Chevrolet Aveo I facelift (2006-2012) org/ Wiring diagrams

12 14 PPL BATTERY BLK WIRE CHARGE IND COMPUTER DATA LINES SYSTEM DK GRN WIRE ENGINE CONTROL MODULE (ECM) (LEFT FRONT FENDER, NEAR THE BATTERY) FUSE FUSE HOLDER GENERATOR GRN WIRE HOT AT ALL TIMES IGN IGNITION SWITCH INSTRUMENT PANEL CLUSTER (IPC) LOGIC OFF ORG/ WIRE POWER DISTRIBUTION SYSTEM PPL 10 11 RED WIRE RUN WIRE STARTER MOTOR YEL WIRE

ABS IND. AIR BAG IND BATT VOLT + BATT VOLT + BLK WIRE BRAKE IND BRN WIRE BRN/WHT WIRE CHARGE IND CLOCK CIRCUIT CLOCK CIRCUIT WARNING SYSTEM ANTI-THEFT SYSTEM WARNING SYSTEM COMPUTER DATA LINES SYSTEM COMPUTER DATA LINES SYSTEM POWER WINDOWS SYSTEM COURTESY LP LO CTRL SIG CRUISE IND DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE DOOR LOCKS SYSTEM DR LOCK IND DRL IND ENGINE COOLANT TEMPERATURE GAUGE FOG LAMP IND FOG LP SW SPLY VOLT A/T SHIFT LK CTRL SOL ABS IND FAILURE CTRL FUEL LEVEL GAUGE FUSE GND GND GRY WIRE GRY/BLK WIRE HEADLIGHTS SYSTEM HEADLIGHTS SYSTEM EXTERIOR LIGHTS SYSTEM HEADLIGHTS SYSTEM TRANSMISSIONS SYSTEM ANTI-LOCK BRAKES SYSTEM HI-BEAM IND HOLD IND HOT AT ALL TIMES IGN IGNITION SWITCH INSTRUMENT PANEL CLUSTER (IPC) INTERIOR LIGHTS SYSTEM COMPUTER DATA LINES SYSTEM IPC FUSE BLOCK (LEFT SIDE OF ENGINE COMPT) LH TURN IND LOGIC LOW FUEL IND LOW TIRE PRESSURE IND LT BLU WIRE LT GRN WIRE MALFUNCTION IND MIL CTRL BRAKE WARN IND CTRL OFF OIL PRESSURE IND ORG/ WIRE ORG/BLK WIRE PANEL LAMP CTRL DIC SW SIG REMOTE CTRL DR SIG POWER DISTRIBUTION SYSTEM PPL RED/BLK WIRE RED/WHT WIRE RH TURN IND RUN WIRE SAFETY SW SIG LH SEAT BELT SW SEAT BELT IND SECURITY IND CTRL CHARGE IND SIG KEY IN IGN SW SIG VEHICLE SPD SIG CHIME CTRL SHIFT INTERLOCK SYSTEM SEATS SYSTEM SPEEDOMETER TACHOMETER UNDERHOOD WHT WIRE YEL WIRE YEL/BLK WIRE

A/ CON A/ CON RELAY A/C COMP A/C RELAY AUTOMATIC TRANSMISSION SHIFT PROGRAM SWITCH (4 SPEED TRANSMISSION) BATTERY BLK WIRE BRN WIRE CLOCK HVAC CONTROL MODULE (MANUAL A/C) DK BLU WIRE DK GRN WIRE DLIS FAN HI FAN HI RELAY FAN LOW FAN LOW RELAY FUEL PUMP FUEL PUMP RELAY FUSE FUSE HOLDER FUSE 100 A GENERATOR HAZARD HAZARD WARNING SWITCH HOOD AJAR SWITCH HVAC DRIVER CONTROL SEAT MODULE HEATED SWITCH (AUTOMATIC (IF EQUIPPED) A/C) I/P DIMMER SWITCH (IF EQUIPPED) I/P FUSE BLOCK (LEFT SIDE OF DASH, IN DOOR OPENING) IGN 1 RELAY IGNITION SWITCH INSTRUMENT PANEL CLUSTER (IPC) KEY-IN IGNITION SWITCH LOGIC LT BLU WIRE LT GRN WIRE OFF OFF ON ORG/ WIRE PNK WIRE PPL RADIO RED WIRE SHUNT SPLICE PACK STARTER MOTOR TO CIGAR LIGHTER (DIAGRAM 3 OF 4) TO ECU TO EMS 1 TO I/P FUSE BLOCK (DIAGRAM 2 OF 4) TO PKLP RH TO UNDERHOOD FUSE BLOCK (DIAGRAM 2 OF 4) WHT WIRE

ACC/RAP ACC/RAP RELAY BLK WIRE BLOWER MOTOR SWITCH DATA LINK CONNECTOR (DLC) DEFOG MIRROR FUSE DEFOGGER RELAY DK BLU WIRE DOOR LOCK CLOCK REMOTE CONTROL RECEIVER (RCDLR) (W/ THEFT DETERRENT) DOOR LOCK FUSE DOOR LOCK RELAY DOOR UNLOCK RELAY DRIVER HVAC OUTSIDE CONTROL REARVIEW MODULE MIRROR DRIVER WINDOW SWITCH ENGINE CONTROL MODULE (ECM) FIELD EFFECT TRANSISTOR NA DRL FUSE FROM FAN HI FROM FUSE IGN 1 RELAY (DIAGRAM 1 OF 4) FROM INSTRUMENT PANEL CLUSTER (DIAGRAM 1 OF 4) FUSE GRN WIRE HAZARD STOP TIRE WARNING LAMP PRESSURE SWITCH SWITCH MODULE (IF EQUIPPED) HORN RELAY I/P FUSE BLOCK (LEFT SIDE OF DASH, IN DOOR OPENING) INFLATABLE RESTRAINT SENSING, DIAGNOSTIC MODULE (SDM) LOGIC LT GRN WIRE OBD FUSE HORN FUSE ORG/ WIRE P/WINDOW 1 P/WINDOW 2 PASSENGER OUTSIDE REARVIEW MIRROR PASSENGER WINDOW SWITCH PNK PNK PNK WIRE PNK PNK WIRE PNK WIRE PPL REAR WINDOW WIPER/ WASHER SWITCH (IF EQUIPPED) RED WIRE RED/BLK WIRE RED/WHT WIRE RELAY RR DEFOG FUSE SDM FUSE STARTER RELAY T/SIG FUSE CLUSTER FUSE TO ENGINE MAIN RELAY (DIAGRAM 3 OF 4) TO I/P FUSE BLOCK (DIAGRAM 3 OF 4) TO STOP LAMP TO UNDERHOOD FUSE BLOCK (DIAGRAM 4 OF 4) TRANSMISSION CONTROL MODULE (TCM) VEHICLE COMMUNICATION INTERFACE MODULE (VCIM) WHT WIRE WINDSHIELD REAR WIPER WINDOW MOTOR WIPER MOTOR (IF EQUIPPED) WIPER FUSE WIPER RELAY

A/C RELAY ACCESSORY POWER OUTLET (IF EQUIPPED) AUDIO AUDIO/RKE FUSE B/UP LAMP BLK WIRE BRN WIRE CIGAR CIGAR LIGHTER (W/ ILLUMINATION) CLOCK RADIO THEFT DETERRENT MODULE (TDM) (W/ SECURITY SYSTEM) EMS 1 EMS 2 ENGINE CONTROL MODULE (ECM) ENGINE COOLANT THERMOSTAT ENGINE MAIN RELAY EVAPORATIVE EMISSION (EVAP) CANISTER PURGE SOLENOID VALVE FROM ACC/RAP FROM ACC/RAP RELAY (DIAGRAM 2 OF 4) FROM DEFOG MIRROR (DIAGRAM CLUSTER/ ROOM LAMP FUSE STOP 2 OF 4) LAMP FUSE FROM FAN HI RELAY (DIAGRAM 1 OF 4) FROM SPLICE FUEL INJECTOR FUSE HATCHBACK HEATED OXYGEN SENSOR HVAC HVAC CONTROL CONTROL MODULE MODULE I/P FUSE BLOCK (LEFT SIDE OF DASH, IN DOOR OPENING) INSTRUMENT PANEL CLUSTER (IPC) LEFT BACKUP LAMP LEFT RIGHT TAIL TAIL LAMP LAMP LOGIC LT GRN WIRE MANUAL A/C AUTOMATIC A/C 10 3 MANUAL AUTOMATIC A/C A/C MASS AIR FLOW (MAF)/ INTAKE AIR TEMPERATURE (IAT) SENSOR MIRROR/SUNROOF NOTCHBACK ORG/ WIRE PNK WIRE REAR OVERHEAD COMPARTMENT CONSOLE LID RELEASE LAMPS SWITCH (NOTCHBACK) RED WIRE REMOTE CONTROL DOOR LOCK RECEIVER (W/ THEFT DETERENT) RIGHT BACKUP LAMP SOCKET STOP REAR LAMP COMPARTMENT SWITCH COURTESY LAMP SUNROOF FUSE SUNROOF RADIO CLOCK CONTROL MODULE (IF EQUIPPED) TIRE HVAC PRESSURE CONTROL MODULE MODULE (IF EQUIPPED) TO ABS 1 UNDERHOOD FUSE BLOCK W/ SUN ROOF W/O SUN ROOF WHT WIRE YEL WIRE

6 3 1 8 HATCHBACK NOTCHBACK AMP PRESENT SIG BLK WIRE BLU WIRE BRN WIRE CLUSTER DEFOGGER SYSTEM DOWN FUSE GRN WIRE GRY WIRE GRY/BLK WIRE HATCHBACK NOTCHBACK 6 3 1 8 1 1 2 2 5 6 HOT AT ALL TIMES HOT IN ON I/P FUSE BLOCK (LEFT SIDE OF DASH, IN DOOR OPENING) IGN 3 VOLT LEFT LEFT OUTSIDE REARVIEW MIRROR LEFT RIGHT LOGIC OUTSIDE REARVIEW MIRROR FOLDING MODULE (IF EQUIPPED) LT BLU WIRE LT LT MIRROR/SUNROOF MTR EXTEND CTRL MTR RETRACT CTRL ORG/ WIRE OUTSIDE REARVIEW MIRROR SWITCH PASSENGER DRIVER RED WIRE RED/WHT WIRE RIGHT RIGHT OUTSIDE REARVIEW MIRROR UP DOWN UP/ DOWN LEFT/ RIGHT WHT WIRE YEL WIRE

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 DIM CTRL 1 2 3 4 5 6 7 8 9 10 11 12 13 14 BAT VOLT LF FEED RF FEED 372 5060 230 COMPUTER DATA LINES SYSTEM AUDIO AUDIO/ RKE BLK WIRE BLU WIRE BRN WIRE BRN/WHT WIRE DK BLU WIRE DK GRN WIRE DK LT DK FUSE GND LF RETURN RF RETURN GRN WIRE GRY WIRE HOT AT ALL TIMES HOT W/ ACCY RELAY ENERGIZED I/P FUSE BLOCK (LEFT SIDE OF DASH, IN DOOR OPENING) ILLU INFLATABLE RESTRAINT STEERING WHEEL MODULE COIL LEFT FRONT SPEAKER LEFT REAR SPEAKER LEFT STEERING WHEEL CONTROL SWITCH LEFT TWEETER SPEAKER (IF EQUIPPED) LR OUT (+) RR OUT (+) MIX IN (+) LT BLU WIRE LT DK LT GRN WIRE MIX IN (-) MODE NCA WIRE NOTCHBACK W/O ONSTAR ORG/ WIRE POWER DISTRIBUTION SYSTEM PR ANT RLY PWR RADIO REAR WINDOW DEFOGGER GRID RADIO ANTENNA RED WIRE RED/WHT WIRE RETURN SER DATA RIGHT FRONT SPEAKER RIGHT REAR SPEAKER RIGHT TWEETER SPEAKER (IF EQUIPPED) SEEK SIGNAL LR OUT (+) RR OUT (+) MIX IN (-) IGN VOLT TAN WIRE VEHICLE COMMUNICATION INTERFACE MODULE (VCIM) VOL (-) WHT WIRE YEL WIRE

1 2 3 PNK WIRE BLK WIRE BLK/WHT WIRE BRN WIRE BRN/WHT WIRE CLUSTER COMPUTER DATA LINES SYSTEM DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE DRIVER SEAT BELT FUSE GRY WIRE GRY/BLK WIRE HOT AT ALL TIMES HOT IN ACC OR RUN I/P FUSE BLOCK (LEFT SIDE OF DASH, IN DOOR OPENING) INFLATABLE RESTRAINT SENSING, DIAGNOSTIC MODULE (SDM) (BELOW CENTER CONSOLE) LEFT INFLATABLE RESTRAINT FRONT END SENSOR (VEHICLE FRONT END) LF SEAT BELT SW LOGIC LT BLU WIRE LT BLU/BLK WIRE LT GRN WIRE LT GRN/WHT WIRE OBD ORG/ WIRE ORG/WHT WIRE PNK PNK WIRE PNK WIRE PPL RED WIRE RED/WHT WIRE RESTRAINT SYSTEM RIGHT INFLATABLE RESTRAINT FRONT END SENSOR (VEHICLE FRONT END) SDM SWITCH (DRIVER SEAT BELT BUCKLE) VOL+ ING 1 VOL PNK WIRE W/ DRIVER SEAT INFLATABLE W/O DRIVER SEAT INFLATABLE WHT WIRE WHT/BLK WIRE YEL WIRE

19 20 21 22 23 24 25 PNK WIRE BLK WIRE BRN WIRE BRN/BLK WIRE CLUSTER/ ROOM LAMP FUSE CRANKSHAFT POSITION (CKP) SENSOR (LEFT REAR OF ENGINE, BELOW THE OIL FILTER) EXHAUST CAMSHAFT POSITION (CMP) ACTUATOR SOLENOID VALVE EXHAUST CAMSHAFT POSITION (CMP) SENSOR FUSE GRY WIRE HEATED OXYGEN SENSOR HOT AT ALL TIMES HOT W/ IGN 1 RELAY ENERGIZED I/P FUSE BLOCK (LEFT SIDE OF DASH, IN DOOR OPENING) INTAKE CAMSHAFT POSITION (CMP) ACTUATOR SOLENOID VALVE LT BLU/WHT WIRE LT GRN/BLK WIRE ORG/ WIRE ORG/BLK WIRE PNK WIRE PPL RED/WHT WIRE TAN WIRE WHT WIRE YEL WIRE

BLK WIRE BRN WIRE BRN/BLK WIRE DK BLU WIRE ENGINE CONTROL MODULE (ECM) (LEFT FRONT FENDER, NEAR THE BATTERY) EVAP PURGE SOL CTRL EVAPORATIVE EMISSION (EVAP) CANISTER PURGE SOLENOID VALVE GRY WIRE IC TIMING CONTROL IC TIMING CTRL IC TIMING SIG IGNITION 1 VOLT IGNITION CONTROL MODULE (ICM) INTAKE CRANKSHAFT POSITION (CMP) SENSOR LOW REF LOW REF FUEL INJ 1 FUEL INJ 3 LOW REF IGN COIL C CTRL IGN COIL D CTRL LOW REF LOW REF LT BLU WIRE LT BLU/WHT WIRE LT GRN/BLK WIRE ORG/ WIRE ORG/BLK WIRE PNK WIRE PPL PPL 5-VOLT REF 1 KNOCK SENS SIG 5-VOLT REF 4 RED WIRE REFERENCE TEMP SENS SIG WHT WIRE YEL WIRE