Chevrolet Aveo I (2003-2008) (behind right headlamp, under air cleaner) Wiring diagrams

A/C COMP A/C COMP RLY A/C COMPRESSOR CLUTCH (LOWER RIGHT FRONT OF ENGINE) A/C COMPRESSOR RELAY A/C REQUEST A/C SW SIG ABS, ENGINE BLK WIRE BLU WIRE BRN WIRE DK GRN WIRE DK GRN/WHT WIRE DK LT ENGINE CONTROL MODULE (ECM) (LEFT FRONT FENDER, NEAR THE BATTERY) FUSE FUSE DK GRN WIRE HOT AT ALL TIMES HOT IN RUN OR START HVAC CONTROL SWITCH I/P FUSE BLOCK LT GRN WIRE SPLICE PACK UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT)

50 34 36 LOW SPD CTRL HI SPD CTRL MAIN RELAY BLK WIRE BRN WIRE COOLING COOLING FAN (BEHIND RADIATOR) COOLING FAN HI RELAY COOLING FAN LOW RELAY COOLING FAN RESISTOR (BEHIND RIGHT SIDE OF RADIATOR) ECT SENS ENGINE CONTROL MODULE (ECM) (LEFT FRONT FENDER, NEAR THE BATTERY) FUSE GRN WIRE GRY WIRE HOT AT ALL TIMES IRC 1 LOW REF LT GRN WIRE MAIN RELAY PPL PPL (IN FRONT HARNESS) WHT WIRE

BLK WIRE BRN WIRE BRN/DK BLU WIRE HATCHBACK HEAD HEADLAMP SWITCH HOT AT ALL TIMES ILLUM LAMP ILLUM LH ILLUM RELAY ILLUM RH LAMP CONTROL MODULE (BEHIND DRIVER SIDE KNEE BOLSTER) LEFT FRONT DOOR JAM SWITCH LEFT FRONT PARK POSITION LAMP LEFT FRONT TURN SIGNAL LAMP LEFT SIDE MARKER LAMP LICENSE LAMP LEFT TAIL LAMP LIGHTS ON SIG BATT SAVR SIG BATT VOLT GROUND LT DR AJAR SIG KEY IN IGN SIG LT BLU WIRE LT GRN WIRE NOTCHBACK OFF PARK ORG/ WIRE PPL PPL PPL RIGHT FRONT PARK POSITION LAMP RIGHT FRONT TURN SIGNAL LAMP RIGHT REAR TAIL LAMP RIGHT SIDE MARKER LAMP TURN SIGNAL SWITCH UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT) WHT WIRE

7 9 RIGHT IND LEFT IND BLINK RELAY (IN PASSENGER COMPT FUSE BLOCK) BLK WIRE BRN WIRE DK BLU WIRE DK GRN WIRE DOOR LOCKS SYSTEM GRY WIRE HAZARD SWITCH HOT IN RUN OR START I/P CLUSTER I/P FUSE BLOCK LEFT FRONT TURN SIGNAL LAMP LEFT FRONT TURN SIGNAL REPEATER LAMP LEFT TAIL LAMP LT BLU WIRE LT GRN WIRE NCA WIRE ORG/ WIRE PNK WIRE RED WIRE RIGHT FRONT TURN SIGNAL LAMP RIGHT FRONT TURN SIGNAL REPEATER LAMP RIGHT TAIL LAMP TIE BAR) TSIG FUSE 3 TURN SIGNAL SWITCH TURN SIGNAL/ HAZARD FLASHER (IN PASSENGER COMPARTMENT FUSE BLOCK) WHT WIRE

A/C COMPRESSOR CLUTCH BLK WIRE BRAKE FLUID LEVEL SWITCH FAN CONTROL RELAY FOG LAMP RELAY FRONT WINDSHIELD WASHER FLUID PUMP LEFT FRONT LEFT TURN FRONT SIGNAL FOG REPEATER LAMP LAMP LEFT FRONT PARK/TURN SIGNAL LEFT HEADLAMP ELECTRONIC BRAKE LEVELING CONTROL MODULE MOTOR (EBCM) LEFT PARK LEFT POSITION HEAD- LAMP LAMP MAIN COOLING FAN OIL FEEDING CONNECTOR POWER FUEL WINDOW PUMP RELAY RELAY REAR WINDSHIELD WASHER FLUID PUMP RIGHT FRONT FOG LAMP RIGHT FRONT TURN SIGNAL RIGHT HEAD- LAMP RIGHT HEADLAMP LEVELING MOTOR RIGHT PARK POSITION LAMP RIGHT TURN SIGNAL REPEATER LAMP WINDSHIELD WIPER MOTOR

BLK WIRE BLK/WHT WIRE BLU WIRE BRN WIRE BRN/WHT WIRE DK BLU WIRE FOG LAMP RELAY FRT FOG FUSE FUSE FUSE GRY WIRE GRY/DK BLU WIRE H/L HI RH H/L HI LH H/L LOW LH H/L LOW RH HEAD PARK HEADLAMP HEADLAMP HIGH RELAY HEADLAMP LOW RELAY HEADLAMP SWITCH HOT AT ALL TIMES HOT W/HEADLAMP SWITCH IN PARK/ HEAD ENERGIZED ILLUM RH LEFT FRONT FOG LAMP RIGHT FRONT FOG LAMP LEFT HEAD- LAMP LOW BEAM HIGH BEAM LOW BEAM OFF ORG/ WIRE PNK WIRE PPL PPL PPL RIGHT HEAD- LAMP HIGH BEAM TURN SIGNAL SWITCH UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT) WHT WIRE WHT/YEL WIRE YEL WIRE

1 2 HVAC ON SIG ACC VOLT 3 4 5 6 MED 2 LO MED 1 BLOWER CTRL A/C COMP A/C COMPRESSOR CLUTCH (LOWER RIGHT FRONT OF ENGINE) A/C COMPRESSOR RELAY A/C RECIRCULATION ACTUATOR A/C REFRIGERANT PRESSURE SENSOR (ON HIGH PRESSURE REFRIGERANT LINE) ABS, ENGINE BLK WIRE BLOWER BLOWER MOTOR (BEHIND RIGHT SIDE OF DASH) BLOWER RELAY (IN PASSENGER COMPT FUSE BLOCK) BLOWER SWITCH BLU WIRE BRN WIRE BRN/WHT WIRE COOLING COOLING FAN (BEHIND RADIATOR) COOLING FAN HI RELAY COOLING FAN LOW RELAY COOLING FAN RESISTOR (ON RADIATOR, DEFOGGER SYSTEM DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/WHT WIRE DK LT ENGINE CONTROL MODULE (ECM) (LEFT FRONT FENDER, NEAR THE BATTERY) ENGINE CONTROLS SYSTEM FUSE GRN WIRE GRY WIRE HOT AT ALL TIMES HOT IN RUN OR START HVAC BLOWER HVAC CONTROL SWITCH I/P FUSE BLOCK IRC 1 LT BLU WIRE LT GRN WIRE LT GRN/BLK WIRE MAIN RELAY PPL RED WIRE SPLICE PACK WHT WIRE WHT/PNK WIRE YEL WIRE

ABS, ENGINE FUSE BLK WIRE BLU WIRE BRN WIRE BRN/ORG WIRE DK GRN WIRE DOWN DOWN UP GRN WIRE HOT AT ALL TIMES HOT IN ON I/P FUSE BLOCK LEFT FRONT POWER WINDOW MOTOR NCA WIRE ORG/ WIRE POWER WINDOW FUSE POWER WINDOW RELAY POWER WINDOW SWITCH RED/WHT WIRE RIGHT FRONT POWER WINDOW MOTOR RIGHT FRONT POWER WINDOW UP SWITCH UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT) WHT WIRE

ABS, ENGINE FUSE BLK WIRE BLU WIRE BRN WIRE DK GRN WIRE DK LT DWN DWN UP DWN UP DWN GRN WIRE GRY WIRE HOT AT ALL TIMES HOT IN ON I/P FUSE BLOCK LEFT FRONT POWER WINDOW MOTOR (IN LEFT FRONT DOOR) LEFT REAR POWER WINDOW SWITCH RIGHT REAR POWER WINDOW SWITCH LOCK LT GRN WIRE LT PPL NCA WIRE ORG/ WIRE POWER WINDOW FUSE POWER WINDOW MAIN SWITCH POWER WINDOW RELAY RED WIRE RIGHT FRONT POWER WINDOW MOTOR (IN RIGHT FRONT DOOR) RIGHT FRONT POWER WINDOW SWITCH UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT) UP DWN UP DWN DWN UP DWN UP WHT WIRE YEL WIRE

BLK WIRE BRN WIRE BRN/BLK WIRE BRN/WHT WIRE DK BLU WIRE DK BLU/BLK WIRE DK GRN WIRE EVAPORATIVE CANISTER PURGE SOLENOID VALVE (ON INTAKE MANIFOLD) EXHAUST GAS RECIRCULATION (EGR) VALVE (ON TOP REAR OF ENGINE) FUEL PUMP FUEL PUMP FUSE HOT AT ALL TIMES INTAKE MANIFOLD TUNING VALVE POSITION SENSOR IRC 1 IRC 2 FUSE FUSE LT BLU WIRE LT GRN WIRE MAIN RELAY MANIFOLD ABSOLUTE (MAP) PRESSURE SENSOR (LEFT REAR OF ENGINE) ORG/ WIRE PNK PNK PNK PNK WIRE PNK PNK WIRE PNK WIRE PNK/DK BLU WIRE UNDERHOOD FUSE BLOCK FUEL PUMP RELAY (LEFT SIDE OF ENGINE COMPT) WHT WIRE YEL WIRE YEL/BLK WIRE