Chevrolet Aveo I (2003-2008) (in i/p harness, behind left tie bar) Wiring diagrams

122 157 867 540 450 358 318 238 749 749 419 HEADLIGHTS SYSTEM ABS IND. AIR BAG IND ANTI-LOCK BRAKES SYSTEM AUDIO, CLOCK BATTERY BLK WIRE BLK/WHT WIRE BRN/BLK WIRE BRN/WHT WIRE CHARGE IND CLOCK CLOCK, AUDIO DISPLAY DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE DOOR JAMB SWITCHES DOOR LOCK RECEIVER (RCDLR) (UNDER FLOOR CONSOLE) DOOR OPEN IND ENGINE CONTROL MODULE (LEFT FRONT FENDER, NEAR THE BATTERY) FRONT FOG LAMP IND HAZARD IND HEADLIGHTS SYSTEM HOLD IND HOT AT ALL TIMES HOT IN RUN OR ACC HOT IN RUN OR START I/P FUSE BLOCK ILLUM GROUND LEFT FRONT LEFT REAR LT GRN WIRE METER CLOCK MIL CTRL MIL IND OIL PRESS IND OIL PRESSURE SWITCH (FRONT OF ENGINE, ON OIL PUMP HOUSING) ORG/ WIRE OUTLET PASSENGER AIR BAG OFF IND PNK PPL WIRE PNK WIRE PPL REAR FOG LAMP IND RED WIRE REMOTE CONTROL RIGHT FRONT RIGHT REAR SEAT BELT IND SPLICE PACK STARTING/ CHARGING SYSTEM STATUS ANTI-THEFT IND TRANSMISSION HAZARD SWITCH CONTROL MODULE WARNING SYSTEM WHT WIRE WHT/YEL WIRE YEL WIRE

BLK WIRE BLK/WHT WIRE BRN WIRE BRN/WHT WIRE DATA LINK CONNECTOR (BELOW LEFT SIDE OF DASH, RIGHT OF STEERING COLUMN) DK BLU WIRE DK BLU/WHT WIRE ECM/TCM FUSE 16 ELECTRONIC BRAKE CONTROL MODULE (EBCM) (LEFT ENGINE COMPT) HOT AT ALL TIMES I/P FUSE BLOCK OIL FEEDING CONNECTOR ORG/ WIRE REMOTE CONTROL DOOR LOCK RECEIVER (UNDER FLOOR CONSOLE) SERIAL DATA SPLICE PACK TRANSMISSION CONTROL MODULE (TCM) (RIGHT REAR CORNER OF VEHICLE) W/ IMMOBILIZER W/O IMMOBILIZER

A/C CONTROL SWITCH BLK WIRE BLOWER SWITCH BLU WIRE BRN WIRE DEFOG FUSE EF 21 DEFOGGER GRID LINES DEFOGGER RELAY (IN PASSENGER COMPT FUSE BLOCK) DEFOGGER SWITCH DK BLU WIRE DRIVER OUTSIDE REARVIEW MIRROR HEATER HATCHBACK HOT AT ALL TIMES HOT IN RUN HVAC BLOWER FUSE I/P FUSE BLOCK LT GRN WIRE NEAR LEFT "B" PILLAR) NOTCHBACK ORG/ WIRE PASSENGER OUTSIDE REARVIEW MIRROR HEATER PPL RED WIRE UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT) W/ A/C W/O A/C W/O DIMMING WHT WIRE YEL WIRE

BLK WIRE BRN WIRE BRN/DK BLU WIRE HATCHBACK HEAD HEADLAMP SWITCH HOT AT ALL TIMES ILLUM LAMP ILLUM LH ILLUM RELAY ILLUM RH LAMP CONTROL MODULE (BEHIND DRIVER SIDE KNEE BOLSTER) LEFT FRONT DOOR JAM SWITCH LEFT FRONT PARK POSITION LAMP LEFT FRONT TURN SIGNAL LAMP LEFT SIDE MARKER LAMP LICENSE LAMP LEFT TAIL LAMP LIGHTS ON SIG BATT SAVR SIG BATT VOLT GROUND LT DR AJAR SIG KEY IN IGN SIG LT BLU WIRE LT GRN WIRE NOTCHBACK OFF PARK ORG/ WIRE PPL PPL PPL RIGHT FRONT PARK POSITION LAMP RIGHT FRONT TURN SIGNAL LAMP RIGHT REAR TAIL LAMP RIGHT SIDE MARKER LAMP TURN SIGNAL SWITCH UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT) WHT WIRE

11 12 (EXCEPT RDS) (RDS) 14 16 (EXCEPT RDS) (RDS) A/T SHIFT SHIFT PROGRAM SWITCH LEVER ASHTRAY RADIO LAMP BATTERY BLK WIRE BLOWER MOTOR CENTER HIGH MOUNTED STOP LAMP (CHMSL) CIGAR LIGHTER CLOCK DATA LINK CONNECTOR (DLC) DAYTIME RUNNING LAMP (DRL) CONTROL MODULE FUEL PUMP HEADLAMP LEVELING SWITCH HORN RELAY HVAC CONTROL DEFOGGER SWITCH SWITCH INFLATABLE RESTRAINT SENSING, DIAGNOSTIC MODULE INSTRUMENT PANEL CLUSTER (IPC) INSTRUMENT PANEL DIMMER HAZARD SWITCH SWITCH INSTRUMENT TURN PANEL SIGNAL CLUSTER BLOWER WIPER SWITCH (IPC) RELAY RELAY LICENSE LAMP MULTI-FUNCTION ALARM MODULE NOTCHBACK RADIO REAR COMPT LOCK CYLINDER SWITCH REAR FOG LAMP SWITCH REAR FOG REAR LAMP FOG SWITCH RELAY REAR WINDOW DEFOGGER SHIFT INDICATOR LAMP SHIFT PROGRAM SWITCH THEFT IGNITION DETERRENT LOCK CONTROL MODULE MODULE TURN SIGNAL LAMP HAZARD CONTROL FLASHER MODULE W/O DIM W/O DIM W/O DIM

BLK WIRE BLK/WHT WIRE BLU WIRE BRN WIRE BRN/WHT WIRE DK BLU WIRE FOG LAMP RELAY FRT FOG FUSE FUSE FUSE GRY WIRE GRY/DK BLU WIRE H/L HI RH H/L HI LH H/L LOW LH H/L LOW RH HEAD PARK HEADLAMP HEADLAMP HIGH RELAY HEADLAMP LOW RELAY HEADLAMP SWITCH HOT AT ALL TIMES HOT W/HEADLAMP SWITCH IN PARK/ HEAD ENERGIZED ILLUM RH LEFT FRONT FOG LAMP RIGHT FRONT FOG LAMP LEFT HEAD- LAMP LOW BEAM HIGH BEAM LOW BEAM OFF ORG/ WIRE PNK WIRE PPL PPL PPL RIGHT HEAD- LAMP HIGH BEAM TURN SIGNAL SWITCH UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT) WHT WIRE WHT/YEL WIRE YEL WIRE

ABS, ENGINE FUSE 18 BATTERY HI BM PWR LO BM PWR PARK BRAKE GND IGN + DRL ILLU BLK WIRE BRAKE HANDLE) BRN WIRE BRN/WHT WIRE CLOCK (W/ TACHOMETER) DAYTIME RUNNING LAMPS (DRL) MODULE (BEHIND DASH, RIGHT OF CENTER CONSOLE) DRL IND FOG LAMP IND GRY/DK BLU WIRE HEADLAMP DIODE HEADLAMP SWITCH HIGH BEAM IND HOT IN RUN HOT IN RUN OR START I/P FUSE BLOCK INSTRUMENT CLUSTER SYSTEM INSTRUMENT PANEL CLUSTER LT GRN WIRE METER, CLOCK FUSE 4 ORG/ WIRE PARK BRAKE SWITCH (ON PARK PNK WIRE WHT WIRE WHT/YEL WIRE YEL WIRE YEL/DK GRN WIRE

BLK WIRE BLOWER MOTOR (BEHIND RIGHT SIDE OF DASH) BLOWER RELAY (IN PASSENGER COMPARTMENT FUSE BLOCK) BLOWER SWITCH BRN WIRE DEFOGGER SYSTEM DK BLU/WHT WIRE FUSE HOT AT ALL TIMES UNDERHOOD BLOWER FUSE BLOCK (LEFT SIDE OF FUSE ENGINE COMPT) HOT IN RUN OR START HVAC BLOWER I/P FUSE BLOCK IGN 1 MED 2 LO MED 1 BLOWER CTRL 3 4 5 6 LT BLU WIRE RED WIRE SPLICE PACK WHT WIRE YEL WIRE

1 2 HVAC ON SIG ACC VOLT 3 4 5 6 MED 2 LO MED 1 BLOWER CTRL A/C COMP A/C COMPRESSOR CLUTCH (LOWER RIGHT FRONT OF ENGINE) A/C COMPRESSOR RELAY A/C RECIRCULATION ACTUATOR A/C REFRIGERANT PRESSURE SENSOR (ON HIGH PRESSURE REFRIGERANT LINE) ABS, ENGINE BLK WIRE BLOWER BLOWER MOTOR (BEHIND RIGHT SIDE OF DASH) BLOWER RELAY (IN PASSENGER COMPT FUSE BLOCK) BLOWER SWITCH BLU WIRE BRN WIRE BRN/WHT WIRE COOLING COOLING FAN (BEHIND RADIATOR) COOLING FAN HI RELAY COOLING FAN LOW RELAY COOLING FAN RESISTOR (ON RADIATOR, DEFOGGER SYSTEM DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/WHT WIRE DK LT ENGINE CONTROL MODULE (ECM) (LEFT FRONT FENDER, NEAR THE BATTERY) ENGINE CONTROLS SYSTEM FUSE GRN WIRE GRY WIRE HOT AT ALL TIMES HOT IN RUN OR START HVAC BLOWER HVAC CONTROL SWITCH I/P FUSE BLOCK IRC 1 LT BLU WIRE LT GRN WIRE LT GRN/BLK WIRE MAIN RELAY PPL RED WIRE SPLICE PACK WHT WIRE WHT/PNK WIRE YEL WIRE

14 2 SPEEDOMETER 3 26 TACHOMETER A/C REQ SIG STOP LMP SW AIR CONDITIONING SYSTEM EXTERIOR LIGHTS SYSTEM ANTI-LOCK BRAKES SYSTEM BATTERY BATTERY GND GND GND GND BLK WIRE BLK/WHT WIRE BRN WIRE BRN/BLK WIRE CLOCK COMPUTER DATA LINES SYSTEM COOLING FANS SYSTEM COOLING FANS SYSTEM AIR CONDITIONING SYSTEM CRUISE CONTROL SYSTEM DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE ECM, TCM FUSE ECT SENS SIG ENGINE CONTROL MODULE (ECM) (LEFT FRONT FENDER, NEAR THE BATTERY) EXTERIOR LIGHTS SYSTEM CRUISE CONTROL SYSTEM FUEL GAUGE FUEL LVL SENS FUEL PUMP/ SENDER ASSEMBLY (IN FUEL TANK) FUEL TANK PRESSURE SENSOR (IN FUEL TANK) GRY WIRE GRY/DK GRN WIRE HOT AT ALL TIMES HOT IN RUN OR START I/P FUSE BLOCK IGN 1 VOLT IGN 1 VOLT INSTRUMENT PANEL CLUSTER LOW REF LOW REF LOW REF LOW REF LT BLU WIRE LT BLU/PPL WIRE LT GRN WIRE M/T M/T A/T MALFUNCTION INDICATOR LMP (W/ TACHOMETER) MALFUNCTION INDICATOR LMP (W/O TACHOMETER) METER, CLOCK FUSE ORG/ WIRE PNK IGN 1 VOLT COOL FAN CTRL A/C SPLY MAIN RLY CTRL CRUISE IND CTRL VSS SIG WIRE PNK WIRE PNK/DK BLU WIRE PPL PPL 1807 710 PPL FUEL WARNING LAMP SER DATA LO STOP LMP SW APP SEN 1 SIG A/C PRESS SIG DATA SERIAL TEMP GAUGE W/ TACHOMETER W/O TACHOMETER WHT WIRE WHT/DK BLU WIRE WHT/PNK WIRE YEL WIRE YEL/BLK WIRE