUSE-RELAY CENTER HOT IN RUN HOT IN RUN OR START HTR A/C FUSE 12 IGN 1 FUSE LT BLU WIRE LT GRN WIRE OFF LO ORG/ WIRE PNK WIRE POWERTRAIN CONTROL MODULE (LEFT REAR OF ENGINE COMPT) PPL REAR DEFOGGER SYSTEM RED WIRE TAN WIRE WHT WIRE YEL WIRE

A/C COMP FUSE A/C COMPRESSOR CLUTCH A/C COMPRESSOR CLUTCH RELAY (IN UNDERHOOD FUSE/RELAY CENTER) A/C COMPRESSOR CYCLING SWITCH A/C CONTROL A/C DISABLE A/C ENABLE A/C HIGH PRESSURE CUTOUT SWITCH (ON A/C COMPRESSOR) A/C LOW PRESSURE CUTOUT SWITCH A/C SWITCH BLK WIRE BLOWER SWITCH BRN WIRE DIODE DK GRN WIRE DK GRN/WHT WIRE FUSE BLOCK HOT IN RUN HVAC CONTROL MODULE HTR A/C FUSE 12 HOT IN RUN OR START IGNITION LO OFF LT GRN WIRE ORG/ WIRE PNK WIRE POWERTRAIN CONTROL MODULE (BEHIND RIGHT SIDE OF DASH) RECIRC SIGNAL RECIRCULATION DOOR MOTOR (ON A/C- HEATER HOUSING) UNDERHOOD FUSE BLOCK IGN 1 FUSE WHT WIRE

1 2 3 4 5 6 7 8 9 10 ILLUMINATION GROUND A/C DISABLE AUX FAN CTRL IGNITION A/C COMPRESSOR CLUTCH A/C COMPRESSOR CLUTCH RELAY (IN UNDERHOOD FUSE/RELAY CENTER) A/C COMPRESSOR CYCLING SWITCH (IN LOW PRESSURE LINE, ON ACCUMULATOR) A/C CTRL A/C HIGH PRESSURE CUTOUT SWITCH (ON A/C COMPRESSOR) A/C LOW PRESSURE CUTOUT SWITCH (ON A/C COMPRESSOR) A/C REQ AUX FAN FUSE AUXILIARY COOLING FAN MOTOR AUXILIARY COOLING FAN RELAY (EXC 4.3L) (IN UNDERHOOD FUSE/RELAY CENTER) BATTERY IGNITION GROUND DEFOGGER ELEMENT BLK WIRE BLK/WHT WIRE BLOWER FUSE 3 BLOWER MOTOR (UNDER RIGHT SIDE OF DASH) BLOWER RESISTOR (ON BLOWER MOTOR HOUSING) BLOWER SWITCH BRN WIRE DIODE DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE FRONT MODE DOOR MOTOR (ON FRONT A/C-HEATER HOUSING) FUSE BLOCK GRY WIRE GRY/BLK WIRE HIGH BLOWER RELAY (ON TOP OF FRONT A/C-HEATER HOUSING) HOT AT ALL TIMES HOT AT ALL TIMES UNDERHOOD FUSE-RELAY CENTER HOT IN RUN HOT IN RUN OR START HTR A/C FUSE 12 HVAC CONTROL MODULE IGN E FUSE A/C COMP FUSE LT BLU WIRE LT GRN WIRE OFF LO ORG/ WIRE PNK WIRE PPL REAR DEFOGGER SYSTEM RED WIRE SW SIG SW SIG RELAY CTRL TAN WIRE UNDERHOOD FUSE-RELAY CENTER VALVE CTRL AIR TEMP DR SENSOR MODE SIGNAL A/C SWITCH VEHICLE CONTROL MODULE (LEFT SIDE OF ENGINE COMPT) WATER VALVE (SUBURBAN, UTILITY, CREW CAB ONLY) (RIGHT CENTER OF INTAKE AREA) WHT WIRE YEL WIRE

A/C COMP FUSE A/C COMPRESSOR CLUTCH A/C COMPRESSOR CLUTCH RELAY (IN UNDERHOOD FUSE BLOCK) A/C COMPRESSOR CYCLING SWITCH A/C CONTROL A/C DISABLE A/C HIGH PRESSURE CUTOUT SWITCH (ON A/C COMPRESSOR) A/C LOW PRESSURE CUTOUT SWITCH A/C REQ A/C SWITCH BLK WIRE BLK/ WHT WIRE BLOWER SWITCH BRN WIRE DIODE DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE FUSE BLOCK HOT IN RUN HTR A/C FUSE 12 HOT IN RUN OR START HVAC CONTROL MODULE LO OFF IGNITION LT GRN WIRE ORG/ WIRE PNK WIRE SW SIG UNDERHOOD FUSE BLOCK IGN E FUSE VEHICLE CONTROL MODULE (LEFT SIDE OF ENGINE COMPT) WHT WIRE

1-2 SHIFT SOL 1-2 SHIFT SOLENOID 2-3 SHIFT SOL 2-3 SHIFT SOLENOID A/T ISS HI IN A/T ISS LO IN AUTOMATIC TRANSMISSION BATTERY IN BLK WIRE BLK/WHT WIRE BLU/WHT WIRE BRAKE FUSE 18 BRAKE SWITCH ASSEMBLY (ON BRAKE PEDAL BRACKET) BRAKE SWITCH INPUT BRN WIRE BRN/WHT WIRE DATA CLASS II DK BLU WIRE ECM 1 FUSE ECM-B FUSE ECT SENS INPUT ELECTRONIC BRAKE CONTROL MODULE ENG 1 FUSE FRONT WHEEL LOCK FUEL INJECTORS, IGNITION CONTROL MOUDULE, IGNITION COIL FUEL PUMP, OIL PRESS SWITCH/ SENDER, FUEL PUMP RELAY GAUGES FUSE 4 GRY WIRE GRY/BLK WIRE HEADLAMP, PANEL DIMMER SWITCH PNK WIRE HOT AT ALL TIMES HOT IN RUN HOT IN RUN OR START HOT IN RUN, BULB TEST OR START I/P FUSE BLOCK IGNITION IN INSTRUMENT CLUSTER LEFT REAR SIDE LT BLU WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/BLK WIRE MAF SENSOR, HEATED OXYGEN SENSORS MALFUNCTION INDICATOR LAMP MIL CONTROL ORG/ WIRE PCM GROUND PCS SOL HI OUT PCS SOL LO OUT PNK WIRE PPL PPL DATA LINK CONNECTOR (UNDER LEFT SIDE OF DASH) PPL/WHT WIRE PRESS CTRL HI SOLENOID LO RANGE SIGNAL "A" RANGE SIGNAL "B" RANGE SIGNAL "C" RED WIRE RED/BLK WIRE SENSOR GROUND SENSOR RETURN TAN WIRE TCC PWM SOL TCC PWM SOLENOID THROTTLE POSITION SENSOR (MOUNTED TO SIDE OF THROTTLE BODY) TP SENS INPUT TRANS FLUID TEMP SENSOR TRANS FUSE 20 TRANS RANGE PRESSURE SWITCH ASSEMBLY TRANS RANGE SWITCHES TRANS TEMP SIG IN TRANSFER CASE, AXLE SWITCHES UNDERHOOD FUSE/RELAY CENTER VEHICLE CONTROL MODULE (VCM) (LEFT SIDE OF ENGINE COMPT) VEHICLE SPEED SENSOR VEHICLE SPEED SENSOR ADAPTOR VSS HI VSS LO YEL WIRE YEL/BLK WIRE

BLK WIRE HOT IN RUN OR START I/P FUSE BLOCK LEFT BACK-UP LAMP LT GRN WIRE MIRRORS SYSTEM (AUTOMATIC DAY/NIGHT MIRROR) PNK A/T WIRE PNK M/T WIRE PNK WIRE RIGHT BACK-UP LAMP TRAILER TOW CONNECTOR TRANSMISSION RANGE SWITCH (LEFT SIDE OF TRANSMISSION) TURN B/U FUSE 16

1134 1134 39 10 10 PARK BRAKE SIG IND BULB CHK IGNITION LAMP FEED PNK WIRE 33 33 BRAKE IND CTRL BRAKE WARN IN 592 592 150 DRL RELAY CTRL BLK WIRE BLK/WHT WIRE BRN WIRE BULB TEST CONVENIENCE CENTER (UNDER LEFT SIDE OF DASH) DAYTIME RUNNING LAMP MODULE (BEHIND LEFT SIDE OF DASH) DAYTIME RUNNING LAMPS RELAY DIODE 203 DRL INDICATOR DRL-FOG FUSE 15 FOG LAMP RELAY FOG LAMP SWITCH GAUGES FUSE 4 GRN WIRE GROUND GRY WIRE HEAD OFF PARK HEAD- LAMP DIMMER SWITCH HEADLAMP, PANEL DIMMER SWITCH HIGH BEAM INDICATOR HOT AT ALL TIMES HOT IN RUN, BULB TEST OR START I/P FUSE BLOCK (LEFT SIDE OF DASH, IGNITION SWITCH ILLUM LAMP INSTRUMENT CLUSTER INSTRUMENT CLUSTER SYSTEM (BRAKE WARNING INDICATOR) LEFT FOG LAMP LEFT HEAD- LAMP RIGHT HEAD- LAMP LIGHTING FUSE 8 LOCK OFF LT BLU WIRE LT GRN WIRE LT GRN/BLK WIRE NCA WIRE OFF ON INDICATOR ORG/ WIRE PARK BRAKE WARNING SWITCH PK LPS FUSE 9 PNK WIRE PPL RED WIRE RIGHT FOG LAMP RUN WIRE TAN WIRE TAN/WHT WIRE UNDERHOOD FUSE BLOCK (LEFT REAR OF ENGINE COMPT) W/ FOG LAMPS WHT WIRE YEL WIRE