Chevrolet Aveo I facelift (2006-2012) (next to starter) Wiring diagrams

A/C COMPRESSOR CLUTCH (LOWER RIGHT FRONT OF ENGINE) A/C ENGINE COOLANT TEMPERATURE (ECT) SENSOR A/C REFRIGERANT PRESSURE SENSOR (HIGH PRESSURE REFRIGERANT LINE) A/C RELAY BLK WIRE BLK/YEL WIRE BRN WIRE DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE ENGINE CONTROL MODULE (ECM) (LEFT FRONT FENDER, NEAR THE BATTERY) ENGINE COOLANT THERMOSTAT ENGINE COOLING ENGINE COOLING FAN FAN HI FAN HI RELAY FAN LOW FAN LOW RELAY FAN RESISTOR FUSE GRY WIRE GRY/RED WIRE HOT AT ALL TIMES HOT AT AT TIMES A/C COMP HOT W/ MAIN RELAY ENERGIZED HVAC AMBIENT AIR TEMPERATURE SENSOR INSTRUMENT CLUSTER LT BLU WIRE LT GRN/BLK WIRE MAIN RELAY ORG/BLK WIRE PPL PPL/WHT WIRE SYSTEM UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT) WHT WIRE WHT/BLK WIRE YEL WIRE

B/UP LAMP FUSE BACKUP SWITCH (TRANS- MISSION ASSEMBLY) BLK WIRE BRN WIRE ENGINE CONTROL MODULE (ECM) (LEFT FRONT FENDER, NEAR THE BATTERY) I/P FUSE BLOCK LEFT BACKUP LAMP LT GRN WIRE M/T A/T PARK/NEUTRAL POSITION (PNP) SWITCH (SIDE OF TRANSAXLE) RELAY ENERGIZED RIGHT BACKUP LAMP TRANSMISSION CONTROL MODULE (TCM) WHT WIRE

A/T B/UP LAMP FUSE BACKUP SWITCH (TRANS- MISSION ASSEMBLY) BLK WIRE BRN WIRE ENGINE CONTROL MODULE (ECM) (LEFT FRONT FENDER, NEAR THE BATTERY) I/P FUSE BLOCK LEFT BACKUP LAMP LEFT TAIL LAMP LT GRN WIRE M/T PARK/NEUTRAL POSITION (PNP) SWITCH (SIDE OF TRANSAXLE) RELAY ENERGIZED RIGHT BACKUP LAMP RIGHT TAIL LAMP TRANSMISSION CONTROL MODULE (TCM)

4 41 A/C COMP A/C REQ SIG PPL 45 33 LOW REF 5-VOLT REF 1 A/C COMP A/C COMPRESSOR CLUTCH (LOWER RIGHT FRONT OF ENGINE) A/C REFRIGERANT PRESSURE SENSOR (HIGH PRESSURE REFRIGERANT LINE) A/C RELAY BLK WIRE BRN WIRE ENGINE CONTROL MODULE (ECM) (LEFT FRONT FENDER, NEAR THE BATTERY) FUSE HOT AT AT TIMES HOT W/ MAIN RELAY ENERGIZED LT BLU WIRE ORG/BLK WIRE PPL PPL/WHT WIRE UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT)

267 (OR 540) 4 41 A/C COMP A/C REQ SIG 45 33 1937 1031 LOW REF 5-VOLT REF 1 67 203 PPL A/C COMP A/C COMPRESSOR CLUTCH (LOWER RIGHT FRONT OF ENGINE) A/C REFRIGERANT PRESSURE SENSOR (HIGH PRESSURE REFRIGERANT LINE) A/C RELAY BLK WIRE BLOWER MOTOR SWITCH BRN WIRE DEF IND DEF SW DEFOGGER 292 (OR 193) SYSTEM DK GRN/WHT WIRE ENGINE CONTROL MODULE (ECM) (LEFT FRONT FENDER, NEAR THE BATTERY) FUSE HOT AT AT TIMES HOT W/ MAIN RELAY ENERGIZED HVAC CONTROL MODULE (CENTER OF DASH) INSTRUMENT PANEL CLUSTER (IPC) LT BLU WIRE LT GRN/BLK WIRE ORG/ WIRE ORG/BLK WIRE PNK WIRE PNK/WHT WIRE PPL PPL/WHT WIRE RECIRCULATION ACTUATOR (UNDER DASH AT RIGHT SIDE OF HVAC UNIT) RED/WHT WIRE UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT)

1 2 PNK WIRE 25 20 40 5 21 42 19 BRK SW SIG LOW REFERENCE APP SENS 1 SIG 5 56 9 60 69 68 73 SENS 1 SIG PPL ACCELERATOR PEDAL POSITION (APP) SENSOR BLK WIRE BRN WIRE BRN/BLK WIRE CLUTCH PEDAL POSITION (CPP) SENSOR (W/ 5 SPEED M/T) COMPUTER DATA LINES SYSTEM CRUISE IND CRUISE PWR OUT DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE EMS 1 FUSE 6 ENGINE CONTROL MODULE (ECM) (LEFT FRONT FENDER, NEAR THE BATTERY) FUSE 7 GRY WIRE HIGH SPEED DATA HOT AT ALL TIMES HOT IN RUN OR START IGNITION SWITCH IND INFLATABLE RESTRAINT STEERING WHEEL MODULE COIL (UNDER DRIVER AIR BAG MODULE) INSTRUMENT PANEL CLUSTER (IPC) LOGIC LOW REFERENCE APP SENS 2 SIG LOW REFERENCE POSITION SENS SIG IGNITION 1 VOLT HIGH SPEED DATA LOW REFERENCE VEH SPD SENS SIG LOW SPEED DATA LT BLU WIRE LT GRN/BLK WIRE NCA WIRE ON SW SIG CRUISE CTRL ORG/ WIRE ORG/BLK WIRE PNK PPL PPL WIRE PNK WIRE PPL RED WIRE RED/WHT WIRE RESUME + SWITCH RIGHT STEERING WHEEL CONTROL SWITCH RUN WIRE SENS 2 SIG LOW REFERENCE MOTOR CTRL - 2 MOTOR CTRL - 1 GND SET SWITCH STOP LAMP STOP LAMP SWITCH (BRAKE PEDAL ASSEMBLY) TRANSMISSION CONTROL MODULE (TCM) UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT) VEHICLE SPEED SENSOR (VSS) (A/T) (RIGHT REAR OF ENGINE) VEHICLE SPEED SENSOR (VSS) (W/ 5 SPEED M/T) (RIGHT REAR OF ENGINE) WHT WIRE YEL WIRE YEL/BLK WIRE YEL/RED WIRE

A/T ACC/RAP RELAY AUTOMATIC TRANSMISSION SHIFT LEVER CLOCK AUTOMATIC TRANSMISSION SHIFT PROGRAM SWITCH BACKUP LAMP SWITCH BATTERY BLK WIRE BRAKE FLUID LEVEL SWITCH CIGAR LIGHTER ENGINE CONTROL MODULE (ECM) ENGINE COOLING FAN F/PUMP RELAY IGN 2 RELAY IGNITION CONTROL MODULE (ICM) IGNITION CONTROL MODULE (ICM) SHIELD INPUT SHAFT SPEED SENSOR (ISS) SHIELD INSTRUMENT PANEL CLUSTER (IPC) LEFT HEADLAMP LEFT PARK/TURN SIGNAL LAMP LEFT RIGHT HORN HORN LT GRN WIRE MASS AIR FLOW (MAF)/ INTAKE AIR TEMPERATURE (IAT) SENSOR PARK/NEUTRAL POSITION (PNP) SWITCH RADIO RIGHT HEADLAMP RIGHT PARK/TURN SIGNAL LAMP RIGHT TAIL/STOP LAMP STARTER RELAY TRANSMISSION CONTROL MODULE (TCM) VEHICLE SPEED SENSOR (VSS) WINDSHIELD WASHER FLUID PUMP WINDSHIELD WIPER MOTOR

A/C COMPRESSOR CLUTCH (LOWER RIGHT FRONT OF ENGINE) A/C REFRIGERANT PRESSURE SENSOR (HIGH PRESSURE REFRIGERANT LINE) A/C RELAY BLK WIRE BRN WIRE DK BLU WIRE DK GRN WIRE ENGINE CONTROL MODULE (ECM) (LEFT FRONT FENDER, NEAR THE BATTERY) ENGINE COOLANT THERMOSTAT ENGINE COOLING ENGINE COOLING FAN FAN HI FAN HI RELAY FAN LOW FAN LOW RELAY FAN RESISTOR FUSE GRY WIRE HOT AT ALL TIMES HOT AT AT TIMES HOT AT AT TIMES A/C COMP HOT IN ACC HOT W/ MAIN RELAY ENERGIZED IGN 2 RELAY LT BLU WIRE LT GRN/BLK WIRE MAIN RELAY FUSE ORG/ WIRE ORG/BLK WIRE PNK/WHT WIRE PPL PPL/WHT WIRE RECIRCULATION ACTUATOR (UNDER DASH AT RIGHT SIDE OF HVAC UNIT) RED/BLK WIRE UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT) WHT WIRE

1807 1807 710 710 440 COMPUTER DATA LINES SYSTEM 203 1161 AIR CONDITIONING SYSTEM 5-VOLT REF 2 (MLM) 5-VOLT REF 1 5-VOLT REF 1 5-VOLT REF 3 LO REF LO REF 539 473 441 COOLING FANS SYSTEM ACCELERATOR PEDAL POSITION (APP) SENSOR AIR CONDITIONING SYSTEM BLK WIRE BRN WIRE BRN/BLK WIRE BRN/WHT WIRE COMPUTER DATA LINES SYSTEM DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE EMS 1 EMS 2 ENGINE CONTROL MODULE (ECM) (LEFT FRONT FENDER, NEAR THE BATTERY) ENGINE COOLANT TEMPERATURE (ECT) SENSOR 2 ENGINE MAIN RELAY EXTERIOR LIGHTS SYSTEM STARTING/CHARGING SYSTEM FUEL TANK PRESSURE (FTP) SENSOR (FUEL TANK) FUSE GMLAN LOW SPD GRY WIRE HOT AT ALL TIMES IGN 1 VOLT MALFUNCTION IND LAMP INSTRUMENT PANEL CLUSTER (IPC) LOGIC LOW FUEL IND LOW REF LOW SPD GMLAN SER DATA LT BLU WIRE LT GRN WIRE LT GRN/BLK WIRE ORG/ WIRE ORG/BLK WIRE PNK 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 WIRE PNK IGN 1 VOLT FAN HI RLY CTRL MAIN RLY CTRL WIRE PNK WIRE PNK/BLK WIRE PPL PPL PNK WIRE PPL PPL HI SPD GMLAN SER DATA PPL/WHT WIRE RED WIRE RED/WHT WIRE UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT) VEHICLE WAKE UP SIG WHT WIRE YEL WIRE YEL/RED WIRE

BLK WIRE BRN WIRE BRN/BLK WIRE DK BLU WIRE ENGINE CONTROL MODULE (ECM) (LEFT FRONT FENDER, NEAR THE BATTERY) EVAP PURGE SOL CTRL EVAPORATIVE EMISSION (EVAP) CANISTER PURGE SOLENOID VALVE GRY WIRE IC TIMING CONTROL IC TIMING CTRL IC TIMING SIG IGNITION 1 VOLT IGNITION CONTROL MODULE (ICM) INTAKE CRANKSHAFT POSITION (CMP) SENSOR LOW REF LOW REF FUEL INJ 1 FUEL INJ 3 LOW REF IGN COIL C CTRL IGN COIL D CTRL LOW REF LOW REF LT BLU WIRE LT BLU/WHT WIRE LT GRN/BLK WIRE ORG/ WIRE ORG/BLK WIRE PNK WIRE PPL PPL 5-VOLT REF 1 KNOCK SENS SIG 5-VOLT REF 4 RED WIRE REFERENCE TEMP SENS SIG WHT WIRE YEL WIRE