BMW 7 series E65/E66 (2001-2005) a/c control module Wiring diagrams

1 2 3 4 5 6 7 8 9 10 11 12 SENS SYS GND RH TEMP SIG 1 2 3 STEPPER MTR SPLY STEPPER MTR GND 1 2 TERMINAL 30 SPLY GROUND A/C CONTROL MODULE BLK WIRE BLK/BRN WIRE BLK/GRN WIRE BLK/YEL WIRE BLU WIRE BLU/BLK WIRE BLU/BRN WIRE BLU/GRN WIRE BRN WIRE BRN/BLK WIRE BRN/BLU WIRE BRN/YEL WIRE CENTER LOCK SIG HAZ WARN IND SIG COMPUTER DATA LINES SYSTEM DEFOGGER SYSTEM DEFROSTER FLAP ACTUATOR (RIGHT SIDE OF DASH) FLAP ACTUATOR SIG FLAP ACTUATOR SIG FLAP ACTUATOR SIG FLAP ACTUATOR SIG EVAPORATOR SIG LH TEMP SIG FUSE GRN WIRE GRN/ORG WIRE GRY WIRE GRY/BLK WIRE GRY/BRN WIRE HOT AT ALL TIMES HOT AT ALL TIMES FRONT FUSE HOLDER (RIGHT SIDE OF DASH) FUSE LEFT COLD AIR FLAP ACTUATOR (2007: CENTER OF DASH) LEFT WARM AIR FLAP ACTUATOR (2007: TOP RIGHT SIDE OF DASH) OF DASH) RIGHT HEAT EXCHANGER TEMPERATURE SENSOR RED WIRE RED/BLU WIRE RED/VIO/YEL WIRE RIGHT FOOTWELL FLAP ACTUATOR (2007: CENTER OF DASH, BELOW RADIO) STEPPER MTR BUS SIG VENTILATION TEMP SIG VENTILATION TEMPERATURE SENSOR UNIT WHT WIRE YEL WIRE YEL/BLU WIRE YEL/BRN WIRE YEL/GRN WIRE YEL/RED WIRE YEL/VIO WIRE YEL/WHT WIRE

1 2 TERMINAL 30 SPLY GROUND 2004 TO 2005 EARLY PRODUCTION 2005 LATE PRODUCTION TO 2007 A/C CONTROL MODULE AUC SENSOR (2004 TO 2005 EARLY PRODUCTION) BLK/BRN WIRE BLK/GRN WIRE BLOWER MOTOR (RIGHT SIDE OF DASH) BLOWER OUTPUT STAGE (RIGHT SIDE OF DASH) BLU WIRE BLU/BLK WIRE BLU/BRN WIRE BLU/GRN WIRE BLU/YEL WIRE BRN WIRE BRN/BLK WIRE BRN/BLU WIRE BRN/YEL WIRE CAR ACCESS CONTROL MODULE CENTER LOCK SIG HAZ WARN IND SIG COMPUTER DATA LINES SYSTEM CONDENSATION SENSOR COOLANT PRESSURE SENSOR (2007: RIGHT SIDE OF ENGINE COMPT) DEFOGGER SYSTEM FRONT SEAT) FUSE GRN WIRE GRN/GRY WIRE GRN/ORG WIRE GRY WIRE GRY/BLK WIRE GRY/BRN WIRE HOT AT ALL TIMES HOT AT ALL TIMES FRONT FUSE HOLDER (RIGHT SIDE OF DASH) FUSE LIGHT MODULE (LEFT SIDE OF DASH) RED WIRE RED/BLU WIRE RED/VIO/YEL WIRE W/ AUC SENSOR W/ AUC SENSOR II WHT WIRE WHT/BLK WIRE WHT/BLU WIRE WHT/GRN WIRE WHT/RED WIRE WHT/VIO WIRE YEL/BRN WIRE YEL/GRN WIRE YEL/RED WIRE YEL/VIO WIRE YEL/WHT WIRE

1 2 3 4 5 6 7 8 9 10 11 12 SENS SYSTEM GND RH HEAT TEMP SIG RH VENTIL TEMP SIG 1 2 3 STEPPER MTR SPLY STEPPER MTR GND STEPPER MTR SIG 4.8L 4.8L 6.0L 6.0L A/C CONTROL MODULE ACTUATOR SIG ACTUATOR SIG ACTUATOR SIG ACTUATOR SIG EVAP TEMP AFT SIG LH HEAT TEMP SIG LH VENTIL TEMP SIG AUXILIARY WATER PUMP (LEFT SIDE OF ENGINE COMPT) BLK WIRE BLK/GRN WIRE BLK/GRN/YEL WIRE BLU WIRE BLU/ YEL WIRE BLU/GRN WIRE BLU/RED WIRE BRN WIRE BRN/BLK WIRE BRN/YEL WIRE CHARACTERISTIC MAP THERMOSTAT (2007: FRONT OF ENGINE) COMPUTER DATA LINES SYSTEM DEFROSTER FLAP ACTUATOR (RIGHT SIDE OF DASH) DME CONTROL MODULE (4.8L) ENGINE CONTROL MODULE I (DME) (6.0L) (RIGHT REAR OF ENGINE COMPT) ENGINE COOLANT TEMPERATURE SENSOR (4.8L: TOP FRONT CENTER OF ENGINE) FUSE GRN WIRE GRY WIRE GRY/BRN WIRE HOT AT ALL TIMES JUMP FUSE TERMINAL POINT HOT W/ DME RELAY 1 ENERGIZED INTEGRATED SUPPLY MODULE (IVM) FUSE HOT W/ DME RELAY 2 ENERGIZED LEFT LEFT COLD AIR FLAP ACTUATOR (2007: CENTER OF DASH) LEFT FOOTWELL FLAP ACTUATOR (2007: CENTER OF DASH, BELOW RADIO) LEFT REAR COMPARTMENT FLAP ACTUATOR (2007: CENTER OF DASH, BELOW RADIO) LEFT WARM AIR FLAP ACTUATOR (2007: TOP RIGHT SIDE OF DASH) ORG/ WIRE RED WIRE RED/WHT/YEL WIRE REFRIGERANT COMPRESSOR CONTROL VALVE (RIGHT SIDE OF ENGINE COMPT) RIGHT RIGHT COLD AIR FLAP ACTUATOR (2007: LEFT SIDE OF RIGHT FOOTWELL) RIGHT FOOTWELL FLAP ACTUATOR (2007: CENTER OF DASH, BELOW RADIO) RIGHT REAR COMPARTMENT FLAP ACTUATOR (2007: CENTER OF DASH, BELOW RADIO) RIGHT WARM AIR FLAP ACTUATOR (2007: TOP CENTER OF DASH) TEMPERATURE SENSOR AT RADIATOR OUTLET VENTILATION TEMPERATURE SENSOR UNIT WHT WIRE WHT/GRN WIRE YEL BLU/ WIRE YEL WIRE YEL/BLU WIRE YEL/BRN WIRE YEL/GRN WIRE YEL/RED WIRE YEL/VIO WIRE

A/C CONTROL MODULE BLK WIRE BLU WIRE BLU/RED WIRE BLU/VIO WIRE BRN WIRE BRN/BLK WIRE BRN/WHT WIRE CAR ACCESS CONTROL MODULE CENTRAL LOCK SWITCH COMPUTER DATA LINES SYSTEM DRIVER'S DOOR LOCK SYSTEM (2007: REAR OF DRIVER'S DOOR) DRIVER'S DOOR MODULE (DRIVER'S DOOR) FUEL FILLER FLAP CENTRAL LOCKING DRIVE FUSE GRY/BLK WIRE GRY/BRN WIRE HOT AT ALL TIMES HOT AT ALL TIMES FRONT FUSE HOLDER (RIGHT SIDE OF DASH) FUSE PASSENGER'S DOOR LOCK SYSTEM (2007: REAR OF FRONT PASSENGER'S DOOR) PASSENGER'S DOOR MODULE REAR FUSE HOLDER (RIGHT REAR LUGGAGE COMPT) RED WIRE RED/GRN WIRE RED/VIO WIRE WHT WIRE WHT/BLK WIRE YEL/RED WIRE YEL/WHT WIRE

A/C CONTROL MODULE BLK WIRE BLU WIRE BRN WIRE BRN/BLK WIRE COMPUTER DATA LINES SYSTEM DRIVER'S SIDE REAR DOOR MODULE (2007: BOTTOM LEFT SIDE OF LEFT REAR DOOR) DRIVER'S SIDE REAR DOOR SWITCH BLOCK FUSE GRN/ORG WIRE GRY/BLK WIRE GRY/BRN WIRE HOT AT ALL TIMES HOT AT ALL TIMES FRONT FUSE HOLDER (RIGHT SIDE OF DASH) FUSE HOT AT ALL TIMES REAR FUSE HOLDER (RIGHT REAR LUGGAGE COMPT) FUSE LEFT REAR ROLLER BLIND QUARTER LIGHT MOTOR (2007: BOTTOM REAR OF LEFT REAR DOOR) LEFT REAR ROLLER BLIND WINDOW MOTOR NCA WIRE PASSENGER'S SIDE REAR DOOR MODULE (2007: BOTTOM RIGHT SIDE OF RIGHT REAR DOOR) PASSENGER'S SIDE REAR DOOR SWITCH BLOCK RED/VIO/YEL WIRE RED/YEL WIRE RIGHT REAR ROLLER BLIND WINDOW MOTOR WHT WIRE WHT/RED WIRE WHT/VIO WIRE YEL RED/VIO/ WIRE YEL WIRE