Chevrolet Cab & Chassis C3500 (1989-2000) grn Wiring diagrams

39 (OR 1020) 7.4L VIN J ONLY 900 419 507 389 12 5 15 4 FUEL RET MIL IND UPSHIFT IND SPEEDO ACCY ANTI- LOCK BRAKES IND ANTI-LOCK BRAKES SYSTEM ANTI-THEFT SYSTEM BAT IND HI BEAM IND BLK WIRE BLK/WHT WIRE BRAKE IND BRAKE PRESSURE WARNING SWITCH (ON UNDERSIDE OF ELECTRONIC BRAKE CONTROL MODULE) BRN WIRE BRN/WHT WIRE CHECK GAUGES IND CHECK GAUGES LAMP DRIVER CONVENIENCE CENTER DAYTIME RUNNING LAMPS IND AIR BAG IND DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE ELECTRONIC BRAKE CONTROL MODULE (EBCM) (ON LEFT SIDE OF ENGINE COMPT) ENGINE CONTROLS SYSTEM (FUEL PUMP BALANCE RELAY) FUEL GAUGE FUEL PUMP BALANCE MODULE (INSIDE LEFT SIDE OF FRAME RAIL) FUEL PUMP, SENDER (IN FUEL TANK) GRN WIRE GRY WIRE HEADLIGHTS SYSTEM HOT IN RUN OR START I/P FUSE BLOCK GAUGES FUSE 4 HOT IN RUN, BULB TEST OR START IGN IGN E MINI FUSE IGN SW BRAKE IND BRAKE PSI PK BRAKE 33 33 IGNITION COIL (TOP LEFT REAR OF ENGINE) IGNITION SWITCH ILLUMINATION INSTRUMENT CLUSTER LED DIMMING LEFT TURN IND LOCK OFF LT BLU WIRE LT GRN WIRE LT GRN/BLK WIRE M/T A/T PNK WIRE MALFUNC- TION INDICATOR LAMP NCA WIRE PARITY PRNDL PARK BRAKE SWITCH (ON PARK BRAKE PEDAL BRACKET) PNK WIRE PPL PPL 9 29 30 FUEL VSS VSS PPL/WHT WIRE PRNDL PRNDL A PRNDL B PRNDL C RIGHT TURN IND RUN WIRE SAFETY BELT IND SECONDARY FUEL GAUGE SENDER (IN REAR FUEL TANK) SECURITY IND SENS RTRN FUEL IN SERVICE ENGINE SOON SINGLE FUEL TANK DUAL FUEL TANKS SPEEDOMETER STARTING/CHARGING SYSTEM SUPPLEMENTAL RESTRAINTS SYSTEM TACH TAN WIRE TAN/WHT WIRE TEMP GAUGE OIL GAUGE TRANS FUSE 20 TRANSMISSION RANGE SWITCH TWISTED PAIR UNDERHOOD FUSE BLOCK UPSHIFT IND (M/T ONLY) VEHICLE CONTROL MODULE (VCM) (LEFT SIDE OF ENGINE COMPT) VEHICLE SPEED SENSOR (LEFT SIDE OF TRANSMISSION, LEFT SIDE OF TRAN- VEHICLE SPEED SENSOR (VSS) ADAPTER VOLTMETER WARNING SYSTEMS WHT WIRE YEL WIRE

A/T M/T ACCY ANTI-LOCK BRAKES SYSTEM BLK WIRE BLK/WHT WIRE BRAKE PRESSURE WARNING SWITCH (ON REAR OF EBCM CASTING) BRN WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/WHT WIRE DUAL FUEL TANKS SINGLE FUEL TANK ELECTRONIC BRAKE CONTROL MODULE (EBCM) (ON LEFT SIDE OF ENGINE COMPT) ENG-1 MINI FUSE ENGINE CONTROLS SYSTEM (FUEL PUMP BALANCE RELAY) ENGINE CONTROLS SYSTEM RADIO ENGINE CONTROLS SYSTEM FUEL GAUGE SENDER (IN FRONT FUEL TANK) FUEL PUMP BALANCE MODULE (INSIDE LEFT SIDE OF FRAME RAIL) FUEL PUMP/ SENDER GAUGES FUSE 4 GRN WIRE HOT IN RUN OR START HOT IN RUN OR START FUSE/RELAY BLOCK (LEFT REAR OF ENGINE COMPT) HOT IN RUN, BULB TEST OR START I/P FUSE BLOCK (UNDER LEFT SIDE OF DASH) IGN E MINI FUSE IGN SW BRAKE IND BRAKE PSI PK BRAKE 33 33 IGNITION SWITCH LOCK OFF LT BLU WIRE LT GRN WIRE LT GRN/BLK WIRE NCA WIRE PARK BRAKE SWITCH (ON PARK BRAKE PEDAL BRACKET) PNK 639 975 970 497 451 30 WIRE PNK PNK WIRE PNK PPL WIRE PNK WIRE PPL PPL/WHT WIRE RUN WIRE SECONDARY FUEL GAUGE SENDER (IN REAR FUEL TANK) TAN/WHT WIRE TRANS FUSE 20 TWISTED PAIR VEHICLE SPEED SENSOR (LEFT SIDE OF TRANSMISSION, LEFT SIDE OF TRANSFER CASE VEHICLE SPEED SENSOR (VSS) ADAPTER VEHICLE SPEED SENSOR BUFFER (BEHIND RIGHT SIDE OF DASH) YEL/BLK WIRE

39 (OR 1020) 7.4L VIN J ONLY 900 419 507 389 12 5 15 4 FUEL RET MIL IND UPSHIFT IND SPEEDO ACCY ANTI- LOCK BRAKES IND ANTI-LOCK BRAKES SYSTEM ANTI-THEFT SYSTEM BAT IND HI BEAM IND BLK WIRE BLK/WHT WIRE BRAKE IND BRAKE PRESSURE WARNING SWITCH (ON UNDERSIDE OF ELECTRONIC BRAKE CONTROL MODULE) BRN WIRE BRN/WHT WIRE CHECK GAUGES IND CHECK GAUGES LAMP DRIVER CONVENIENCE CENTER DAYTIME RUNNING LAMPS IND AIR BAG IND DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE ELECTRONIC BRAKE CONTROL MODULE (EBCM) (ON LEFT SIDE OF ENGINE COMPT) ENGINE CONTROLS SYSTEM (FUEL PUMP BALANCE RELAY) FUEL GAUGE FUEL PUMP BALANCE MODULE (INSIDE LEFT SIDE OF FRAME RAIL) FUEL PUMP, SENDER (IN FUEL TANK) GRN WIRE GRY WIRE HEADLIGHTS SYSTEM HOT IN RUN OR START I/P FUSE BLOCK GAUGES FUSE 4 HOT IN RUN, BULB TEST OR START IGN IGN E MINI FUSE IGN SW BRAKE IND BRAKE PSI PK BRAKE 33 33 IGNITION COIL (TOP LEFT REAR OF ENGINE) IGNITION SWITCH ILLUMINATION INSTRUMENT CLUSTER LED DIMMING LEFT TURN IND LOCK OFF LT BLU WIRE LT GRN WIRE LT GRN/BLK WIRE M/T A/T PNK WIRE MALFUNC- TION INDICATOR LAMP NCA WIRE PARITY PRNDL PARK BRAKE SWITCH (ON PARK BRAKE PEDAL BRACKET) PNK WIRE PPL PPL 9 29 30 FUEL VSS VSS PPL/WHT WIRE PRNDL PRNDL A PRNDL B PRNDL C RIGHT TURN IND RUN WIRE SAFETY BELT IND SECONDARY FUEL GAUGE SENDER (IN REAR FUEL TANK) SECURITY IND SENS RTRN FUEL IN SERVICE ENGINE SOON SINGLE FUEL TANK DUAL FUEL TANKS SPEEDOMETER STARTING/CHARGING SYSTEM SUPPLEMENTAL RESTRAINTS SYSTEM TACH TAN WIRE TAN/WHT WIRE TEMP GAUGE OIL GAUGE TRANS FUSE 20 TRANSMISSION RANGE SWITCH TWISTED PAIR UNDERHOOD FUSE BLOCK UPSHIFT IND (M/T ONLY) VEHICLE CONTROL MODULE (VCM) (LEFT SIDE OF ENGINE COMPT) VEHICLE SPEED SENSOR (LEFT SIDE OF TRANSMISSION, LEFT SIDE OF TRAN- VEHICLE SPEED SENSOR (VSS) ADAPTER VOLTMETER WARNING SYSTEMS WHT WIRE YEL WIRE

1134 1134 39 10 10 PARK BRAKE SIG IND BULB CHK IGNITION LAMP FEED PNK WIRE 33 33 BRAKE IND CTRL BRAKE WARN IN 592 592 150 DRL RELAY CTRL BLK WIRE BLK/WHT WIRE BRN WIRE BULB TEST CONVENIENCE CENTER (UNDER LEFT SIDE OF DASH) DAYTIME RUNNING LAMP MODULE (BEHIND LEFT SIDE OF DASH) DAYTIME RUNNING LAMPS RELAY DIODE 203 DRL INDICATOR DRL-FOG FUSE 15 FOG LAMP RELAY FOG LAMP SWITCH GAUGES FUSE 4 GRN WIRE GROUND GRY WIRE HEAD OFF PARK HEAD- LAMP DIMMER SWITCH HEADLAMP, PANEL DIMMER SWITCH HIGH BEAM INDICATOR HOT AT ALL TIMES HOT IN RUN, BULB TEST OR START I/P FUSE BLOCK (LEFT SIDE OF DASH, IGNITION SWITCH ILLUM LAMP INSTRUMENT CLUSTER INSTRUMENT CLUSTER SYSTEM (BRAKE WARNING INDICATOR) LEFT FOG LAMP LEFT HEAD- LAMP RIGHT HEAD- LAMP LIGHTING FUSE 8 LOCK OFF LT BLU WIRE LT GRN WIRE LT GRN/BLK WIRE NCA WIRE OFF ON INDICATOR ORG/ WIRE PARK BRAKE WARNING SWITCH PK LPS FUSE 9 PNK WIRE PPL RED WIRE RIGHT FOG LAMP RUN WIRE TAN WIRE TAN/WHT WIRE UNDERHOOD FUSE BLOCK (LEFT REAR OF ENGINE COMPT) W/ FOG LAMPS WHT WIRE YEL WIRE

AUDIO ALARM MODULE (ON CONVENIENCE CENTER) AUTOMATIC TRANSFER CASE CONTROL SWITCH (LUXURY) AUTOMATIC TRANSFER CASH SELECT SWITCH AUXILIARY HEATER CONTROL BASE BLK WIRE CARGO LAMP SWITCH (PICKUP ONLY) TRANSFER CASE SWITCH CONVEN- IENCE CENTER DAYTIME RUNNING LAMP (DRL)/ RADIO OVERRIDE SWITCH DAYTIME RUNNING LAMPS (DRL)/ RADIO OVERRIDE SWITCH DISPLAY DIM SIG DISPLAY DISPLAY DIM DIM SIG SIG FOG LAMP SWITCH FRONT AUXILIARY HVAC CONTROL LAMP GRN WIRE GRY WIRE HEADLAMP, PANEL DIMMER SWITCH HOT AT ALL TIMES HVAC CONTROL LAMP I/P FUSE BLOCK ILLUM FUSE 14 ILLUMINATION INFLATABLE RESTAINT I/P MODULE SWITCH INSTRUMENT CLUSTER LIFTGATE RELEASE SWITCH (SUBUR- BAN/ UTILITIY ONLY) LUXURY OFF ORG/ WIRE PARADE MODE SW PARK PARK LPS FUSE 9 PICKUP/ EXTENDED CAB ONLY PPL PPL PPL RADIO RADIO INFLATABLE RESTAINT I/P MODULE SWITCH REAR AUXILIARY HVAC CONTROL LAMP REAR AUXILIARY HVAC CONTROL SWITCH REAR WINDOW WIPER/ WASHER SWITCH RHEO- STAT SUBURBAN, UTILITY ONLY SWITCH (SUBUR- BAN/ UTILITIY ONLY) TRANSFER CASE SHIFT ILLUMINATION LAMP TRANSFER CASE SWITCH WHT WIRE

2-3 SHIFT SOL CTRL 3-2 SHIFT SOL CTRL AIR PUMP REL CTRL VSS SIG BLK WIRE BLK/WHT WIRE BLU WIRE BRN WIRE BRN/WHT WIRE CAM POSIT SENS SIG CAMSHAFT POSITION SENSOR (INSIDE DISTRIBUTOR) DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/WHT WIRE DK PNK WIRE GRN WIRE IGN FEED SENS RTN INLINE GENDER ADAPTER KNOCK SENS SIG LOW REF FUEL GAUGE LVL TCC SOL CTRL PPL LT BLU/BLK WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/WHT WIRE LT LT LT PPL NCA WIRE OTHERS PNK IGNITION FEED WIRE PNK PNK 1 2 3 4 5 6 7 8 WIRE PNK PNK PNK PNK WIRE PNK PPL WIRE PNK WIRE PNK/BLK WIRE PPL PPL PNK WIRE PPL SENSOR RETURN LOW REF VSS SIGNAL CRANK POSIT SENS SIG PPL/WHT WIRE RED/BLK WIRE SENS SIG SENSOR RETURN SENSOR SIGNAL TAN WIRE TAN/BLK WIRE TAN/WHT WIRE VEHICLE CONTROL MODULE (VCM) (LEFT SIDE OF ENGINE COMPT) VEHICLE SPEED SENSOR (LEFT SIDE OF TRANSMISSION, LEFT SIDE OF VENT CTLR WHT WIRE YEL WIRE YEL/BLK WIRE

1-2 SHIFT SOL LT 16 17 18 PPL 2-3 SHIFT SOLENOID 3-2 SHIFT SOLENOID AIR INJECTION REACTION PUMP MOTOR (LEFT FRONT OF ENG COMPT) AIR INJECTION REACTION PUMP RELAY (CALIFORNIA) (UNDERHOOD FUSE/ RELAY CENTER) AUTOMATIC TRANSMISSION AUTOMATIC TRANSMISSION FLUID PRESSURE (TFP) MANUAL VALVE POSITION SWITCH AUX-B FUSE BLK WIRE BLK/WHT WIRE BLU WIRE BRN WIRE BRN/WHT WIRE DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/WHT WIRE EVAPORATIVE EMISSIONS (EVAP) CANISTER VENT VALVE (LEFT SIDE OF ENGINE COMPT) EXHAUST GAS RECIRCULATION (EGR) VALVE (FRONT OF ENGINE NEAR THERMOSTAT HOUSING) FUEL INJ 1 FUEL INJ 2 FUEL INJ 3 FUEL INJ 4 FUEL INJ 5 FUEL INJ 6 FUEL INJ 7 FUSE GRN WIRE GRY WIRE HOT AT ALL TIMES HOT IN RUN, START HOT IN RUN, START UNDER HOOD FUSE/RELAY CENTER LT BLU WIRE LT BLU/BLK WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/BLK WIRE LT PNK WIRE NCA WIRE ORG/ WIRE PNK FUEL INJ 8 WIRE PNK PNK 1 2 3 4 5 6 7 8 WIRE PNK PNK PNK 3 4 5 6 7 8 9 10 11 12 13 14 WIRE PNK PNK PNK PNK PNK WIRE PNK PNK PNK PNK WIRE PNK PNK WIRE PNK WIRE PNK/BLK WIRE PPL PPL LT PPL PNK WIRE PPL/WHT WIRE PRESSURE CONTROL SOLENOID VALVE RED WIRE RED/BLK WIRE SOLENOID CHECK VALVE TAN WIRE TAN/BLK WIRE TAN/WHT WIRE TCC SOLENOID TORQUE CONVERTER CLUTCH PULSE WIDTH MODULATION SOLENOID TRANS FLUID TEMPERATURE SENSOR WHT WIRE YEL WIRE YEL/BLK WIRE

16 PPL 32 33 PPL AUTOMATIC TRANSMISSION INPUT SHAFT SPEED SENSOR (LEFT SIDE OF TRANSMISSION) BLK WIRE BLK/WHT WIRE BLU WIRE BLU/WHT WIRE BRN WIRE BRN/WHT WIRE CONVENIENCE CENTER (UNDER LEFT SIDE OF DASH) DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE FUEL GAUGE FUEL PUMP, SENDER (IN FUEL TANK) FUEL TANK PRESSURE SENSOR (IN FUEL TANK) GAUGES FUSE 4 GRN WIRE GRY WIRE GRY/BLK WIRE HOT IN OFF, RUN OR START HOT IN RUN OR START I/P FUSE BLOCK INPUT INSTRUMENT CLUSTER INTAKE AIR TEMPERATURE SENSOR (IN AIR INTAKE DUCT) LT BLU/WHT WIRE LT GRN WIRE M/T ONLY MASS AIRFLOW SENSOR (IN AIR INTAKE DUCT) PNK (TAILLAMP EXTENSION HARN, 6 CM FROM THE FUEL PUMP HARN BREAKOUT) WIRE PNK 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 WIRE PNK PNK PNK WIRE PNK WIRE PPL PPL/WHT WIRE RED WIRE RED/BLK WIRE SERVICE ENGINE SOON INDICATOR SIG IGN GRD PNK WIRE SPEEDOMETER TACHOMETER TAN WIRE TAN/BLK WIRE THROTTLE POSITION SENSOR (ON THROTTLE BODY ASSEMBLY) TRANS FUSE 20 UPSHIFT LAMP W/O DUAL FUEL TANK WHT WIRE YEL WIRE YEL/BLK WIRE

A/C REQUEST SIGNAL AIR CONDITIONING SYSTEM AIR INLET VLV MTR CTLR AUTOMATIC AUTOMATIC TRANSFER CASE SHIFT CONTROLLER BLK WIRE BLK/WHT WIRE BLU WIRE BLU/WHT WIRE BRAKE FUSE 18 BRN WIRE BRN/WHT WIRE CLUTCH PEDAL POSITION (CPP) SWITCH (AT TOP OF CLUTCH PEDAL BRACKET) CPP SW INPUT FOUR WHL DR SIG LO CRUISE CTRL SIG ENG 23 24 CRUISE CONTROL MODULE (LEFT REAR OF ENGINE COMPT, ON FIREWALL) DATA LINK CONNECTOR (UNDER LEFT SIDE OF DASH, LEFT SIDE OF STEERING COLUMN) DISTRIBUTOR DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE ELECTRONIC BRAKE CONTROL MODULE (EBCM) (ON LEFT SIDE OF ENGINE COMPT) ELECTRONIC VARIABLE ORIFICE/ PASSLOCK CONTROL MODULE (CENTER OF DASH) FORCE MOTOR FEED TRANS INPUT SPEED RTN TRANS INPUT SPEED SIG EST OUTPUT SIG FORCE MOTOR RETURN GROUND GROUND SENSOR GROUND FUEL LEVEL INPUT SWITCH SIGNAL FUEL PUMP PRIME CONNECTOR (LEFT REAR OF ENG COMPT) FUEL PUMP RELAY GRN WIRE GROUND GRY WIRE GRY/BLK WIRE HIGH VOLTAGE COIL WIRE HOT AT ALL TIMES UNDERHOOD FUSE- RELAY CENTER ECMB FUSE HOT IN RUN I/P FUSE BLOCK IGN INPUT BRAKE SW INPUT INPUT IGNITION IGNITION COIL (TOP RIGHT REAR OF ENGINE) IGNITION CONTROL MODULE (RIGHT SIDE REAR OF ENGINE) IGNITION FEED IGN TIMING SIG. IGN COIL OUT IGNITION PRESSURE SWITCH INPUT PRESSURE SWITCH INPUT LT BLU/BLK WIRE LT BLU/WHT WIRE LT DK VSS INPUT SERIAL DATA SIG MANUAL OR SELECTABLE ORG/ WIRE PNK 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 WIRE PNK IGNITION FOUR WHL DR SIG EGR VLV GROUND WIRE PNK PNK PNK WIRE PNK WIRE PPL PPL (OR PPL A/T M/T PPL PPL PPL PPL 420 OR PPL/WHT WIRE PRESSURE SWITCH INPUT RADIO RED WIRE RED/BLK WIRE SENSOR RETURN SHIFT IND LP OUT EGR VLV FEED SPEED SENSOR SPEED SENSOR INPUT STOPLAMP/ CLUTCH SWITCH INPUT VCM SIG STOPLAMP SWITCH (TOP OF BRAKE PEDAL) SWITCH SIGNAL TAN/BLK WIRE TRANSFER CASE CONTROL MODULE (UNDER DASH ON STEERING COLUMN SUPPORT BRACKET) TRANSFER CASE SWITCH (LEFT TOP OF TRANSFER CASE) TRANSMISSIONS SYSTEM UNDERHOOD FUSE-RELAY CENTER VEHICLE CONTROL MODULE (VCM) (LEFT SIDE OF ENGINE COMPT) WHT WIRE WHT/BLK WIRE YEL WIRE YEL/BLK WIRE